Huffy Sports user manual

2/05 P/N 211017

Toll-Free Customer Service Number for U.S: 1-800-558-5234,

For Canada: 1-800-284-8339,

For Europe: 00 800 555 85234 (Sweden: 009 555 85234),

For Australia: 1-800-632 7921

Internet Address: http://www.huffysports.com

REQUIRED TOOLS

AND MATERIALS:

AND/OR

OPTIONAL TOOLS

AND MATERIALS:

Portable System

Owners Manual

Customer Service Center

• N53 W24700 South Corporate Circle • Sussex, WI 53089 • U.S.A.

A DIVISION OF RUSSELL CORPORATION

READ AND UNDERSTAND OPERATOR'S MANUAL BEFORE USING THIS UNIT.

FAILURE TO FOLLOW OPERATING INSTRUCTIONS COULD RESULT IN INJURY OR DAMAGE TO PROPERTY.

WARNING!

7/16" 1/2" 9/16" 3/4"

• 2 People

• Tape Measure

• Wood Board (scrap)

• Sawhorse or Support Table

• Hammer

• Safety Glasses

• Step Ladder - 8ft. (2.4 m)

SAND

(360 lb.)

(163 kg)

Write Model Number

From Box Here:

• (2 each) Wrenches and/or Socket Wrenches and Sockets (DeepWell Sockets are Recommended).

• Extension is Recommended.

• Large and Small Adjustable

Wrenches

P/N 211017 2/05

201246 11/04

In the U.S.:1-800-558-5234 and Canada: 1-800-284-8339

FAILURE TO FOLLOW THESE WARNINGS MAY RESULT IN

SERIOUS INJURY AND/OR PROPERTY DAMAGE.

Owner must ensure that all players know and follow these

rules for safe operation of the system.

WARNING

•

DO NOT HANG on the rim or any part of the system including backboard, support braces or net.

•

During play, especially when performing dunk type activities, keep player's face away from the backboard, rim and net. Serious injury could occur if teeth/face come in contact with backboard, rim or net.

•

Do not slide, climb, shake or play on base and/or pole.

•

After assembly is complete, fill system completely with water or sand and stake to the ground. Never leave system in an upright position without filling base with weight, assystem may tip over causing injuries.

•

When adjusting height or moving system, keep hands and fingers away from moving parts.

•

Do not allow children to move or adjust system.

•

During play, do not wear jewelry (rings, watches, necklaces, etc.). Objects may entangle in net.

•

Surface beneath the base must be smooth and free of gravel or other sharp objects. Punctures cause leakage and could cause system to tip over.

•

Keep organic material away from pole base. Grass, litter, etc. could cause corrosion and/or deterioration.

•

Check pole system for signs of corrosion (rust, pitting, chipping) and repaint with exterior enamel paint. If rust has penetrated through the steel anywhere, replace pole immediately.

•

Check system before each use for proper ballast, loose hardware, excessive wear and signs corrosion and repair before use.

•

Check system before each use for instability.

•

Do not use system during windy and/or severe weather conditions; system may tip over. Place system in the storage position and/or in an area protected from the wind and free from personal property and/or overhead wires.

•

Never play on damaged equipment.

•

See instruction manual for proper installation and maintenance.

•

When moving system, use caution to keep mechanism from shifting.

•

Keep pole top covered with cap at all times.

•

Do not allow water in tank to freeze. During sub-freezing weather add non-toxic antifreeze, sand or empty tank completely and store. (Do not use salt.)

•

While moving system, do not allow anyone to stand or sit on base or have added ballasting on base.

•

Do not leave system unsupervised or play on system when wheels are engaged for moving.

•

Use Caution when moving system across uneven surfaces. System may tip over.

•

Use extreme caution if placing system on sloped surface. System may tip over more easily.

BEFORE YOU START!

To ensure optimal playability of backboard system, a

close tolerance fit between the elevator components

and hardware is required. Test-fit large bolts into large

holes of elevator tubes, backboard brackets, and

triangle plates. Carefully rock them in a circular

motion to ream out any excess paint from holes if

necessary.

Not all items pictured are included with every model.

2/05 P/N 211017

204583 12/04

MOVING SYSTEM

HEIGHT ADJUSTMENT

TO ADJUST BACKBOARD:

1. Grasp handle and press button.

2. Raise or lower to desired height.

3. Release button.

SAFETY INSTRUCTIONS

Most injuries are caused by misuse and/or not following

instructions.

Use caution when using this system.

• If using a ladder during assembly, use extreme caution.

• Two (2) people are recommended for this operation.

• Check base regularly for leakage. Slow leaks could cause system to tip over unexpectedly.

• Seat the pole sections properly (if applicable). Failure to do so could allow the pole sections to separate during play and/or transport of the system.

• Climate, corrosion or misuse could result in system failure.

• Minimum operational height is 6' 6" (1.98 m) to the bottom of backboard.

• This equipment is intended for home recreational use only and NOT excessive competitive play.

• Read and understand the warning label affixed to pole. Label is shown to the right.

• The life of your basketball pole depends on many conditions. The climate, placement of the pole, the location of the pole, exposure to corrosives such as pesticides, herbicides or salts are all important.

• If technical assistance is required, contact Huffy Sports.

• Adult supervision is recommended when adjusting height.

FAILURE TO FOLLOW THESE SAFETY INSTRUCTIONS MAY

RESULT IN SERIOUS INJURY, PROPERTY DAMAGE AND

WILL VOID WARRANTY.

Owner must ensure that all players know and follow these

rules for safe operation of the system.

To ensure safety, do not attempt to assemble this system without following the instructions carefully. Proper and complete assembly, use and supervision is essential for proper operation and to reduce the risk of accident or injury. A high probability of serious injury exists if this system is not installed, maintained, and operated properly. Check entire box and inside all packing material for parts and/or additional instructional material. Before beginning assembly, read the instructions and identify parts using the hardware identifier and parts list in this document.

For more information on assembly, placement, proper use and maintenance, visit The American Basketball Council website at http://www.smarthoops.com.

P/N 211017 2/05

For more information on assembly, placement, proper use, and maintenance, visit The American Basketball Council website at http://www.smarthoops.com.

IMPORTANT!

Remove all contents from boxes.

Be sure to check inside pole sections;

hardware and additional parts are packed inside.

NOTICE TO ASSEMBLERS

ALL Huffy Sports Basketball Systems, including those used for DISPLAYS, MUST be assembled

and ballasted with sand or water according to the instructions. Failure to follow instructions

could result in SERIOUS INJURY. It is NOT acceptable to devise a makeshift weight system.

WARRANTY CARD:

Please remember to complete your product registration form either on-line at: www.huffysports.com or mail-in the enclosed postcard.

2/05 P/N 211017

Get to know the basic parts of your basketball system...

SUPPORT

STRUT

BACK VIEW

RIM

BASE

POLE

ELEVATOR

ADJUSTMENT

BACKBOARD

FRONT VIEW

RIM

POLE

ELEVATOR

ADJUSTMENT

SUPPORT

STRUT

BASE

P/N 211017 2/05

WARRANTY CARD:

Please remember to complete your product registration form either on-line at:

www.huffysports.com/warrantycard or mail-in the enclosed postcard.

WARNING: IF YOUR SYSTEM IS EQUIPPED WITH AN ACRYLIC

BACKBOARD, EXAMINE BACKBOARD FOR ANY DAMAGE THAT MAY HAVE OCCURRED DURING SHIPMENT. CRACKS IN THE BACKBOARD COULD RESULT IN SUDDEN BREAKAGE. IF BACKBOARD IS DAMAGED IN ANY WAY PRIOR TO OR AFTER ASSEMBLY, CALL TOLL-FREE NUMBER FOR FREE REPLACEMENT: U.S. 1-800-558-5234; CANADA: 1-800-284-8339; http://www.huffysports.com

PARTS LIST - See Hardware Identifier

NOTE: Hardware kit is designed for more than one style of basketball system. Not all hardware will be

used.

Item Qty. Part No. Description

1 1 206657 Tank, (Black) 2 1 200628 Wheel Axle 3 2 226401 Wheel, 4“ (Black) 4 1 908170 Top Pole Section 5 1 904840 Middle Pole Section 6 1 900136 Bottom Pole Section 7 1 202820 Rod, 3/8 O.D. x 4-3/4 Long 8 1 202822 Eyebolt, 3/8-16 x 2-1/2 Long

9 3 203063 Nut, Nylock, 3/8-16 10 2 906206 Tank Strut 11 1 201625 Bolt, Yellow Dichromate, 5/16-18 x 3.60" Long 12 6 203218 Washer, Flat, 3/8 I.D. 13 2 203099 Nut, Nylock, 5/16-18 14 1 201568 Anchor, T-Strap 15 6* 205528 Bolt, Hex Flange, 5/16-18 x 1 Long 16 8* 203100 Nut, Hex Flange, 5/16-18 17 2 201651 Spacer 0.50 I.D. x 0.25 Long 18 1 203143 Bolt, Hex, 5/16-18 x 1.5 Long 19 1 200627 Wheel Carriage 20 12 201219 Clip, Net Holder 21 1 Rim 22 1 206219 Cap, Pole Top 3” 23 1 203124 Stake, Tie Down 24 2 203617 Plug Cap

Item

Qty. Part No. Description

25 1 204583 Label, Height Adjustment and Moving 26 1 Net 27 1 200209 Pole Mount Bracket 28 2 203231 Bolt, Carriage, 5/16-18 x 3.5 Long 29 2 900964 Backboard Bracket 30 1 203472 Spring, Black, Slam Jam 31 1 200318 Bracket, Reinforcement, Slam Jam 32 1 900033 Bracket, Slam Jam 33 2 200874 Spacer 0.402 I.D. x 0.50 O.D. x 1.5 Long 34 1 206990 Reinforcement Bracket 35 2* 206360 Bolt, Hex 3/8-16 x 2.625 Long 36 1 203796 T-Bolt, 3/8-16 x 5 Long 37 4 201642 Spacer 0.530 I.D. x 0.50 O.D. x 0.63 Long 38 1 203470 Washer, Flat, Slam Jam 39 6 206340 Nut 1/2-13 40 1 203795 Nut, Special 41 2 908173 Elevator Tube, Lower 42 2 904808 Elevator Tubes, Upper 43 6 206304 Bolt, Hex, 1/2-13 x 6-5/16 Long 44 1 204838 Spring, Elevator 45 1 204872 Label, Height Indicator 46 1 918153 Tube Assembly w/Handle, Adjustment, Outer 47 1 908174 Tube, Adjustment, Inner 48 2 201681 Spacer 0.563 I.D. x 0.88 Long

* YOU MAY HAVE EXTRA PARTS WITH THIS MODEL.

2/05 P/N 211017

* You may have extra parts with this model.

HARDWARE IDENTIFIER (BOLTS & PINS)

HARDWARE IDENTIFIER (NUTS & WASHERS)

Item #8 (1)

Item #12 (6)

Item #13 (2)

Item #15 (6)*

Item #16 (8)*

Item #9 (3)

Item #35 (2)*

Item #18 (1)

Item #43 (6)

Item #39 (6)

Item #40 (1)

Item #38 (1)

Item #11 (1)

Item #36 (1)

Item #28 (2)

+ 15 hidden pages