Huffy 21154006 User Manual

02/04 P/N 21154006

Toll-Free Customer Service Number for U.S: 1-800-558-5234,

For Canada: 1-800-284-8339,

For Europe: 00 800 555 85234 (Sweden: 009 555 85234),

For Australia: 1-800-333 061

Internet Address: http://www.huffysports.com

Backboard and Rim

Owners Manual

Customer Service Center

• N53 W24700 South Corporate Circle • Sussex, WI 53089 • U.S.A.

REQUIRED TOOLS AND

MATERIALS:

• Step Ladder 8 ft. (2.4 m)

• Adjustable Wrench

• Wrenches: 7/16”, 1/2”, 9/16”, 3/4”

READ AND UNDERSTAND OPERATOR'S MANUAL BEFORE USING THIS UNIT.

FAILURE TO FOLLOW OPERATING INSTRUCTIONS COULD RESULT IN INJURY OR DAMAGE TO PROPERTY.

WARNING!

P/N 21154006 02/04

BEFORE YOU START!

To ensure optimal playability of backboard system, a close tolerance fit between the elevator

components and hardware is required. Test fit large bolts into large holes of elevator tubes,

backboard brackets and triangle plates. Carefully rock them in a circular motion to ream out

any excess paint from holes if necessary.

AVANT DE COMMENCER !

Pour garantir l'utilisation optimale du panneau, les composants du système élévateur et la visserie doivent être bien

ajustés (serrés). À titre d'essai, insérez les gros boulons dans les gros trous des tubes du système élévateur, des supports

du panneau et des plaques triangulaires. Basculez-les avec précaution en imprimant un mouvement circulaire pour

éliminer l'excédent de peinture, si nécessaire.

¡ANTES DE COMENZAR!

Para asegurar el óptimo rendimiento del sistema del respaldo en el juego, se requiere un ajuste de tolerancia estrecha

entre los componentes del elevador y el herraje. Pruebe el ajuste de los pernos grandes en los orificios grandes de los

tubos elevadores, soportes del respaldo y placas triangulares. Cuidadosamente muévalos en círculos para eliminar

cualquier exceso de pintura, si es necesario.

VORBEREITENDE MASSNAHMEN

Um sicherzustellen, dass das Korbwandsystem optimal für den Spielbetrieb geeignet ist, müssen die Komponenten der

Verlängerungsvorrichtung und die verschiedenen Befestigungsteile fest miteinander verschraubt werden. Große Schrauben

zur Probe in die großen Löcher der Verlängerungsrohre, Korbwandklammern und Dreiecksplatte stecken und diese

vorsichtig in einer Kreisbewegung hin- und herbewegen, um eventuelle Farbrückstände aus den Bohrungen zu entfernen.

02/04 P/N 21154006

WARNING

FAILURE TO FOLLOW THESE WARNINGS MAY RESULT

IN SERIOUS INJURY AND/OR PROPERTY DAMAGE.

Owner must ensure that all players know and

follow these rules for safe operation of the unit.

In the U.S.: 1-800-558-5234 and Canada Only: 1-800-284-8339

In Australia: 1-800-632-792

206118 5/97

See instruction manual for proper installation and maintenance. Use caution when performing dunk type activities on this unit. Do not hang from any part of unit, including backboard, support braces, rim or net. Check unit before each use for loose hardware, excessive wear and signs of corrosion and repair before using. During play, use extreme caution to keep player's face away from the backboard, rim or net. Serious injury could occur if teeth/face come in contact with backboard, rim or net. During play, do not wear jewelry (rings, watches, necklaces, etc.) Objects may entangle in net.

SAFETY INSTRUCTIONS

Most injuries are caused by misuse and/or not following instructions.

Use caution when using this system.

• If using a ladder during assembly, use extreme caution.

• Two (2) people are recommended for this operation.

• Check base regularly for leakage. Slow leaks could cause system to tip over unexpectedly.

• Seat the pole sections properly (if applicable). Failure to do so could allow the pole sections to separate during play and/or transport of the system.

• Climate, corrosion or misuse could result in system failure.

• Minimum operational height is 6' 6" (1.98 m) to the bottom of backboard.

• This equipment is intended for home recreational use only and NOT excessive competitive play.

• Read and understand the warning label affixed to pole. Label is shown on page 1.

• The life of your basketball pole depends on many conditions. The climate, placement of the pole, the location of the pole, exposure to corrosives such as pesticides, herbicides or salts are all important.

• If technical assistance is required, contact Huffy Sports.

• Adult supervision is recommended when adjusting height.

FAILURE TO FOLLOW THESE SAFETY INSTRUCTIONS MAY RESULT IN

SERIOUS INJURY OR PROPERTY DAMAGE AND WILL VOID WARRANTY.

Owner must ensure that all players know and follow these rules for safe

operation of the system.

To ensure safety, do not attempt to assemble this system without following the instructions carefully. Proper and complete assembly, use and supervision is essential for proper operation and to reduce the risk of accident or injury. A high probability of serious injury exists if this system is not installed, maintained, and operated properly. Check entire box and inside all packing material for parts and/or additional instructional material. Before beginning assembly, read the instructions and identify parts using the hardware identifier and parts list in this document.

P/N 21154006 02/04

For more information on assembly, placement, proper use and maintenance, visit The American Basketball Council website at http://www.smarthoops.com.

IMPORTANT!

Remove all contents from boxes.

NOTICE TO ASSEMBLERS

ALL Huffy Sports Basketball Systems, including those used for DISPLAYS, MUST be assembled

and ballasted with sand or water according to instructions. Failure to follow instructions could

result in SERIOUS INJURY. It is NOT acceptable to devise a makeshift weight system.

WARRANTY CARD:

Please remember to complete your product registration form either on-line at: www.huffysports.com/warrantycard or mail-in the enclosed postcard.

02/04 P/N 21154006

Get to know the basic parts of your basketball system.....

BACKBOARD

FRONT

RIM

NET

P/N 21154006 02/04

Item Qty. Part No. Description

1 4 202341 “L” Bracket 2 2 200837 Spacer, Plastic 3 6 201107 Bolt, Hex Head, 1/4-20 x 1/2 Long 4 6 203326 Washer, Lock, 1/4 5 6 203228 Nut, 1/4-20 6 8 203100 Hex Flange Nut 5/16-18 7 4 203104 Bolt, Hex Flange, 5/16-18 x 2 Long 8 2 900964 Bracket, Backboard Support

9 2 206360 Bolt, Hex Head, 3/8-16 x 2.625 Long 10 2 200874 Spacer, Steel .402 I.D. x .50 O.D. x 1.5 Long 11 2 201124 Nut, 3/8-16

Item Qty. Part No. Description

12 1 Rim 13 12 201219 Clip, Net Holder, Smart Clips 14 1 Net 15 4 205528 Bolt, Hex Flange, 5/16-18 x 1 Long 16 8 203309 Washer, Flat 17 4 202862 Spacer, Plastic,1.19" Long 18 2 201640 Bolt, Hex, 1/2-13 X 7.25 Long 19 2 206340 Lock Nut, Nylon Insert, 1/2-13

Item #13 (12*)

Item #3 (6)

Item #5 (6)

Item #6 (8)

Item #11 (2)

Item #15 (4)

Item #16 (8)

Item #4 (6)

Item #10 (2)

Item #7 (4)

Item #9 (2)

HARDWARE IDENTIFIER (BOLTS)

HARDWARE IDENTIFIER (NUTS & WASHERS)

HARDWARE IDENTIFIER (STEEL SPACERS)

HARDWARE IDENTIFIER (PLASTIC SPACERS & CLIPS)

PARTS LIST (See Hardware Identifiers)

Item #18 (2)

Item #19 (2)

Item #17 (4)

+ 12 hidden pages