Thank you for your purchase of this Hotchkis Performance product. Your stabilizer bar set was
designed with the performance and durability you’ve come to expect from Hotchkis Performance.
Rear Sway Bar Installation:
1R. Jack up the vehicle and properly support with jack stands or lift jacks. Make sure the rear end
is supported with the vehicle’s load on the leaf springs. This is to ensure yo u i nstall the rear
bar in the proper position.
2R. Take the bushings and grease the inner surface with the included white silicon grease.
3R. Install the bushings on the ba r . (5) Place the bracket over top of the bushing. (6)
2236 GM F-Body Stabilizer Bar Installation Instructions Page 1 of 16
2236 GM F-Body Stabilizer Bar Installation Instructions Page 2 of 16
4R. Take the sway bar assembly and hold it up under the rear end of the car. The arms will point
forward and the dog bone end links point up. Check for exhaust clearance in this area. You
may have to have the exhaust pipes re-bent to provide clearance for the new sway bar
assembly. Any competent exhaust shop can handle this modification easily.
5R. After you determine there’s enough clearance for the bar, note the a pproximate location o f the
sway bar axle bushing.
6R Take a screwdriver and ca r efully pry up the brake line to allow the U-Bolt to drop down over
the axle. (10)
7R Install the U-Bolts on the axle and slip the axle bracket over the U-Bolt on the bottom side of
the axle. Use masking or duct tape to secure them. Place the sway bar assembly under the
axle and slip the U-bolt legs t hr ough the sway bar bracket s. Place washers and nylock nuts on
the U-Bolt. Snugly fasten the nylock nuts a bit , but do not fully tight en at this time.
2236 GM F-Body Stabilizer Bar Installation Instructions Page 3 of 16
2236 GM F-Body Stabilizer Bar Installation Instructions Page 4 of 16
8R
Undo Frame Rail Lines
We are going to be mounting the dog bone endlinks to the frame rails. However, we first
need to access the side of the frame rails. We will need to undo the fuel/brake lines that are
mounted to the rails.
The driver side has a brake line and vent line that is mounted to the frame rail. Undo the line
tabs as shown in the picture below.
2236 GM F-Body Stabilizer Bar Installation Instructions Page 5 of 16
The passenger side has the fuel line mounted to the frame rail. Undo the line tabs as shown
in the picture below.
2236 GM F-Body Stabilizer Bar Installation Instructions Page 6 of 16
9R
Install Frame Rail Reinforcements
We will be installing reinforcement p l ates onto the frame rails. This will require drilling two ¾”
holes for through each frame rail.
Start on the passenger side fra m e rail. The hole that was used to hole the line tab is in the
same position as one of your holes. (see picture) Use one o f the reinforcement pl ates as a
template to mark out the other hole.
2236 GM F-Body Stabilizer Bar Installation Instructions Page 7 of 16
Drill out the ¾” hole only on the inner side of the frame rail. Do not drill through both walls o f
the frame rail. We found that a unibit works best.
2236 GM F-Body Stabilizer Bar Installation Instructions Page 8 of 16
Insert the reinforcement plate with the 2 tubes welded to it into the frame rail. Use a vise
clamp to secure the plate onto the frame rail. Drill t he outer wall of the frame rail wi th a ½”
drill bit. The reinforcement t ubes will act as a guide for you to drill. So when you are finished,
you will have two ¾” holes on t he inside of the frame rail and two ½” holes on the outer
sided of the frame rail.
2236 GM F-Body Stabilizer Bar Installation Instructions Page 9 of 16
Remove the vise clamp and insert 1 short bolt w/ washer and 1 long bolt w/ washer from the
outside of the frame rail. ( hardware kit #1757) Make sure to add the other reinforcement
plate to the outside before you insert the bolts through the frame.
2236 GM F-Body Stabilizer Bar Installation Instructions Page 10 of 16
Install a washer and a nut to the top (shorter) bolt. Do not fully tight en this bolt at this time.
(hardware kit #1757)
2236 GM F-Body Stabilizer Bar Installation Instructions Page 11 of 16
Grease up your new dog bone end links with the provided grease. Install the dog bone on the
bottom (longer bolt) with the grease fittings pointing rearward.
Install the line bracket onto the long bolt and inst all a washer and nut. Do not fully tighten at
this time. (hardware kit #1757)
2236 GM F-Body Stabilizer Bar Installation Instructions Page 12 of 16
Line up the mounting tab w ith the line bracket you just insta l led. Use the provided 5/16” bolt
and washer to secure the mounting tab to the line bracket. (hardware kit #1757) M ake sure
the ½” Nut is not too close to the fuel line.
2236 GM F-Body Stabilizer Bar Installation Instructions Page 13 of 16
Fully tighten both short and long bolts completely.
You’re given new hardware for a ttaching the dog bone end l inks to the sway bar. Use the
bolts, nuts, and washers from the #T1712 hardware kit.
2236 GM F-Body Stabilizer Bar Installation Instructions Page 14 of 16
Once the passenger side is completely mounted together, you can now figure out where the
other frame rail reinforcement plate goes on the driver side. Mock up the driver side dog bone
end link onto the sway bar and mark where the bottom hole should be. Again, use the
reinforcement plate as guide t o mark the upper hole. Drill the hol es in the same manner as
before.
You can remove the mounting tabs that are no longer in use.
2236 GM F-Body Stabilizer Bar Installation Instructions Page 15 of 16
10R
Double Check all Hardware
Double check and make sure all hardware is full tightened before driving the vehicle. You are
finished with the rear sway bar kit.
2236 GM F-Body Stabilizer Bar Installation Instructions Page 16 of 16
Hotchkis Performance LLC
Return Policy & Limited Warranty
Effective December 1, 2010 all Hotchkis products must be register ed t o qualify for warranty at
www.hotchkis.net or via the mail-in warranty card, included with the product, within 30 days of the original
purchase date.
IMPORTANT: This warranty supersedes all other warranties included with this product.
Return Policy
We want you to be completely satisfied with your Hotchkis Performance product. For products, presenting signs
of shipping damage please contact the freight carrier immediately. All our products are guaranteed to be free
from manufacturer’s defects. If your order arrives with a manufacture defect, please contact our Customer
Service Departmen t at (562) 907-7757. You will be assigned a Returned Goods Authorization Number (RGA). The
package you return must show the RGA on the outside of the package, include the original invoice and be
shipped prepaid to our facility. The product has to be unused and in its original packaging materials. Exchanges
or refunds made after 30 days will be subject to a 20% restocking charge. If you purchased your Hotchkis
Performance product f rom an authorized dealer, you are still covered by this return policy. All returns however, should be
made to your dealer, not to Hotchkis Performance directly.
Limited Warranty
Hotchkis Performance offers a Limited Warranty against defects in materials and workmanship for the term of 36
months (3 years) fr o m th e date of purchase of this product. This Warranty only applies to the original retail
purchaser who retains ownership of the vehicle on which the product was origina lly installed. If th e product is
determined to be defective, Hotchkis Performance will repair, replace or refund the purchase pric e of the
defective product at Hotchkis Performance's s o le discretion, which shall fully satisfy and discharge any and all
warranty claims. Any re p aired or replaced product will be returned to the sender excluding the cost of freight.
Products must be registered to qualify for warranty at www.hotchkis.net or via the mail-in warranty card, included with the
product, within 30 days of the original purchase date.
Exclusions from Warranty
Items offered but not manufactured by Hotchkis Performance are warranted according to the manufacturer's
terms and are not covered by this limited warranty. Hotchkis Performance shall not be responsible for any labor,
removal, installation, re-installation or maintenance costs. This warranty does not cover the cosmetic finish or
plating of any product or any normal wear and tear to any product including, but not limited to bushings,
brackets, end-links, hardware, st eering comp onent s, shocks or spr ings. In addition, this warranty does not apply
to any products that have been:
Improperly installed or installed by someone other than a qualified, licensed auto mechanic experienced in
the installation and removal of suspension products;
Improperly serviced, misused, or modified, altered or subjected to abuse, n egligence, accident o r collision;
Installed in any veh icle that has been modified;
Installed on any vehicle that has carried loads in excess of au to m o b ile manufacturer suggested weight limits;
or
Installed on any vehicle that has been subject to abnormal or excessive use, including ral lying, racing, or
racing-type activities or off-road use.
Limitation of Warranty
This limited warranty is the entire and only warranty for the products and may not be modified or supplemented
by any other person or company in any form. Any description of the products, by anyone, is for the sole purpose
of identifying them and is not part of the basis of the bargain, and does not constitute a warranty that the
products will conform to that description. The statements of any salesperson do not constitute part of this
limited warranty and cannot be relied upon as a war ranty.
THERE ARE NO W ARRANTIES, EXPRESSED O R IMPLIED, INCLUDING ANY I MPLIED WARRANTI ES OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, WHICH EXTEND BEYOND THE
DESCRIPTION ON THE FACE HEREOF. ANY IMPLIED WARRANTIES ARE DISCLAIMED TO THE
FULLEST EXTENT PERMITTED BY LAW. THIS WARRANTY DOES NOT COVER CONSEQUENTIAL
2236 GM F-Body Stabilizer Bar Installation Instructions Page 17 of 16
Loading...
+ hidden pages
You need points to download manuals.
1 point = 1 manual.
You can buy points or you can get point for every manual you upload.