Honda Power Equipment EG3500X User Manual

Thank you for purchasing a Honda generator. This manual covers operation

All information in this publication is based on the latest product information available at the time of approval for printing.

Honda Motor Co., Ltd. reserves the right to make changes at any time without notice

and without incurring any obligation.

No part of this publication may be reproduced .without written permission.

This manual should be considered a permanent part of the generator and remain with the generator when sold.

Pay special attention to statements preceded by the following words:

if instructions are not followed. CAUTION: Indicates a possibility of personal injury or equlpment damage if

inetructions am not followed.

NOTE: Gives helpful information.

If a problem should arise, or if you have any questions about the generator, consult an authorized Honda dealer.

m The Honda generator is designed to give safe and dependable service lf operated according to instructions. Read and understand the Owner’s Manual beforc operating the generator. Failure to do so could result in personal injury or equipmen damage.

Indicates a strong possibility of severe personal injury or loss of life

and

maintenance of the EG3500X generators.

CONTENTS

1. CAUTION LABEL LOCATION..

2. GENERATOR SAFETY..

3. COMPONENT IIJENTIFICATION..

4. PRE-OPERATION CHECK..

5. STARTING THE ENGINE

6. GENERATOR USE

7. STOPPING THE ENGINE.. .................................................................... 17

9 High altitude operation .....................................................................

8. MAINTENANCE .................................................................................... 19

9. TRANSPORTING/STORAGE.. .............................................................. 27

10. TROUBLESHOOTING.. 1 1. SPECIFICATIONS..

12. WIRING DIAGRAM ............................................................................... 32

13. WARRANTY SERVICE

........................................................................

.................................................................................

.........................................................................

...............................................................................

..........................................................................

............................................................

........................................................

...................................................................

......................................................................

3 5 6

6 11 14

29 31

1. CAUTION LABEL LOCATION

HONDA MOTOR CO., LTD.

MADE IN JAPAN Q

mCnfCK fOR SPItlEO

SIOP fnGlYt

flttl OR fUtL LtAKS.

BIfORf RfflMN6

lCONlROrol OUll IYI A NI fUlli All

f.SSfNCf

ARRflfR Lf MOIfUR

AVAYl

Of ROARf Lf PLIIW.

~INSPWIUNAR PARA COMBUSllBLf OOlRAYADO

2. GENERATOR SAFETY

To ensure safe operation -

Place the generator at least lm (3 ft) away from buildings or other equipment

when operating the generator.

Operate the generator on a level surface. If the generator is tilted, fuel spillage may result.

Exhaust gas contains poisonous carbon monoxide. Never run the generator in an enclosed area. Be sure to provide adequate ventilation;

Know how to stop the generator quickly and understand operation of all the controls. Never permit anyone to operate the generator without proper instrutions.

Keep children and pats away from the generator when it is in operation.

Keep away from rotating parts while the generator is running.

0 The generator is a potential

with wet hands.

Do not operate the generator in rain or snow and do not let it get wet.

source of electrical shbcks when misuad; do not operat

3. COMPONENT IDENTIFICATION

FUEL

VALVE

CARBUR DRAlN S

OIL ALERT

CHOKE LEVER

SEDkENt CUP

RECOIL STARTER GRIP

LAMP

ENGINE SWITCH

VOLTAGE SELECTOR SWITCH

AC CIRCUIT BREAKER

ENGINE

AC RECEPTACLER

OIL-FILLER CAP

ENG‘INE OIL DRAIN PLUG

GROUND TERMINAL

GASOLINE FILLER CAP

AIR CLEANER

RK PLUG

4. BRE-OPERATION CHECK

ENGINE OIL

CAUTION :

Engine oil is a major factor affecting engine performance and service lie. Non-detergent oils and vegetable oils are not recommended.

Be sure to check the engine on a level surface with the angina stopped.

Use Honda 4-stroke oil, or an equivalent high detergent premium quality motor oil certified to meet or exceed U.S. auto-mobile manufacturer’s requirements for Service Classification SE or SF. (Motor oils classified SE or SF will show this designation on the container.) SAE low-40 is recommended for general all-temperature use. shown in the chart may be used when the everage temperature in your area is within

the indicated range.

1. Remove the oil filler cap and wipe the dipstick clean.

2. Insert the dipstick into the oil filler neck, but do not screw it in.

3. If the level is low, fill to the top of the oil filler neck with the recommended oil. CAUTION : Running the angina with insufficient oil can cause serious angina damage.

Other viscosities

FILLER HOLE

CAP

-50

-20

Ambient temperature

1 1

-10

10 20

30 40%

FUEL Use any regular grade automotive gasoline (unleaded gasoline is preferred) with a

pump octane rating of 88 or higher. Never use an oil/gasoline mixture or dirty gasoline.

Avoid getting dirt, dust or water

in the fuel tank. CAUTION : Gasoline substitutes are not recommended ; they may be harmful to the

fuel system components.

Gasoline is extremely flammable and explosive under certain conditions. Refuel in a well ventilated area with the engine stopped.

Do not smoke or allow flames or sparks in the area where the engine is refueled or where gasoline is stored.

Do not overfill the tank and make sure the filler cap is securely closed after refueling.

Be careful not to spill fuel when refueling.

Fuel vapor or spilled fuel may ignite.

If any fuel is spilled, make sure the area is dry before starting the engine.

Fuel tank capacity : 6.0 lit. (12.7 US pt. 10.6 Imp pt)

1. Check the fuel level.

2. If level is low, fill to the shoulder of the fuel filter.

FUEL FILLER CAP

FUEL FILTER

GASOLINES CONTAINING ALCOHOL If you decide to use a gasoline containing alcohol (“gasohol”), be sure the octane

rating is at feast as high as that recommended by Honda. There are two types of “gasohol” : that containing ethanol, and that containing methanol.

Do not use gasohol that contains more than 10% ethanol. Do not use gasoline containing methanol (methyl or wood alcohol) that does not also contain cosolvents and corrosion inhibitors for methanol. Never use gasoline containing more than 5% methanol, even if it has cosolvents and corrosion inhibitors.

NOTE :

Fuel system damage or engine performance problems resulting from the use of such fuels are not covered under Power Equipment Warranties. Honda cannot endorse the use of fuels containing methanol since evidence of their suitability is as yet incomplete.

Before purchasing fuel from an unfamiliar station, try to confirm whether the fuel

contains alcohol, and to what percentage. If you notice any undesirable operating symptoms after using a gasoline that contains alcohol ; or one that you think contains alcohol, switch to a gasoline that you know does not contain alcohol.

+ 28 hidden pages