Honda Power Equipment EB5000X User Manual
The generator is a potential source
misused.
the generator get wet, and
Do
not expose the generator to moisture, rain or snow.
of
do
not operate it with wet hands.
electrical shock
Do
not let
if
Thank you for purchasing a Honda generator.
This manual covers operation and maintenance
All
information
available at the time of approval for printing.
Honda Motor
without notice and without incurring any obligation.
No part of this publication may be reproduced without written permission.
This manual should be considered a permanent part
remain
Pay special attention to statements preceded by the following words:
ADANGER: Indicates severe personal injury or
structions are not followed.
i.f
CAUTION:
if instructions are not followed.
NOTE: Gives helpful information.
If
consult
with
instructions are not followed.
a
problem should arise, or if
an
in
this publication is based on the latest product information
Co.,
Ltd. reserves the right to make changes
the generator when sold.
Indicates a strong possibility of severe personal injury or death
Indicates a possibility of personal injury or equipment damage
you
have any questions about the generator,
authorized Honda dealer.
of
the EB5000X generator.
at
any time
of
the generator and
death
will result
if
in-
The Honda generator is designed to give safe and dependable
if
service
Owner's Manual
result
operated according to instructions. Read and understand the
in
personal
before operating the generator. Failure to do
injury or equipment damage.
so
could
I
I.
GENERATOR
SAFETY
Place the generator on a firm. level surface: avoid loose sand or snow.
the generator is tilted or overturned, ,fuel spillage may result.
generator is overturned or sinks
may enter the generator.
To
prevent fire hazards and to provide adequate ventilation, keep the
generator at least ?'meter
ment during operation.
generator.
Know
of
without proper instructions.
The generator is a potential source of electrical shock
not expose the generator to moisture, rain or snow.
generator get we.t, and
Do
away Grorn the area of operation.
Gasoline is extremely flammable and is explosive under certain conditions.
refueled or where gasoline is stored. Refuel
with
Exhaust gas contains poisonous carbon monoxide. Avoid inhalation of
exhaust gasses. Never run the engine
area.
The rnuffler becomes very hot during operation and remains hot for
while after stopping the engine. Be careful not to touch the rnuffler
while
Connections ,for standby power to a building's electrical system tnust
be made by a qualified electrician and must comply
laws and electrical codes. Improper connections can allow electrical
current from the generator to backfeed into the utility lines. Such
backfeed may electrocute utility company workers
tact the lines during a power outage, and when utility power is restored,
the generator may explode, burn, or cause fires
trical system.
how
to
stop the generator quickly, and understand .the operation
all the controls. Newer permit anyone to operate the generator
not allow children to operate the generator. Keep children and pets
DQ
not smoke or allow flames or sparks where the generator
the engine stopped.
it
is hot. Let the engine cool before storing the generator indoors.
Do
do
into
a soft surjace, sand, dirt, or water
(3
feet) away from buildings and other equip-
not place flammable objects Close to the
not operate
it
with
wet hands.
in
a well-ventilated area
in
a
closed garage or confined
with
or
in
the building's elec-
Also,
if
misused.
Do
not
all applicable
others who
If
if the
Do
let the
is
a
con-
3
RNlNG
DO NOT USE INDOORS. EXHAUST GAS CONTAINS
POISONOUS CARBON MONOXIDE.
NE PAS UTlLlSER DANS UN ENDROIT FERME
A
CAUSE
DU RISQUE D'EMPOISONNEMENT DU GAZ.
NO LO USE EN LUGARES CERRADOS PORQUE EL
MONOXIDE DE CARBON0 ES VENENOSO.
BCHECK
FOR
STOP ENGINE BEFORE REFUELING
~COHTROLER
REPANOUE
ARRETER LE
llNSPECClONAR PARA COMBUSTIBLE DERRAMADO
0
SPILLED FUEL
au'lt
SUR
MOlEUR
ESCAPE
PARAR MOTOR ANTES OE ECHAA
OR
FUEL LEAKS
N'Y
A
HI
FUITE
L'APP4REIL
AVANT DE REFAIRE LE PLEIN.
NI
+
ESSENCE
4
EB5000X
HONDA
MOTOR
CO.,
LTD.
MADE
IN
JAPAN
B'
WITH
RECOMMENDED
BEFORE USING.
SEE THE OWNER'S MANUAL. PHASE
OIL
FREQUENCY
RATED OUTPUT 4.5kVA
120f240V
5
2.
COMPONENT IDENTIFICATIOIU
VOLTAGE SELECTOR
FUEL
VALVE
OIL ALERT
I
RECOIL STARTER
GRIP
""'i""
\
ENGINE OIL DRAIN PLUG
AC CIRCUIT BREAKER
6
FUEL FILLER
CAP
7
I
MUFFLER
\'
SPARK
PLUG
CAP
7
3.
PRE-OPERATION
CHECK
Engine Oil
CAUTION:
Engine oil is a major factor affecting engine performance and service life.
Non-detergent and 2-stroke engine
oils
are not recommended.
Check the generator on a level surface with the engine stopped.
Use Honda 4-stroke oil, or an
equivalent high detergent, premium
quality motor oil certified to meet
exceed
U.S.
automobile manufac-
or
turer’s requirements for Service
Classification
oils classified
SG,
SF/CC, CD. Motor
SG,
SF/CC,
CD
will
show this designation on the container.
SAE
IOW-30
general, all-temperature use. Other
viscosities shown
is recommended for
in
the chart may
7
-30
,
4
-20
-10
0
Ambient temperature
I
,
I
10
20
30
be used when the average tempera-
in
ture
your area is
within
the indi-
cated range.
1.
Remove the oil filler cap and wipe the dipstick clean.
2.
Check the oil level
it
screwing
3.
If the level is low, add the recommended oil to the upper mark on the
in.
by
inserting the dipstick
in
the filler neck without
dipstick.
I
40°C
NOTE:
The Oil Alert System
oil level falls below the safe
an unexpected shutdown,
regularly.
OIL FILLER
CAP
\
OIL FILLER
HOLE
8
will
automatically stop the engine before the
limit.
However, to avoid the inconvenience of
it
is advisable to visually inspect the oil level
LEVEL
Fuel
Remove the filler cap and check the fuel level. Refill the tank
level is low.
Your engine is designed to use any gasoline that has a pump octane
number
91
or higher. Gasoline pumps at service station normally display
Do not fill above the
R+M
(7)
of
86
or higher, or that has a research octane number of
UPPER
LEVEL
line.
if
the fuel
the
pump
octane number.
it
We recommend that you use unleaded fuel because
produces fewer
engine and spark plug deposits and extends the life of exhaust system
components.
Never use stale or contaminated gasoline or an oil/gasoline mixture. Avoid
in
the
fuel
getting dirt, dust or water
can cause persistent "pinging"
tank. Use of a lower octane gasoline
or
heavy "spark knock" (a metallic
rapping noise) which, if severe, can lead to engine damage.
CAUTION:
speed under normal load, change brands
pinging persists, consult your authorized Honda dealer. Failure
If
"spark knock" or "pinging" occurs at a steady engine
of
gasoline.
If
spark knock or
to
do
so
is
considered misuse, and damage caused by misuse is not covered by
Honda's Limited Warranty.
Occasionally you may experience light spark knock
it
heavy loads. This is no cause for concern,
simply means your engine
while
operating under
is
operating efficiently.
Fuel tank capacity:
17.0
lit.
(4.5
us gal)
FUEL
FILLER
CAP
FUEL
UPPER
LEVEL
STRAINER
LINE
9
Gasoline is extremely flammable and is explosive under certain
conditions.
0
Refuel
or allow flames
where gasoline is stored.
Do
After refueling, make sure the tank cap is closed properly and securely.
Be careful not to spill fuel when refueling. Spilled fuel or fuel vapor
ignite. If any fuel is spilled, make sure the area is dry before starting the
engine.
Avoid repeated or prolonged contact
KEEP
in
a well-ventilated area
or
sparks
not overfill the fuel tank (there should be no fuel
OUT
OF
REACH
OF
with
the engine stopped.
in
the area where the engine
with
skin or breathing of vapor.
CHILDREN.
Do
not smoke
is
refueled or
in
the filler neck).
may
GASOLINES CONTAINING ALCOHOL
If
you decide to use a gasoline containing alcohol (gasohol), be sure it's
octane rating is at least as high as that recommended by Honda. There are
two types of "gasohol": one containing ethanol, and the other containing
Do
methanol.
not use gasoline containing methanol (methyl or wood alcohol) that does
not also contain cosolvents and corrosion inhibitors for methanol. Never
use gasoline containing more than
and corrosion inhibitors.
NOTE:
Fuel system damage or engine performance problems resulting from the
use of fuels that contain alcohol is not covered under the warranty.
Honda cannot endorse the use of fuels containing methanol since
evidence of their suitability is as yet incomplete.
Before buying fuel from an unfamiliar station, try to find out if the fuel
contains alcohol,
used. If you notice any undesirable operating symptoms while using a
gasoline that contains alcohol,
switch to a gasoline that you know does not contain alcohol.
not use gasohol that contains more than
5% methanol, even if
if
it
does, confirm the type and percentage of alcohol
or
one that you think contains alcohol,
10%
ethanol.
it
has cosolvents
Do
IO
Air Cleaner
~~
Check the air
Clean or replace the element
cleaner
element
to
be sure
if
necessary (page
it
is
clean and
25).
in
good
condition.
CAUTION: Never run the engine without the air cleaner, Rapid engine wear
will result.
AIR
CLEANER
ELEMENT
Loading...