Homecrest CF-12, CF-1224, NF-719, NF-16, CF-20 User Manual

2018 CRYSTAL FIRE

FIRE TABLE MANUAL

MADE IN THE USA

DANGER

DANGER

WARNING

DANGER

USER MANUAL FOR:

DANGER

DANGER

CF-12 (LP & NG), CF-1224 (LP & NG) and CF-20 (LP & NG)

GAS-FIRED

Installation and service of this appliance should be performed by qualied personnel.

Homecrest Outdoor Living suggests NFI certied, factory-professionals, or technicians

supervised by an NFI certied professional.

CAUTION

DO NOT DISCARD THIS MANUAL.

• Important operating and maintenance instructions included.

• Read, understand, and follow these instructions for safe installation and operation.

WARNING

IF THE INFORMATION IN THESE INSTRUCTIONS IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING

PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.

• Do not store gasoline or other ammable vapors or liquids in the vicinity of this or any other appliance.

• What to do if you smell gas:

• Do not try to light any appliance.

• Do not touch any electrical switch. Do not use any phone in your building.

• Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the re department.

• Installation and service must be performed by a qualied installer, ser vice agency, or the gas supplier.

WARNING

HOT! DO NOT TOUCH. SEVERE BURNS MAY RESULT. CLOTHING IGNITION MAY RESULT.

Glass and other surfaces are hot during operation and cool-down.

• Keep children away.

• CAREFULLY SUPERVISE children near this appliance.

• Alert children and adults to hazards of high temperatures.

• Keep clothing, furniture, draperies, and other combustibles away.

• Installation and service must be performed by a qualied installer, ser vice agency, or the gas supplier.

WARNING

Improper installation, adjustment, alteration, service, or maintenance can cause injury or proper ty damage. Read the installation

and maintenance instructions thoroughly before installing or servicing this equipment.

WARNING

For outdoor use only. It is imperative the burner be kept clean.

2 | www.homecrest.com

42W4

Model: All Crystal Fires

Gas, Propane Gas

Eagan, MN 55122

WARNING: Must Not Be Used For Cooking.

WARNING: Improper installation, adjustment, alteration, service

agency or the gas supplier.

CF-UL Rev B 7-28-2014

READ THIS MANUAL BEFORE INSTALLING OR OPERATING THIS APPLIANCE.

PLEASE RETAIN THIS OWNER’S MANUAL FOR FUTURE REFERENCE.

Congratulations

Congratulations on selecting a Homecrest Outdoor Living decorative gas appliance. The Crystal Fire you have selected is designed

to provide the utmost in safety, reliability, and efciency.

As the owner of a Crystal Fire, you’ll want to read and carefully follow all of the instructions contained in this owner’s manual. Pay

special attention to all cautions and warnings.

This owner’s manual should be retained for future reference. We suggest you keep it with other important documents and product

manuals.

This information contained in this owner’s manual, unless noted otherwise, applies to all models and gas control systems.

Your new Crystal Fire will give you years of durable use and trouble-free enjoyment.

Homeowner Reference Information

We recommend that you record the following

pertinent information about your appliance.

Model Name:_____________________________________________ Date of Purchase/Installation:____________________________

Serial Number:____________________________________________ Location on Appliance:___________________________________

Dealer Purchased From:____________________________________ Dealer Phone:__________________________________________

Notes:__________________________________________________________________________________________________________

________________________________________________________________________________________________________________

________________________________________________________________________________________________________________

LISTING LABEL INFORMATION/LOCATION:

The model information regarding your specic appliance can be found on the rating plate attached to your burner via a metal chain.

See the sample rating plate below for locations of specications.

The Outdoor GreatRoom Company
2015 Silver Bell Road, #195

MFG. DATE XX/XX SERIAL # XXXX DATE DE FAB. XX/XX

Orifice Size Max input BTU

Model

LP NG LP NG

·CF-20
#43 #31 55331 51706

·NF-16

·CF-1224
#43 #31 55331 51706

·NF-719

·CF-2424
#36 #17 79229 107465

·NF-1919

·CF-1242
#31 #21 100588 90776

·NF-737

·CF-1264 #31 #21 100588 90776

·CF-12120 #31(2) #21(2) 100588 (per half) 90776 (per half)

MODEL

FUEL TYPE

ORIFICE SIZE

SERIAL NO.

DECORATIVE OUTDOOR
GAS-FIRED FIREPLACE

ANSI Z21.97-2014 and CSA 2.41­2014 for Canada. Installation must
conform with local codes or in the
absence of local codes, ANSI
Z223.1 * NFPA 54 National Fuel
Gas Code – Natural gas and
propane installation code, CSA
B149.1 – or propane storage and
handling code CSA B149.2

Type of Gas: Natural

WARNING: For Outdoor Use Only. If stored indoors, detach and leave cylinder
outdoors.
MINIMUM CLEARANCES: Top: 6 Ft. (72”) Sides: 2 Ft. (24”) Boom: 8 In.
Minimum clearance from sides and back of unit to adjacent combusble
construcon below top of unit is 8 inches from sides and 8 inches from back.
Minimum horizontal clearance from sides and back of unit to adjacent vercal
combusble construcon extending above top of unit is 24 inches from sides and 24
inches from back.

or maintenance can cause injury or property damage. Refer to the
owner’s information manual provided with this appliance. For
assistance or additional information consult a qualified installer, service

Fire Table Manual | 3

4 | www.homecrest.com

TABLE OF CONTENTS

1: LISTING & CODE APPROVALS

Appliance Certication ............................................. 6

BTU Specications ..................................................6

2: GETTING STARTED

Tools & Supplies Required .......................................7

Inspect the Appliance & Components .......................7

3: SETTING UP THE BURNER

Burner Assembly ..................................................... 8

Glass Installation .................................................... 8

4: GAS HOOK-UP INFORMATION

Fuel........................................................................9

Gas Pressure ..........................................................9

Gas Connection ......................................................9

LP Gas Supply .......................................................11

5: LIGHTING & OPERATION

Lighting & Operation ..............................................12

6: TROUBLESHOOTING

Troubleshooting .....................................................14

7: SERVICE & MAINTENANCE

Service & Maintenance ..........................................15

8: REFERENCE MATERIALS

Service Parts List .................................................. 16

9: FIRE TABLE ACCESSORIES

Fire Table Accessories ........................................... 17

10: WARRANTY

Homecrest Limited Warranties................................18

WHAT IS INCLUDED...

CF-12

• Round Burner Assembly

• Black Propane Hose with Regulator

• Flexible Metal Gas Line

• #55 Orice (LP Gas)

• #49 Orice (Natural Gas)

• 1 Bag of Decorative Fire Glass

• Key Valve

• Key

CF-1224/NF-719

• Rectangular Burner Assembly

• Black Propane Hose with Regulator

• Flexible Metal Gas Line

• #43 Orice (LP Gas)

• #31 Orice (Natural Gas)

• 2 Bags of Decorative Fire Glass

• Key Valve

• Key

CF-20/NF-16

• Round Burner Assembly

• Black Propane Hose with Regulator

• Flexible Metal Gas Line

• #43 Orice (LP Gas)

• #31 Orice (Natural Gas)

• 2 Bags of Decorative Fire Glass

• Key Valve

• Key

Fire Table Manual | 5

1 LISTING & CODE APPROVALS

A. APPLIANCE CERTIFICATION

MODEL: CRYSTAL FIRE CF-12, CF-1224 and CF-20

LABORATORY: Underwriters Laboratories, Inc. (UL)

TYPE: Decorative Gas-Fired Outdoor Fireplace

STANDARD: Out Decorative Gas Appliances ANSI Z21.97-2014 * CSA 2.41-2014

The Crystal Fire has been tested in accordance with ANSI Z21.97-2014 and CSA 2.41-2014 for Canada and has been listed by

Underwriters Laboratory (UL) for installation and operation as described in these installation and operating instructions.

The installation must conform with local codes or, in the absence of local codes, ANSI Z223.1 * NFPA 54 National fuel gas code –

Natural gas and propane installation code, CSA B149.1 – or propane storage and handling code, CSA B149.2.

B. BTU SPECIFICATIONS

ORIFICE SIZE MAX INPUT (BTU)

MODEL

LP GAS NATURAL GAS LP GAS NATURAL GAS

CF-12 #55 #49 20000 19500

CF-1224

NF-719

CF-20

NF-16

#43 #31 55331 51706

#43 #31 55331 51706

6 | www.homecrest.com