Hitachi С29-TF641S, С29-TF641SN, С29-TF641ST, С29-TF641SNT, С29-TF651S Service Manual

…

HITACHI

HCPT

C29-TF641S/SN/ST/SNT C29-TF651S/SN/ST/SNT

T1-003

SERVICE MANUAL

C29-TF751S/SN/ST/SNT

T1 Chassis

CAUTION :

CONTENTS

SAFETY PRECAUTIONS ...………………...…………….…………………………………………… PRODUCT SAFETY NOTICE …………...…………….………...……………...…………….……… REMOTE CONTROL UNIT ……………..………...…………….…………………………………… GENERAL OPERATIONS GUIDE .………………...…………….……………………………………

Before servicing this chassis, it is important that the service techician reads the " Safety Precaution "

and " Product Safety Notices " in this Service Manual.

2

3

4

CIRCUIT DESCRIPTION …………...…………….…………………………………………………… ADJUSTMENT INSTRUCTIONS ……………………...…………….………………………………… REPLACEMENT PARTS LIST …………………...…………….………………………………………

SPECIFICATIONS AND PARTS ARE SUBJECT TO CHANGE FOR IMPROVEMENT.

COLOR TELEVISION

5

6

12

MARCH 2005 Hitachi Consumer Products ( THAILAND ) , Ltd.

SAFTY PRECAUTIONS

WARNING: The following precautions should be

opserved.

1. Do not install , remove, or handle the picture tube in could produce X-radiation moderately in excess of de any manner unless shatter proof goggles are worn. sign levels. The high voltage must not, under any cir People not so equipped should be kept away while cumstances, exceed 34kV on the chassis. picture tubes are handled. Keep picture tube away from the body while handing.

2. When service is required, an isolation transformer receiver is the picture tube. The tube utilized for the should be inserted between power line and the above mentioned function in this chassis is specially receiver before any service is performed on the constructed to limit X - radiatuion. chassis. For continued X-radiation protection, replace tube with

3. When replacing the chassis in the cabinet,ensure all the protective devices are put back in place,such as barriers, non - metallic knobs, adjustment or compartment covers or shields, isolation resistors/ Many electrical and mechanical parts in HITACHI capacitors, etc. television receiver have special safety related

4. When service is required, observe the original lead evident from visual inspection, nor can be protection dressing. Extra precaution should be taken to afforded by them necessarily be obtained by using

assure correct lead dressing in the high voltage

circuitry area. Particularly note the R. G. B. lead wattage, etc. Replacement parts which have these dressing. Ensure they are dressed well away from special safety characteristics are identified by marking the horizontal scan and F.B.T. circuitry. with a on the schematics and replacement

5. Always use the manufacturer ' s replacement component. Always replace original spacers and safety characteristics as the HITACHI recommended maintain lead lengths. Especially critical components replacement one, shown in the parts list in this Service are indicated thus on the parts list and Manual, may create electrical shock, fire, X - radiation, should not be replaced by other makes. Furthermore, where a short circuit has occurred, replace those components that indicate evidence of Product Safety is continuously under review and new overheating. instructions are issued from time to time. For the latest

6. Before returning a serviced receiver to the customer, Manual. A subscription to ,or additional copies of the service technician must thoroughly test the unit HITACHI Service Manuals may be obtained at a nominal to be certain that it is completely safe to operate charge from your HITACHI sales offices. without danger of electrical shock, and be sure that no protective device built into the instrucment by the manufacturer has became defective, or inadvertenly The line output stage can develop voltages in excess damaged during servicing. Therefore, the following of 25 kV; if the E.H.T cap is required to be removed, checks are recommended for the continued discharge the anode cap to chassis via a high value protection of the customers and service techninians. resistor, prior to its removal from the tube.

HIGH VOLTAGE

High voltage should always be kept at the rated value of the chassis and no higher. Operating at higher voltages may cause a failure of the picture tube or high voltage supply, and also, under certain circumstances

X-RADIATION

TUBES : The primary source of X - radiation in this

the same type as the original, HITACHI approved type.

PRODUCT SAFETY NOTICE

characteristics. These characteristics are often not

replacement components rated for higher voltage,

parts list in this Service Manual.The use of a substitute

replacement component which does not have the same

or other hazards.

information,always consult the current HITACHI Service

TUBE DISCHARGE

INSULATION

Insulation resistantce should not be less than 4.5 Mohm at 500 VDC between the mains poles and any accessible metal parts. Also, no flashover or breakdown should occur during the dielectric strength test, applying 3.2kV AC for two seconds between the main poles and accessible metal parts.

- 2 -

R

REMOTE CONTROL UNIT

19

16

10

11

2

1

6

7

5

17

18

14

4

8 9

12

3 15 13

19

16

20

10

11

2

1

6

7

5

17

18

14

4

9 8

12

3 15 13

Models without Teletext Models with Teletext

POWER ON/OFF SWITCH DEFAULT

1. 11.

2. 12.

INPUT SELECTOR MUTE

3. 13.

VOLUME UP/DOWN CHI/II (FOR NICAM/A2 MODELS)

4. 14.

PROGRAMME UP/DOWN PROGRAMME SELECTOR (DIRECT KEY)

5. 15.

RECALL CURSO

6. 16.

SURROUND SOUND RETURN

7. 17.

MENU COLOR SYSTEM

8. 18.

TIMER SOUND SYSTEM

9. 19.

PICTURE EQUALIZER

10. 20

SOUND T/TEXT FUNCTION KEY (T/TEXT MODELS ONLY)

- 3 -

GENERAL OPERATIONS GUIDE

With this set, all adjustments/settings are performed by selecting from menu screens. Different menu screens and details

of adjustments/settings are shown below. To access the menu screen, press the button, then select the item by

pressing the up/down cursor buttons and adjust by the left/right cursor buttons .

MENU

- 4 -

BLOCK DIAGRAM

- 5 -

A

DJUSTMENT INSTRUCTIONS

HOW TO GO TO SERVICE MODE

1. How to go to adjustment mode no 001 ~ 022

Procedure

(1) Turn TV off by power switch on the TV set.

(2) Press " FUNCTION " button on the TV set and kept depress the button.

(3) Turn TV on by power switch on the TV set.

2. How to go to adjustment mode no 101 ~ 328

Procedure

(1) Set volume to be “0”.

(2) Press button on remote control to go to standby mode.

(3) Press “TV/VIDEO” button on the TV set, and kept depress the button.

(4) Press button on remote control to go to operation mode.

(5) TV will show service table,then please cancel to keep depress the "TV/VIDEO" button.

Note : 1. Press the UP/DOWN cursor buttons

2. Adjust data by the left/right cursor buttons .

3. Press "RECALL" buttons to restore the data.

+B ADJUSTMENT

PREPARATION PROCEDURES

1

AC input voltage 230 +

2 Turns on the set and set the brightness and contrast +B voltage : TP902

to Max.(Signal : Philips Pattern) GND : TP901

3 After 30 sec heat-run, check & adjust the +B voltage

FREE RUN FREQUENCY ADJUSTMENT

Receive a PAL-I monoscope signal on TV mode.

1

5V(50Hz)

PREPARATION PROCEDURES

to select adjustment mode no.

1

djust R954 to obtain +B voltage as below

Select adjustment mode no. 1 and press "MENU" button

one time.

VIF-VCO FREE RUN FREQUENCY ADJUSTMENT

PREPARATION PROCEDURES

Receive a PAL-I monoscope signal on TV mode.

1

Select adjustment mode no. 2 and press "MENU" button

1

one time.

- 6 -

SOUND TRAP FREQUENCY ADJUSTMENT

A

PREPARATION PROCEDURES

Receive a PAL-I monoscope signal on TV mode.

1

Select adjustment mode no. 3 and press "MENU" button

1

one time.

SECAM R-Y OFFSET ADJUSTMENT

PREPARATION PROCEDURES

1 Receive a secam color bar signal on Video 2. 1 Select adjustment mode no. 4.

2 Connect oscilloscope probe to pin 5 of E701. 2 Adjust output level at pin 5 of E701 as indicated below

using service mode no. 4.

0.1 V

0 +

SECAM B-Y OFFSET ADJUSTMENT

PREPARATION

1 Receive a secam color bar signal on Video 2. 1

2 Connect oscilloscope probe to pin 5 of E701. 2

Select adjustment mode no. 5.

djust output level at pin 5 of E701 as indicated below

PROCEDURES

using service mode no. 5.

0.1 V

0 +

WHITE PEAK LEVEL ADJUSTMENT

PREPARATION PROCEDURES

1 Connect oscilloscope probe to pin 3 of E202 on CPT 1 Adjust output level at pin 3 of E202 as indicated below

P.W.B with respect to ground. using service mode no. 15.

2 Input PAL cross hatch signal to Video 2 terminal.

Cross hatch signal input level : 1 Vpp + 10%(with load

A

75 ohm) or 2 Vpp + 10%(no load).

3 Set CONTRAST to MAX.

1H

4 Set data in adjustment mode no.15 to 90. A = 2.8 + 0.1Vpp

- 7 -

VERTICAL SHIFT ADJUSTMENT

PREPARATION PROCEDURES

1 Preheat more than 5 minutes of power supply. 1 Select the IIC control address No. 11.

2 Receive PAL Philips pattern signal. 2 Set the horizontal center line to vertical center maker

of CRT by adjustment of IIC.

Vertical center marker of CRT

VERTICAL SIZE ADJUSTMENT

PREPARATION PROCEDURES

1 Preheat more than 5 minutes of power supply. 1 Select the IIC control address No. 12.

2 Receive Philips pattern signal. 2 Adjust IIC data to obtain the following conditions.

PAL

Check vertical amplitude as below by

3

NTSC circle pattern.

NTSC

4 If picture isn't center, go back to IIC control No. 11 and

adjust IIC data to obtain the following conditions.

- 8 -

SIDE PIN DISTORTION ADJUSTMENT

PREPARATION PROCEDURES

Purity adjustment and convergence adjustment should

1

be already completed. 2

Set Contrast = 100, Brightness = 50

2

Set horizontal size adjustment to approximately 2-2 by

3

1 Receive the circle pattern signal.

st

Adjust the 1

outer vertical line (R/L) to pin, 2nd outer

vertical line (R/L) to straight using side pin adjustment

(PCC-AMP VR R557 / PCC-PHASE VR R564).

H-WIDTH VR R559. 3 Receive the cross hatch signal.

Vertical amplitude adjustment should be already

4

4 Check that the vertical line is straight, except 1st outer

completed. vertical line (R/L).

*Pin distortion spec. DL ≤ 3mm ,DR ≤ 2mm*

HORIZONTAL CENTER ADJUSTMENT

PREPARATION PROCEDURES

1 Side pin adjustment should be already completed. 1 Adjust adjustment mode no. 13 so that the average

2 Receive circle pattern signal. reading of R and L is 2.0 +

HORIZONTAL SIZE ADJUSTMENT

PREPARATION PROCEDURES

Horizontal center adjustment should be already

1

1 Adjust Horizontal size (H-WIDTH VR R559) so that the

completed. average reading of right and left is 2.0 +

2 Receive circle pattern signal.

3 Set Contrast = 100, Brightness = 50

2.0 + 0.5

0.5 at circle pattern signal.

0.5.

2.0 + 0.5

- 9 -

FOCUS ADJUSTMENT

s

A

PREPARATION

PROCEDURES

1 Receive Philips pattern signal. 1 Set picture to mode 1

2 Vertical amplitude adjustment should be already 2 Turn the focus VR gradually clockwise from the full

completed. counterclockwise and adjust so that the halo of vertical

3 Adjust the cut-off after pre-adjust focus VR. center line does not appear, and horizontal line is

4 Check the cut-off in case focus is re-adjusted MIN. width.

HORIZONTAL

1 2 3 4 5 6 7

NO.5

ZOOM

HALO

VERTICAL

WHITE BALANCE ADJUSTMENT

PREPARATION

1 Adjust the W/B after the Power is turned ON for 20 minute

1 Turn the screen adjusting VR clockwise and set it to the

PROCEDURES

2 Purity adjustment should be completed. position where the bright line starts appearing on CPT

3 Set the vertical incident illumination on the CPT surface screen.

to 20 lux or less. 2 Take the first appeared color as the reference. Adjust the

4 Receive white raster signal. other colors by remote until both appear to be the same

5 Set adjustment mode data as table on the next page level as the reference. (A white horizontal line is seen at

to default.

Disp No ITEM Default

016

017

018

019

020

021

R-CUTOFF

G-CUTOFF

B-CUTOFF

R-DRIVE

B-DRIVE

SUB-BRIGHT

127

63

127

6 Turn the screen adjustment VR fully counterclockwise. 5

7 Set to lateral line mode by Press “MUTE” button on

the CPT center.)

Low brightness adjustment data

Red

Green

Blue

………. ”1” key for up, “4” key for down.

………. ”2” key for up, “5” key for down.

………. ”3” key for up, “6” key for down

Don’t change the data of the reference color

3 Exit the lateral line mode. (Press “MUTE” by remote).

4 Set white balance meter at the center of the screen.

djust brightness control so that the indication of the

brightness meter is a prescribed value of brightness

remote control . adjustment. Adjust white balance with the white balance

control data (Red/Blue).

High brightness adjustment data

Red

Blue

………. ”7” key for up, “0” key for down.

………. ”8” key for up, “9” key for down.

- 10 -

SUB-BRIGHTNESS ADJUSTMENT

A

PREPARATION PROCEDURES

1 Turn the TV set on and heat run for 20 minutes or more. 1 Press "PICTURE" key until go to picture mode 2.

2 Horizontal size adjustment and side pin adjustment 2 The sub-brightness should be adjusted (Adjustment

should be completed. mode no. 21) using11 steps gray scale (A1-A1) of color

3 Receive Philips pattern signal. bar pattern

Set picture mode 2 as shown below. 3 Adjust until A10 is complete black and A9 is lightly black.

4 Go out from service mode.

CONTRAST : 0

COLOR : 0

BRIGHTNESS : 50

A

11

A10A

A8A7A6A5A4A3A2A

9

1

5 Adjust picture mode 2 as below.

CONTRAST : 100

COLOR : 60

BRIGHTNESS : 50

6 Press "PICTURE" key until go to picture mode 1.

AGC ADJUSTMENT

PREPARATION PROCEDURES

1 All adjustment except for AGC adjustment should be 1 Select adjustment mode no. 14 (TUNER AGC) and press

completed. Heat-run for more than 5 min. “MENU” key one time. Data will be adjusted automatically

2 Receive signal as table on the next page. 2 .When AGC adjustment is complete,screen should be

3 Set Contrast = 100, Brightness = 50. shown "OK" on the right-top side. It the screen show

4 Set the Sound System and Color System depending on "NG" ,it means AGC adjustment is abnormal.

the broadcast system.

5 Set the antenna input level as specified below.

NO.

014 43 OK

DJUSTMENT 10

"OK"

MODEL T1

DESTINATION ALL

BGSYSTEM

CHANNEL CH10

INPUT SIGNAL Philips Pattern

INPUT LEVEL - 54 dBm / 55dBµ(75Ω)

NO.

014 15 NG

Caution : After AGC adjustment is complete, data in

adjustmentment mode no. 14 should be more than 30.

DJUSTMENT 10

"NG"

If not, please re-check or/and adjust again.

- 11 -

REPLACEMENT PARTS LIST

O

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

1 2 3 4 5 6 7 8

9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36

#I904 #I501

#Q502

#I901 #Q503 #D902

C101 C102 C103 C107 C108 C201 C202 C203 C206 C207 C208 C209 C210 C211 C212 C213 C214 C215 C216 C217 C218 C219 C220 C221 C222 C223 C224 C225 C226 C227

HITACHI HITACHI

PARTS NO. DESCRIPTION THS0401001P THS0402001P THS0403001P THS0404002P THS0405001P THS0405002P

0800358R

CE-1TZ103

0800294R 0800303R 0890092R 0800352R

CE-1TZ104

CE-1TZ103 CE-1TCHJ181

CE-1TZ103

0800352R 0800279R

CE-1TZ103

0800279R 0800279R 0880183R

CE-1TCHJ221

CE-1TZ104

0800352R 0800317R

EL-B10V471R

0800362F 0890092R 0800279R 0890065R 0800277R 0880198R 0880198R

CE-1TZ104

HEAT SINK I904 / I905 HEAT SINK I501 HEAT SINK Q502 HEAT SINK I901 ( L = 60mm ) HEAT SINK Q503 ( L = 40mm ) HEAT SINK D902 ( L = 25mm ) CAP ELEC 1000UF 6.3V M CAP CER 0.01UF 50V Z CAP ELEC 10UF 50V M CAP ELEC 22UF 50V M CAP CER 2200PF 50V M CAP ELEC 470UF 10V M CAP CER 0.1UF 50V Z CAP CER 0.1UF 50V Z CAP CER 0.01UF 50V Z CAP CER 180PF 50V J CH CAP CER 0.01UF 50V Z CAP ELEC 470UF 10V M CAP ELEC 1UF 50V M CAP CER 0.01UF 50V Z CAP ELEC 1UF 50V M CAP ELEC 1UF 50V M CAP POLYESTER 0.015UF 50V J CAP CER 220PF 50V J CH CAP CER 0.1UF 50V Z CAP ELEC 470UF 10V M CAP ELEC 47UF 16V M

CAP ELEC 470UF 10V M 105 CAP ELEC 1000UF 25V M

CAP CER 2200PF 50V M CAP ELEC 1UF 50V M CAP CER 22PF 50V J SL CAP ELEC 0.47UF 50V M CAP POLYESTER 0.22UF 50V J CAP POLYESTER 0.22UF 50V J CAP CER 0.1UF 50V Z

SN ST SNT S

REMARK

C

- 12 -

REPLACEMENT PARTS LIST

O

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72

C228 C229 C232 C233 C234 C236 C237 C238 C239 C241 C242 C243 C244 C245 C247 C248 C249 C250 C251 C252 C253 C255 C256 C257 C258 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411

HITACHI HITACHI

PARTS NO. DESCRIPTION

0880198R 0880181R 0890093R 0880194R 0800279R

CE-1TZ103

0890074R 0890074R AL00002R 0800279R 0880207R

CE-1TZ103

0800326R 0800279R 0880184R

CE-1TZ103

0800326R

EL-B16V101R

0800294R

EL-B50V100R

0800326R

CE-1TZ103

CE-1TZ103 CE-1TCHJ181

0800326R 0800277R 0800277R 0800294R

CE-1TZ103

0800294R 0800277R 0800277R

CE-1TZ103

0800294R 0800294R

CAP POLYESTER 0.22UF 50V J CAP POLYESTER 0.01UF 50V J CAP CER 2700PF 50V M CAP POLYESTER 0.1UF 50V J CAP ELEC 1UF 50V M CAP CER 0.01UF 50V Z CAP CER 100PF 50V J SL CAP CER 100PF 50V J SL CAP ELEC 1UF 160V M CAP ELEC 1UF 50V M CAP POLYESTER 1UF 50V J CAP CER 0.01UF 50V Z CAP CER 0.01UF 50V Z CAP ELEC 100UF 16V M CAP ELEC 1UF 50V M CAP POLYESTER 0.018UF 50V J CAP CER 0.01UF 50V Z CAP ELEC 100UF 16V M

CAP ELEC 100UF 16V M 105 CAP ELEC 10UF 50V M

CAP ELEC 10UF 50V M 105 CAP ELEC 100UF 16V M

CAP CER 0.01UF 50V Z CAP CER 0.01UF 50V Z CAP CER 180PF 50V J CH CAP ELEC 100UF 16V M CAP ELEC 0.47UF 50V M CAP ELEC 0.47UF 50V M CAP ELEC 10UF 50V M CAP CER 0.01UF 50V Z CAP ELEC 10UF 50V M CAP ELEC 0.47UF 50V M CAP ELEC 0.47UF 50V M CAP CER 0.01UF 50V Z CAP ELEC 10UF 50V M CAP ELEC 10UF 50V M

SN ST SNT S

REMARK

C

- 13 -

REPLACEMENT PARTS LIST

O

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98

99 100 101 102 103 104 105 106 107 108

C412 C413 C414 C415 C416 C417 C418 C431 C432 C433 C436 C437 C451 C501

C501A

C502 C504 C505 C506 C507 C509 C510 C511 C515 C516 C517 C518 C519 C520 C521 C522 C524 C525 C526 C527 C701

HITACHI HITACHI

PARTS NO. DESCRIPTION

0800277R 0800294R 0800294R 0800294R 0800277R

CE-1TZ103

0800352R 0800294R 0800294R 0800294R 0800294R 0800294R 0800277R

0279693R 0279693R

0800328R 0800368F

0880209R

0800355R

0800354R AL00028R 0880204R

0800355R

0299622F

0284642R

0243510R

0243503R

EL-B160V010R

0262427F

0299987F

0262423F

CM-50V3U3J

AN01177F

0890074R

0279690R

0800315R

CAP ELEC 0.47UF 50V M CAP ELEC 10UF 50V M CAP ELEC 10UF 50V M CAP ELEC 10UF 50V M CAP ELEC 0.47UF 50V M CAP CER 0.01UF 50V Z CAP ELEC 470UF 10V M CAP ELEC 10UF 50V M CAP ELEC 10UF 50V M CAP ELEC 10UF 50V M CAP ELEC 10UF 50V M CAP ELEC 10UF 50V M CAP ELEC 0.47UF 50V M CAP POLY FILM 0.1UF 100V K CAP POLY FILM 0.1UF 100V K CAP ELEC 100UF 35V M CAP ELEC 2200UF 25V M CAP POLYESTER 1.5UF 50V J CAP ELEC 470UF 35V M CAP ELEC 470UF 25V M CAP ELEC 10UF 250V M CAP POLYESTER 0.56UF 50V J CAP ELEC 470UF 35V M CAP POLYPROPY 0.01UF 630V J CAP ELEC 50V 10 UF (NP) CAP CER 560PF 500V K CAP CER 150PF 500V K

CAP ELEC 1UF 160V M 105 CAP M-POLYPRO 0.01UF J 1.8KHP

CAP POLYPRO 0.039UF J 630V CAP M-POLYPRO 6800PF J 1.8KHP CAP POLYESTER 3.3UF 50V J CAP M-POLYPRO 0.43UF J 250V CAP CER 100PF 50V J CAP POLYESTER 0.033UF 100V K CAP ELEC 47UF 6.3V

SN ST SNT S

REMARK

C

- 14 -

REPLACEMENT PARTS LIST

o

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144

C701A

C702 C703 C704 C705 C711 C712 C713 C714 C716 C902 C903 C904 C905 C906 C907 C908 C909 C910 C911 C912 C913 C914 C915 C916 C917 C919 C921 C923 C924 C924 C928 C929 C930 C931 C932

HITACHI HITACHI

PARTS NO. DESCRIPTION

0880057R

0800326R

CE-1TZ103

0890083R

CE-1TZ103 CE-1TZ103 CE-1TZ103

0800326R

0890087R

0800294R

0880035R

EL-B35V470R

0880038R

EL-B50V010R

0880038R

EL-B50V010R EL-B50V100R

CE-1TZ104

EL-B25V222R

0880194R

EL-B25V102R

AL01663 0800294R AJ00542F 0890087R

CE-1TCHJ181

0800348R

CE-1TZ104

AJ00454F 0890083R 0800294R

AL01702

AN02083S

CAP POLYESTER 0.1UF 50V K CAP ELEC 100UF 16V M CAP CER 0.01UF 50V Z CAP CER 470PF 50V K CAP CER 0.01UF 50V Z CAP CER 0.01UF 50V Z CAP CER 0.01UF 50V Z CAP ELEC 100UF 16V M CAP CER 1000PF 50V K CAP ELEC 10UF 50V M CAP POLYESTER 2200PF 50V K

CAP ELEC 47UF 35V M 105 CAP POLYESTER 3900PF 50V K

CAP ELEC 1UF 50V M 105 CAP POLYESTER 3900PF 50V K

CAP ELEC 1UF 50V M 105 CAP ELEC 10UF 50V M 105

CAP CER 0.1UF 50V Z CAP ELEC 2200UF 25V M 105

CAP POLYESTER 0.1UF 50V J CAP POLYESTER 0.1UF 50V J CAP POLYESTER 0.1UF 50V J CAP POLYESTER 0.1UF 50V J

CAP ELEC 1000UF 25V M 105 CAP ELEC 330UF 160V M

CAP ELEC 10UF 50V M CAP CER 4700PF 1KV K CAP CER 1000PF 50V K CAP CER 180PF 50V J CH CAP ELEC 330UF 63V M CAP CER 0.1UF 50V Z CAP CER 1000PF 1KV K CAP CER 470PF 50V K CAP ELEC 10UF 50V M CAP ELEC 220UF 450V M CAP M-POLYPRO X2 0.1UF K 250V

SN ST SNT S

REMARK

C

Code 433, 435 only

- 15 -

REPLACEMENT PARTS LIST

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 165 166 167 168 169 170 171 172 173 174 175 176 177 178 179 180

C933 C934 C935

CT001

D101 D203 D204 D205 D206 D207 D208 D209 D210 D211 D212 D213 D214

D214A

D215

D215A

D216

D216A

D219 D220 D501 D502 D503 D504 D505 D506 D507 D508 D509 D510 D511 D703

HITACHI HITACHI

PARTS NO. DESCRIPTION

AN02083S

AJ00539F

AJ00824 0880045R

2339971M 2338321M 2338321M 2339887M 2339862M 2338321M

DS-0004AAM

2338321M 2338321M 2338321M

DS-0004AAM

2339837M 2338321M 2338321M 2338321M 2338321M 2338321M 2338321M 2338321M 2339862M

DS-0004AAM DS-0004AAM DS-0004AAM

2339887M 2338321M

DS-0004AAM DS-0003AAM DS-0001AAM DS-0004AAM DS-0004AAM DS-0004AAM

2339853M

CAP M-POLYPRO X2 0.1UF K 250V CAP CER 2200PF 1KV K CAP CER 3300PF 250V M CAP POLYESTER 0.012UF 50V K DI HZS33-1 DI 1SS270 DI 1SS270 DI HZS12C1 DI HZS9A2 DI 1SS270 DI EU2A(V1) DI 1SS270 DI 1SS270 DI 1SS270 DI EU2A(V1) DI HZS5C1 DI 1SS270 DI 1SS270 DI 1SS270 DI 1SS270 DI 1SS270 DI 1SS270 DI 1SS270 DI HZS9A2 DI EU2A(V1) DI EU2A(V1) DI EU2A(V1) DI HZS12C1 DI 1SS270 DI EU2A(V1) DI RS-4FS DI RU4AM DI EU2A(V1) DI EU2A(V1) DI EU2A(V1) DI HZS7A3

SN ST SNT S

REMARK

- 16 -

REPLACEMENT PARTS LIST

A

R

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199 200 201 202 203 204 205 206 207 208 209 210 211 212 213 214 215 216

D704 D705 D706 D707 D901 D902 D903 D904 D905 D906 D907 D908 D910 D911 D912

DC701

DI905

DT001

E202 E401 E402 E403 E405 E502 E503 E505 E701 E702 E703 E901

E902 E903 E904

F903 F904

FK230

HITACHI HITACHI

PARTS NO. DESCRIPTION

2339837M 2339971M 2339858M 2339858M

DS-0004AAM

DS-0001AA2

DS-0001AAM

2338321M 2338321M

DS-0004AAM DS-0004AAM

2339911M 2339841M 2338321M

DS-0001ANM

2339858M 2343161M 2338321M

1EF2035

JP-09P01AB

EY01161

TWI4004302P

JP-03P02AB

1EF2024

ED03659

TWI4003702

2902264

TWI4003604P

2902261TA

2902263

XXX

TWI4004102P

ED03174

AZ00898M

AZ00101 AZ00105

DI HZS5C1 DI HZS33-1 DI HZS7C2 DI HZS7C2 DI EU2A(V1) DI FMB-G16L DI RU4AM DI 1SS270 DI 1SS270 DI EU2A(V1) DI EU2A(V1) DI HZS18-1 DI HZS6A1 DI 1SS270 DI D3SBA60-7100 DI HZS7C2 DI HZS36-1L DI 1SS270 6P CONN W/WIRE JACK 9P YKC21-4690N JACK S-VIDEO YKF51-5503N 6PIN CONNECTOR PLUG JACK 3P YKC21-4399N BOARD-IN-CONNECTO 4P WITH BASE (VOID 2 PIN) CONNECTOR PLUG (L=490mm) 5PIN CONNECTOR PLUG 2PCON WITH WIRE (L=520mm) 2P CONNECTOR 4P WITH BASE AC CORD CONNECTO 4P WITH BASE MICRO FUSE 5 MICRO FUSE 0.5 MICRO FUSE 2.5

SN ST SNT S

REMARK

SEE APPENDIX I

- 17 -

REPLACEMENT PARTS LIST

K

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

217 218 219 220 221 222 223 224 225 226 227 228 229 230 231 232 233 234 235 236 237 238 239 240 241 242 243 244 245 246 247 248 249 250 251 252

I201 I401 I501 I701 I702 I901 I902 I903

I904 L101 L102 L104 L201 L203 L501 L502 L503 L901 L902 L903

Q101 Q201 Q202 Q203 Q204 Q205 Q206 Q207 Q401 Q501 Q502 Q503 Q504 Q701 Q702 Q703

HITACHI HITACHI

PARTS NO. DESCRIPTION IC-0001AC1 IC-0002AC1 IC-0002AD2

IC-0002AE0

XXX

IC-0003AD3

IC-0001AA2

CP08261U

IC-0002AA2

2123412M 2122253M 2122253M

2123109M 2123103M

2124183

LF-T332J LH-0001AR BH01162M

BZ02124

TB-0002ACR TB-0001ACR

TB-0001AFR TB-0002ACR TB-0003ACR TB-0003ACR

TB-0005AFR

TB-0001AFR TB-0003ACR

CF01061R

CF02521

2312174

CF01431R

TB-0003ACR

TB-0001AFR TB-0003ACR

IC M61262BFP IC M52791FP IC LA78041 IC M24C08-WBN6G IC M37160M8 IC LA42152 IC SE130N OPTOCOUPLERS H11A817B300W IC STR-F6656 COIL AXIAL 1.2UH COIL AXIAL 100UH COIL AXIAL 100UH COIL AXIAL 33UH COIL AXIAL 10UH COIL CHOKE 500UH COIL FILTER 3300UH J LINEARITY COIL ELH5L436163 FERRITE BEAD WITH CORE 2.3UH LINE FILTER ELF24V020AM LINE FILTER ELF24V020AM TRS 2SC1906 TRS 2SA1993-E,F TRS 2SC2236-O,Y TRS 2SC1906 TRS 2SC5395-E,F TRS 2SC5395-E,F TRS 2SC5171(LBS4MBS-K)(Lead straight) TRS 2SC2236-O,Y TRS 2SC5395-E,F TRS MPSA42 TRS 2SD2581-RF TRS 2SD2375-P TRS KTA1266 TRS 2SC5395-E,F TRS 2SC2236-O,Y TRS 2SC5395-E,F

SN ST SNT S

REMARK

SEE APPENDIX II

Code 433, 435 only

- 18 -

REPLACEMENT PARTS LIST

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

253 254 255 256 257 258 259 260 261 262 263 264 265 266 267 268 269 270 271 272 273 274 275 276 277 278 279 280 281 282 283 284 285 286 287 288

Q901

QT001

R102 R103 R104 R105 R106 R108 R109 R110 R111 R201 R202 R203 R204 R208 R209 R210 R211 R212 R213 R214 R215 R216 R217 R219 R220 R221 R222 R223 R224 R226 R228 R230 R232 R233

HITACHI HITACHI

PARTS NO. DESCRIPTION

TB-0003ACR

2320637M 0700027M

0700049M 0700037M 0700059M 0700049M 0700027M 0700027M 0700043M 0700018M

0187038M 0187038M

0700027M 0700027M 0700052M 0700063M 0700063M 0700045M 0700058M 0700058M 0700027M 0700054M

RM-W01F561JA

AT00318S 0700034M 0700047M 0700041M 0700038M 0700045M 0700041M 0700034M

AT03694M

0700058M 0700081M 0700027M

TRS 2SC5395-E,F TRS 2SA673 C/D RES CAR 1/16W 100R J RES CAR 1/16W 4.7K J RES CAR 1/16W 560R J RES CAR 1/16W 27K J RES CAR 1/16W 4.7K J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 1.5K J RES CAR 1/16W 22R J RES CAR 1/16W 75R J RES CAR 1/16W 75R J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 6.8K J RES CAR 1/16W 47K J RES CAR 1/16W 47K J RES CAR 1/16W 2.2K J RES CAR 1/16W 22K J RES CAR 1/16W 22K J RES CAR 1/16W 100R J RES CAR 1/16W 10K J RES MTL OXIDE 1W 560R J RES MTL OXIDE ERG3F 330H J RES CAR 1/16W 330RJ RES CAR 1/16W 3.3K J RES CAR 1/16W 1K J RES CAR 1/16W 680R J RES CAR 1/16W 2.2K J RES CAR 1/16W 1K J RES CAR 1/16W 330R J RES SURGE 1/2W 10M RES CAR 1/16W 22K J RES CAR 1/16W 1M J RES CAR 1/16W 100R J

SN ST SNT S

REMARK

- 19 -

REPLACEMENT PARTS LIST

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

289 290 291 292 293 294 295 296 297 298 299 300 301 302 303 304 305 306 307 308 309 310 311 312 313 314 315 316 317 318 319 320 321 322 323 324

R234 R237 R238 R239 R240 R241 R242 R243 R244 R245 R246 R247 R248 R249 R250 R251 R252 R253 R254 R255 R256 R257 R258 R259 R260 R261 R275 R276 R277 R401 R402 R403 R404 R405 R406 R407

HITACHI HITACHI

PARTS NO. DESCRIPTION

0700027M 0700027M

RM-W01F472JA RM-S25U153FA

0700064M RM-S25U153FA RM-S25U333FA

0700059M

0700052M

AT03884M

0700054M

0700068M

0700045M

0700054M

0700027M

0700041M

AT00321S

AT00316S

0700027M

0700039M

0700032M

0700067M

0187038M

0700067M

0187038M

0700067M

0187038M

RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES MTL OXIDE 1W 4.7K J RES MTL OXIDE 1/16W 15K-F RES CAR 1/16W 56K J RES MTL OXIDE 1/16W 15K-F RES MTL OXIDE 1/16W 33K-F RES CAR 1/16W 27K J RES CAR 1/16W 6.8K J RES CAR 1/2W 10K J RES CAR 1/16W 10K J RES CAR 1/16W 10K J RES CAR 1/16W 120K J RES CAR 1/16W 2.2K J RES CAR 1/16W 2.2K J RES CAR 1/16W 2.2K J RES CAR 1/16W 2.2K J RES CAR 1/16W 10K J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 1K J RES MTL OXIDE ERG3F 390H J RES MTL OXIDE ERG3F 270H J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 820R J RES CAR 1/16W 220R J RES CAR 1/16W 100K J RES CAR 1/16W 75R J RES CAR 1/16W 75R J RES CAR 1/16W 100K J RES CAR 1/16W 75R J RES CAR 1/16W 100K J RES CAR 1/16W 75R J

SN ST SNT S

REMARK

- 20 -

REPLACEMENT PARTS LIST

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

325 326 327 328 329 330 331 332 333 334 335 336 337 338 339 340 341 342 343 344 345 346 347 348 349 350 351 352 353 354 355 356 357 358 359 360

R408 R409 R410 R411 R412 R413 R414 R415 R416 R417 R418 R419 R428 R429 R430 R431 R432 R433 R434 R435 R436 R437 R438 R451 R452 R453 R454 R455 R456 R501 R503 R505 R506

R506A

R507 R508

HITACHI HITACHI

PARTS NO. DESCRIPTION

0187038M

0700027M

0700041M

0700027M

0700041M

0700027M

AT03861M

0700025M

0700067M

0700041M

0700054M

0700067M

0700027M

0700041M

0700067M

0187038M

0700067M

0700041M

0700027M

0700041M

0700036M

AT03897M

0188097M

0700053M

0700041M

RF-S25F2R2JA

0188096M

RES CAR 1/16W 75R J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 1K J RES CAR 1/16W 100R J RES CAR 1/16W 1K J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/2W 180R J RES CAR 1/16W 68R J RES CAR 1/16W 100K J RES CAR 1/16W 100K J RES CAR 1/16W 1K J RES CAR 1/16W 1K J RES CAR 1/16W 10K J RES CAR 1/16W 100K J RES CAR 1/16W 100K J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 1K J RES CAR 1/16W 1K J RES CAR 1/16W 100K J RES CAR 1/16W 75R J RES CAR 1/16W 100K J RES CAR 1/16W 1K J RES CAR 1/16W 100R J RES CAR 1/16W 1K J RES CAR 1/16W 470R J RES CAR 1/2W 100K J RES CAR 1/2W 3.3R J RES CAR 1/16W 8.2K J RES CAR 1/16W 1K J RES FUSE 1/4W 2.2R J RES CAR 1/2W 2.7R J

SN ST SNT S

REMARK

- 21 -

REPLACEMENT PARTS LIST

A

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

361 362 363 364 365 366 367 368 369 370 371 372 373 374 375 376 377 378 379 380 381 382 383 384 385 386 387 388 389 390 391 392 393 394 395 396

R509 R510 R511 R512 R513 R514 R515 R517 R518 R519 R520 R521 R522 R523 R524 R525 R526 R527 R528 R529 R701 R708 R709 R710 R711 R713 R714 R717 R718 R719 R720 R721 R722 R723 R725 R727

HITACHI HITACHI

PARTS NO. DESCRIPTION

0700055M

0700058M RM-W03F1R2JA RM-W03F1R2JA RM-W03F1R2JA

0188093M

AZ00892M

0700033M

0700027M

AT00381S

0700051M

AT00381S

0700026M RM-W03F471JA

RM-W03F4R7JA

0700027M

0700063M

0110243S

AT03861M

0100129M

0700041M

0700036M

0700027M

0700052M

0700058M

0700054M

0700058M

0700041M

0700027M

0700052M

RES CAR 1/16W 12K J RES CAR 1/16W 22K J RES MTL OXIDE 3W 1.2R J RES MTL OXIDE 3W 1.2R J RES MTL OXIDE 3W 1.2R J RES CAR 1/2W 1.5R J MICRO FUSE 1 RES CAR 1/16W 270R J RES CAR 1/16W 100R J RES MTL OXIDE ERG3F 682H J RES CAR 1/16W 5.6K J RES MTL OXIDE ERG3F 682H J RES CAR 1/16W 82R J RES MTL OXIDE 3W 470 J RES MTL OXIDE 3W 4.7R J RES CAR 1/16W 100R J RES CAR 1/16W 47K J RES MTL OXIDE 2W 820R J RES CAR 1/2W 180R J RES CAR 1/8W 470K J RES CAR 1/16W 1K J RES CAR 1/16W 470R J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 6.8K J RES CAR 1/16W 6.8K J RES CAR 1/16W 22K J RES CAR 1/16W 10K J RES CAR 1/16W 10K J RES CAR 1/16W 22K J RES CAR 1/16W 22K J RES CAR 1/16W 1K J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 6.8K J

SN ST SNT S

REMARK

- 22 -

REPLACEMENT PARTS LIST

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

397 398 399 400 401 402 403 404 405 406 407 408 409 410 411 412 413 414 415 416 417 418 419 420 421 422 423 424 425 426 427 428 429 430 431 432

R728 R729 R730 R731 R732 R733 R734 R735 R736 R737 R738 R739 R740 R741 R742 R743 R744 R746 R747 R749 R750 R752 R753 R754 R902 R903 R904 R905 R906 R907 R908 R909 R910 R911 R913 R914

HITACHI HITACHI

PARTS NO. DESCRIPTION

0700052M

0700041M

0700058M

0700054M

0700058M

0700041M

0700058M

0700027M

0700054M

0700048M

0700054M

0700027M

0700064M

0700027M

0700041M

0700062M

0700058M

0700047M

0700046M

0700054M

0700051M

0700005M

0700041M

0700037M

RES CAR 1/16W 6.8K J RES CAR 1/16W 1K J RES CAR 1/16W 22K J RES CAR 1/16W 22K J RES CAR 1/16W 10K J RES CAR 1/16W 22K J RES CAR 1/16W 1K J RES CAR 1/16W 1K J RES CAR 1/16W 22K J RES CAR 1/16W 22K J RES CAR 1/16W 22K J RES CAR 1/16W 100R J RES CAR 1/16W 10K J RES CAR 1/16W 3.9K J RES CAR 1/16W 10K J RES CAR 1/16W 100R J RES CAR 1/16W 56K J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 1K J RES CAR 1/16W 1K J RES CAR 1/16W 39K J RES CAR 1/16W 22K J RES CAR 1/16W 22K J RES CAR 1/16W 3.3K J RES CAR 1/16W 2.7K J RES CAR 1/16W 10K J RES CAR 1/16W 10K J RES CAR 1/16W 5.6K J RES CAR 1/16W 5.6K J RES CAR 1/16W 2.2R J RES CAR 1/16W 2.2R J RES CAR 1/16W 2.2R J RES CAR 1/16W 2.2R J RES CAR 1/16W 1K J RES CAR 1/16W 560JB

SN ST SNT S

REMARK

- 23 -

REPLACEMENT PARTS LIST

R

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

433 434 435 436 437 438 439 440 441 442 443 444 445 446 447 448 449 450 451 452 453 454 455 456 457 458 459 460 461 462 463 464 465 466 467 468

R916 R917 R919 R920 R921 R922 R923 R924 R925 R926 R928 R929 R930

RT001 RK116 RK229 RK702

T501 T502 T901

TH901

U101 W001 W002 W003 W005

W006

WI801

X201 X202 X701

C234A

C419

C420

C421

C422

HITACHI HITACHI

PARTS NO. DESCRIPTION

0113733M

0700056M RM-W01FR27JA RM-W01FR27JA

RM-W01F681JA RM-W02F683JA

RM-W02F683JA

RW-15ZK1R5

AT03906M

RM-W01FR27JA

AT03694M

0700054M RM-W03F680JA

0700041M

0700042M

0700041M

TF-0002AJ

BS00011

TS-0002AI

2341325

HJ00472TA

9374945 9374948 9374948 9374948 9374949 9374948

XL-04M43AK

BG01561

CZ01161 0880048R 0800326R

CE-1TZ103

0800326R 0800294R

RES CAR 1/2W 220R J RES CAR 1/16W 15K J RES MTL OXIDE 1W 0.27R J RES MTL OXIDE 1W 0.27R J RES MTL OXIDE 1W 680R J RES MTL OXIDE 2W 68K J RES MTL OXIDE 2W 68K J RES WIRE WOUND 15W 1.5R J RES CAR 1/2W 470K J RES MTL OXIDE 1W 0.27R J RES SURGE 1/2W 10M RES CAR 1/16W 10K J RES MTL OXIDE 3W 68 J RES CAR 1/16W 1K J RES CAR 1/16W 1.2K J RES CAR 1/16W 1K J RES CAR 1/16W 1K J FBT HLF1433X(FOR 25",29") HOR TRANSFORMER SWITCHING TRANS ETS39AD2H6AC THERMISTOR PTDCA1BF4R5Q200 TUNER ENV59K05G3 UL 1007 BLACK L = 25 MM UL 1007 ORANGE L = 170 MM UL 1007 ORANGE L = 50 MM UL 1007 ORANGE L = 210 MM UL 1007 ORANGE L = 70 MM UL 1007 ORANGE L = 120 MM CRYSTAL 9SL4433619BCSF4DZ001 SAW FILTER K7252M RC RECEIVE CAP POLYESTER 0.022UF 50 V J CAP ELEC 100UF 16V M CAP CER 0.01UF 50V Z CAP ELEC 100UF 16V M CAP ELEC 10UF 50V M

SN ST SNT S

REMARK

- 24 -

REPLACEMENT PARTS LIST

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

469 470 471 472 473 474 475 476 477 478 479 480 481 482 483 484 485 486 487 488 489 490 491 492 493 494 495 496 497 498 499 500 501 502 503 504

C423 C424 C425 C426 C427 C428 C429 C430 C438 C439 C440

I402

Q203

R218 R219 R225 R420 R421 R422 R423 R424 R425 R426 R439 R440 R441 R442 R506 R535

R537A

R751

#C234A

C551 C552 C553 C554

HITACHI HITACHI

PARTS NO. DESCRIPTION

0800294R 0880181R 0880181R 0284625R 0880182R 0890074R

CE-1TZ103

0890087R 0284625R 0880182R 0890074R

IC-0003AC1

TB-0003ACR

0700036M 0700041M 0700027M 0700039M 0700039M 0700045M 0700054M 0700042M 0700042M 0700067M 0700045M 0700054M 0700027M 0700027M 0700054M 0700058M 0700042M 0700058M

97401107 0800294R 0880012R 0880184R 0880194R

CAP ELEC 10UF 50V M CAP POLYESTER 0.01UF 50V J CAP POLYESTER 0.01UF 50V J CAP ELEC 50V 2.2 UF (NP) CAP POLYESTER 0.012UF 50V J CAP CER 100PF 50V J SL CAP CER 0.01UF 50V Z CAP CER 1000PF 50V K CAP ELEC 50V 2.2 UF (NP) CAP POLYESTER 0.012UF 50V J CAP CER 100PF 50V J SL IC M62420FP TRS 2SC5395-E,F RES CAR 1/16W 470R J RES CAR 1/16W 1K J RES CAR 1/16W 100R J RES CAR 1/16W 820R J RES CAR 1/16W 820R J RES CAR 1/16W 2.2K J RES CAR 1/16W 10K J RES CAR 1/16W 1.2K J RES CAR 1/16W 1.2K J RES CAR 1/16W 100K J RES CAR 1/16W 2.2K J RES CAR 1/16W 10K J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 10K J RES CAR 1/16W 22K J RES CAR 1/16W 1.2K J RES CAR 1/16W 22K J VANISH TUBE 0.5mm L = 18mm CAP ELEC 10UF 50V M CAP POLYESTER 0.022UF 50V K CAP POLYESTER 0.018UF 50V J CAP POLYESTER 0.1UF 50V J

SN ST SNT S

REMARK

- 25 -

REPLACEMENT PARTS LIST

K

R

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

505 506 507 508 509 510 511 512 513 514 515 516 517 518 519 520 521 522 523 524 525 526 527 528 529 530 531 532 533 534 535 536 537 538 539 540

C555 C556 C557 C558 C559 C560 C561 C562 C563 C564 C565 C566 D551

DC563

E551

I551

LK553

Q551 Q552 Q553 Q554 Q581

R551 R552 R553 R554 R555 R556 R557 R558 R559 R560 R561 R562 R563 R564

HITACHI HITACHI

PARTS NO. DESCRIPTION

0284639R 0284639R 0880187R 0800319R 0800312R 0800303R 0800288R 0800312R 0800294R 0880012R 0880181R 0880037R

2339932M 2339222M

ED00366

IC-0004AC0

2122253M

TB-0003ACR TB-0003ACR TB-0003ACR TB-0003ACR TB-0003ACR

0700054M 0700059M

RM-S25U272FA

0700051M 0114161M 0700045M

AW00299

0700058M

AW00295 0700041M 0700051M 0700062M

RM-S25U182FA

AW00297

CAP ELEC 25V 10 UF (NP) CAP ELEC 25V 10 UF (NP) CAP POLYESTER 0.033UF 50V J CAP ELEC 47UF 35V M CAP ELEC 33UF 50V M CAP ELEC 22UF 50V M CAP ELEC 4.7UF 50V M CAP ELEC 33UF 50V M CAP ELEC 10UF 50V M CAP POLYESTER 0.022UF 50V K CAP POLYESTER 0.01UF 50V J CAP POLYESTER 0.0033UF 50V K DI HZS22-2 DI HZS27-2 8PIN CONNECTO IC HA17358A COIL AXIAL 100UH TRS 2SC5395-E,F TRS 2SC5395-E,F TRS 2SC5395-E,F TRS 2SC5395-E,F TRS 2SC5395-E,F RES CAR 1/16W 10K J RES CAR 1/16W 27K J RES MTL OXIDE 1/16W 2.7K-F RES CAR 1/16W 5.6K J RES CAR 1/4W 1K J RES CAR 1/16W 2.2K J RES VAR 50K-B RES CAR 1/16W 22K J RES VAR 2K-B RES CAR 1/16W 1K J RES CAR 1/16W 5.6K J RES CAR 1/16W 39K J RES MTL OXIDE 1/16W 1.8K-F RES VAR 10K-B

SN ST SNT S

REMARK

- 26 -

REPLACEMENT PARTS LIST

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

541 542 543 544 545 546 547 548 549 550 551 552 553 554 555 556 557 558 559 560 561 562 563 564 565 566 567 568 569 570 571 572 573 574 575 576

R565 R566 R567 R568 R569 R570 R571 R572 R573 R574 R575 R576 R581 R582 R583 R584 R585 R586 R587 C803 C804 C805 C806 C807 C809 C811 C812 C814 C815 C816 C817 C818 C819 C822 D801 D802

HITACHI HITACHI

PARTS NO. DESCRIPTION

0700051M 0700042M 0700065M 0700031M 0700041M 0700052M 0700036M 0700047M 0700051M 0700044M 0700054M 0700042M 0700057M 0700063M

AT03675M

0700075M 0700058M 0700079M 0700075M

0246464R 0800282R 0890121R 0890121R

CE-1TZ103 CE-1TZ104 CE-1TZ104 CE-1TZ103 CE-1TZ104 CE-1TZ104 CE-1TZ104

0800294R

CE-1TZ103

0800294R

0890118R 2338321M 2338321M

RES CAR 1/16W 5.6K J RES CAR 1/16W 1.2K J RES CAR 1/16W 68K J RES CAR 1/16W 180R J RES CAR 1/16W 1K J RES CAR 1/16W 6.8K J RES CAR 1/16W 470R J RES CAR 1/16W 3.3K J RES CAR 1/16W 5.6K J RES CAR 1/16W 1.8K J RES CAR 1/16W 10K J RES CAR 1/16W 1.2K J RES CAR 1/16W 18K J RES CAR 1/16W 47K J RES CAR FILM 1/2W 5.6M JB RES CAR 1/16W 390K J RES CAR 1/16W 22K J RES CAR 1/16W 820K J RES CAR 1/16W 390K J CAP CER 100PF 50V J CH CAP ELEC 2.2UF 50V M CAP CER 33PF 50V J CH CAP CER 33PF 50V J CH CAP CER 0.01UF 50V Z CAP CER 0.1UF 50V Z CAP CER 0.1UF 50V Z CAP CER 0.01UF 50V Z CAP CER 0.1UF 50V Z CAP CER 0.1UF 50V Z CAP CER 0.1UF 50V Z CAP ELEC 10UF 50V M CAP CER 0.01UF 50V Z CAP ELEC 10UF 50V M CAP CER 22PF 50V J CH DI 1SS270 DI 1SS270

SN ST SNT S

REMARK

- 27 -

R

REPLACEMENT PARTS LIST

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

577 578 579 580 581 582 583 584 585 586 587 588 589 590 591 592 593 594 595 596 597 598 599 600 601 602 603 604 605 606 607 608 609 610 611 612

D803 D804 D805 D806 D807 D808 D809 D810 D811

E801

I801 I802

I804 Q801 Q802 Q803

R801 R802 R803 R804 R805 R806 R807 R808 R809 R810 R811 R812 R813 R814 R817 R818 R819 R820 R821 R822

HITACHI HITACHI

PARTS NO. DESCRIPTION

2338321M 2338321M 2338321M 2338321M 2338321M 2338321M 2338321M 2338321M 2338321M

ED00374 IC-0001AH0 IC-0001AM0

IC-0006AC3

TB-0003ACR TB-0003ACR TB-0003ACR

0700049M 0700049M 0700049M 0700049M 0700049M 0700049M 0700049M 0700049M 0700049M 0700049M 0700049M 0700049M 0700027M 0700027M 0700049M 0700049M 0700049M 0700049M 0700049M 0700054M

DI 1SS270 DI 1SS270 DI 1SS270 DI 1SS270 DI 1SS270 DI 1SS270 DI 1SS270 DI 1SS270 DI 1SS270 15PIN CONNECTO IC SAA5264PS/M3/0448 IC RT9161-33PZL IC HA178L05A TRS 2SC5395-E,F TRS 2SC5395-E,F TRS 2SC5395-E,F RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 100 JB RES CAR 1/16W 100 JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 10K JB

SN ST SNT S

REMARK

- 28 -

REPLACEMENT PARTS LIST

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

613 614 615 616 617 618 619 620 621 622 623 624 625 626 627 628 629 630 631 632 633 634 635 636 637 638 639 640 641 642 643 644 645 646 647 648

R823 R824 R825 R826 R827 R828 R829 R830 R831 R832 R833 R834 R835 R836 R837 R838 R839 R840 R841 R842 R843 R844 R845 R846 R847 R848 R849 R850 R851 R852 R853 R854

X801 C351 C352 C353

HITACHI HITACHI

PARTS NO. DESCRIPTION

0700054M 0700042M 0700042M 0700042M 0700054M 0700036M 0700036M 0700049M 0700049M 0700049M 0700049M 0700049M

RM-S25U243FA

0700054M 0700054M 0700049M 0700049M 0700042M 0700036M 0700042M 0700042M 0700036M 0700046M 0700036M 0700049M 0700049M 0700049M 0700067M 0700067M 0700045M 0700045M

AT03864M

BP01321 0800294R 0893122R 0800317R

RES CAR 1/16W 10K JB RES CAR 1/16W 1.2K JB RES CAR 1/16W 1.2K JB RES CAR 1/16W 1.2K JB RES CAR 1/16W 10K JB RES CAR 1/16W 470 JB RES CAR 1/16W 470 JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES MTL OXIDE 1/16W 24K F RES CAR 1/16M 10K JB RES CAR 1/16M 10K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 1.2K JB RES CAR 1/16W 470 JB RES CAR 1/16W 1.2K JB RES CAR 1/16W 1.2K JB RES CAR 1/16W 470 JB RES CAR 1/16W 2.7K JB RES CAR 1/16W 470 JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 4.7K JB RES CAR 1/16W 100K JB RES CAR 1/16W 100K JB RES CAR 1/16W 2.2K JB RES CAR 1/16W 2.2K JB RES MTL OXIDE 1/2W 330 J CRYSTAL 12MHz CAP ELEC 10UF 50V M CHIP CAP 1608 47PF 50VJ CH CAP ELEC 47UF 16V M

SN ST SNT S

REMARK

- 29 -

REPLACEMENT PARTS LIST

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

649 650 651 652 653 654 655 656 657 658 659 660 661 662 663 664 665 666 667 668 669 670 671 672 673 674 675 676 677 678 679 680 681 682 683 684

C354 C355 C356 C357 C358 C359 C360 C361 C362 C363 C371 C372 C373 C374 C375 C376 C377 C378 C379 C380 C381 C382 C383 C384 C385 C386 C387 C388 C389 C390 C391 C392 C393 C394 C395 C397

HITACHI HITACHI

PARTS NO. DESCRIPTION

0893193R 0800294R 0893232R

AA01121R AA01121R

0893232R 0800284R 0893193R 0800352R 0800352R 0893126R 0893123R 0893123R 0893114R 0893175R 0893114R 0893123R 0893193R 0893175R 0800294R 0893175R 0800294R 0893232R 0893232R 0800317R 0893193R 0800317R 0893193R 0800317R 0893193R

CH-25V105ZAV

0893175R 0893175R 0800353R 0893193R 0893127R

CHIP CAP 1608 0.01UF 25V K CAP ELEC 10UF 50V M CHIP CAP C1608 0.1UF 25V CHIP CAP 1608 0.47UF 10V K CHIP CAP 1608 0.47UF 10V K CHIP CAP C1608 0.1UF 25V CAP ELEC 3.3UF 50V M CHIP CAP 1608 0.01UF 25V K CAP ELEC 470UF 10V M CAP ELEC 470UF 10V M CHIP CAP 1608 100PF 50V J CH CHIP CAP 1608 56PF 50V J CH CHIP CAP 1608 56PF 50V J CH CHIP CAP 1608 12PF 50V J CH CHIP CAP 1608 1000PF 50V J SL CHIP CAP 1608 12PF 50V J CH CHIP CAP 1608 56PF 50V J CH CHIP CAP 1608 0.01UF 25V K CHIP CAP 1608 1000PF 50V J SL CAP ELEC 10UF 50V M CHIP CAP 1608 1000PF 50V J SL CAP ELEC 10UF 50V M CHIP CAP C1608 0.1UF 25V CHIP CAP C1608 0.1UF 25V CAP ELEC 47UF 16V M CHIP CAP 1608 0.01UF 25V K CAP ELEC 47UF 16V M CHIP CAP 1608 0.01UF 25V K CAP ELEC 47UF 16V M CHIP CAP 1608 0.01UF 25V K CHIP CAP 1608 1UF Z 25V CHIP CAP 1608 1000PF 50V J SL CHIP CAP 1608 1000PF 50V J SL CAP ELEC 470UF 16V M CHIP CAP 1608 0.01UF 25V K CHIP CAP 1608 120PF 50V J CH

SN ST SNT S

REMARK

- 30 -

REPLACEMENT PARTS LIST

R

K

R

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

685 686 687 688 689 690 691 692 693 694 695 696 697 698 699 700 701 702 703 704 705 706 707 708 709 710 711 712 713 714 715 716 717 718 719 720

D351

E351

I352 I353 I354

I355 L351 L352 L353 L354 L357

Q352 Q354 Q355

R351 R352 R359 R360 R361 R363 R364 R366 R367 R368 R369 R370 R371 R372 R373 R377 R378 R379 R380 R381 R384 R385

HITACHI HITACHI

PARTS NO. DESCRIPTION

DS-0001AC1

CN-A13P01AU

IC-0001AQ0 IC-0006AC3 IC-0007AC3 IC-0008AC3

2123103M

LF-T100J 2123411M 2123103M 2123411M

TB-0004AC1 TB-0005AC1 TB-0005AC1

0790031R 0790041R 0790024R 0790033R 0790024R 0790038R 0790001R 0790028R 0790051R 0790037R 0790038R 0790042R 0790051R 0790037R 0790051R 0790024R 0790024R 0790001R 0790024R 0790024R 0790037R 0790042R

CHIP DIODE HSM2838 13 PIN CONNECTO

IC-C-MOS MSP3410G-QI-B8V3 IC HA178L05A IC HA178L09 IC M51951BSL

COIL AXIAL 10UH RADIAL COIL 10U COIL AXIAL 1UH COIL AXIAL 10UH COIL AXIAL 1UH TRS. CHIP 2SC4265JCTR-E TRS. CHIP 2SC3052-T112-E,F TRS. CHIP 2SC3052-T112-E,F

CHIP RES RNC 1/16W 330R J CHIP RES RNC 1/16W 1.8K J CHIP RES RNC 1/16W 100R J CHIP RES RNC 1/16W 470R J CHIP RES RNC 1/16W 100R J CHIP RES RNC 1/16W 1.2K J CHIP RES RNC 1/16W 0 CHIP RES RNC 1/16W 220R J CHIP RES RNC 1/16W 10K J CHIP RES RNC 1/16W 1K J CHIP RES RNC 1/16W 1.2K J CHIP RES RNC 1/16W 2.2K J CHIP RES RNC 1/16W 10K J CHIP RES RNC 1/16W 1K J CHIP RES RNC 1/16W 10K J CHIP RES RNC 1/16W 100R J CHIP RES RNC 1/16W 100R J CHIP RES RNC 1/16W 0 CHIP RES RNC 1/16W 100R J CHIP RES RNC 1/16W 100R J CHIP RES RNC 1/16W 1K J CHIP RES RNC 1/16W 2.2K J

SN ST SNT S

REMARK

- 31 -

REPLACEMENT PARTS LIST

R

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

721 722 723 724 725 726 727 728 729 730 731 732 733 734 735 736 737 738 739 740 741 742 743 744 745 746 747 748 749 750 751 752 753 754 755 756

R386 R387 R388 R395

X352 X353

E404

E906L

E906R

F901 R702 R703 R704 R705 R706

S702

S703

S704

S705

S707

S901

RK704

X701

#D701

D701

EP404

EP906L

EP906R

FP901 RP702 RP703 RP704 RP705 RP706 RP707

SP701

HITACHI HITACHI

PARTS NO.

0790051R 0790024R 0790024R 0790001R

CP-04M43AP

BP01161

EQ00212 2729252BR-H 2729252BR-H

2721615A 0700032M 0700032M 0700034M 0700037M 0700039M TA-0001AI TA-0001AI TA-0001AI TA-0001AI TA-0001AI

FG00221

0700045M

CZ01161

TSP2015601

CH02081

CHIP RES RNC 1/16W 10K J CHIP RES RNC 1/16W 100R J CHIP RES RNC 1/16W 100R J CHIP RES RNC 1/16W 0 CERAMIC-TRAP TPSRF4M43J00-B0

X'TAL 18.432M JACK-3P YKC21-5071 FUSE HOLDER FUSE HOLDER FUSE T3.15A RES CAR 1/16W 220R J RES CAR 1/16W 220R J RES CAR 1/16W 330R J RES CAR 1/16W 560R J RES CAR 1/16W 820R J TACT SWITCH EVQ11A05R TACT SWITCH EVQ11A05R TACT SWITCH EVQ11A05R TACT SWITCH EVQ11A05R TACT SWITCH EVQ11A05R POWER SWITCH RES CAR 1/16W 2.2K J RC RECEIVE LED HOLDER LED

DESCRIPTION

EQ00212 JACK-3P YKC21-5071 2729252BR-H 2729252BR-H

2721617 0700032M 0700032M 0700034M 0700037M 0700039M 0700045M

FUSE HOLDER FUSE HOLDER FUSE T5A RES CAR 1/16W 220R J RES CAR 1/16W 220R J RES CAR 1/16W 330R J RES CAR 1/16W 560R J

RES CAR 1/16W 820R J RES CAR 1/16W 2.2K J

TA-0001AI TACT SWITCH EVQ11A05R

SN ST SNT S

REMARK

Only Front Control Model

Only Side Control Model

- 32 -

REPLACEMENT PARTS LIST

R

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

757 758 759 760 761 762 763 764 765

SP702 SP703 SP704 SP705 SP706 SP901

XR701

#DR701

DR701

HITACHI HITACHI

PARTS NO. DESCRIPTION

TA-0001AI TACT SWITCH EVQ11A05R TA-0001AI TACT SWITCH EVQ11A05R TA-0001AI TACT SWITCH EVQ11A05R TA-0001AI TACT SWITCH EVQ11A05R TA-0001AI TACT SWITCH EVQ11A05R

FG00221 POWER SWITCH CZ01161 RC RECEIVE

TSP2015601 LED HOLDER

CH02081 LED

SN ST SNT S

REMARK

Only Side Control Model

VMCRT

1 2 3 4 5 6 7 8

9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

C651 C652 C653 C654 C655 C656 C657 C658 C659 C660 C661 C662 C663 C664 C665 C666 C667 C668 C669 C672 C673 C674 C675 D651

0890082R 0890082R 0890082R 0890087R 0890087R 0890087R

CE-1TZ103

0800354R 0299914F

CE-1TZ103

0800326R

CE-1TZ103

0890123R 0800319R 0247846R

AL00006R

0800317R 0800326R 0246466R 0800319R

AL00007

0890081R

AJ00559

2338321M

CAP CER 390PF 50V K CAP CER 390PF 50V K CAP CER 390PF 50V K CAP CER 1000PF 50V K CAP CER 1000PF 50V K CAP CER 1000PF 50V K CAP CER 0.01UF 50V Z CAP ELEC 470UF 25V M CAP POLYPROPY 0.01UF 200V K CAP CER 0.01UF 50V Z CAP ELEC 100UF 16V M CAP CER 0.01UF 50V Z CAP CER 47PF 50V J CH CAP ELEC 47UF 35V M CAP CER 47PF 500V J SL CAP ELEC 10UF 160V M CAP ELEC 47UF 16V M CAP ELEC 100UF 16V M CAP CER 120PF 50V J CH CAP ELEC 47UF 35V M CAP ELEC 22UF 160V M CAP CER 330PF 50V K CAP CER 2200PF 2KV K DI 1SS270

- 33 -

REPLACEMENT PARTS LIST

K

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

D652 D653 D654

DQ661

E202 E502 E505 E651 E652 E654 L651 L652 L653 L654 L655 L656 L657 L661 L662

L663 Q651 Q652 Q653 Q654 Q655 Q656 Q657 Q658 Q659 Q660 Q661 Q663

R651 R653 R654 R655

HITACHI HITACHI

PARTS NO. DESCRIPTION

2338321M DS-0005AAM DS-0005AAM

2338321M

2902265 2902263 2902262

ED03172

2902261

2698352C

2123766R 2123766R

2123766R 2123116M 2123407M

BH01162M

2123109M

BH00697R BH00697R BH00697R

TB-0002AFR TB-0002AFR

TB-0002AFR TB-0003ACR TB-0003ACR TB-0003ACR TB-0003ACR TB-0001ACR

TB-0003AFR

TB-0004AFR TB-0003ACR TB-0003ACR

0700063M

AT03863M

0700044M 0700044M

DI 1SS270 DI EU1(V1) DI EU1(V1) DI 1SS270 6P CONNECTOR 4P WITH BASE PLUG PIN SUB MINI 2P WITH BASE 2P CONNECTOR CRT SOCKET HPS0521-010401 COIL RADIAL 180UH COIL RADIAL 180UH COIL RADIAL 180UH COIL AXIAL 100UH COIL AXIAL 0.47UH FERRITE BEAD CORE 2.3UH COIL AXIAL 33UH COIL RADIAL 100UH COIL RADIAL 100UH COIL RADIAL 100UH TRS 2SC3620 (Form1) TRS 2SC3620 (Form1) TRS 2SC3620 (Form1) TRS 2SC5395-E,F TRS 2SC5395-E,F TRS 2SC5395-E,F TRS 2SC5395-E,F TRS 2SA1993-E,F TRS 2SA1930(LBS4MBS-K) TRS 2SC5171(LBS4MBS-K)(Form) TRS 2SC5395-E,F TRS 2SC5395-E,F RES CAR 1/16W 47K J RES CAR 1/2W 270R J RES CAR 1/16W 1.8K J RES CAR 1/16W 1.8K J

SN ST SNT S

REMARK

- 34 -

REPLACEMENT PARTS LIST

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96

R656 R657 R658 R659 R660 R661 R662 R663 R664 R665 R666 R667 R668 R669 R670 R671 R672 R673 R674 R675 R676 R677 R678 R680 R681 R682 R683 R685 R686 R687 R688 R689 R690 R691 R692 R693

HITACHI HITACHI

PARTS NO. DESCRIPTION

0700044M 0700017M

RF-S50F471JA

0700037M 0700065M 0700024M 0700024M 0700024M 0700033M 0700033M 0700033M 0700065M

AT03853M

0188096M

RM-W02F331JA

0700027M 0700027M 0700027M 0700046M 0700041M 0700038M 0700027M 0700055M

0700027M RM-W03F123JA RM-W03F123JA RM-W03F123JA

0700027M

0700037M

AT03853M

0188096M

0700038M

0700025M

AT03867M AT03867M AT03867M

RES CAR 1/16W 1.8K J RES CAR 1/16W 18R J RES FUSE 1/2W 470R J RES CAR 1/16W 560R J RES CAR 1/16W 68K J RES CAR 1/16W 56R J RES CAR 1/16W 56R J RES CAR 1/16W 56R J RES CAR 1/16W 270R J RES CAR 1/16W 270R J RES CAR 1/16W 270R J RES CAR 1/16W 68K J RES CAR 1/2W 47R J RES CAR 1/2W 2.7R J RES MTL OXIDE 2W 330R J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 100R J RES CAR 1/16W 2.7K J RES CAR 1/16W 1K J RES CAR 1/16W 680R J RES CAR 1/16W 100R J RES CAR 1/16W 12K J RES CAR 1/16W 100R J RES MTL OXIDE 3W 12K J RES MTL OXIDE 3W 12K J RES MTL OXIDE 3W 12K J RES CAR 1/16W 100R J RES CAR 1/16W 560R J RES CAR 1/2W 47R J RES CAR 1/2W 2.7R J RES CAR 1/16W 680R J RES CAR 1/16W 68R J RES CAR 1/2W 560R J RES CAR 1/2W 560R J RES CAR 1/2W 560R J

SN ST SNT S

REMARK

- 35 -

REPLACEMENT PARTS LIST

PRODUCT SAFETY NOTE : Components marked with a have special characteristics important to safety. Before

replacing any of these components, read carefully the PRODUCT SAFETY NOTICE of this Service Manual. Don't degrade the safety of the receiver through improper servicing

NO CCT NO.

97 98

99 100 101

102 103

R694 R695 R696 R697

V1

HITACHI HITACHI

PARTS NO. DESCRIPTION

AT03844M

0100095M 0100095M

0100095M PT-A29F01AI FLAT CRT A68QCU770X71N LGV1 PT-B29F01AI FLAT CRT A68QCU770X71N LG

BY01911 DY 29 INCH

2276067L DEGUASSING COIL

-

RES CAR 1/2W 10R J RES CAR 1/8W 18K J RES CAR 1/8W 18K J RES CAR 1/8W 18K J

SN ST SNT S

REMARK

- 36 -

A

APPENDIX

I. For using AC CORD , please see information in Table 1

Table 1.

No Part No Description Destination

1 TWI4002601P AC CORD Code 071, 193 ( SAU )

2 2972581A AC CORD

3 2972591A AC CORD Code 081 ,433 , 435 , 101 , 194 (IRAN) , 194(Brunei) 4 EV00071U AC CORD Code 051 , 193 ( KUW )

II. For using I702, Please see information in Table 2

Table 2.

No Part No Description Destination

IC-0010AC1 IC M37160M8-081FP(V0.62)

1

IC-0005AC1 IC M37160M8-074FP(V0.60)

2 IC-0010AC1 IC M37160M8-081FP(V0.62)

IC-0009AC1 IC M37160M8-077FP(V5.62)

3

IC-0011AC1 IC M37160M8-082FP(V5.63)

ll code, except Code 051,081,433,435,101,193(SAU),

193(KUW),194(IRAN),194(Brunei)

Code 071

ll code except code 193, 194

Code 193, 194

III. Front control or Side control

Table 3.

No Model Name

1 C29-TF641S/SN/ST/SNT 2 C29-TF651S/SN/ST/SNT 3 C29-TF751S/SN/ST/SNT

Control

Front control Side control

- 37 -

HITACHI

Hitachi Consumer Products ( Thailand ) , Ltd.

99/9 Moo 3 Soi Wat Saothongklang, Bangna-Trad k.m.23rd Rd., Tambol Bangsaothong,

Ging Amphur Bangsaothong, Samutprakarn 10540

Tel. (001-66-2) 3979040 Fax. (001-66-2) 3979050

Hitachi, Ltd.

Head Office : 5-1 , 1-Chome, Marunouchi, Chiyoda-ku, Tokyo

Tel : TOKYO (212) 1111 ( 80 Lines )

Cable Address : " HITACHY " TOKYO Codes : All Codes Used