Page 1
SERVICE SERVICE
MANUALMANUAL
Page 2
CONTENTS
X-RAY RADIATION PRECAUTION………………………………………………………1
SAFETY PRECAUTION
…………………………………………………………………..
1
PRODUCT SAFETY NOTICE…………………………………………………………….2
GENERAL INSTRUCTION……………………………………………………………………2
ALIGNMENT ITEMS AND PROCEDURE………………………………………………..2
FACTORY ADJUSTMENT MODE
…………………………………………………………
4
ADJUSTMENT METHOD………………………………………………………………………4
CHECKING POINTS……………………………………………………………………………6
OUT-FACTORY MODE PRESET……………………………………………………………6
POWER ADAPTABILITY CHECK
……………………………………………………………
USA CHANNEL FREQUENCY TABLE (181 CH)
………………………………………
7
15
WIRING DIAGRAM……………………………………………………………………….17
BLOCK DIAGRAM………………………………………………………………………...18
TDC200 WIRING DIAGRAM……………………………………………………………….19
TDC200 BLOCK DIAGRAM
………………………………………………………………...
20
IC BLOCK DIAGRAM……………………………………………………………………..21
SCHEMATIC DIAGRAM………………………………………………………………….29
ELECTRICAL PARTS LIST………………………………………………………………31
0
Page 3
CAUTION: THIS SERVICE MANUAL IS ONLY FOR PROFESSIONAL SERVICE PERSONNEL’S
REFERENCE. BEFORE SERVICING THIS CHASSIS, PLEASE READ THE FOLLOWING
NOTICE ITEMS.
1. SAFETY INSTRUCTION AND GENERAL INSTRUCTION
Before servicing and aligning this equipment, please read the following “X-RAY RADIATION
PRECAUTION” ,“SAFETY PRECAUTION” and “PRODUCT SAFETY NOTICE”.
1.1 X-RAY RADIATION PRECAUTION
1) Excessive high voltage can produce potentially hazardous X-RAY RADIATION. To avoid such hazards, the
high voltage must not be above the specified limit. The normal value of the high voltage of this receiver is under
30 kV at zero beam current (minimum brightness) under DC135V main power(B+) , the high voltage must not,
under any circumstances, exceed 32 kV.
2) Each time a receiver requires servicing, the high voltage should be checked following the HIGH VOLTAGE
CHECK procedure in this manual. It is recommended the reading of the high voltage be recorded as a part of
service record. It is important to use an accurate and reliable high voltage meter.
* When checking, main power (B+) should be kept at (100V : for 20”).
3) The primary source of X-RAY RADIATION in this TV receiver is the picture tube. For continuous X-RAY
RADIATION protection, the replacement tube must be exactly the same type tube as specified in the parts list.
4) Some parts in this receiver have special safety-related characteristics for X-RAY RADIATION protection.
For continuous safety, parts replacement should be undertaken only after referring to the PRODUCT SAFETY
NOTICE below.
1.2 SAFETY PRECAUTION
WA RN I N G:
Service should not be attempted by anyone unfamiliar with the necessary precaution on this receiver. The
following are the necessary precautions to be observed before servicing this chassis.
1) Since the power supply circuit of this receiver is directly connected to the AC power line, an isolation
transformer should be used during any dynamic service to avoid possible shock hazard.
2) Always discharge the picture tube anode to the CRT conductive coating before handling the picture tube. The
picture tube is highly evacuated and if broken, glass fragments will be violently expelled. Use shatter proof
goggles and keep picture tube away from the unprotected body while handling.
3) When replacing a chassis in the cabinet, always be certain that all the protective devices are put back in place,
such as: non-metallic control knobs, insulating covers, shields, isolation resistor-capacitor network etc.
4) When replacing parts or circuit boards, disconnect the power cord.
5) When replacing a high wattage resistor (oxiode metal film resistor) on the circuit board, keep the resistor
10mm (1/2in) away from circuit board.
6) Connection wires must be kept away from components with high voltage or high temperature.
7) If any fuse in this TV receiver is blown, replace it with the FUSE specified in the chassis parts list.
1
Page 4
1.3 PRODUCT SAFETY NOTICE
Many electrical and mechanical parts in the chassis have special safety-related characteristics. These
characteristics are often passed unnoticed by a visual inspection and the X-RAY RADIATION protection
afforded by them cannot necessarily be obtained by using replacement components rated for higher wattage,
etc. Replacement parts which have these special safety characteristics are identified in this manual and its
supplement electrical components having such features are shaded on the schematic diagram and the parts
list.
Before replacing any of these components, read the parts list in this manual carefully. The use of substitute
replacement parts which do not have the same characteristics as specified in the parts list may create shock,
fire, X-RAY RADIATION or other hazards.
1.4 General instruction
1.4.1 This chassis’ EEPROM(N801 M24C08) should copy standard data first, if necessary, deal it with
2
“factory adjustment”. If directly use blank EEPROM, should first preset I
C data, then go on other
common alignment. For factory adjustment method, refer to The appendix: Factory adjustment
mode.
1.4.2
If without special indication, the alignment is conducted on the below condition:
AC power supply 120 V/60 Hz.(North America area) or others (depending on selling market).
a)
b)
The whole unit is preheated for more than 30 min.
There is built-in auto degaussing circuit, it will degauss automatically within 1second after turning on. And
1.4.3
the auto degaussing circuit can effect only when turning off the set and waiting for at least 30min and then
turning on.
1.4.4
If CRT is with magnetism and affects color purity and convergence, the internal degaussing can not
degauss completely, can use degaussor to degauss externally. If color purity and convergence is still poor,
then do color purity and convergence adjustment.
2 Alignment items and procedure
2.1 B+ voltage check
2.2 OSD character center adjustment
2.3 RFAGC voltage adjustment
2.4 Focus adjustment
2.5 Screen-grid voltage and white balance adjustment
2.6 SECAM colour adjustment
2.7 Horizontal, vertical scanning center adjustment
2.8 Horizontal, vertical scanning amplitude adjustment
2.9 Raster correction adjustment
2.10 The alignment flow chart see below figure.
2
Page 5
EEPROM copy
High voltage check
X-ray protection check
B+ check
Filament voltage check
OSD position
RFAGC adjustment
Picture and sound
Stereo/mono/SAP
Sub-brightness check
FOCUS
White balance check
Screen-grid voltage
White balance adjustment
Color purity
convergence check
¡¢
Scanning amplitude center &
raster correction adjustment
AV terminals
Video/S-VHS/DVD
DVD function check
Self alignment
Check
The TV set & remote
controller's function check
Figure 1: Alignment flow chart
3
Page 6
3 Factory adjustment mode
3.1 Enter into factory adjustment menu
Press SLEEP→MUTE→DSP→MENU button on the remote controller in order (the period of two
press should be less than 5 seconds), the screen will appear factory alignment menu.
3.2 Factory menu operation
Repeatedly press“MENU” button, then the menu will enter into PAGE 1→PAGE 2→PAGE 3→
PAGE 4→PAGE 5 and recycle, press ▲ or ▼ button can select adjustment items upward or
downward, and press ◄ or ► button to confirm or adjust the item’s value.
3.3 To exit the factory menu
Press “SLEEP”button to exit the factory adjustment menu.
4 Adjustment method
4.1 B+ voltage adjustment
a) Make sure the power supply is AC120 V/60 Hz(for America or Canada area).
b) Connect the digital voltmeter to B+ testing point, receive A7 signal, set the picture control to
“STANDARD”status, adjust RP501 to make B+ voltage be (24”: 135V ±0.2 V , 20”: 100 V±
0.2 V ) (just for pure flat CRT, as regards to other CRT, B+ value will be marked on the parts list.)
c) In STAND BY mode, the B+ voltage will be under 20V.
4.2 OSD position adjustment
Receive NTSC signal, change the factory adjustment menu page 3 OSD item’s value to make user’s
menu be in screen’s center position.
4.3 AGC adjustment
a) Receive 60 dB split field (or grey-scale) signal.
b) Use oscilloscope or digital voltmeter to monitor tuner 1 pin’s voltage (RFAGC pin).
c) Select factory adjustment menu page 4 R-AGC item, making use of [←][ →] button to increase the
value from down to up until the voltage just reach 4.0 V, at this time picture noisy spots should
disappear basically. Otherwise continue to fine tune R-AGC item.
d) Exit the factory menu.
4.4 Focus adjustment
4.4.1 Receive A12 signal, set picture mode to “STANDARD”status.
4.4.2 Adjust FBT FOCUS potentiometer to make screen’s B area’s focus optimum.
4.5 Screen-grid voltage,white balance adjustment
4.5.1 Receive A7 split field signal, set picture mode to “STANDARD” status.
4.5.2 Keep RCUT’s value, not change it (for example set it to 60), roughly adjust GCUT and BCUT
value to make white balance basically normal.
4.5.3 Set colour,contrast to minimum, set brightness to 50. Use oscilloscope to monitor CRT board red
gun waveform, adjust PAGE 4 BRTS value to make black level be 175 V.
4.5.4 Adjust SCREEN, accelerating electrode, potentiometer to make picture brighten 4 lattices.
4.5.5 Fine adjust white balance(colour temperature:12000K±8MPCD X=0.270±0.008 Y=0.283±
4
Page 7
0.008).
4.5.6 Adjust PAGE 2 BRTN value to make colour ,brightness,contrast all be minimumpicture“white block”
slightly lights up.
4.6 Horizontal,vertical scanning center adjustment
4.6.1 PAL(50 Hz)horizontal,vertical center adjustment
Receive G23 signal, set picture mode to “STANDARD”status, fine tune vertical center VP50,
horizontal center HPOS, to make picture center be in accordance with screen center.
4.6.2 NTSC(60 Hz)H-center,V-center adjustment
Receive A6 signal, set picture mode to “STANDARD” status, adjust V-center VP60, H-center HPS, to
make picture center be in accordance with screen center.
4.7 Vertical scanning amplitude adjustment
4.7.1 PAL(50 Hz)vertical amplitude adjustment
Receive D35 signal, set picture mode to “STANDARD” status, adjust vertical amplitude HIT, to make
picture up/down overscanning be screen size’s 8%.
4.7.2 NTSC(60 Hz)vertical amplitude adjustment
Receive A12 signal, set picture mode to “STANDARD”status, adjust V-amplitude HITS, to make
picture up/down overscanning be screen size’s 8%.
4.8 Raster correction adjustment,H-amplitude adjustment
4.8.1 PAL(50 Hz)raster correction adjustment ,H-amplitude adjustment.
Receive PAL white crosshatch signal, set picture mode to “STANDARD” status, adjust DPC to make
raster distortion be in minimum, adjust WID to make picture left/right overscanning be screen size’s
8%.
4.8.2 NTSC(60 Hz)raster correction adjustment
Receive NTSC A21 signal, set picture mode to “STANDARD” status, adjust DPCS to make raster
distortion minimum, adjust WIDS to make picture left/right overscanning be screen size’s 8%.
4.9 If scanning linearity distortion and raster geometrical distortion can not reach the requirements, and if
necessary, can make use of factory adjustment menu to adjust the following items:
VLIN V-linearity adjustment(PAL)
VLIS V-linearity adjustment (NTSC)
VSC Vertical S-correction adjustment (PAL)
VSS Vertical S-correction adjustment (NTSC)
CNRT Top corners’ correction
CNRB Bottom corners’ correction
KEY Trapezoid correction (PAL)
KEYS Trapezoid correction(NTSC)
4.10 Maximum sound output power
Receive single tone signal, set volume to maximum, the sound output power is 2×3 W(24”) and
2×2.5 W(20”) . (can fine adjust factory menu V100)
5
Page 8
5 Checking points
5.1 High voltage check
5.1.1 Connect high voltmeter to CRT second anode and GND.
5.1.2 Receive A7 signal, set picture mode to “STANDARD” status, measure the high voltage value, the
reading should be 29 kV±1 kV.
5.1.3 When setting brightness and contrast to minimum(zero beam current), measure the high voltage value,
the reading should not exceed 32 kV.
5.2 CRT filament voltage check
Receive A7 signal, set picture mode to “STANDARD” status, use effective value voltmeter to measure
CRT filament voltage, the reading should be (6.3±0.3)Vrms.
5.3 X-ray protection check
5.3.1 Receive A7 signal, set picture mode to “STANDARD” status.
5.3.2 Short S301, X-ray protection circuit should effect.
5.4 Picture and sound check
5.4.1 Receive standard TV signal.
5.4.2 Make use of picture control buttons to check colour,contrast,brightness,sharpenss,tint’s control
function.
5.4.3 Make use of sound control buttons to check sound control function.
5.5 Sub-brightness check.
Receive A7 signal, set colour,contrast,brightness all to 0, picture left one lattice slightly lights up.
5.6 This set can produce 14 kinds of testing signals by itself. In factory menu when select some adjustment
item, every press of AV button for one time, it will produce one testing signal.
5.7 Colour purity and convergence check(in normal way)
5.8 AV terminal input/output check
5.9 Other control buttons on the set/remote controller function check
6 Out-factory mode preset
Press“SHOP OUT” button, out-factory status will be preset to:
6.1 Picture menu: Colour 70
Brightness 70
Contrast 100
Sharpness 50
Tint 00
Blue background On
6.2 Volume preset to: 30
6.3 Language menu: ENGLISH
6.4 Colour system : AUTO
6.5 NOISE REDUCE: OFF
6
Page 9
6.6 TV mode: Channel positionA2
6.7 SVM: MILD
6.8 V-CHIP PASSWORD: 0000
6.9 CHILD LOCK MENU
PAS SW OR D:
0000
6.10 SOUND MODE: NEWS
6.11 TV/CATV CHANNEL: Both set to ADD
6.12 CCD CHANNEL: Set to C1
6.13 V-CHIP: Set all ratings and contents to IGNORE
6.14 V-CHIP BLOCK ON/OFF: Set to ON
7 Power adaptability check
AC 120V/60Hz (for North America area. If have other special AC power supply requirements, then check with
requirements).
Page Item
NO.
1
1 HPOS 0E 50Hz H-center STANDARD D35
2 WID 10 50Hz H-size STANDARD D35 To make H-size meet standard
3 HPS 03 60Hz H-center STANDARD A12
4 WIDS 01 60Hz H-size STANDARD A12 To make H-size meet standard
5 HIT 35 50Hz V-size STANDARD D35 To make V-size meet standard
6 VP50 06 50Hz V-center STANDARD D35
7 VLIN 0E 50Hz V-linearity STANDARD D35
8 VSC 05
9 HEHT 04
10 VEHT 04
11 TNTC 40
OSD
symbol
APPENDIX 1 FACTORY ADJUSTMENT MENU
Preset
Adjustment
item
50Hz
V S-correction
Horizontal high
voltage
compensation
Vertical high
voltage
compensation
NTSC tint center
value setting
Analogue
setting
STANDARD D35
STANDARD D35/A12 Fix
STANDARD D35/A12 Fix
Contrast 100
Tint 100
brightness70
color70
Input
signal
A7 Fix
Adjustment method
To make picture horizontal
center be in accordance with
CRT center
To make picture vertical center
be in accordance with CRT
center
To make picture vertical center
be in accordance with CRT
center
To make upper/dower part
crosshatch height be equal
To make upper/middle/lower
part crosshatch height be in
equal
7
Page 10
12 TNTN 00
NTSC tint
minimum value
setting
13 SCOL 02
14 SCNT 07
15 ASSH 00
Sub-color
adjustment
Sub-brightness
adjustment
Non-symmetry
sharpness
Contrast 100
Tint 0
brightness70
A7 fix
color 70
STANDARD A7 Fix
STANDARD Gray scale Fix
Fix
ABL control
16 ABL 23
(refer to
appendix 2 for
SPORTS A7 Fix
details)
17 VSS 02
1
60Hz
V S-correction
STANDARD A12
18 VLIS FE 60Hz V-linearity STANDARD A12
To make upper/middle/lower
part crosshatch height be
equal.
To make upper/lower part
crosshatch height be equal
To make picture vertical center
19 VP60 02 60Hz V-center STANDARD A12
be in accordance with CRT
center.
20 HITS 03 60Hz V-size STANDARD A12 To make V-size meet standard
2
21 G CUT 66
22 B CUT 6C
23 G DRV 45
24 B DRV 4D
Dark area white
balance
Bright area white
balance
SPORTS
Black/white
balance
signal or
A7
Black/white
balance
signal or
A7
To make picture dark area
obtain standard white color.
To make picture bright area
obtain standard white color.
Black/whit
25 R CUT 60
Dark area white
balance
e balance
signal or
To make picture dark area
obtain standard white color.
A7
Contrast
26 CNTX 3D
maximum value
SPORTS Gray scale Fix
setting
27 CNTC 36
28 CNTN 22
29 BRTX 3D
Contrast center
value setting
Contrast
minimum value
setting
Brightness
maximum value
setting
Contrast 50 Gray scale Fix
Contrast0
color 0
Gray scale Fix
brightness50
Contrast50
color 0
brightness10
A7 Fix
0
8
Page 11
30 BRTC 36
31 OSD 17
32 COLX 70
33 COLC 3B
34 COLP 20
35 COLN 00
36 TNTX 6F
37 BRTN 20
38 BRTS 24 Sub-brightness
39 V100 E0
40 RAGC 2A RF AGC STANDARD A7 Refer to adjustment method
3
41 DPC 0C
42 KEY 1B
43 DEF 01
44 FLG 0 52
45 FLG 1 E5
Brightness
center value
setting
OSD H-position
setting
Color maximum
value setting
Color center
value setting
(NTSC)
Color center
value setting
(PAL)
Color minimum
value setting
NTSC tint
maximum value
setting
Brightness
minimum value
setting
VOL-100%
volume setting
50Hz pincushion
correction
50Hz pincushion
correction
Interlace scan
setting 01
Refer to
Appendix 2 for
details
Refer to
Appendix 2 for
details
contrast0
color 0
brightness50
SPORTS A7 Fix
STANDARD A7 Fix
STANDARD AV(PAL) Fix
Contrast
100
color 0
brightness50
Contrast
100
color 70
brightness70
tint 0
Contrast 0
color 0
brightness0
contrast0
color 0
brightness50
VOL-100%
STANDARD D35
STANDARD D35 To correct picture trapezoid
Fix
Fix
Fix
A7 Refer to adjustment methods
Any TV
signal and
display
MENU
screen
A7 To make picture without color
A7 Fix
A7 Refer to adjustment method
A7 Refer to adjustment method
Mono
signal
The character be in screen
center.
Refer to adjustment method
To correct picture E/W
pincushion
9
Page 12
46 STBY 00
Refer to
Appendix 2 for
Fix
details
47 TNCD 40 Tint center (DVD) Fix
Refer to
48 VBLK 00
Appendix 2 for
Fix
details
Refer to
49 MOD 03
Appendix 2 for
Fix
details
Refer to
50 UCOM 80
Appendix 2
Fix
for details
51
MOD3 80
Refer to
Appendix 2 for
Fix
details
Refer to
52 OPT 17
Appendix 2 for
Fix
details
Refer to
53 OPTM1 B2
Appendix 2 for
Fix
details
Refer to
54 OPTM2 65
3
Appendix 2 for
details
Fix
55 TUNR 02 Tuner select Fix
56 CNRT 1D
Top edge/corner
correction
STANDARD D35/A12
Bottom
57 CNRT 15
edge/corner
STANDARD D35/A12
correction
58 KEYS 01
59 DPCS 00
60Hz trapezoid
correction
60Hz pincushion
correction
STANDARD A12 To correct picture trapezoid
STANDARD A12
Sub-sharpness
center value
4
60 ST3 1F
when input
STANDARD A12 Fix
NTSC3.58 TV
signal
Sub-sharpness
center value
61 SV3 30
when input
STANDARD AV-N3.58 Fix
NTSC3.58 AV
signal
To correct top edge and corner
vertical line
To correct bottom edge and
corner vertical line
To correct picture E/W
pincushion
10
Page 13
Sub-sharpness
center value
62 SV4 30
when input non
STANDARD AV-N4.43 Fix
NTSC3.58 AV
signal.
Sub-sharpness
63 SVD 30
center value
when in DVD
STANDARD DVD Fix
input
64 SHPX 1A
Sharpness
maximum value
setting
Sharpness
100
A12 Fix
Sharpness
65 SHPN 1D
minimum value
Sharpness 0 A12 Fix
setting
66 TXCX 1F
67 RGCN 1F
DVD sub-color
maximum value
DVD sub-color
minimum value
SPORTS DVD Fix
STANDARD DVD Fix
68 DCBS 22 Fix
Refer to
69 CLTM 0F
appendix 2 for
STANDARD A12 Fix
details
Refer to
70 CLVO 4F
appendix 2 for
STANDARD AV Fix
details
Refer to
71 CLVD 58
appendix 2 for
STANDARD DVD Fix
details
72
73
CCD
OSD
CCD
OSDH
16 CCD H-position
CCD OSD
55
oscillating
Fix
frequency
Display
CCD
caption
CCD character be in screen
center
74 HAFC 05 AFC gain Fix
75 VCEN 00
76 NSHP 10
IC output vertical
signal center
Noise reducing
degree
Fix
STANDARD Fix
77 SYCT 08 (TEST) Fix
78 NOIS 01 (TEST) Fix
79 ONTM 00
5
80 V25 D0
POWER ON
MUTE TIMER
Volume setting in
VOL-25%
Fix
VOL-25
MONO
signal
Fix
11
Page 14
81 V50 E0
82 OSDF 55
83 SUR 1 00
84 BASC 30
85 BASX 40
86 TREC 39
87 BALC 32
88 WOFC 3D
89 BAS 1 32
90 BAS 2 5A
91 TRB 1 32
92 TRB 2 28
5
Note 1: firstly adjust PAL signal (D35), then adjust NTSC (A12), then recheck PAL signal (D35), please prior to guarantee
NTSC raster.
Note 2: when check PAL color, the inputting signal should be AV signal.
93 WCTL 30 Woofer control Fix
94 WON 1 00
Volume setting in
VOL-50%
OSD oscillating
frequency
Surround sound
data at Sound
register 1
Bass center
value setting
Bass maximum
value setting
Treble center
value setting
Balance center
value setting
Woofer center
value setting
Bass data at
Sound Register 1
Bass data at
Sound Register 2
Treble data at
Sound Register 1
Treble data at
Sound
Register2
“Woofer on” at
Sound Register 1
VOL-50
Fix
Fix
VOL-50
VOL-50 Fix
VOL-50 Fix
VOL-50 Fix
Fix
VOL-50 Fix
VOL-50 Fix
VOL-50 Fix
VOL-50 Fix
Fix
MONO
signal
Sound
sweep
frequency
signal
Fix
Fix
Appendix 2 factory adjustment menu remarks
1:POF over-modulation switch
is connected
FLG0
BIT0 Over Mod Switch 0:normal
BIT1 AFT window 0:out of AFT window 1:in the AFT window
BIT2 Buzz reduction 0:Nyquist Buzz cancel on 1:off
BIT3 Orthogonal detection gain 0:ont use 1:not use
BIT4 Local SECAM 0:not use 1:not use
BIT5 5.65MHz SIF 0:not use 1:not use
BIT6 5.74MHz SIF 0:not use 1:not use
BIT7
Frequency select no VCO
adjustment
0:have VCO 1:without VCO
12
Page 15
CW on/off 0:off 1:on, CW ouput from IC pin26#
BIT1 Y out on 0:not use 1:not use
FLG1
MOD
UCOM
MOD3
OPT
OPTM1
OPTM2
CLTM
(in TV
mode)
13
BIT2 MIZ gain
BIT5 C trap pass(test) 0:not use 1:not use
BIT6 Detection NTSC3.58 0:not use 1:not use
BIT7 teletext 0:not use 1:not use
BIT0
BIT1
BIT2 Cut off range 0:-0.65 to +6.5 1:-0.65 to +0.85
BIT0 00:GND 10:B out
BIT1
BIT2 rest pattern from ucom 0:normal 1:
BIT3 use ucom sync switch 0:normal 1:use ucom sync
BIT4 Sync to ucom 0:no use 1:no use
BIT5 v-switch out ucom 0:no use 1:no use
BIT7 OSD HD input polarity 0:no use 1:no use
BIT4-0 VIDEO mute time Mute time=data X 8ms
BIT7 VIDEO mute type 0:Y mute 1:RGB out cut off DC
BIT0 FBB-MUTE 0:
BIT1 FBB-EXMUTE 0:
BIT2 FYMUTE USE 0:
BIT3 Sound gain SW 0:50Hz 1:500mV RMS-25kHz/dev
BIT4 Vertical frequency force 0:50Hz 1:60Hz
BIT5 Sync detection 0:exernal 1:internal
BIT7 Sync distinguish way 0: 1:gain noise detection
BIT0 FJP-SVM USE 0:SVM out 1:monitor out
BI T1 AV selec t 0:AV 1-AV2(D VD)-AV3 1 :AV1-AV2 -DVD
BIT2 FJP-GAME 0:without game 1:have game
BIT3 On-timer indication 0:low level, on-timer on 1:high level, on-timer on
BIT6 FJP-M-PAL 0:others 1:only PAL-M
BIT7 FJP-stereo 0:without stereo 1:have stereo
BIT0 FJP-Y.U.V 0:without Y.U.V 1:have Y.U.V
BIT1 FJP-language 0:English/French/Spanish 1:English/Tradtional Chinese
BIT2 F52797-VAMP 0:no gain 1:6dB gain
BIT4 FJP-display button 0;timer display OSD 1:always display
BIT5 FJP-woofer 0:without woofer 1:have woofer
BIT6 FJP-AUTO
BIT0
BIT1
BIT2
AKB CUT OFF sensitivity gain
inner ADC
Y delay (in TV mode)
0:SIF 1MHz convert gain,
low gain
00:X9.75
01:X10
01:R out 11:Monito RF AGC via ADC
0:AUTO2(35N,M-PAL,N-PA
L)
000:-40ns
001:0
010:40ns
011:80ns
1:high gain
10:X10.25
11: X10.5 0
1:when blue background off, not do
MUTE
1: when blue background off, not
do EXT-MUTE
1:when switching channels, use
Y- MU T E
1:AUTO1(44P,35N,44N)
100:120ns
101:160ns
110:200ns
111: 240n s
Page 16
CLVO
(in AV
mode)
CLVD
(in DVD
mode)
NDHP When NOISE REDUCE ON, sharpness register′s content = OSD sharpness value-NSHP value
BIT3 00:NTSC1(93°)
BIT4
BIT5 C-GAMMA 0:Chromaγcorrection off 1:Chroma correction on
BIT6 Color kill off 0:normal 1:color killer always off
BIT7 P/N ID
BIT0
BIT1
BIT2
BIT3 00:NTSC1(93°)
BIT4
BIT5 C-GAMMA 0:Chromaγcorrection off 1:Chromaγcorrection on
BIT6 Color kill off 0:normal 1:color killer always off
BIT7 P/N ID
BIT0
BIT1
BIT2
BIT3 00:NTSC1(93°)
BIT4
BIT5 C-GAMMA 0:Chromaγcorrection off 1:Chromaγcorrection on
BIT6 Color kill off 0:normal 1:color killer always off
BIT7 P/N ID
NTSC matrix
Y delay (in TV mode)
NTSC matrix
Y delay (in TV mode)
NTSC matrix
01:NTSC2(108°)
0:P/N color killing
sensitivity 1.2/1.5mVp-p
000:-40ns
001:0
010:40ns
011:80ns
01:NTSC2(108°)
0:P/N color killing
sensitivity 1.2/1.5mVp-p
000:-40ns
001:0
010:40ns
011:80ns
01:NTSC2(108°)
0:P/N color killing
sensitivity 1.2/1.5mVp-p
10,11 for DVD
1:6.6/6.4mVp-p
100:120ns
101:160ns
110:200ns
111: 240n s
10,11 for DVD
1:6.6/6.4mVp-p
100:120ns
101:160ns
110:200ns
111: 240n s
10,11 for DVD
1:6.6/6.4mVp-p
14
Page 17
BAN
D
VHF
Low
VHF
High
USA CHANNEL FREQUENCY TABLE (181 CH)
P IF=45.75 MHz
C IF=42.17MHz
S IF=41.25MHz
UNIT: MHz
CHANNE
L
W+1
W+2
W+3
W+4
W+5
W+6
W+7
W+8
W+9
W+10
P
CARRIER
2 55.25 59.75 101
3 61.25 65.75 107
4 67.25 71.75 113
5 77.25 81.75 123
6 83.25 87.75 129
A-6
A-5
A-4
A-3
A-2
A-1
A
B
C
D
E
F
G
H
I
7 175.25 179.75 221 15 477.25 481.75 523
8 181.25 185.75 227 16 483.25 487.75 529
9 187.25 191.75 233 17 489.25 493.75 535
10 193.25 197.75 239 18 495.25 499.75 541
11 199.25 203.75 245 19 501.25 505.75 547
12 205.25 209.75 251 20 507.25 511.75 553
13 211.25 215.75 257 21 513.25 517.75 559
J
K
L
M
N
O
P
Q
R
S
T
U
V
W
S
CARRIER
85.25 89.75 131
91.25 95.75 137
97.25 101.75 143
103.25 107.75 149
109.25 113.75 155
115.25 119.75 161
121.25 125.75 167
127.25 131.75 173
133.25 137.75 179
139.25 143.75 185
145.25 149.75 191
151.25 155.75 197
157.25 161.75 203
163.25 167.75 209
169.25 173.75 215 14 471.25 475.75 517
217.25 221.75 263 22 519.25 523.75 565
223.25 227.75 269 23 525.25 529.75 571
229.25 233.75 275 24 531.25 535.75 577
235.25 239.75 281 25 537.25 541.75 583
241.25 245.75 287 26 543.25 547.75 589
247.25 251.75 293 27 549.25 553.75 595
253.25 257.75 299 28 555.25 559.75 601
259.25 263.75 305 29 561.25 565.75 607
265.25 269.75 311 30 567.25 571.75 613
271.25 275.75 317 31 573.25 577.75 619
277.25 281.75 323 32 579.25 583.75 625
283.25 287.75 329 33 585.25 589.75 631
289.25 293.75 335 34 591.25 595.75 637
295.25 299.75 341 35 597.25 601.75 643
301.25 305.75 347 36 603.25 607.75 649
307.25 311.75 353 37 609.25 613.75 655
313.25 317.75 359 38 615.25 619.75 661
319.25 323.75 365 39 621.25 625.75 667
325.25 329.75 371 40 627.25 631.75 673
331.25 335.75 377 41 633.25 637.75 679
337.25 341.75 383 42 639.25 643.75 685
343.25 347.75 389 43 645.25 649.75 691
349.25 353.75 395 44 651.25 655.75 697
355.25 359.75 401
LOCAL BAND CHANN
EL
W+11
UHF
W+12
W+13
W+14
W+15
W+16
W+17
W+18 403.25
W+19
W+20
W+21
W+22
W+23
W+24
W+25
W+26
W+27
W+28
W+29
45 657.25 661.75 703
P
CARRIER
S
CARRIER
361.25 365.75 407
367.25 371.75 413
373.25 377.75 419
379.25 383.75 425
385.25 389.75 431
391.25 395.75 437
397.25 401.75 443
409.25 413.75 455
415.25 419.75 461
421.25 425.75 467
427.25 431.75 473
433.25 437.75 479
439.25 443.75 485
445.25 449.75 491
451.25 455.75 497
457.25 461.75 503
463.25 467.75 509
469.25 473.75 515
LOC
AL
407.75 449
15
Page 18
USA CHANNEL FREQUENCY TABLE (181 CH)
P IF=45.75 MHz
C IF=42.17MHz
S IF=41.25MHz
UNIT: MHz
BAND CHANNEL P CARRIER S CARRIER LOCAL
UHF
46 663.25 667.75 709
47 669.25 673.75 715
48 675.25 679.75 721
49 681.25 685.75 727
50 687.25 691.75 733
51 693.25 697.75 739
52 699.25 703.75 745
53 705.25 709.75 751
54 711.25 715.75 757
55 717.25 721.75 763
56 723.25 727.75 769
57 729.25 733.75 775
58 735.25 739.75 781
59 741.25 745.75 787
60 747.25 751.75 793
61 753.25 757.75 799
62 759.25 763.75 805
63 765.25 769.75 811
64 771.25 775.75 817
65 777.25 781.75 823
66 783.25 787.75 829
67 789.25 793.75 835
68 795.25 799.75 841
69 801.25 805.75 847
16
Page 19
Page 20
Page 21
IC BLOCK DIAGRAM
150V
1D
S
0.3V
2
Vth1
+--
1.7V
O.C.P/F.B
5
Vth2
+
0V
GND
3
STR-G9656
O.S.C
Vin
4
18V
START O.V.P LATCH DRIVE
REG
21
Page 22
/
/
/
A
TMPA8807
P60/ADC 8 bit
8MHz
-
+
+
-
1
2
3
4
5
6
7
8
9
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
I/O
12 I/O port
14-bit PWM 1
7-bit PWM 1
8-bit ADC Ext. 3
Int. 1
Romote preprocessor
16-bit int.timer 2
8-bit int.timer 2
Watchdog timer
Interrupt
Ext. 5 Int. 11
IIC bus interfece
Ext. 1 Int. 1
¡Á¡Á
¡Á¡Á
¡Á
¡Á
870X CPU core
STOP/IDLE mode
¡Á
¡Á
¡Á
¡Á
ROM: 32KB
RAM: 2KB
ROM correction
64
P63/LED2
63
P30/In t3/RXIN
62 61 60 59 58
P31/In t4/TC3
P20/In t5/Stop
P40/PWM14 bit
P51/SCL
57
OSD R,G,B,Y/BL,I
Font:16
Display:32C 12L
Color:8
Character:384
Half-tone Test signal
Transparent
¡Á18
Hor.Proc.
Sync.sepa
Hor.VCD HAFC-1
HAFC-2 H-shift
1H DL Int/Ext switch
Color Uni-color
RGB Matrix
Base Band Proc.
Vert.Proc.
V. C/ D
V. ram p
V.geometry
V. Dri ve
¡Á
Cut-off Drive
AKB
Brightness
Half-tone
Transparent
RGB switch
P52/SDA
56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
P56
UP AV 5V
+
-
DD
UP MPAGND
TV AGND
BOUT
GOUT
ROUT
-
+
RGB V 9V
-
+
C-Trap
Black stretch
Y gamma
Sharpness
YProc.
TINT
C-BPF
PAL
Chroma Proc.
NTSC
SECAM
-
+
TRAP
-
+
Fsc
EW
PAL
Auto. VCO
alignm ent
PIF Proc.
NTSC demod
DET
AGC
IF
AGC
Reg.
DEMO
FM
AFT
SIF out
EHT in
BPF
CC
Ikin
-
+
APC Fil
+
-
Black Det
SVM out
-
+
YC V 5V
CC
RF AGC
IF GND
IF AGC
-
+
udio out
Deemp
S-Reg.F
-
+
IF V 5V
CC
-
+
-
+
PIF PLL
-
+
DC NF
H.correc/SIF in
22
Page 23
5V 3.3V
1
64
2
4.2V 5V
362
5V 4.4V
0V 5V
461
560
5V 0V
659
2.25V 4.6V
2.0V 5V
758
857
0V 5V
5V 0V
956
10 55
0V 5V
0V 0V
11 54
12 53
1.17V 0V
13 52
1.5V 3.3V
14 51
6.7V 3.3V
4.15V 3.5V
15 50
4.37V 9V
16 49
17 48
9V 0V
0V 2.5V
18 47
2.5V 2.4V
19 46
63
2.5V 2.4V
20 45
21 44
2.5V 5V
22 43
0V 4V
2.5V 0.5V
23 42
2.7V 0.5V
24 41
25 40
3.4V 0V
26 39
1.9V 2V
4.7V 4.35V
27 38
5V 2.1V
28 37
9.1V 5V
29 36
3.6V 2.4V
30 35
1.8V 2.1V
31 34
3.6V 3V
32
33
23
Page 24
A
AN7522
1 2 3 4 5 6 7 8 9 10
+
470¦Ì
OUT1
8ohm
Vc c
0V
Note: If the standby pin is open or 0V, the IC is on standby state.
The IC is in the state of volume minimum if the Volume pin is ground.
The IC is in the state of volume maximum if the Volume pin is open.
+
Stand-by
68k
5V
270
k
+
Vin1
+
10k
Vin1
0V
10k
Vol ume
11 12
OUT2
8ohm
1.25V
Thermal
Protection
Pump
Up
12 45637
INVERTING INPUT
2.5V 2.5V
24
26V
Vcc
PUMP UP OUT
GND
0V 12V
OUTPUT
MP
OUTPUT
27V
Vcc
-
+
NON INV.INPUT
2.5V
Page 25
X
AGC
VOL 1
VOL 1
1
2
3
4
5
eala
&
Simulatod
Stereo
NJW1166
AGC
SR-FIL
SS-FIL
TONE-Ha
TONE-La
TONE
TONE
LPF
TONE-Hb
VOL2
VOL2
VOL2
X
INb
LF1
LF2
LF3
32
31
30
29
28
2
ICBus
Interface
Blas
6
7
8
9
10
11
12
13
14
15
16
OUTW
OUTa
AGC1
AUX0
AUX1
PORT0
PORT1
CBS
SDA
SCL
GND
TONE-Lb
OUTb
AGC2
CVA
CVB
CVW
CTH
CTL
CSR
Vref
V+
27
26
25
24
23
22
21
20
19
18
17
25
Page 26
VCC
1
2
TUNER IN
VIDEO 2 IN
VIDEO 3 IN
VIDEO 4 IN
Rch T IN
Rch 2 IN
Rch 3 IN
Rch 4 IN
Lch T IN
Lch 2 IN
Lch 3 IN
Lch 4 IN
26
+
4
+
7
+
10
+
V-SW
0/6dB
0dB
26
20
V 1 OUT
V 2 OUT
M52797SP/FP
25
+
5
+
8
+
11
+
27
+
3
+
6
+
9
+
R-SW
L-SW
R-MODE
R
M
L
L-MODE
R
M
L
0/6dB
0/6dB
22
24
Rch 1 OUT
Lch 1 OUT
Lch 4 IN
BIAS
+
21
+
BIAS
IC Control
NC
GND
26
2
13
12
SDA
SCL
17181916152814
D4 D5
CHIP SELECT
Page 27
16
TC90A45P/F
14
X-COMMON
A
B
INH
11
10
OUT
OUT
OUT
OUT
OUT
IN
c
IN
c
IN
c
IN
c
IN
c
12
0X
1X
13
0Y
2
1
1Y
5
0Z
9C
OUT
LOOIC LEVEL CONVERTER
6
IN
c
3
1Z
Z-
4
COMMON
Y-
15
COMMON
TC4053BP
8
VSS
7
VEE
OUT
TRUTH TABLE
CONTROL
C
H
L
* See Electrical Characteristics
27
Impedance Between
IN-OUT *
0.5~5 10
¡µ10
IN
c
2
¡Á
2
Page 28
TC90A45P/F
Composite
Video input
4
ADC
Clamp
1H Line
Memory
SC
PLL10F
System Clock
TERMINAL CONNECTION DIAGRAM
AV
VRB
VRT
ADIN
+
Color killer
BPF
BPF
1
SS
2
3
4
Dynamic
Comb Filter
+
+
-
1/2
16
15
14
13
BPF
AV
DD
Y
OUT
BIAS2
C
OUT
ADC
-
DAC
Y
15+
OUT
Color
7
Killer
13
C
OUT
BIAS1
TEST
KILLER
DV
5
6
7
8
DD
12
11
10
9
BIAS3
VFIL
CKIN
DV
SS
(TOP VIEW)
28
Page 29
Page 30
Page 31
Page 32
Page 33
Page 34
Page 35
WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION
CAUTION: 1. The shaded areas makes in the schematic diagram and the parts list designate components
PERCAUTION”, “SAFETY PRECAUTION” AND “PRODUCT SAFETY NOTICE” ON
PAGE 1&2 OF THIS MANUAL.
which have special characteristics important for safety and should be replaced only with
type identical to those in the original circuit or specified in the parts list. Before replacing
any of these components, read carefully the PRODUCT SAFETY NOTICE on page 2.
2. Do not degrade the safety of the receiver through improper servicing.
ELECTRICAL PARTS LIST
MAIN BOARD
SYMBOL PART NO. DESCRIPTION
782-TDC18-0100 MAIN PCB
CRYSTAL
Z801 329-58001-00 8MHZ
DIODE
D303 340-00014-00 RGP10J
D806 340-00001-003 1N4148
D804 340-00001-003 1N4148
D802 340-00001-003 1N4148
D801 340-00001-003 1N4148
D204 340-00001-003 1N4148
D307 340-00005-003 S5295J
D302 340-00010-003 S5295G
D301 340-00014-003 RGP10J
D304 340-00014-003 RGP10J
D305 340-00086-003 TVR-1B
REGULATED DIODE
D807 340-50390-003 HZ4B2
D314 340-50910-003 HZ9C1
D207 340-50910-003 HZ9C1
D208 340-50910-003 HZ9C1
D205 340-50910-003 HZ9C1
D206 340-50910-003 HZ9C1
D210 340-50910-003 HZ9C1
D211 340-50910-003 HZ9C1
D203 340-50910-003 HZ9C1
D202 340-50910-003 HZ9C1
31
Page 36
SYMBOL PART NO. DESCRIPTION
D201 340-50910-003 HZ9C1
D310 340-51850-003 HZ18-3
TRANSISTOR
V301 343-15550-00 2SD2499
V307 343-00420-404 SFORIB42
V608 343-10150-104 2SA1015Y Pr2.5
V609 343-10150-104 2SA1015Y Pr2.5
V805 343-10150-104 2SA1015Y Pr2.5
V804 343-10150-104 2SA1015Y Pr2.5
V604 343-10150-104 2SA1015Y Pr2.5
V806 343-10150-704 2SA1015GR
V101 343-18150-114 2SC1815-Y
V102 343-18150-114 2SC1815-Y
V103 343-18150-114 2SC1815-Y
V802 343-18150-114 2SC1815-Y
V803 343-18150-114 2SC1815-Y
V205 343-18150-114 2SC1815-Y
V801 343-18150-604 2SC 1815-0
V610 343-18150-604 2SC 1815-0
V204 343-18150-604 2SC 1815-0
V607 343-18150-604 2SC 1815-0
V606 343-18150-604 2SC 1815-0
V202 343-18150-604 2SC 1815-0
V602 343-18150-604 2SC 1815-0
V603 343-18150-604 2SC 1815-0
V605 343-18150-604 2SC 1815-0
V305 343-23830-604 2SC2383-0
V203 343-27170-004 2SC2717
CERAMIC CAPACITOR
C649 459-2047H-102 CC45-CH1H470JYR
C814 459-2051H-102 CC1-08-CH-63V-51pF-J
C813 459-2051H-102 CC1-08-CH-63V-51pF-J
C648 459-2056H-102 CC1-08-CH-63V-56pF-J
C647 459-2118H-102 CC45-CH1H181JYR
C807 459-2118H-102 CC45-CH1H181JYR
C313 459-2133K-902 RBU07SL331K-H46CA
C316 459-2133K-902 RBU07SL331K-H46CA
C811 459-2147H-902 CC1-12-SL-63V-471J
C830 459-2210K-002 CK45-B1H102KYR
C341 459-2210K-002 CK45-B1H102KYR
C222 459-2210K-002 CK45-B1H102KYR
C608 459-2210K-002 CK45-B1H102KYR
32
Page 37
SYMBOL PART NO. DESCRIPTION
C609 459-2210K-002 CK45-B1H102KYR
C611 459-2210K-002 CK45-B1H102KYR
C622 459-2210K-002 CK45-B1H102KYR
C607 459-2210K-002 CK45-B1H102KYR
C606 459-2210K-002 CK45-B1H102KYR
C605 459-2210K-002 CK45-B1H102KYR
C311 459-2247R-002 CT1-08-2E4-63V-472Z
C639 459-2310R-002 CK45-F1H103ZYR
C644 459-2310R-002 CK45-F1H103ZYR
C218 459-2310R-002 CK45-F1H103ZYR
C223 459-2310R-002 CK45-F1H103ZYR
C225 459-2310R-002 CK45-F1H103ZYR
C816 459-2310R-002 CK45-F1H103ZYR
C618 459-2310R-002 CK45-F1H103ZYR
C216 459-2310R-002 CK45-F1H103ZYR
C806 459-2310R-002 CK45-F1H103ZYR
C237 459-2310R-002 CK45-F1H103ZYR
C632 459-2310R-002 CK45-F1H103ZYR
C819 459-2310R-002 CK45-F1H103ZYR
C228 459-2410R-002 DD308-63F104Z50
C227 459-2410R-002 DD308-63F104Z50
C118 459-2410R-002 DD308-63F104Z50
C120 459-2410R-002 DD308-63F104Z50
C125 459-2410R-002 DD308-63F104Z50
C817 459-2410R-002 DD308-63F104Z50
C234 459-2410R-002 DD308-63F104Z50
C235 459-2410R-002 DD308-63F104Z50
C119 459-2410R-002 DD308-63F104Z50
C233 459-2410R-002 DD308-63F104Z50
C653 459-2410R-002 DD308-63F104Z50
C214 459-2410R-002 DD308-63F104Z50
C334 459-5139K-002 CK45-B2H391KYR
C335 459-5182K-002 DD06-999B812K500
C815 459-2110H-10D CC1-08-CH-63V-101J
C812 459-2110H-10D CC1-08-CH-63V-101J
C207 459-2110H-10D CC1-08-CH-63V-101J
C308 459-5133K-00 RQC05B331K-H46CA
C328 459-8133K-00 DE0707B331K2K
THIN-FILM CAPACITOR
C226 462-B0410-H02 CL21X-50V-0.1uF-J
C651 462-00210-H02 CL11-100V-1000PF-J
C804 462-00215-K02 CL11-100V-1500PF-K
33
Page 38
SYMBOL PART NO. DESCRIPTION
C137 462-00222-H02 CL11-100V-2200PF-J
C823 462-00222-H02 CL11-100V-2200PF-J
C338 462-00222-H02 CL11-100V-2200PF-J
C322 462-00222-K02 CL11-100V-2200PF-K
C646 462-00310-H02 CL11-100V-0.01uF-J
C636 462-00310-H02 CL11-100V-0.01uF-J
C637 462-00310-H02 CL11-100V-0.01uF-J
C638 462-00310-H02 CL11-100V-0.01uF-J
C641 462-00310-H02 CL11-100V-0.01uF-J
C642 462-00310-H02 CL11-100V-0.01uF-J
C643 462-00310-H02 CL11-100V-0.01uF-J
C650 462-00310-H02 CL11-100V-0.01uF-J
C236 462-00310-H02 CL11-100V-0.01uF-J
C109 462-00333-H02 CL11-100V-0.033uF-J
C134 462-00333-K02 CL11-100V-0.033uF-K
C115 462-00333-K02 CL11-100V-0.033uF-K
C824 462-90410-H02 63V-0.1uF-J
C147 462-90410-H02 63V-0.1uF-J
C123 462-90410-H02 63V-0.1uF-J
C122 462-90410-H02 63V-0.1uF-J
C140 462-90410-H02 63V-0.1uF-J
C329 462-90410-H02 63V-0.1uF-J
C624 462-90410-H02 63V-0.1uF-J
C112 462-00222-H0 CL11-100V-2200PF-J
C803 462-00227-K0 CL11-100V-2700PF-K
C203 462-00282-H0 CL11-100V-8200pF-J
C136 462-00322-H0 CL11-100V-0.022uF-J
C135 462-00347-H0 CL11-100V-0.047uF-J
C339 462-00410-H0 CL11-100V-0.1uF-J
C604 462-10310-H0 CL12-100V-10000pF-J
C301 462-53356-K0 CBB12-200V-0.056uF-K
C332 462-53433-H0 CBB13-200V-0.33uF-J
C319 462-88247-H0 CBB81-1600V-4700PF-J
C324 462-88268-H0 CBB81-1600V-6800PF-J
ELECTROLYTIC CAPACITOR
C337 464-3D610-M02 CD11W-16V-10uF-M
C217 464-3D610-M02 CD11W-16V-10uF-M
C219 464-6C710-M02 CD110-10V-100uF-M
C810 464-6C710-M02 CD110-10V-100uF-M
C231 464-6C722-M02 CD110-10V-220uF-M
C212 464-6C722-M02 CD110-10V-220uF-M
C230 464-6C722-M02 CD110-10V-220uF-M
34
Page 39
SYMBOL PART NO. DESCRIPTION
C629 464-6C747-M02 CD110-10V-470uF-M
C132 464-6D547-M02 CD110-16V-4.7uF-M
C142 464-6D547-M02 CD110-16V-4.7uF-M
C143 464-6D547-M02 CD110-16V-4.7uF-M
C144 464-6D547-M02 CD110-16V-4.7uF-M
C145 464-6D547-M02 CD110-16V-4.7uF-M
C146 464-6D547-M02 CD110-16V-4.7uF-M
C116 464-6D547-M02 CD110-16V-4.7uF-M
C232 464-6D547-M02 CD110-16V-4.7uF-M
C215 464-6D547-M02 CD110-16V-4.7uF-M
C129 464-6D547-M02 CD110-16V-4.7uF-M
C820 464-6D610-M02 CD110-16V-10uF-M
C634 464-6D647-M02 CD110-16V-47uF-M
C610 464-6D710-M02 CD110-16V-100uF-M
C117 464-6D710-M02 CD110-16V-100uF-M
C633 464-6D710-M02 CD110-16V-100uF-M
C206 464-6D710-M02 CD110-16V-100uF-M
C655 464-6D710-M02 CD110-16V-100uF-M
C829 464-6D710-M02 CD110-16V-100uF-M
C831 464-6D710-M02 CD110-16V-100uF-M
C205 464-6D733-M02 CD110-16V-330uF-M
C623 464-6E610-M02 CD110-25V-10uF-M
C625 464-6E610-M02 CD110-25V-10uF-M
C802 464-6E610-M02 CD110-25V-10uF-M
C626 464-6E610-M02 CD110-25V-10uF-M
C631 464-6E610-M02 CD110-25V-10uF-M
C630 464-6E610-M02 CD110-25V-10uF-M
C131 464-6E610-M02 CD110-25V-10uF-M
C130 464-6E610-M02 CD110-25V-10uF-M
C314 464-6E722-M02 CD110-25V-220uF-M
C310 464-6F710-M02 CD110-35V-100uF-M
C640 464-60447-M02 CD110-50V-0.47uF-M
C202 464-60447-M02 CD110-50V-0.47uF-M
C204 464-60447-M02 CD110-50V-0.47uF-M
C601 464-60510-M02 CD110-50V-1uF-M
C213 464-60510-M02 CD110-50V-1uF-M
C111 464-60510-M02 CD110-50V-1uF-M
C113 464-60510-M02 CD110-50V-1uF-M
C620 464-60510-M02 CD110-50V-1uF-M
C616 464-60510-M02 CD110-50V-1uF-M
C613 464-60510-M02 CD110-50V-1uF-M
C208 464-60510-M02 CD110-50V-1uF-M
35
Page 40
SYMBOL PART NO. DESCRIPTION
C209 464-60510-M02 CD110-50V-1uF-M
C210 464-60510-M02 CD110-50V-1uF-M
C801 464-60510-M02 CD110-50V-1uF-M
C211 464-60510-M02 CD110-50V-1uF-M
C305 464-60547-M02 CD110-50V-4.7uF-M
C635 464-60610-M02 CD110-50V-10uF-M
C652 464-60610-M02 CD110-50V-10uF-M
C612 464-60610-M02 CD110-50V-10uF-M
C614 464-60610-M02 CD110-50V-10uF-M
C615 464-60610-M02 CD110-50V-10uF-M
C617 464-60610-M02 CD110-50V-10uF-M
C619 464-60610-M02 CD110-50V-10uF-M
C621 464-60610-M02 CD110-50V-10uF-M
C221 464-60610-M02 CD110-50V-10uF-M
C307 464-60610-M02 CD110-50V-10uF-M
C320 464-60610-M02 CD110-50V-10uF-M
C229 464-60647-M02 CD110-50V-47uF-M
C306 464-61422-M02 CD110-100V-0.22uF-M
C330 464-62510-M02 CD288-160V-1uF-M
C818 464-6C710-M0 CD110-10V-100uF-M
C114 464-6D622-M0 CD110-16V-22uF-M
C340 464-6D710-M0 CD110-16V-100uF-M
C220 464-6D710-M0 CD110-16V-100uF-M
C110 464-6D810-M0 CD110-16V-1000uF-M
C654 464-6E647-M0 CD110-25V-47uF-M
C302 464-6E822-M0 CD110-25V-2200uF-M
C321 464-6F810-M0 CD110-35V-1000uF-M
C224 464-60447-M0 CD110-50V-0.47uF-M
C141 464-60522-M0 CD110-50V-2.2uF-M
C121 464-60522-M0 CD110-50V-2.2uF-M
C645 464-60610-M0 CD110-50V-10uF-M
C331 464-65547-M0 CD288-250V-4.7uF-M
C315 464-65633-M0 CD288-250V-33uF-M
C312 464-65633-M0 CD288-250V-33uF-M
CARBON RESISTOR
R226 467-1C027-H03 1/6W-27Ω-J
R627 467-1C168-H03 1/6W-680Ω-J
R633 467-1C168-H03 1/6W-680Ω-J
R835 467-1C075-H03 1/6W-75Ω-J
R609 467-1C075-H03 1/6W-75Ω-J
R615 467-1C075-H03 1/6W-75Ω-J
R619 467-1C075-H03 1/6W-75Ω-J
36
Page 41
SYMBOL PART NO. DESCRIPTION
R607 467-1C075-H03 1/6W-75Ω-J
R622 467-1C075-H03 1/6W-75Ω-J
R601 467-1C082-H03 1/6W-82Ω-J
R604 467-1C082-H03 1/6W-82Ω-J
R809 467-1C110-H03 1/6W-100Ω-J
R217 467-1C110-H03 1/6W-100Ω-J
R209 467-1C110-H03 1/6W-100Ω-J
R211 467-1C110-H03 1/6W-100Ω-J
R212 467-1C110-H03 1/6W-100Ω-J
R613 467-1C110-H03 1/6W-100Ω-J
R614 467-1C110-H03 1/6W-100Ω-J
R616 467-1C110-H03 1/6W-100Ω-J
R618 467-1C110-H03 1/6W-100Ω-J
R617 467-1C110-H03 1/6W-100Ω-J
R637 467-1C110-H03 1/6W-100Ω-J
R118 467-1C110-H03 1/6W-100Ω-J
R119 467-1C110-H03 1/6W-100Ω-J
R234 467-1C110-H03 1/6W-100Ω-J
R235 467-1C110-H03 1/6W-100Ω-J
R113 467-1C110-H03 1/6W-100Ω-J
R114 467-1C110-H03 1/6W-100Ω-J
R115 467-1C110-H03 1/6W-100Ω-J
R643 467-1C110-H03 1/6W-100Ω-J
R640 467-1C110-H03 1/6W-100Ω-J
R224 467-1C110-H03 1/6W-100Ω-J
R236 467-1C110-H03 1/6W-100Ω-J
R814 467-1C110-H03 1/6W-100Ω-J
R344 467-1C110-H03 1/6W-100Ω-J
R642 467-1C112-H03 1/6W-120Ω-J
R343 467-1C115-H03 1/6W-150Ω-J
R342 467-1C115-H03 1/6W-150Ω-J
R652 467-1C115-H03 1/6W-150Ω-J
R641 467-1C120-H03 1/6W-200Ω-J
R812 467-1C122-H03 1/6W-220Ω-J
R639 467-1C122-H03 1/6W-220Ω-J
R222 467-1C122-H03 1/6W-220Ω-J
R621 467-1C122-H03 1/6W-220Ω-J
R237 467-1C122-H03 1/6W-220Ω-J
R225 467-1C127-H03 1/6W-270Ω-J
R220 467-1C127-H03 1/6W-270Ω-J
R824 467-1C133-H03 1/6W-330Ω-J
R832 467-1C133-H03 1/6W-330Ω-J
37
Page 42
SYMBOL PART NO. DESCRIPTION
R830 467-1C133-H03 1/6W-330Ω-J
R214 467-1C133-H03 1/6W-330Ω-J
R630 467-1C133-H03 1/6W-330Ω-J
R202 467-1C133-H03 1/6W-330Ω-J
R203 467-1C133-H03 1/6W-330Ω-J
R205 467-1C133-H03 1/6W-330Ω-J
R644 467-1C133-H03 1/6W-330Ω-J
R623 467-1C133-H03 1/6W-330Ω-J
R229 467-1C133-H03 1/6W-330Ω-J
R653 467-1C139-H03 1/6W-390Ω-J
R815 467-1C147-H03 1/6W-470Ω-J
R624 467-1C156-H03 1/6W-560Ω-J
R634 467-1C156-H03 1/6W-560Ω-J
R807 467-1C168-H03 1/6W-680Ω-J
R648 467-1C168-H03 1/6W-680Ω-J
R121 467-1C168-H03 1/6W-680Ω-J
R122 467-1C168-H03 1/6W-680Ω-J
R625 467-1C168-H03 1/6W-680Ω-J
R631 467-1C168-H03 1/6W-680Ω-J
R645 467-1C182-H03 1/6W-820Ω-J
R219 467-1C182-H03 1/6W-820Ω-J
R649 467-1C191-H03 1/6W-910Ω-J
R116 467-1C210-H03 1/6W-1K-J
R112 467-1C210-H03 1/6W-1K-J
R232 467-1C210-H03 1/6W-1K-J
R646 467-1C210-H03 1/6W-1K-J
R647 467-1C210-H03 1/6W-1K-J
R839 467-1C210-H03 1/6W-1K-J
R651 467-1C210-H03 1/6W-1K-J
R650 467-1C210-H03 1/6W-1K-J
R311 467-1C210-H03 1/6W-1K-J
R804 467-1C210-H03 1/6W-1K-J
R228 467-1C210-H03 1/6W-1K-J
R206 467-1C210-H03 1/6W-1K-J
R828 467-1C210-H03 1/6W-1K-J
R827 467-1C210-H03 1/6W-1K-J
R826 467-1C210-H03 1/6W-1K-J
R816 467-1C215-H03 1/6W-1.5K-J
R335 467-1C220-H03 1/6W-2K-J
R805 467-1C222-H03 1/6W-2.2K-J
R626 467-1C222-H03 1/6W-2.2K-J
R632 467-1C222-H03 1/6W-2.2K-J
38
Page 43
SYMBOL PART NO. DESCRIPTION
R238 467-1C222-H03 1/6W-2.2K-J
R656 467-1C233-H03 1/6W-3.3K-J
R659 467-1C233-H03 1/6W-3.3K-J
R833 467-1C233-H03 1/6W-3.3K-J
R215 467-1C233-H03 1/6W-3.3K-J
R635 467-1C233-H03 1/6W-3.3K-J
R811 467-1C239-H03 1/6W-3.9K-J
R808 467-1C239-H03 1/6W-3.9K-J
R661 467-1C239-H03 1/6W-3.9K-J
R821 467-1C247-H03 1/6W-4.7K-J
R314 467-1C251-H03 1/6W-5.1K-J
R227 467-1C256-H03 1/6W-5.6K-J
R204 467-1C282-H03 1/6W-8.2K-J
R655 467-1C310-H03 1/6W-10K-J
R810 467-1C310-H03 1/6W-10K-J
R818 467-1C310-H03 1/6W-10K-J
R819 467-1C310-H03 1/6W-10K-J
R820 467-1C310-H03 1/6W-10K-J
R801 467-1C310-H03 1/6W-10K-J
R802 467-1C310-H03 1/6W-10K-J
R201 467-1C310-H03 1/6W-10K-J
R323 467-1C310-H03 1/6W-10K-J
R838 467-1C310-H03 1/6W-10K-J
R658 467-1C310-H03 1/6W-10K-J
R803 467-1C312-H03 1/6W-12K-J
R221 467-1C315-H03 1/6W-15K-J
R318 467-1C315-H03 1/6W-15K-J
R822 467-1C320-H03 1/6W-20K-J
R603 467-1C320-H03 1/6W-20K-J
R309 467-1C320-H03 1/6W-20K-J
R320 467-1C322-H03 1/6W-22K-J
R817 467-1C322-H03 1/6W-22K-J
R107 467-1C330-H03 1/6W-30K-J
R328 467-1C330-H03 1/6W-30K-J
R110 467-1C333-H03 1/6W-33K-J
R307 467-1C333-H03 1/6W-33K-J
R834 467-1C333-H03 1/6W-33K-J
R829 467-1C333-H03 1/6W-33K-J
R608 467-1C347-H03 1/6W-47K-J
R610 467-1C347-H03 1/6W-47K-J
R611 467-1C347-H03 1/6W-47K-J
R612 467-1C347-H03 1/6W-47K-J
39
Page 44
SYMBOL PART NO. DESCRIPTION
R606 467-1C347-H03 1/6W-47K-J
R605 467-1C347-H03 1/6W-47K-J
R629 467-1C347-H03 1/6W-47K-J
R620 467-1C347-H03 1/6W-47K-J
R124 467-1C347-H03 1/6W-47K-J
R230 467-1C347-H03 1/6W-47K-J
R231 467-1C356-H03 1/6W-56K-J
R379 467-1C356-H03 1/6W-56K-J
R233 467-1C362-H03 1/6W-62K-J
R813 467-1C368-H03 1/6W-68K-J
R123 467-1C410-H03 1/6W-100K-J
R109 467-1C410-H03 1/6W-100K-J
R120 467-1C410-H03 1/6W-100K-J
R657 467-1C410-H03 1/6W-100K-J
R660 467-1C410-H03 1/6W-100K-J
R216 467-1C410-H03 1/6W-100K-J
R636 467-1C410-H03 1/6W-100K-J
R638 467-1C410-H03 1/6W-100K-J
R108 467-1C422-H03 1/6W-220K-J
R806 467-1C456-H03 1/6W-560K-J
R223 467-1C515-H03 1/6W-1.5M-J
R326 467-1D033-H03 RT14-1/4W-33Ω-J
R336 467-1D227-H03 RT14-1/4W-2.7K-J
R303 467-1D291-H03 RT14-1/4W-9.1K-J
WIRE-ROUND RESISTOR
R333 467-B0239-H0 RX25-5W-3.9K-J
R302 467-6FA12-H0 RX21-1-1.2Ω-J
METAL RESISTOR
R306 467-2D311-F03 1/4W-11K-F
R305 467-2EB82-H0 1/2W-0.82Ω-JL
R329 467-2F210-H0 1W-1KΩ-JL
R324 467-2F210-H0 1W-1KΩ-JL
R332 467-2F310-H0 1W-10kΩ-JL
R317 467-2F310-H0 1W-10kΩ-JL
R316 467-2G012-H0 2W-12Ω-JL
R301 467-2G127-H0 2W-270Ω-JL
INDUCTANCE WITH COLOUR CODES
L208 471-2B56K-003 SPT0305-R56K-5
L205 471-2B82K-003 SPT0305-R82K-5
L603 471-2010K-003 SPT0305-100K-5
L604 471-2010K-003 SPT0305-100K-5
L607 471-2010K-003 SPT0305-100K-5
40
Page 45
SYMBOL PART NO. DESCRIPTION
L608 471-2010K-003 SPT0305-100K-5
L601 471-2056K-003 SPT0305-560K-5
L207 471-2068K-003 SPT0305-680K-5
L606 471-2110K-003 SPT0305-101K-5
L611 471-2110K-003 SPT0305-101K-5
L203 471-1056K-00 EL0606SK1-560K
L612 471-2010K-A0 SP0203-10uH-K
L605 471-2010K-A0 SP0203-10uH-K
L602 471-2010K-A0 SP0203-10uH-K
L614 471-2015K-A0 SP0203-15uH-K
L615 471-2027K-A0 SP0203-27uH-K
L202 471-2056H-60 LGA0307-56uH-J
L101 471-2056H-60 LGA0307-56uH-J
L801 471-2056H-60 LGA0307-56uH-J
L204 471-2056H-60 LGA0307-56uH-J
L206 471-2056H-60 LGA0307-56uH-J
L616 471-2110K-10 LGA0410-100uH-K
L613 471-2110K-10 LGA0410-100uH-K
J208 471-2110K-10 LGA0410-100uH-K
L802 471-2110K-10 LGA0410-100uH-K
L201 471-2110K-10 LGA0410-100uH-K
L609 471-2110K-10 LGA0410-100uH-K
IC
D209 352-05740-00 uPC574
N802 352-11660-10 NJW1166
N801 352-24080-50 M24C08BN6
N603 352-40530-00 TC4053BP
N601 352-52797-20 M52797SP
N301 352-55220-00 AN5522
N803 352-75220-00 AN7522N
N302 352-78050-00 KA7805
N807 352-78090-40 TA78M09P
N201 352-88070-00 TMPA8807PSAN
N602 352-90450-50 TC90A45P
AV SOCKET
X601 364-92210-00 417
X803 364-92213-00 AV417-3
X806 364-92221-00 AV-8409-1
SAW FILTER
Z201 458-07008-00 M1962M
MELTABLE RESISTOR
R315 467-4E001-H0 1/2W-1Ω-JL
41
Page 46
SYMBOL PART NO. DESCRIPTION
R312 467-4FB33-H0 1W-0.33Ω-JL
R322 467-4F001-H0 1W-1Ω-JL
R313 467-4F001-H0 1W-1Ω-JL
R308 467-4F010-H0 1W-10Ω-JL
ADJUSTABLE INDUCTANCE
L308 477-30026-00 TLN2130
H-DRIVE TRANSFORMER
T303 472-10001-00 XR0961
CERAMIC FILTER
Z202 475-15451-00 LT4.5MH
CERAMIC TRAP FILTER
Z601 475-25451-00 XT4.5MB
H-LINEARITY COIL
L303 477-00066-00 HL1830H-X14
FBT
T302 472-24213-00 BSC24-3031*UL!
OTHER
TUNER 590-40707-00 115-B-8035AZ
DEGAUSSING COIL 477-12105-00 DX-56-2
POWER CORD 491-702D0-02 UL
CRT 335-2122L-00U A51QDX992X002(H)
CRT BOARD
SYMBOL PART NO. DESCRIPTION
782-W2935-0200 CRT PCB
MELTABLE RESISTOR
R442 467-4FA33-H0 1W-3.3Ω-JL
TRANSISTOR
V411 343-05620-10 2SA562TM-Y
V404 343-18150-11 2SC1815-Y
V406 343-18150-11 2SC1815-Y
V408 343-18150-11 2SC1815-Y
V403 343-26880-60 2SC2688M
V405 343-26880-60 2SC2688M
V407 343-26880-60 2SC2688M
CRT SOCKET
X404 364-58210-00 GZS10-2-102G
CERAMIC CAPACITOR
C446 459-2082H-10 CC1-08-63V-82pF-J
C447 459-2082H-10 CC1-08-63V-82pF-J
C448 459-2082H-10 CC1-08-63V-82pF-J
42
Page 47
SYMBOL PART NO. DESCRIPTION
C403 459-2127H-90 CC1-08-SL-63V-271J
C405 459-2127H-90 CC1-08-SL-63V-271J
C406 459-2127H-90 CC1-08-SL-63V-271J
C409 459-2147H-90 CC1-12-SL-63V-471J
C410 459-2147H-90 CC1-12-SL-63V-471J
C411 459-2147H-90 CC1-12-SL-63V-471J
C404 459-2310R-00 CT1-08-2F4-63V-103Z
C424 459-8222K-00 DE1005B222K2K
ELECTROLYTIC CAPACITOR
C415 464-6D722-M0 CD110-16V-220uF-M
C401 464-6E610-M0 CD110-25V-10uF-M
C416 464-65633-M0 CD288-250V-33uF-M
CARBON RESISTOR
R429 467-1C022-H0 1/6W-22Ω-J
R418 467-1C056-H0 1/6W-56Ω-J
R419 467-1C056-H0 1/6W-56Ω-J
R420 467-1C056-H0 1/6W-56Ω-J
R415 467-1C127-H0 1/6W-270Ω-J
R406 467-1C139-H0 1/6W-390Ω-J
R407 467-1C139-H0 1/6W-390Ω-J
R408 467-1C139-H0 1/6W-390Ω-J
R412 467-1C156-H0 1/6W-560Ω-J
R413 467-1C156-H0 1/6W-560Ω-J
R414 467-1C156-H0 1/6W-560Ω-J
R423 467-1C168-H0 1/6W-680Ω-J
R424 467-1C168-H0 1/6W-680Ω-J
R425 467-1C168-H0 1/6W-680Ω-J
R404 467-1C212-H0 1/6W-1.2K-J
R403 467-1C247-H0 1/6W-4.7K-J
R430 467-1C310-H0 1/6W-10K-J
R405 467-1D168-H0 RT14-1/4W-680Ω-J
METAL RESISTOR
R432 467-2G312-H0 2W-12kΩ-JL
R434 467-2G312-H0 2W-12kΩ-JL
R437 467-2G312-H0 2W-12kΩ-JL
CARBON RESISTOR
R433 467-8E227-H1A 1/2W-2.7KΩ-J
R435 467-8E227-H1A 1/2W-2.7KΩ-J
R436 467-8E227-H1A 1/2W-2.7KΩ-J
INDUCTANCE WITH COLOUR CODES
L401 471-1056H-00 EL0606SKI-560J
L402 471-2110K-00 SPT0305-101K-5
43
Page 48
SYMBOL PART NO. DESCRIPTION
DIODE
D401 340-00001-00 1N4148
D402 340-00001-00 1N4148
D403 340-00001-00 1N4148
D404 340-00001-00 1N4148
D405 340-00001-00 1N4148
STEREO BOARD
SYMBOL PART NO. DESCRIPTION
782-Q2735-310A STEREO PCB
TRANSISTOR
VS01 343-18150-104 2SC1815-Y
VS02 343-18150-104 2SC1815-Y
CERAMIC CAPACITOR
CS04 459-2410R-00 DD308-63F104Z50
CS06 459-2410R-00 DD308-63F104Z50
CS10 459-2410R-00 DD308-63F104Z50
CS21 459-2410R-00 DD308-63F104Z50
CS12 459-5210K-00 RQC07B102K-H46CA
THIN-FILM CAPACITOR
CS05 462-B0322-H02 CL21X-50V-0.022uF-J
CS07 462-B0333-H02 CL21X-50V-0.033uF
CS11 462-B0422-H02 CL21X-50V-0.22uF-J
ELECTROLYTIC CAPACITOR
CS19 464-6D710-M0 CD110-16V-100uF-M
CS14 464-6E547-M0 CD110-25V-4.7uF-M
CS02 464-60433-M0 CD110-50V-0.33uF-M
CS09 464-60433-M0 CD110-50V-0.33uF-M
CS08 464-60522-M0 CD110-50V-2.2uF-M
CS15 464-60522-M0 CD110-50V-2.2uF-M
CS16 464-60522-M0 CD110-50V-2.2uF-M
CS17 464-60522-M0 CD110-50V-2.2uF-M
CS18 464-60522-M0 CD110-50V-2.2uF-M
CS20 464-60522-M0 CD110-50V-2.2uF-M
CS03 464-60533-M0 CD110-50V-3.3uF-M
CS01 464-60610-M0 CD110-50V-10uF-M
CARBON RESISTOR
RS06 467-1C110-H03 1/6W-100Ω-J
RS07 467-1C110-H03 1/6W-100Ω-J
44
Page 49
SYMBOL PART NO. DESCRIPTION
RS04 467-1C115-H03 1/6W-150Ω-J
RS09 467-1C115-H03 1/6W-150Ω-J
RS05 467-1C168-H03 1/6W-680Ω-J
RS10 467-1C168-H03 1/6W-680Ω-J
RS03 467-1C210-H03 1/6W-1K-J
RS08 467-1C210-H03 1/6W-1K-J
RS01 467-1C233-H03 1/6W-3.3K-J
RS02 467-1C418-H03 1/6W-180K-J
INDUCTANCE WITH COLOUR CODES
LS01 471-2068K-103 LGA0410-68uH-K
PASTE
NS01 353-58320-50 ICAN5832SA
BUTTON BOARD
SYMBOL PART NO. DESCRIPTION
782-TDC18-0500 BUTTON PCB
LIGHT-TOUCH SWITCH
S901 360-10001-00 KFC-A06-4X4.5X5B
S902 360-10001-00 KFC-A06-4X4.5X5B
S903 360-10001-00 KFC-A06-4X4.5X5B
S904 360-10001-00 KFC-A06-4X4.5X5B
S905 360-10001-00 KFC-A06-4X4.5X5B
S906 360-10001-00 KFC-A06-4X4.5X5B
S907 360-10001-00 KFC-A06-4X4.5X5B
S908 360-10001-00 KFC-A06-4X4.5X5B
S909 360-10001-00 KFC-A06-4X4.5X5B
SW901 360-10001-00 KFC-A06-4X4.5X5B
CARBON RESISTOR
R901 467-1C256-H0 1/6W-5.6K-J
R902 467-1C312-H0 1/6W-12K-J
R903 467-1C315-H0 1/6W-15K-J
R904 467-1C330-H0 1/6W-30K-J
R905 467-1C412-H0 1/6W-120K-J
BUTTON BOARD
SYMBOL PART NO. DESCRIPTION
782-TDC18-0900 INFRARED SENSOR PCB
LIGHT-EMITTING DIODE
LED1 340-10039-20 HFR205 (RED）
45
Page 50
SYMBOL PART NO. DESCRIPTION
CERAMIC CAPACITOR
C901 459-2310R-00 CT1-08-2F4-63V-103Z
ELECTROLYTIC CAPACITOR
C902 464-6D647-M0 CD110-16V-47uF-M
CARBON RESISTOR
R901 467-1C056-H0 1/6W-56Ω-J
R902 467-1C210-H0 1/6W-1K-J
R903 467-1D130-H0 RT14-1/4W-300Ω-J
IC
N901 352-03810-80 AT138B-T12
POWER BOARD
SYMBOL PART NO. DESCRIPTION
782-TDC18-200A POWER PCB
RECTIFIER
D506 340-80010-00 RUIP
D501 340-80022-00 T2SB60
DIODE
D517 340-00257-00 BYT56J
340-00257-00 BYT56J
D514 340-00283-00 TRU3YX
D515 340-00283-00 TRU3YX
D516 340-00284-00 TRU4YX
D518 340-00284-00 TRU4YX
D528 340-00291-00 TEU2YX
D511 340-00001-003 1N4148
D508 340-00001-003 1N4148
D503 340-00001-003 1N4148
D507 340-00001-003 1N4148
D504 340-00001-003 1N4148
D524 340-00001-003 1N4148
D527 340-00001-003 1N4148
D509 340-00001-003 1N4148
D510 340-00005-003 S5295J
D523 340-00014-003 RGP10J
D513 340-00288-00 TFR155
REGULATED DIODE
D522 340-50380-003 HZ4B1
D526 340-50560-003 HZ6B1
D519 340-50610-003 HZ6C2
D525 340-50950-003 HZ9C3
46
Page 51
SYMBOL PART NO. DESCRIPTION
D505 340-51560-003 HZ16-1
TRANSISTOR
V515 343-18150-60 2SC1815-0
V512 343-01800-00 KSE180 TO-126
V513 343-01800-00 KSE180 TO-126
V502 343-10130-60 2SA1013-0
V514 343-16680-00 2SA1668
V505 343-24820-00 2SC2482
V501 343-24820-00 2SC2482
V511 343-10150-104 2SA1015Y Pr2.5
V504 343-18150-114 2SC1815-Y
CERAMIC CAPACITOR
459-6147K-00 DE0705B471K1k
C528 459-2210K-002 CK45-B1H102KYR
C544 459-2310R-002 CK45-F1H103ZYR
C536 459-2310R-002 CK45-F1H103ZYR
C537 459-2310R-002 CK45-F1H103ZYR
C530 459-5147K-002 RQC05B471K-H46CA
C532 459-5147K-002 RQC05B471K-H46CA
C525 459-5147K-002 RQC05B471K-H46CA
C526 459-5147K-002 RQC05B471K-H46CA
C543 459-5210K-002 CK45-B2H102KYR
C501 459-B147M-20 ECK-DNS471MBX
C505 459-B147M-20 ECK-DNS471MBX
C522 459-B222M-20 ECK-DNS222MEX
C508 459-B247R-00 DE0807F472ZAC250V
C504 459-B247R-00 DE0807F472ZAC250V
C509 459-B247R-00 DE0807F472ZAC250V
C507 459-B247R-00 DE0807F472ZAC250V
C527 459-6210K-00 DE0705B102K1K
C561 459-6210K-00 DE0705B102K1K
C529 459-6215K-00 DE0905B152K1K
C513 459-8210K-00 DE0907B102K2K
THIN-FILM CAPACITOR
C520 462-00210-H02 CL11-100V-1000PF-J
C514 462-00210-H02 CL11-100V-1000PF-J
C521 462-00210-H02 CL11-100V-1000PF-J
C538 462-00310-H02 CL11-100V-0.01uF-J
C502 462-2B410-M0V 250VAC-0.1uF-M
C506 462-2B410-M0V 250VAC-0.1uF-M
C510 462-2B410-M0V 250VAC-0.1uF-M
C503 462-2B410-M0V 250VAC-0.1uF-M
47
Page 52
SYMBOL PART NO. DESCRIPTION
C518 462-26310-K0 CL21-630V-0.01uF-K
ELECTROLYTIC CAPACITOR
C515 464-61610-M0 CD110-100V-10uF-M
C540 464-04747-M0R 200USP470MA35
C516 464-07715-M0R CD293X-400V-150uF-M
C541 464-6E747-M0 CD110-25V-470uF-M
C534 464-6E747-M0 CD110-25V-470uF-M
C535 464-6F747-M0 CD110-35V-470uF-M
C556 464-6F810-M0 CD110-35V-1000uF-M
C546 464-60710-M0 CD110-50V-100uF-M
C524 464-62610-M0 CD288-160V-10uF-M
C548 464-6B747-M02 CD110-6.3V-470uF-M
C550 464-6B747-M02 CD110-6.3V-470uF-M
C545 464-6D547-M02 CD110-16V-4.7uF-M
C549 464-6D710-M02 CD110-16V-100uF-M
C559 464-6E647-M02 CD110-25V-47uF-M
C560 464-6E647-M02 CD110-25V-47uF-M
C557 464-6E710-M02 CD110-25V-100uF-M
C558 464-6E710-M02 CD110-25V-100uF-M
C517 464-60647-M02 CD110-50V-47uF-M
C547 464-6F710-M0 CD110-35V-100uF-M
CARBON RESISTOR
R531 467-1C122-H03 1/6W-220Ω-J
R525 467-1C156-H03 1/6W-560Ω-J
R508 467-1C168-H03 1/6W-680Ω-J
R523 467-1C210-H03 1/6W-1K-J
R522 467-1C210-H03 1/6W-1K-J
R535 467-1C210-H03 1/6W-1K-J
R539 467-1C210-H03 1/6W-1K-J
R541 467-1C210-H03 1/6W-1K-J
R514 467-1C222-H03 1/6W-2.2K-J
R507 467-1C310-H03 1/6W-10K-J
R509 467-1C310-H03 1/6W-10K-J
R511 467-1C318-H03 1/6W-18K-J
R536 467-1C322-H03 1/6W-22K-J
R537 467-1C333-H03 1/6W-33K-J
R546 467-1D033-H03 RT14-1/4W-33Ω-J
R533 467-1D147-H03 RT14-1/4W-470Ω-J
R534 467-1D175-H03 RT14-1/4W-750Ω-J
R528 467-1D251-H03 RT14-1/4W-5.1K-J
R532 467-1D268-H03 RT14-1/4W-6.8K-J
R527 467-1D415-H03 RT14-1/4W-150K-J
48
Page 53
SYMBOL PART NO. DESCRIPTION
R515 467-1EA33-H03 1/2W-3.3Ω-J
METAL RESISTOR
R530 467-2D322-H03 1/4W-22K-J
R521 467-2EB22-H0 1/2W-0.22Ω-JL
R543 467-2E001-H0 1/2W-1Ω-JL
R524 467-2F012-H0 1W-12Ω-JL
R526 467-2F018-H0 1W-18Ω-JL
R538 467-2F315-H0 1W-15kΩ-JL
R512 467-2F322-H0 1W-22kΩ-JL
R529 467-2F368-H0 1W-68kΩ-JL
R510 467-2F382-H0 1W-82kΩ-JL
R506 467-2GB22-H0 2W-0.22Ω-JL
R544 467-2GB22-H0 2W-0.22Ω-JL
IC
N504 352-00120-70 PQ12RF1
N502 352-06210-70 TLP621-GB(UL)
N501 352-96560-00 STR-G9656
N503 352-05210-00 PQ05RD21
RELAY
RY1 457-12003-9G JQX-14FF-012-1HS
MELTABLE RESISTOR
R513 467-4E010-H0 1/2W-10Ω-JL
R547 467-4FB47-H0 1W-0.47Ω-JL
POTENTIOMETER
RP501 468-33107-00 EVND8A-A03-B14
THERMISTOR
R504 469-10023-00 96708 (9Ω)
R501 469-40004-00 5D2-14LC
SWITCH TRANSFORMER
T503 470-00309-00 SR4230
POWER FILTER
T502 477-20028-00 LF21065
T501 477-20031-00 LCL-21
FUSE
FU501 569-16101-90 51S 2.5A/250V
CARBON RESISTOR
R520 467-8E582-H0A 1/2W-8.2MΩ-J
49
Page 54
FRONT BOARD
SYMBOL PART NO. DESCRIPTION
782-TDC18-2900 FRONT AV PCB
AV SOCKET
X1 364-93202-00 AV306-2
ELECTROLYTIC CAPACITOR
C1 464-6D647-M0 CD110-16V-47uF-M
C2 464-6D647-M0 CD110-16V-47uF-M
CARBON RESISTOR
R1 467-1D112-H0 RT14-1/4W-120Ω-J
R2 467-1D112-H0 RT14-1/4W-120Ω-J
STAND BUTTON BOARD
SYMBOL PART NO. DESCRIPTION
782-TDC181-0500 STAND BUTTON PCB
LIGHT-TOUCH SWITCH
S1 360-10001-00 KFC-A06-4X4.5X5B
CARBON RESISTOR
R1 467-1C333-H0 1/6W-33K-J
MAIN BOARD
SYMBOL PART NO. DESCRIPTION
782-TDC18-0100 MAIN PCB
CRYSTAL
Z801 329-58001-00 8MHZ
TRANSISTOR
V301 343-15550-00 2SD2499
DIODE
D303 340-00014-00 RGP10J
D806 340-00001-003 1N4148
D804 340-00001-003 1N4148
D802 340-00001-003 1N4148
D801 340-00001-003 1N4148
D204 340-00001-003 1N4148
D307 340-00005-003 S5295J
D302 340-00010-003 S5295G
D301 340-00014-003 RGP10J
50
Page 55
SYMBOL PART NO. DESCRIPTION
D304 340-00014-003 RGP10J
D305 340-00086-003 TVR-1B
REGULATED DIODE
D807 340-50390-003 HZ4B2
D314 340-50910-003 HZ9C1
D207 340-50910-003 HZ9C1
D208 340-50910-003 HZ9C1
D205 340-50910-003 HZ9C1
D206 340-50910-003 HZ9C1
D210 340-50910-003 HZ9C1
D211 340-50910-003 HZ9C1
D203 340-50910-003 HZ9C1
D202 340-50910-003 HZ9C1
D201 340-50910-003 HZ9C1
D310 340-51850-003 HZ18-3
TRANSISTOR
V307 343-00420-404 SFORIB42
V608 343-10150-104 2SA1015Y Pr2.5
V609 343-10150-104 2SA1015Y Pr2.5
V805 343-10150-104 2SA1015Y Pr2.5
V804 343-10150-104 2SA1015Y Pr2.5
V604 343-10150-104 2SA1015Y Pr2.5
V201 343-10150-104 2SA1015Y Pr2.5
V806 343-10150-704 2SA1015GR
V101 343-18150-114 2SC1815-Y
V102 343-18150-114 2SC1815-Y
V103 343-18150-114 2SC1815-Y
V802 343-18150-114 2SC1815-Y
V803 343-18150-114 2SC1815-Y
V205 343-18150-114 2SC1815-Y
V801 343-18150-604 2SC 1815-0
V610 343-18150-604 2SC 1815-0
V204 343-18150-604 2SC 1815-0
V607 343-18150-604 2SC 1815-0
V606 343-18150-604 2SC 1815-0
V202 343-18150-604 2SC 1815-0
V602 343-18150-604 2SC 1815-0
V603 343-18150-604 2SC 1815-0
V605 343-18150-604 2SC 1815-0
V305 343-23830-604 2SC2383-0
V203 343-27170-004 2SC2717
CERAMIC CAPACITOR
51
Page 56
SYMBOL PART NO. DESCRIPTION
C815 459-2110H-10D CC1-08-CH-63V-101J
C812 459-2110H-10D CC1-08-CH-63V-101J
C207 459-2110H-10D CC1-08-CH-63V-101J
C308 459-5133K-00 RQC05B331K-H46CA
C328 459-8182K-00 DE0707B821K2K
C649 459-2047H-102 CC45-CH1H470JYR
C814 459-2051H-102 CC1-08-CH-63V-51pF-J
C813 459-2051H-102 CC1-08-CH-63V-51pF-J
C648 459-2056H-102 CC1-08-CH-63V-56pF-J
C647 459-2118H-102 CC45-CH1H181JYR
C807 459-2118H-102 CC45-CH1H181JYR
C313 459-2133K-902 RBU07SL331K-H46CA
C316 459-2133K-902 RBU07SL331K-H46CA
C811 459-2147H-902 CC1-12-SL-63V-471J
C830 459-2210K-002 CK45-B1H102KYR
C341 459-2210K-002 CK45-B1H102KYR
C222 459-2210K-002 CK45-B1H102KYR
C608 459-2210K-002 CK45-B1H102KYR
C609 459-2210K-002 CK45-B1H102KYR
C611 459-2210K-002 CK45-B1H102KYR
C622 459-2210K-002 CK45-B1H102KYR
C607 459-2210K-002 CK45-B1H102KYR
C606 459-2210K-002 CK45-B1H102KYR
C605 459-2210K-002 CK45-B1H102KYR
C311 459-2247R-002 CT1-08-2E4-63V-472Z
C639 459-2310R-002 CK45-F1H103ZYR
C644 459-2310R-002 CK45-F1H103ZYR
C218 459-2310R-002 CK45-F1H103ZYR
C223 459-2310R-002 CK45-F1H103ZYR
C225 459-2310R-002 CK45-F1H103ZYR
C816 459-2310R-002 CK45-F1H103ZYR
C618 459-2310R-002 CK45-F1H103ZYR
C216 459-2310R-002 CK45-F1H103ZYR
C806 459-2310R-002 CK45-F1H103ZYR
C237 459-2310R-002 CK45-F1H103ZYR
C632 459-2310R-002 CK45-F1H103ZYR
C819 459-2310R-002 CK45-F1H103ZYR
C228 459-2410R-002 DD308-63F104Z50
C227 459-2410R-002 DD308-63F104Z50
C118 459-2410R-002 DD308-63F104Z50
C120 459-2410R-002 DD308-63F104Z50
C125 459-2410R-002 DD308-63F104Z50
52
Page 57
SYMBOL PART NO. DESCRIPTION
C817 459-2410R-002 DD308-63F104Z50
C234 459-2410R-002 DD308-63F104Z50
C235 459-2410R-002 DD308-63F104Z50
C119 459-2410R-002 DD308-63F104Z50
C233 459-2410R-002 DD308-63F104Z50
C653 459-2410R-002 DD308-63F104Z50
C214 459-2410R-002 DD308-63F104Z50
C334 459-5139K-002 CK45-B2H391KYR
C335 459-5182K-002 DD06-999B812K500
THIN-FILM CAPACITOR
C112 462-00222-H0 CL11-100V-2200PF-J
C803 462-00227-K0 CL11-100V-2700PF-K
C203 462-00282-H0 CL11-100V-8200pF-J
C136 462-00322-H0 CL11-100V-0.022uF-J
C135 462-00347-H0 CL11-100V-0.047uF-J
C339 462-00410-H0 CL11-100V-0.1uF-J
C604 462-10310-H0 CL12-100V-10000pF-J
C301 462-53356-K0 CBB12-200V-0.056uF-K
C332 462-53433-H0 CBB13-200V-0.33uF-J
C319 462-88247-H0 CBB81-1600V-4700PF-J
C324 462-88272-H0 CBB81-1600V-7200PF-J
C226 462-B0410-H02 CL21X-50V-0.1uF-J
C651 462-00210-H02 CL11-100V-1000PF-J
C804 462-00215-K02 CL11-100V-1500PF-K
C137 462-00222-H02 CL11-100V-2200PF-J
C823 462-00222-H02 CL11-100V-2200PF-J
C338 462-00222-H02 CL11-100V-2200PF-J
C322 462-00222-K02 CL11-100V-2200PF-K
C646 462-00310-H02 CL11-100V-0.01uF-J
C636 462-00310-H02 CL11-100V-0.01uF-J
C637 462-00310-H02 CL11-100V-0.01uF-J
C638 462-00310-H02 CL11-100V-0.01uF-J
C641 462-00310-H02 CL11-100V-0.01uF-J
C642 462-00310-H02 CL11-100V-0.01uF-J
C643 462-00310-H02 CL11-100V-0.01uF-J
C650 462-00310-H02 CL11-100V-0.01uF-J
C236 462-00310-H02 CL11-100V-0.01uF-J
C109 462-00333-H02 CL11-100V-0.033uF-J
C134 462-00333-K02 CL11-100V-0.033uF-K
C115 462-00333-K02 CL11-100V-0.033uF-K
C824 462-90410-H02 63V-0.1uF-J
C147 462-90410-H02 63V-0.1uF-J
53
Page 58
SYMBOL PART NO. DESCRIPTION
C123 462-90410-H02 63V-0.1uF-J
C122 462-90410-H02 63V-0.1uF-J
C140 462-90410-H02 63V-0.1uF-J
C329 462-90410-H02 63V-0.1uF-J
C624 462-90410-H02 63V-0.1uF-J
ELECTROLYTIC CAPACITOR
C818 464-6C710-M0 CD110-10V-100uF-M
C114 464-6D622-M0 CD110-16V-22uF-M
C340 464-6D710-M0 CD110-16V-100uF-M
C220 464-6D710-M0 CD110-16V-100uF-M
C110 464-6D810-M0 CD110-16V-1000uF-M
C654 464-6E647-M0 CD110-25V-47uF-M
C302 464-6E822-M0 CD110-25V-2200uF-M
C321 464-6F810-M0 CD110-35V-1000uF-M
C224 464-60447-M0 CD110-50V-0.47uF-M
C141 464-60522-M0 CD110-50V-2.2uF-M
C121 464-60522-M0 CD110-50V-2.2uF-M
C645 464-60610-M0 CD110-50V-10uF-M
C331 464-65547-M0 CD288-250V-4.7uF-M
C315 464-65633-M0 CD288-250V-33uF-M
C312 464-65633-M0 CD288-250V-33uF-M
C337 464-3D610-M02 CD11W-16V-10uF-M
C217 464-3D610-M02 CD11W-16V-10uF-M
C219 464-6C710-M02 CD110-10V-100uF-M
C810 464-6C710-M02 CD110-10V-100uF-M
C231 464-6C722-M02 CD110-10V-220uF-M
C212 464-6C722-M02 CD110-10V-220uF-M
C230 464-6C722-M02 CD110-10V-220uF-M
C629 464-6C747-M02 CD110-10V-470uF-M
C132 464-6D547-M02 CD110-16V-4.7uF-M
C142 464-6D547-M02 CD110-16V-4.7uF-M
C143 464-6D547-M02 CD110-16V-4.7uF-M
C144 464-6D547-M02 CD110-16V-4.7uF-M
C145 464-6D547-M02 CD110-16V-4.7uF-M
C146 464-6D547-M02 CD110-16V-4.7uF-M
C116 464-6D547-M02 CD110-16V-4.7uF-M
C232 464-6D547-M02 CD110-16V-4.7uF-M
C215 464-6D547-M02 CD110-16V-4.7uF-M
C129 464-6D547-M02 CD110-16V-4.7uF-M
C820 464-6D610-M02 CD110-16V-10uF-M
C634 464-6D647-M02 CD110-16V-47uF-M
C610 464-6D710-M02 CD110-16V-100uF-M
54
Page 59
SYMBOL PART NO. DESCRIPTION
C117 464-6D710-M02 CD110-16V-100uF-M
C633 464-6D710-M02 CD110-16V-100uF-M
C206 464-6D710-M02 CD110-16V-100uF-M
C655 464-6D710-M02 CD110-16V-100uF-M
C829 464-6D710-M02 CD110-16V-100uF-M
C831 464-6D710-M02 CD110-16V-100uF-M
C205 464-6D733-M02 CD110-16V-330uF-M
C623 464-6E610-M02 CD110-25V-10uF-M
C625 464-6E610-M02 CD110-25V-10uF-M
C802 464-6E610-M02 CD110-25V-10uF-M
C626 464-6E610-M02 CD110-25V-10uF-M
C631 464-6E610-M02 CD110-25V-10uF-M
C630 464-6E610-M02 CD110-25V-10uF-M
C131 464-6E610-M02 CD110-25V-10uF-M
C130 464-6E610-M02 CD110-25V-10uF-M
C314 464-6E722-M02 CD110-25V-220uF-M
C310 464-6F710-M02 CD110-35V-100uF-M
C640 464-60447-M02 CD110-50V-0.47uF-M
C202 464-60447-M02 CD110-50V-0.47uF-M
C204 464-60447-M02 CD110-50V-0.47uF-M
C601 464-60510-M02 CD110-50V-1uF-M
C213 464-60510-M02 CD110-50V-1uF-M
C111 464-60510-M02 CD110-50V-1uF-M
C113 464-60510-M02 CD110-50V-1uF-M
C620 464-60510-M02 CD110-50V-1uF-M
C616 464-60510-M02 CD110-50V-1uF-M
C613 464-60510-M02 CD110-50V-1uF-M
C208 464-60510-M02 CD110-50V-1uF-M
C209 464-60510-M02 CD110-50V-1uF-M
C210 464-60510-M02 CD110-50V-1uF-M
C801 464-60510-M02 CD110-50V-1uF-M
C211 464-60510-M02 CD110-50V-1uF-M
C305 464-60547-M02 CD110-50V-4.7uF-M
C635 464-60610-M02 CD110-50V-10uF-M
C652 464-60610-M02 CD110-50V-10uF-M
C612 464-60610-M02 CD110-50V-10uF-M
C614 464-60610-M02 CD110-50V-10uF-M
C615 464-60610-M02 CD110-50V-10uF-M
C617 464-60610-M02 CD110-50V-10uF-M
C619 464-60610-M02 CD110-50V-10uF-M
C621 464-60610-M02 CD110-50V-10uF-M
C221 464-60610-M02 CD110-50V-10uF-M
55
Page 60
SYMBOL PART NO. DESCRIPTION
C307 464-60610-M02 CD110-50V-10uF-M
C320 464-60610-M02 CD110-50V-10uF-M
C229 464-60647-M02 CD110-50V-47uF-M
C306 464-61422-M02 CD110-100V-0.22uF-M
C330 464-62510-M02 CD288-160V-1uF-M
CARBON RESISTOR
R226 467-1C027-H03 1/6W-27Ω-J
R627 467-1C168-H03 1/6W-680Ω-J
R633 467-1C168-H03 1/6W-680Ω-J
R835 467-1C075-H03 1/6W-75Ω-J
R609 467-1C075-H03 1/6W-75Ω-J
R615 467-1C075-H03 1/6W-75Ω-J
R619 467-1C075-H03 1/6W-75Ω-J
R607 467-1C075-H03 1/6W-75Ω-J
R622 467-1C075-H03 1/6W-75Ω-J
R601 467-1C082-H03 1/6W-82Ω-J
R604 467-1C082-H03 1/6W-82Ω-J
R809 467-1C110-H03 1/6W-100Ω-J
R217 467-1C110-H03 1/6W-100Ω-J
R209 467-1C110-H03 1/6W-100Ω-J
R211 467-1C110-H03 1/6W-100Ω-J
R212 467-1C110-H03 1/6W-100Ω-J
R613 467-1C110-H03 1/6W-100Ω-J
R614 467-1C110-H03 1/6W-100Ω-J
R616 467-1C110-H03 1/6W-100Ω-J
R618 467-1C110-H03 1/6W-100Ω-J
R617 467-1C110-H03 1/6W-100Ω-J
R637 467-1C110-H03 1/6W-100Ω-J
R118 467-1C110-H03 1/6W-100Ω-J
R119 467-1C110-H03 1/6W-100Ω-J
R234 467-1C110-H03 1/6W-100Ω-J
R235 467-1C110-H03 1/6W-100Ω-J
R113 467-1C110-H03 1/6W-100Ω-J
R114 467-1C110-H03 1/6W-100Ω-J
R115 467-1C110-H03 1/6W-100Ω-J
R643 467-1C110-H03 1/6W-100Ω-J
R640 467-1C110-H03 1/6W-100Ω-J
R224 467-1C110-H03 1/6W-100Ω-J
R236 467-1C110-H03 1/6W-100Ω-J
R814 467-1C110-H03 1/6W-100Ω-J
R344 467-1C110-H03 1/6W-100Ω-J
R642 467-1C112-H03 1/6W-120Ω-J
56
Page 61
SYMBOL PART NO. DESCRIPTION
R343 467-1C115-H03 1/6W-150Ω-J
R342 467-1C115-H03 1/6W-150Ω-J
R652 467-1C115-H03 1/6W-150Ω-J
R641 467-1C120-H03 1/6W-200Ω-J
R812 467-1C122-H03 1/6W-220Ω-J
R639 467-1C122-H03 1/6W-220Ω-J
R222 467-1C122-H03 1/6W-220Ω-J
R621 467-1C122-H03 1/6W-220Ω-J
R237 467-1C122-H03 1/6W-220Ω-J
R225 467-1C127-H03 1/6W-270Ω-J
R220 467-1C127-H03 1/6W-270Ω-J
R824 467-1C133-H03 1/6W-330Ω-J
R832 467-1C133-H03 1/6W-330Ω-J
R830 467-1C133-H03 1/6W-330Ω-J
R214 467-1C133-H03 1/6W-330Ω-J
R630 467-1C133-H03 1/6W-330Ω-J
R202 467-1C133-H03 1/6W-330Ω-J
R203 467-1C133-H03 1/6W-330Ω-J
R205 467-1C133-H03 1/6W-330Ω-J
R644 467-1C133-H03 1/6W-330Ω-J
R623 467-1C133-H03 1/6W-330Ω-J
R229 467-1C133-H03 1/6W-330Ω-J
R653 467-1C139-H03 1/6W-390Ω-J
R815 467-1C147-H03 1/6W-470Ω-J
R208 467-1C147-H03 1/6W-470Ω-J
R624 467-1C156-H03 1/6W-560Ω-J
R634 467-1C156-H03 1/6W-560Ω-J
R807 467-1C168-H03 1/6W-680Ω-J
R648 467-1C168-H03 1/6W-680Ω-J
R121 467-1C168-H03 1/6W-680Ω-J
R122 467-1C168-H03 1/6W-680Ω-J
R625 467-1C168-H03 1/6W-680Ω-J
R631 467-1C168-H03 1/6W-680Ω-J
R645 467-1C182-H03 1/6W-820Ω-J
R219 467-1C182-H03 1/6W-820Ω-J
R649 467-1C191-H03 1/6W-910Ω-J
R116 467-1C210-H03 1/6W-1K-J
R112 467-1C210-H03 1/6W-1K-J
R232 467-1C210-H03 1/6W-1K-J
R646 467-1C210-H03 1/6W-1K-J
R647 467-1C210-H03 1/6W-1K-J
R839 467-1C210-H03 1/6W-1K-J
57
Page 62
SYMBOL PART NO. DESCRIPTION
R651 467-1C210-H03 1/6W-1K-J
R650 467-1C210-H03 1/6W-1K-J
R311 467-1C210-H03 1/6W-1K-J
R804 467-1C210-H03 1/6W-1K-J
R228 467-1C210-H03 1/6W-1K-J
R206 467-1C210-H03 1/6W-1K-J
R828 467-1C210-H03 1/6W-1K-J
R827 467-1C210-H03 1/6W-1K-J
R826 467-1C210-H03 1/6W-1K-J
R210 467-1C210-H03 1/6W-1K-J
R816 467-1C215-H03 1/6W-1.5K-J
R335 467-1C220-H03 1/6W-2K-J
R805 467-1C222-H03 1/6W-2.2K-J
R626 467-1C222-H03 1/6W-2.2K-J
R632 467-1C222-H03 1/6W-2.2K-J
R207 467-1C222-H03 1/6W-2.2K-J
R238 467-1C222-H03 1/6W-2.2K-J
R656 467-1C233-H03 1/6W-3.3K-J
R659 467-1C233-H03 1/6W-3.3K-J
R833 467-1C233-H03 1/6W-3.3K-J
R213 467-1C233-H03 1/6W-3.3K-J
R215 467-1C233-H03 1/6W-3.3K-J
R635 467-1C233-H03 1/6W-3.3K-J
R811 467-1C239-H03 1/6W-3.9K-J
R808 467-1C239-H03 1/6W-3.9K-J
R661 467-1C239-H03 1/6W-3.9K-J
R821 467-1C247-H03 1/6W-4.7K-J
R314 467-1C251-H03 1/6W-5.1K-J
R227 467-1C256-H03 1/6W-5.6K-J
R204 467-1C282-H03 1/6W-8.2K-J
R655 467-1C310-H03 1/6W-10K-J
R810 467-1C310-H03 1/6W-10K-J
R818 467-1C310-H03 1/6W-10K-J
R819 467-1C310-H03 1/6W-10K-J
R820 467-1C310-H03 1/6W-10K-J
R801 467-1C310-H03 1/6W-10K-J
R802 467-1C310-H03 1/6W-10K-J
R201 467-1C310-H03 1/6W-10K-J
R323 467-1C310-H03 1/6W-10K-J
R838 467-1C310-H03 1/6W-10K-J
R658 467-1C310-H03 1/6W-10K-J
R803 467-1C312-H03 1/6W-12K-J
58
Page 63
SYMBOL PART NO. DESCRIPTION
R221 467-1C315-H03 1/6W-15K-J
R318 467-1C315-H03 1/6W-15K-J
R822 467-1C320-H03 1/6W-20K-J
R603 467-1C320-H03 1/6W-20K-J
R309 467-1C320-H03 1/6W-20K-J
R320 467-1C322-H03 1/6W-22K-J
R817 467-1C322-H03 1/6W-22K-J
R107 467-1C330-H03 1/6W-30K-J
R328 467-1C330-H03 1/6W-30K-J
R110 467-1C333-H03 1/6W-33K-J
R307 467-1C333-H03 1/6W-33K-J
R834 467-1C333-H03 1/6W-33K-J
R829 467-1C333-H03 1/6W-33K-J
R608 467-1C347-H03 1/6W-47K-J
R610 467-1C347-H03 1/6W-47K-J
R611 467-1C347-H03 1/6W-47K-J
R612 467-1C347-H03 1/6W-47K-J
R606 467-1C347-H03 1/6W-47K-J
R605 467-1C347-H03 1/6W-47K-J
R629 467-1C347-H03 1/6W-47K-J
R620 467-1C347-H03 1/6W-47K-J
R124 467-1C347-H03 1/6W-47K-J
R230 467-1C347-H03 1/6W-47K-J
R231 467-1C356-H03 1/6W-56K-J
R379 467-1C356-H03 1/6W-56K-J
R233 467-1C362-H03 1/6W-62K-J
R813 467-1C368-H03 1/6W-68K-J
R123 467-1C410-H03 1/6W-100K-J
R109 467-1C410-H03 1/6W-100K-J
R120 467-1C410-H03 1/6W-100K-J
R657 467-1C410-H03 1/6W-100K-J
R660 467-1C410-H03 1/6W-100K-J
R216 467-1C410-H03 1/6W-100K-J
R636 467-1C410-H03 1/6W-100K-J
R638 467-1C410-H03 1/6W-100K-J
R108 467-1C422-H03 1/6W-220K-J
R806 467-1C456-H03 1/6W-560K-J
R223 467-1C515-H03 1/6W-1.5M-J
R326 467-1D033-H03 RT14-1/4W-33Ω-J
R336 467-1D227-H03 RT14-1/4W-2.7K-J
R303 467-1D291-H03 RT14-1/4W-9.1K-J
INDUCTANCE WITH COLOUR CODES
59
Page 64
SYMBOL PART NO. DESCRIPTION
L203 471-1056K-00 EL0606SK1-560K
L612 471-2010K-A0 SP0203-10uH-K
L605 471-2010K-A0 SP0203-10uH-K
L602 471-2010K-A0 SP0203-10uH-K
L614 471-2015K-A0 SP0203-15uH-K
L615 471-2027K-A0 SP0203-27uH-K
L202 471-2056H-60 LGA0307-56uH-J
L101 471-2056H-60 LGA0307-56uH-J
L801 471-2056H-60 LGA0307-56uH-J
L204 471-2056H-60 LGA0307-56uH-J
L206 471-2056H-60 LGA0307-56uH-J
L616 471-2110K-10 LGA0410-100uH-K
L613 471-2110K-10 LGA0410-100uH-K
J208 471-2110K-10 LGA0410-100uH-K
L802 471-2110K-10 LGA0410-100uH-K
L201 471-2110K-10 LGA0410-100uH-K
L609 471-2110K-10 LGA0410-100uH-K
L208 471-2B56K-003 SPT0305-R56K-5
L205 471-2B82K-003 SPT0305-R82K-5
L603 471-2010K-003 SPT0305-100K-5
L604 471-2010K-003 SPT0305-100K-5
L607 471-2010K-003 SPT0305-100K-5
L608 471-2010K-003 SPT0305-100K-5
L601 471-2056K-003 SPT0305-560K-5
L207 471-2068K-003 SPT0305-680K-5
L606 471-2110K-003 SPT0305-101K-5
L611 471-2110K-003 SPT0305-101K-5
IC
D209 352-05740-00 uPC574
N802 352-11660-10 NJW1166
N801 352-24080-50 M24C08BN6
N603 352-40530-00 TC4053BP
N601 352-52797-20 M52797SP
N301 352-55220-00 AN5522
N803 352-75220-00 AN7522N
N302 352-78050-00 KA7805
N807 352-78090-40 TA78M09P
N201 352-88070-00 TMPA8807PSAN
N602 352-90450-50 TC90A45P
AV SOCKET
X601 364-92210-00 417
X803 364-92213-00 AV417-3
60
Page 65
SYMBOL PART NO. DESCRIPTION
X806 364-92221-00 AV-8409-1
SAW FILTER
Z201 458-07008-00 M1962M
WIRE-ROUND RESISTOR
R333 467-B0239-H0 RX25-5W-3.9K-J
R302 467-6FA12-H0 RX21-1-1.2Ω-J
METAL RESISTOR
R306 467-2D311-F03 1/4W-11K-F
R305 467-2EB82-H0 1/2W-0.82Ω-JL
R329 467-2F210-H0 1W-1KΩ-JL
R324 467-2F210-H0 1W-1KΩ-JL
R332 467-2F310-H0 1W-10kΩ-JL
R317 467-2F310-H0 1W-10kΩ-JL
R316 467-2G012-H0 2W-12Ω-JL
R301 467-2G127-H0 2W-270Ω-JL
MELTABLE RESISTOR
R315 467-4E001-H0 1/2W-1Ω-JL
R312 467-4FB33-H0 1W-0.33Ω-JL
R322 467-4F001-H0 1W-1Ω-JL
R313 467-4F001-H0 1W-1Ω-JL
R308 467-4F010-H0 1W-10Ω-JL
H-DRIVE TRANSFORMER
T303 472-10001-00 XR0961
CERAMIC FILTER
Z202 475-15451-00 LT4.5MH
CERAMIC TRAP FILTER
Z601 475-25451-00 XT4.5MB
H-LINEARITY COIL
L303 477-00066-00 HL1830H-X14
FBT
T302 472-24213-00 BSC24-3031*UL!
OTHER
TUNER 590-40707-00 115-B-8035AZ
DEGAUSSING COIL 477-12105-00 DX-56-2
POER CORD 491-702D0-02 UL
CRT 335-2122R-00 A51LVV896X-12
61
Page 66
CRT BOARD
SYMBOL PART NO. DESCRIPTION
782-W2935-0200 CRT PCB
TRANSISTOR
V411 343-05620-10 2SA562TM-Y
V415 343-10150-10 2SA1015Y
V401 343-18150-11 2SC1815-Y
V402 343-18150-11 2SC1815-Y
V404 343-18150-11 2SC1815-Y
V406 343-18150-11 2SC1815-Y
V408 343-18150-11 2SC1815-Y
V409 343-18150-11 2SC1815-Y
V410 343-18150-11 2SC1815-Y
V413 343-18150-11 2SC1815-Y
V414 343-18150-11 2SC1815-Y
V416 343-19640-30 2SA1964E
V403 343-26880-60 2SC2688M
V405 343-26880-60 2SC2688M
V407 343-26880-60 2SC2688M
V417 343-52480-30 2SC5248E
CRT SOCKET
X404 364-58210-00 GZS10-2-102G
CERAMIC CAPACITOR
C446 459-2082H-10 CC1-08-63V-82pF-J
C447 459-2082H-10 CC1-08-63V-82pF-J
C448 459-2082H-10 CC1-08-63V-82pF-J
C419 459-2110H-10D CC1-08-CH-63V-101J
C420 459-2110H-10D CC1-08-CH-63V-101J
C403 459-2127H-90 CC1-08-SL-63V-271J
C405 459-2127H-90 CC1-08-SL-63V-271J
C406 459-2127H-90 CC1-08-SL-63V-271J
C409 459-2147H-90 CC1-12-SL-63V-471J
C410 459-2147H-90 CC1-12-SL-63V-471J
C411 459-2147H-90 CC1-12-SL-63V-471J
C414 459-2156H-90 CC1-12-SL-63V-561J
C417 459-2210K-00 CT1-06-2B4-63V-102K
C421 459-2247R-00 CT1-08-2E4-63V-472Z
C422 459-2247R-00 CT1-08-2E4-63V-472Z
C404 459-2310R-00 CT1-08-2F4-63V-103Z
C412 459-2310R-00 CT1-08-2F4-63V-103Z
C426 459-5056H-90 CC45SL2H560JYJ
C424 459-8222K-00 DE1005B222K2K
62
Page 67
SYMBOL PART NO. DESCRIPTION
MELTABLE RESISTOR
R442 467-4FA39-H0 1W-3.9Ω-JL
THIN-FILM CAPACITOR
C402 462-00282-H0 CL11-100V-8200pF-J
ELECTROLYTIC CAPACITOR
C423 464-6D647-M0 CD110-16V-47uF-M
C425 464-6D647-M0 CD110-16V-47uF-M
C415 464-6D722-M0 CD110-16V-220uF-M
C401 464-6E610-M0 CD110-25V-10uF-M
C407 464-6E710-M0 CD110-25V-100uF-M
C418 464-62610-M0 CD288-160V-10uF-M
C427 464-62610-M0 CD288-160V-10uF-M
C416 464-65633-M0 CD288-250V-33uF-M
CARBON RESISTOR
R429 467-1C022-H0 1/6W-22Ω-J
R428 467-1C047-H0 1/6W-47Ω-J
R418 467-1C056-H0 1/6W-56Ω-J
R419 467-1C056-H0 1/6W-56Ω-J
R420 467-1C056-H0 1/6W-56Ω-J
R445 467-1C082-H0 1/6W-82Ω-J
R446 467-1C082-H0 1/6W-82Ω-J
R406 467-1C139-H0 1/6W-390Ω-J
R407 467-1C139-H0 1/6W-390Ω-J
R408 467-1C139-H0 1/6W-390Ω-J
R415 467-1C127-H0 1/6W-270Ω-J
R422 467-1C147-H0 1/6W-470Ω-J
R412 467-1C156-H0 1/6W-560Ω-J
R413 467-1C156-H0 1/6W-560Ω-J
R414 467-1C156-H0 1/6W-560Ω-J
R423 467-1C168-H0 1/6W-680Ω-J
R424 467-1C168-H0 1/6W-680Ω-J
R425 467-1C168-H0 1/6W-680Ω-J
R416 467-1C210-H0 1/6W-1K-J
R453 467-1C210-H0 1/6W-1K-J
R404 467-1C212-H0 1/6W-1.2K-J
R447 467-1C212-H0 1/6W-1.2K-J
R452 467-1C212-H0 1/6W-1.2K-J
R448 467-1C215-H0 1/6W-1.5K-J
R451 467-1C215-H0 1/6W-1.5K-J
R402 467-1C222-H0 1/6W-2.2K-J
R441 467-1C222-H0 1/6W-2.2K-J
R427 467-1C224-H0 1/6W-2.4K-J
63
Page 68
SYMBOL PART NO. DESCRIPTION
R431 467-1C239-H0 1/6W-3.9K-J
R438 467-1C239-H0 1/6W-3.9K-J
R403 467-1C247-H0 1/6W-4.7K-J
R430 467-1C310-H0 1/6W-10K-J
R409 467-1C322-H0 1/6W-22K-J
R421 467-1C327-H0 1/6W-27K-J
R426 467-1C333-H0 1/6W-33K-J
R439 467-1C339-H0 1/6W-39K-J
R440 467-1C356-H0 1/6W-56K-J
R449 467-1C368-H0 1/6W-68K-J
R450 467-1C368-H0 1/6W-68K-J
R454 467-1DA27-H0 RT14-1/4W-2.7Ω-J
R457 467-1DA27-H0 RT14-1/4W-2.7Ω-J
R405 467-1D168-H0 RT14-1/4W-680Ω-J
R455 467-1E047-H0 1/2W-47Ω-J
R456 467-1E047-H0 1/2W-47Ω-J
R417 467-1E147-H0 1/2W-470Ω-J
METAL RESISTOR
R443 467-2E010-H0 1/2W-10Ω-JL
R401 467-2E047-H0 1/2W-47Ω-JL
R444 467-2E133-H0 1/2W-330Ω-JL
R458 467-2F122-H0 1W-220Ω-JL
R432 467-2G312-H0 2W-12kΩ-JL
R434 467-2G312-H0 2W-12kΩ-JL
R437 467-2G312-H0 2W-12kΩ-JL
CARBON RESISTOR
R433 467-8E227-H1A 1/2W-2.7KΩ-J
R435 467-8E227-H1A 1/2W-2.7KΩ-J
R436 467-8E227-H1A 1/2W-2.7KΩ-J
INDUCTANCE WITH COLOUR CODES
L401 471-1056H-00 EL0606SKI-560J
L402 471-2110K-00 SPT0305-101K-5
DIODE
D401 340-00001-00 1N4148
D402 340-00001-00 1N4148
D403 340-00001-00 1N4148
D404 340-00001-00 1N4148
D405 340-00001-00 1N4148
D407 340-00001-00 1N4148
D408 340-00001-00 1N4148
D409 340-00001-00 1N4148
D410 340-00001-00 1N4148
64
Loading...