Hiland SPOA, SPOC, SPOB Owner's Manual

1

Quesons, problems, missing parts? Before returning to your retailer, call our customer
service department at 1-888-775-1330, 8 a.m. - 4 p.m., PST, Monday - Friday.

TABLE OF CONTENTS

Safety Information .................................................................................................. 3

Expanded Diagram.......................................................................... 5

Assembly Instructions.................................................................................... 7

Parts List ........................................................................................................ 6

Gas Cylinder Use............................................................................................14

Operating Instructions.................................................................................... 15

Care and Maintenance................................................................................................. 17

Warranty...................................................................................................................... 19

2

SAFETY INFORMATION

Please read and understand this enre manual before aempng to assemble,
operate or install the product.

1. The installaon of this appliance must conform with local codes or, in the absence
of local codes, with either the Naonal Fuel Gas Code, ANSI Z223.1/NFPA 54, or
Natural Gas and Propane Installaon Code, CSA/CGA-B149.1.

2. This oven is intended for use outdoors and should not be used in a building,
garage or any other enclosed or covered area.

3. This outdoor oven is not intended for installaon in or on recreaon vehicles and
/or boats.

4. A minimum clearance of 61 cm (24 inches) from combusble construcons to the
sides of the grill and 61 cm (24 inches) from the back of the grill to combusble
construcons must be maintained.This outdoor cooking gas appliance must not be
placed under overhead combusble construcon.

5. The use of an electrical source requires that when installed, the grill must be
electrically grounded in accordance with local codes or, in the absence of local
codes.

6. Inspect the hoses before each use for excessive abrasion or wear, or cuts that may
affect safe operaon of the grill. If there is evidence of excessive abrasion or wear, or
the hose is cut, it must be replaced prior to the grill being put into operaon. The
replacement hose assembly must be those specified by the manufacturer.

7. Keep your oven in an area clear and free from combusble materials gasoline and
other flammable vapors and liquids.

8. DO NOT obstruct the flow of combuson and venlaon air to this appliance.

9. Keep the venlaon openings of the tank enclosure free and clear from debris.

10. Check all gas connecons for leaks with a soapy water soluon and brush. Never
use an open flame to check for leaks.

11. Never use charcoal in the oven.

12. Never use the grill in windy areas.

13. Never use the grill without the drip tray installed and hung under the burner box.
Without the drip tray, hot grease and debris could leak downward and produce a fire
hazard.

14. Use only the gas pressure regulator supplied with this appliance.

15. The cylinder used must include a collar to protect the cylinder valve.

16. Do not store a spare LP-gas cylinder under or near the appliance.

17. Never fill the cylinder beyond 80 percent full.

18. If the informaon in “17”and “18”is not followed exactly, a fire causing death or
serious injury may occur.

19. The outdoor cooking gas appliance must be isolated from the gas supply piping
system by closing its individual manual shut off valve during any pressure tesng of

3

the gas supply system at test pressures equal to or less than 1/2 psi (3.5 kPa).

20. CALIFORNIA PROPOSITION 65 WARNING: The burning of gas cooking fuel
generates some by products that are on the list of substances known by the State of
California to cause cancer, reproducve harm, or other birth defects. To reduce
exposure to these substances, always operate this unit according to the use and care
manual, ensuring you provide good venlaon when cooking with gas.

——————————————————————————————————

IMPORTANT: We urge you to read this manual carefully and follow the
recommendaons enclosed. This will ensure you receive the most enjoyable and
trouble-free operaon of your new gas gr ill . We also advise you retain this manual
for future reference.

——————————————————————————————————

WARNING: Your grill has been designed to operate using only the gas specified b y
the manufacturer on the rang plate. Do not aempt to operate your grill on other
gases. Failure to follow this warning could lead to a fire hazard and bodily harm and
will void your warranty.

——————————————————————————————————

WARNING: Make certain your LP (propane) tank is filled by a reputable propane
dealer. An incorrectly filled or an overfilled LP tank can be dangerous. The overfilled
condion combined with the warming of the LP tank (a hot summer day, tank le in
the sun, etc.) can cause LP gas to be released by the pressure relief valve on the tank
since the temperature increase causes the propane to expand. LP gas released from
the tank is flammable and can be explosive. Refer to your Owner’s Manual for more
informaon concerning filling your LP tank.

4

5

Expanded Diagram

Parts List

NO

PART NAME

QTY

1

CHIMNEY

1

2

OVEN DOOR HINGE

2

3

HEAT SPACER

4

4

BACK HEAT-SHIELD

1

5

BACK PANEL

1

6

EXTERIOR

1

7

INTERIOR ASSEMBLY

1

8

LATCH

1

9

GAS PIPE JOINT

1

10

GAS PIPE

1

11

WHEEL

2

12

CART SUPPORT

1

13

WHEEL AXLE

1

14

CHECK NUT

2

15

CART BOTTOM PLATE

1

16

CART FRONT PLATE

1

17

LEG R

2

18

RUBBER FOOT

2

19

LEG L

2

20

GREASE TRAY HOLDER

1

21

GREASE TRAY

1

22

HANDLE

1

23

GLASS DOOR HANDLE

1

24

KNOB

1

25

KNOB BEZEL

1

26

THERMOMETER

1

27

IGNITER

1

28

GLASS DOOR

1

29

VALVE

1

30

CONTROL PANEL

1

31

OVEN FRONT PANEL

1

32

HEAT SHIELD

1

33

PIZZA STONE

1

34

BOTTOM GRILL

1

35

BURNER

1

36

FLAME TEMPER

1 (oponal accessories)

37

COOKING GRILL

2

38

SMOKER BOX ASSEMBLY

1 (oponal accessories)

6

ASSEMBLY INSTRUCTIONS

Before beginning assembly of product, make sure all parts are present. Compare
parts with package contents list and hardware contents list. If any part is missing or
damaged, do not aempt to assemble the product.

Assembly p! (Please lightly ghten the screws during assembly of the cart. When
the cart is completed THEN TIGHTEN ALL THE screws. This will make it easier to
align the holes properly)

STEP 1

Use 16 M6*10 Screws and 16 M6 nuts to aach the 4 Legs to the Cart boom

plate as shown.

Put 2 Rubber feet on le legs.

7

STEP 2

Use 2pcs check nut to assemble the wheel and wheel axle as shown.

8

STEP 4

Use 4 M6*10 screws and 4 M6 nuts to assemble the handle as shown.

9

STEP 3

Use 6 M6*10 screws and 6 M6 nuts to assemble the Cart Front Panel to the Cart Legs.

STEP 6

Use 3 M4*12 screws to assemble the chimney as shown.

10

STEP 5

Use 4 M6*10 screws and 4 M6 nuts to assemble the body and the cart as shown,

use bolt to ghten.

STEP 7

Use 4 M5*30 screws and heat insulaon washer to aach the back heat shield onto
the back panel of the oven as shown.

STEP 8

Place the boom rack, pizza stone and cooking grill (2pcs) into the oven as shown.

11

12

OPTIONAL ACCESSORIES

Put the flame temper and smoker box assembly (hang on the cooking grill, exact posion
is according to the food posion) into the oven as shown.

STEP 9

Insert the knob as shown.

13

Fully-Assembled

14

GAS CYLINDER USE

GAS CONNECTIONS

In the case of a problem arising with the hose and regulator please contact your gas
oven supplier for a list of approved replacement parts . The hose and regulator

assembly parts must be an indicaon gas associaon approved part.

LEAK TESTING

This should be done the first me you connect up the pizza oven, and again every
me you disconnect and reconnect any fing. Inspect the hose before each use.

Turn the gas on at the cylinder, or make sure gas is available to the barbecue, but do
not turn the burners on. This fills the gas lines with gas. Now brush or pour some
soapy water onto all connecons. If there is a leak, bubbles should appear within
about 20 seconds. If you find any leaks, ghten the connecon. If the leak
persists, contact your place of purchase.

As an alternave, you may use a gas leak detector, following the manufacturer’s
instrucons, available at all major barbecue retailers. This provides an easier way to
check for leaks.

15

DO NOT USE NAKED FLAME FOR LOCATING GAS LEAKS.
IF A LEAK PERSISTS, CALL AN AUTHORISED PERSON.

WARNING

STORE CYLINDER IN A WELL VENTILATED AREA
OUT OF REACH OF CHILDREN

OPERATING INSTRUCTIONS

LIGHTING PROCEDURE

1. Lighng the gas oven is easy, but must be done with care.

2. Make sure that gas is turned on at the cylinder, or that gas is available to the gas
oven.

3. Make sure the LPG cylinder is filled.

4. Check that the end of the burner tube is properly located over the valve orifice.

5. Make sure all gas connecons are securely ghtened.

6. Open the gas oven door.

7. Line the grease tray with crumpled aluminium foil.

MANUAL IGNITION

Place a lighted match or gas lighter (not provided). Keep your hand below the boom
of the burner while doing this. Now turn the burner on. You should
See the burner light. Repeat to light the other burners.

PULSE IGNITER IGNITION
Note: Pulse igniter requires one AA baery to operate.

1. Ensure the door is open before lighng the burner.

2. Make sure the knob is in the “OFF” posion.

3. Press and turn THE KNOB to the “HIGH” posion and hold down the KNOB. While
holding down the KNOB, press the “PULSE IGNITON” buon to light the burner.

4. Connue pressing the “PULSE IGNITOR” buon for the next 3 to 5 seconds. Once
the burner is lit, connue holding down the KNOB for another 5 to 8 seconds before
releasing the knob.

5. If the burner FAILS TO light, turn the KNOB to the “OFF”posion and wait for
another 5 minutes before repeang the above steps.

16

CONTROLLING THE FLAMES

The knobs have three basic posions. You can achieve any flame height between
low and high by rotang the knob between posions.

Note: “Blowback” is a situaon where the flame burns inside the burner , towards
the front, recognised by a sharp roaring sound coming from the burner. It is not
dangerous unless allowed to persist. If this occurs, simply turn the burner off, wait a
few seconds, and then relight.

IMPAIRED VENTILATION OF HOT AIR FROM GRILL - In order for the burners to
funcon properly, hot air created by the burners must have a way to escape. The
burners may become deprived of oxygen, causing them to backfire, especially if the
burner output is set at HIGH. If this occurs repeatedly, the burners may crack. This is
the reason your grill was designed with venlaon louvers. These design features
give the hot air an escape route. Accordingly, never operate your grill with very lile
or no open space at the cooking surface (the cooking grids provide sufficient space).
Also, never cover the venlaon louvers with foil or other materials that prevent air
flow. Specifically, do not cover the enre surface with foil, a large pan, etc.

Care & Maintenance

GENERAL MAINTENANCE

- Keep outdoor cooking gas appliance area clear and free from combusble materials,
gasoline and other flammable vapors and liquids.

- Do not obstruct the flow of combuson and venlaon air.

- Keep the venlaon openings of the cylinder enclosure free and clear from debris.

- Visually check the burners.

GENERAL CLEANING
IMPORTANT: Before cleaning, make sure all controls are off and the grill is cool.

Always follow label instrucons on cleaning products.
For roune cleaning, wash with soap and water using a so cloth or sponge. Rinse
with clean water and dry at once with a so, lint-free cloth to avoid spots and
streaks.To avoid scratching the surface, do not use steel wool to clean the grill.
Use a grill cover to protect finish from weather.

COOKING GRATES

The cooking grates can be cleaned immediately aer cooking is completed and aer
turning off the grill. Wear a barbecue mi and scrub the cooking grates with a damp
cloth. If the grill is allowed to cool down, cleaning the grates will be easier if removed
from the grill and cleaned with a mild detergent.

Out of Adjustment: Hard blue

flames-too much air

17

18

Replacing Baery for Electrical Igniter:

1. Remove the igniter cap by turning counterclockwise;

2. Replace the baery;

3. When installing new baery, ensure it is installed with
the posive side facing outward;

4. Put on the igniter cap back by turning clockwise.

USAGE TIPS

Preheating

It is necessary to preheat the appliance for at least
15 minutes before cooking certain foods,
depending on the type of food and the cooking
temperature. Food that requires a low cooking
temperature needs a shorter period of preheating.

Cooking Pizza

A properly cooked, fresh pizza is one of life’s true
pleasures. Using this Pizza Oven you can enjoy
fresh cooked pizza in your own back yard.

Before cooking we recommend installing your
pizza stone and turning the cooker to high until
the cooker reaches just below your desired
temperature. At this stage turn the cooker to low
and the stored heat in the pizza stone will bring it
up to the correct temperature (you may need a
couple of tries to get this right).

Once your pizza is ready for cooking transfer it to
a heated pizza tray on the middle shelf of the Pizza
Oven using a spatula. Five minutes before cooking
is complete transfer to the pizza stone to crisp the
base and finish off. The
pizza stone ensures an intense and even heat for a
perfect crust.

This should produce a delicious pizza, however
everyone’s pizza recipe is a little different and we
suggest you try a few different methods of cooking
until you find the perfect process for you.

Cooking other Foods

Other foods can be cooked within the Pizza Oven
just as you would with a conventional oven. The
thermostat indicates the temperature at the top of
the oven and the temperature within the oven may
exhibit some local
variation. We recommend always using a baking
tray especially if cooking greasy foods.

Smoking with the Pizza Oven

Your Pizza Oven can be used as a hot smoker. Hot
smoking will not produce the intense smoked
flavors obtained by cold smoking for long periods
of time, but will give an added dimension to foods
such as fish and poultry.

We suggest that you fill the smoker box with
wood chips of your choice and hang from the
bottom rack. Leave the smoker box in place in a
lit cooker for 10-15 minutes (or until smoke
appears) before you start cooking. Then simply
cook your food thoroughly as usual.

As with cooking pizza, everyone’s taste is a little
different so enjoy experimenting with a range of
wood chip types and quantities, cooking times
and foods.

Caring for your Pizza Oven

Both the inside and outside of your Pizza Oven
require frequent cleaning to keep them in tip top
shape. We generally recommend washing with
warm soapy water and rinsing thoroughly at least
once per month. Always allow the Pizza Oven to
dry thoroughly before storage or use.

Your pizza stone will pick up flavors from cooking
and smoking. The best way to clean the pizza
stone is first to remove all loose residue and then
soak in warm water for 20 minutes. Then allow to
dry overnight in a dry place. You may need to
repeat this process several times to get rid of all
cooked in flavors.

Using Your Pizza Oven

19

ONE-YEAR LIMITED WARRANTY

Do not return this product to the store where you purchased it. Please call 1-888-775-1330
for assistance.

This product is inspected, tested and carefully packaged to minimize the chance of damage
during shipment. If a part (excluding light bulbs and fuses*) within one year from the date

of purchase proves to be defecve in material or fabricaon under normal use, the part will
be repaired or replaced. The Company's obligaon under the warranty is to replace or repair
defecve parts at our discreon. Any expenses or damage resulng from the installaon,
removal or transportaon of the product will the responsibility of the owner and are not

covered by this warranty. The owner assumes all other risks arising out from the use or
misuse of the product. The warranty will be void if the product damage or failure is deemed

by the Company to be caused by accident, alteraon, misuse, abuse, incorrect installaon or
removal, or connecon to an incorrect power source by the owner. The Company neither
assumes, nor authorizes any person or enty to assume for it any obligaon or liability

associated with its products.
* Light bulbs and fuses are not covered under this warranty.

If you have any quesons regarding the warranty or service, please call our toll free

number: 1-888-775-1330.

Distributed by:

AZ Pao Heaters, LLC

Toll Free Number 1-888-775-1330
Sales Service and Repair

www.azpaoheaters.com