Hiland F-1350-FPT User Manual

Owner’s Manual

OUTDOOR FIRE PIT TABLE

M # F-1350-FPTodel

ANS Z21.97-2010, Outdoor Decorative Gas Appliances CGA CR 97-003 Outdoor Gas Fireplaces

REPLACEMENT PARTS LIST

PART DESCRIPTION QUANTITY

A Burner Cover 1 B Table Top 1 C Burner 1 D Burner Bracket 1 E Side Panel 1 1 F Side Panel 2 1 G H

Side Panel 3 (Burner Controls) Side Panel 4 Door Frame)(

Conneting Rod

Gas Tank Bracket side()

Gas Tank Support bottom()

1 1 1 1

L Bolt 8 55mm Nut M8 Washer Spring Washer(* )/ ( )/ / 4

M Bolt 6 18mm Washer(* )/ ( )M6 12 N Screwdriver 1 O Wrench 1

P Allen Wrench

Glass Beads

2boxes/4bags

HARDWARE CONTENTS

Bolt(8*55mm) Nut(M8)

Washer Spring washer

Bolt (6*18mm) Washer

Qty. 12

Screwdriver

Qty. 4

Wrench

Qty 1

Allen wrench

QtQtyy.1

Glass Beads

2boxes/4bags

SAFETY INFORMATION

Please read and understand this entire manual before attempting to assem

the product

, operate or install

This appliance has been tested to and complies with the ANS Z21

2010 Outdoor, Decorative

.-97 Gas Appliances CGA CR 9 7-003Outdoor Gas Fireplaces. The installation must conform to local codes or the absence of local cs to the National Fuel Gas Code ANS. IZ223 1..

This manual

contains important information about the assembly operation and maintenance of this fire pit General,. safety information is presented in these first few pages and is also located throughout the manual Keep. this manual for future reference This manual should be read.

.product Safety precautions are essential when any mechanical

.,,is involved These precautions are necessary when using storing and

equipment with the respect and caution demanded will reduce the possibilities of

property damage The following symbols shown below are used extensively throughout.

,Always heed these precautions as they are essential when using any mechanical or fueled

DANGER

DANGER indicates an imminently hazardous situation which if not avoided will result in death or serious injury,, .

DANGER

Failure to comply with the precautions and instructions provided with this fire pit can result in death serious, bodily injury and property loss or damage from hazards of fire explosion burn asphyxiation and or,,, ,/ carbon monoxide poisoning Only persons who can. understand and follow the instructions should use or service this fire pit.

FOR YOUR SAFETY If you smell gas: 1 Shut off gas to the appliance.. 2 Extinguish any open flame.. 3 If odor continues keep away from the appliance and., immediately call you gas supplier or fire department.

Solid fuels shall not be burned in this appliance.

in conjunction with the labeling on the

or propane fueled equipment

servicing Using this.

personal injury or

this manual.

equipment.

DANGER

SAFETY INFORMATION

DANGER

· EXPLOSION - FIRE HAZARD

· Keep solid combustibles, such as building materials,

paper or cardboard, a safe distance away from the fire pit as recommended by the instructions.

· Provide adequate clearances around air openings into the combustion chamber.

· Never use the fire pit in spaces which do or may contain volatile or airborne combustibles, or products such as gasoline, solvents, paint thinner, dust particles or unknown chemicals.

· During operation, this product can be a source of ignition. Keep fire pit area clear and free from combustible materials, gasoline, paint thinner, cleaning solvents and other flammable vapors and liquids. Do not use fire pit in areas with high dust content. Minimum fire pit clearances from combustible materials: two (2) feet from the sides & two (2) feet from the rear, 6 feet from ceiling.

DANGER

· EXPLOSION - FIRE HAZARD

· Never store propane near high heat, open flames,

pilot lights, direct sunlight, other ignition sources or where temperatures exceed 120 degrees F (49° ).

· Propane vapors are heavier than air and can accumulate in low places. If you smell gas, leave the area immediately.

· Never install or remove propane cylinder while fire pit is lighted, near flame, pilot lights, other ignition sources or while fire pit is hot to touch.

· This fire pit is red hot during use and can ignite flammables too close to the burner. Keep flammables at least 2 feet from sides & 2 feet from rear, 6 feet from ceiling. Keep gasoline and other flammable liquids and vapors well away from fire pit.

· Store the propane cylinder outdoors in a well ventilated space out of reach of children. Never store the propane cylinder in an enclosed area (house, garage, etc.). If fire pit is to be stored indoors, disconnect the propane cylinder for outdoor storage.

WARNING

We cannot foresee every use which may be made of our fire pit. Check with your local fire safety authority if you have questions about fire pit use. Other standards govern the use of fuel gases and heat producing products for specific uses. Your local authorities can advise you about these. If no local codes exist, follow National Fuel Gas Code, ANSI Z223.1. In Canada, installation must conform to local codes. If no local codes exist, follow the current National standards of CANADA CAN/CGA-B 149.2.

DANGER

· CARBON MONOXIDE HAZARD

· This fire pit is a combustion appliance. All combustion

appliances produce carbon monoxide (CO) during the combustion process. This product is designed to produce extremely minute, non-hazardous amounts of CO if used and maintained in accordance with all warnings and instructions. Do not block air flow into or out of the fire pit.

· Carbon Monoxide (CO) poisoning produces flu-like symptoms, watery eyes, headaches, dizziness, fatigue and possibly death. You can't see it and you can't smell it. It's an invisible killer. If these symptoms are present during operation of this product get fresh air immediately!

· For outdoor use only.

· Never use inside house, or other unventilated or

enclosed areas.

· This fire pit consumes air (oxygen). Do not use in unventilated or enclosed areas to avoid endangering your life.

WARNING

WARNING indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.

WARNING

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. An LP-cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

WARNING: For Outdoor Use Only

DANGER

CARBON MONOXIDE HAZARD This appliance can produce carbon monoxide which has no odor. Using it in an enclosed space can kill you. Never use this appliance in an enclosed space such as a camper, tent or home.

WARNING

Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death. Read the installation, operation and maintenance instructions thoroughly before installing or servicing this equipment.

SAFETY INFORMATION

WARNING

California Proposition 65 Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm.

WARNING

BURN HAZARD

· Never leave fire pit unattended when hot or in use.

· Keep out of reach of children.

WARNING

Certain materials or items, when stored under the fire pit, will be subjected to radiant heat and could be seriously damaged.

CAUTION

SERVICE SAFETY

· Keep all connections and fittings clean. Make sure propane cylinder valve outlet is clean.

· During set up, check all connections and fittings for leaks using soapy water. Never use a flame.

· Use as a heating appliance only. Never alter in any way or use with any device.

CAUTION

CAUTION indicates an imminently hazardous situation which, if not avoided, may result in minor or moderate personal injury, or property damage.

WARNING

· This product is fueled by propane gas. Propane gas is invisible, odorless, and flammable. An odorant is normally added to help detect leaks and can be described as a rotten egg”smell. The odorant can" fade over time so leaking gas is not always detectable by smell alone.

· Propane gas is heavier than air and leaking propane will sink to the lowest level possible. It can ignite by ignition sources including matches, lighters, sparks or open flames of any kind many feet away from the original leak. Use only propane gas set up for vapor withdrawal.

· Store or use propane gas in compliance with local ordinances and codes or with ANSI/NFPA 58. Turn off propane when not in use.

WARNING

· Alert children and adults to the hazards of high surface temperatures. Stay away from these surfaces to avoid burning skin or igniting clothing.

· Carefully supervise young children when in the vicinity of the fire pit.

· Do not hang clothing or any other flammable materials from the fire pit, or place on or near the fire pit.

· Replace any guard or protective device removed for servicing the appliance prior to placing back in service.

· Installation and repair should be done by a qualified service person. The fire pit should be inspected before use and annually by a qualified service person. More frequent cleaning may be required as necessary. It is imperative that the control compartment, burners, and circulating air passageway of the appliance be kept clean.

OPERATION CHECKLIST

Operation Checklist

For a safe and pleasurable heating experience, perform this check before each use.

Before Operating:

1. I am familiar with entire owner’s manual and understand all precautions noted.

2. All components are properly assembled, intact and operable.

3. No alterations have been made.

4. All gas connections are secure and do not leak.

5. Wind velocity is below 10 mph.

6. Unit will operate at reduced efficiency below 40 F

7. Fire pit is outdoors (outside any enclosure).

8. There is adequate fresh air ventilation.Do not use this appliance if any part has been under water. Immediately call a qualified service technician to inspect the appliance and to replace any part of the control system and gas control which has been under water.

9. Fire pit is away from gasoline or other flammable liquids or vapors.

10. Fire pit is away from windows, air intake openings, sprinklers and other water sources.

11. Fire pit is at least 24 in. on rear and at least 24 in. on sides from combustible materials.

12. Fire pit is on a hard and level surface.

13. There are no signs of spider or insect nests.

14. All burner passages are clear.

15. All air circulation passages are clear.

16. Children and adults should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or clothing ignition.

17. Young children should be carefully supervised when they are in the area of the fire pit.

18. Clothing or other protective material should not be hung from the fire pit, or placed on or near the fire pit.

19. Any guard or other protective device removed for servicing the fire pit must be replaced prior to operating the fire pit.

20. Installation and repair should be done by a qualified service person. The fire pit should be inspected before use and at least annually by a qualified service person.

21. More frequent cleaning may be required as necessary. It is imperative that control compartment, burner and circulating air passageways of the fire pit be kept clean.

After Operation

1. Gas control is in OFF position.

2. Gas Tank valve is OFF.

3. Disconnect Gas line.

4. After each use, replace cap on tank.

/4.44°C

PREPARATION

Before beginning assembly of product, make sure all parts are present. Compare parts with package contents list and hardware contents above. If any part is missing or damaged, do not attempt to assemble the product. Contact customer service for replacement parts.

Estimated Assembly Time: 60 minutes

Tools Required for Assembly(not included) : Leak Detection Solution.

+ 11 hidden pages