SAFETY DATA SHEET
1. Identification
Product identifier Hercules MegaBubble
Other means of identification
Product code
Synonyms
Recommended use
Recommended restrictions
Manufacturer/Importer/Supplier/Distributor information
Company Name
Address
Telephone
E-mail
Transport Emergency
Emergency First Aid
Contact person
2. Hazard(s) identification
Physical hazards
7322E
Part Numbers: 45801, 45802, 45803, 45804
Leak Detector
None known.
HCC Holdings, Inc. an Oatey Affiliate
4700 West 160th Street
Cleveland, OH 44135
216-267-7100
info@oatey.com
Chemtrec 1-800-424-9300 (Outside the US 1-703-527-3887)
1-877-740-5015
MSDS Coordinator
Not classified.
Health hazards
Environmental hazards
OSHA defined hazards
Label elements
Hazard symbol
Signal word
Hazard statement
Precautionary statement
Prevention
Response
Storage
Disposal
Hazard(s) not otherwise
classified (HNOC)
Not classified.
hazard
Not classified.
None.
None.
The mixture does not meet the criteria for classification.
Observe good industrial hygiene practices.
Wash hands after handling.
Store away from incompatible materials.
Dispose of waste and residues in accordance with local authority requirements.
None known.
3. Composition/information on ingredients
Mixtures
Not applicableHazardous to the aquatic environment, acute
CAS number %Chemical name
57-55-6 30-60Propylene glycol
7732-18-5 30-60Water
56-81-5 10-30Glycerol
*Designates that a specific chemical identity and/or percentage of composition has been withheld as a trade secret.
4. First-aid measures
Inhalation
Skin contact
Hercules MegaBubble SDS US
924586 Version #: 01 Revision date: - Issue date: 05-February-2015
If breathing is difficult, remove to fresh air and keep at rest in a position comfortable for breathing.
Call a physician if symptoms develop or persist.
Rinse skin with water/shower. Get medical attention if irritation develops and persists.
1 / 6
Eye contact
Ingestion
Most important
symptoms/effects, acute and
delayed
Indication of immediate
medical attention and special
treatment needed
General information
5. Fire-fighting measures
Suitable extinguishing media
Unsuitable extinguishing
media
Specific hazards arising from
the chemical
Special protective equipment
and precautions for firefighters
Fire fighting
equipment/instructions
Specific methods
General fire hazards
Rinse with water. Get medical attention if irritation develops and persists.
Rinse mouth. If ingestion of a large amount does occur, call a poison control center immediately.
Direct contact with eyes may cause temporary irritation.
Treat symptomatically.
Ensure that medical personnel are aware of the material(s) involved, and take precautions to
protect themselves.
Alcohol resistant foam. Water fog. Dry chemical powder. Carbon dioxide (CO2).
Do not use water jet as an extinguisher, as this will spread the fire.
During fire, gases hazardous to health may be formed.
Self-contained breathing apparatus and full protective clothing must be worn in case of fire.
Move containers from fire area if you can do so without risk.
Use standard firefighting procedures and consider the hazards of other involved materials.
No unusual fire or explosion hazards noted.
6. Accidental release measures
Personal precautions,
protective equipment and
emergency procedures
Methods and materials for
containment and cleaning up
Environmental precautions
Keep unnecessary personnel away. For personal protection, see section 8 of the SDS.
Large Spills: Stop the flow of material, if this is without risk. Use water spray to reduce vapors or
divert vapor cloud drift. Dike the spilled material, where this is possible. Cover with plastic sheet to
prevent spreading. Absorb in vermiculite, dry sand or earth and place into containers. Following
product recovery, flush area with water.
Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to
remove residual contamination.
Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS.
Avoid discharge into drains, water courses or onto the ground.
7. Handling and storage
Precautions for safe handling
Conditions for safe storage,
including any incompatibilities
Avoid prolonged exposure. Observe good industrial hygiene practices.
Store in original tightly closed container. Store away from incompatible materials (see Section 10
of the SDS).
8. Exposure controls/personal protection
Occupational exposure limits
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000)
Components
US. Workplace Environmental Exposure Level (WEEL) Guides
Type
PEL 5 mg/m3 Respirable fraction.Glycerol (CAS 56-81-5)
Value
15 mg/m3 Total dust.
Form
Components
57-55-6)
Biological limit values
Hercules MegaBubble SDS US
924586 Version #: 01 Revision date: - Issue date: 05-February-2015
No biological exposure limits noted for the ingredient(s).
Type
TWA 10 mg/m3 Aerosol.Propylene glycol (CAS
Value
Form
2 / 6
Appropriate engineering
controls
Individual protection measures, such as personal protective equipment
Eye/face protection
Skin protection
Hand protection
Other
Respiratory protection
Thermal hazards
General hygiene
considerations
Good general ventilation (typically 10 air changes per hour) should be used. Ventilation rates
should be matched to conditions. If applicable, use process enclosures, local exhaust ventilation,
or other engineering controls to maintain airborne levels below recommended exposure limits. If
exposure limits have not been established, maintain airborne levels to an acceptable level.
Wear safety glasses with side shields (or goggles).
Wear appropriate chemical resistant gloves.
Wear suitable protective clothing.
In case of insufficient ventilation, wear suitable respiratory equipment.
Wear appropriate thermal protective clothing, when necessary.
Always observe good personal hygiene measures, such as washing after handling the material
and before eating, drinking, and/or smoking. Routinely wash work clothing and protective
equipment to remove contaminants.
9. Physical and chemical properties
Appearance
Physical state
Form
Color
Odor
Odor threshold
pH
Melting point/freezing point
Initial boiling point and boiling
range
Flash point
Evaporation rate
Flammability (solid, gas)
Upper/lower flammability or explosive limits
Flammability limit - lower
(%)
Flammability limit - upper
(%)
Explosive limit - lower (%)
Explosive limit - upper (%)
Vapor pressure
Vapor density
Relative density
Solubility(ies)
Solubility (water)
Partition coefficient
(n-octanol/water)
Auto-ignition temperature
Decomposition temperature
Viscosity
Other information
VOC (Weight %)
Liquid.
Liquid.
Blue.
Odorless.
Not available.
7.2
Not available.
212 °F (100 °C)
> 212.0 °F (> 100.0 °C)
Not available.
Not available.
Not available.
Not available.
Not available.
Not available.
Not available.
Not available.
1.05
Not available.
Not available.
Not available.
Not available.
100 cP
435 g/l
10. Stability and reactivity
Reactivity
Chemical stability
Possibility of hazardous
reactions
Hercules MegaBubble SDS US
924586 Version #: 01 Revision date: - Issue date: 05-February-2015
The product is stable and non-reactive under normal conditions of use, storage and transport.
Material is stable under normal conditions.
No dangerous reaction known under conditions of normal use.
3 / 6
Conditions to avoid
t
y
y
Incompatible materials
Hazardous decomposition
products
Contact with incompatible materials.
Strong oxidizing agents.
No hazardous decomposition products are known.
11. Toxicological information
Information on likely routes of exposure
Inhalation
Skin contact
Eye contac
Ingestion
Symptoms related to the
physical, chemical and
toxicological characteristics
Information on toxicological effects
Acute toxicit
Glycerol (CAS 56-81-5)
Acute
Oral
LD50 Rat
Propylene glycol (CAS 57-55-6)
Acute
Oral
LD50 Rat
Prolonged inhalation may be harmful.
No adverse effects due to skin contact are expected.
Direct contact with eyes may cause temporary irritation.
Expected to be a low ingestion hazard.
Direct contact with eyes may cause temporary irritation.
Test ResultsComponents Species
12600 mg/kg
30 g/kg
* Estimates for product may be based on additional component data not shown.
Skin corrosion/irritation
Serious eye damage/eye
irritation
Respiratory or skin sensitization
Respiratory sensitization
Skin sensitization
Germ cell mutagenicity
Carcinogenicit
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
Not listed.
Reproductive toxicity
Specific target organ toxicity -
single exposure
Specific target organ toxicity -
repeated exposure
Aspiration hazard
Chronic effects
Further information
Prolonged skin contact may cause temporary irritation.
Direct contact with eyes may cause temporary irritation.
Not a respiratory sensitizer.
This product is not expected to cause skin sensitization.
No data available to indicate product or any components present at greater than 0.1% are
mutagenic or genotoxic.
This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA.
This product is not expected to cause reproductive or developmental effects.
Not classified.
Not classified.
Not an aspiration hazard.
Prolonged inhalation may be harmful.
This product has no known adverse effect on human health.
12. Ecological information
Ecotoxicity
The product is not classified as environmentally hazardous. However, this does not exclude the
possibility that large or frequent spills can have a harmful or damaging effect on the environment.
Hercules MegaBubble SDS US
924586 Version #: 01 Revision date: - Issue date: 05-February-2015
4 / 6
Components Test ResultsSpecies
Propylene glycol (CAS 57-55-6)
Aquatic
LC50Crustacea 18340 mg/l, 48 hoursCeriodaphnia dubia
LC50Fish 46500 mg/l, 96 hoursPimephales promelas
* Estimates for product may be based on additional component data not shown.
Persistence and degradability
Bioaccumulative potential
Partition coefficient n-octanol / water (log Kow)
Glycerol (CAS 56-81-5) -1.76
Propylene glycol (CAS 57-55-6) -0.92
Mobility in soil
Other adverse effects
No data is available on the degradability of this product.
No data available.
No other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation
potential, endocrine disruption, global warming potential) are expected from this component.
13. Disposal considerations
Disposal instructions
Local disposal regulations
Hazardous waste code
Waste from residues / unused
products
Contaminated packaging
Collect and reclaim or dispose in sealed containers at licensed waste disposal site.
Dispose in accordance with all applicable regulations.
The waste code should be assigned in discussion between the user, the producer and the waste
disposal company.
Dispose of in accordance with local regulations. Empty containers or liners may retain some
product residues. This material and its container must be disposed of in a safe manner (see:
Disposal instructions).
Empty containers should be taken to an approved waste handling site for recycling or disposal.
Since emptied containers may retain product residue, follow label warnings even after container is
emptied.
14. Transport information
DOT
Not regulated as dangerous goods.
IATA
Not regulated as dangerous goods.
IMDG
Not regulated as dangerous goods.
Transport in bulk according to
Annex II of MARPOL 73/78 and
the IBC Code
Not established.
15. Regulatory information
US federal regulations
TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)
Not regulated.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
Not listed.
CERCLA Hazardous Substance List (40 CFR 302.4)
Not listed.
Superfund Amendments and Reauthorization Act of 1986 (SARA)
Hazard categories
SARA 302 Extremely hazardous substance
Not listed.
This product is not known to be a "Hazardous Chemical" as defined by the OSHA Hazard
Communication Standard, 29 CFR 1910.1200.
All components are on the U.S. EPA TSCA Inventory List.
Immediate Hazard - No
Delayed Hazard - No
Fire Hazard - No
Pressure Hazard - No
Reactivity Hazard - No
Hercules MegaBubble SDS US
924586 Version #: 01 Revision date: - Issue date: 05-February-2015
5 / 6
SARA 311/312 Hazardous
A
No
chemical
SARA 313 (TRI reporting)
Not regulated.
Other federal regulations
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List
Not regulated.
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)
Not regulated.
Safe Drinking Water Act
Not regulated.
(SDWA)
US state regulations
US. Massachusetts RTK - Substance List
Glycerol (CAS 56-81-5)
US. New Jersey Worker and Community Right-to-Know Act
Glycerol (CAS 56-81-5)
Propylene glycol (CAS 57-55-6)
US. Pennsylvania Worker and Community Right-to-Know Law
Glycerol (CAS 56-81-5)
Propylene glycol (CAS 57-55-6)
US. Rhode Island RTK
Not regulated.
US. California Proposition 65
California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65): This material is not known to contain
any chemicals currently listed as carcinogens or reproductive toxins.
International Inventories
Country(s) or region Inventory name On inventory (yes/no)*
Australian Inventory of Chemical Substances (AICS) YesAustralia
Domestic Substances List (DSL) YesCanada
Inventory of Existing Chemical Substances in China (IECSC) YesChina
European Inventory of Existing Commercial Chemical
Substances (EINECS)
Inventory of Existing and New Chemical Substances (ENCS) NoJapan
New Zealand Inventory YesNew Zealand
Philippine Inventory of Chemicals and Chemical Substances
(PICCS)
Toxic Substances Control Act (TSCA) Inventory YesUnited States & Puerto Rico
*A "Yes" indicates this product complies with the inventory requirements administered by the governing country(s).
"No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing
country(s).
YesEurope
YesPhilippines
16. Other information, including date of preparation or last revision
Issue date
Revision date
Version #
HMIS® ratings
Disclaimer
Hercules MegaBubble SDS US
924586 Version #: 01 Revision date: - Issue date: 05-February-2015
05-February-2015
01
Health: 0
Flammability: 0
Physical hazard: 0
HCC Holdings Inc. an Oatey Affiliate cannot anticipate all conditions under which this information
and its product, or the products of other manufacturers in combination with its product, may be
used. It is the user’s responsibility to ensure safe conditions for handling, storage and disposal of
the product, and to assume liability for loss, injury, damage or expense due to improper use. The
information in the sheet was written based on the best knowledge and experience currently
available.
6 / 6
Loading...