HEATSTRIP TGH34WN Operation, Installation, And Maintenance Manual
Manual # P80196006A - Date:2017/03/22
DANGER
!
!
1.
2.
3.
If you smell gas:
Shut off gas to the appliance.
Extinguish any open flame.
If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
WARNING
!
!
Improper Installation, adjustment,
alteration, service, or maintenance can
cause property damage, injury or death.
Read this operating and assembly
instruction thoroughly before installing
or serving this heater.
WARNING
!
!
FOR OUTDOOR AND NON-RESIDENTIAL INDOOR
USE ONLY.
THIS APPLIANCE MUST NOT BE INSTALLED OR
USED IN RESIDENTIAL DOMESTIC INDOORS.
Appliance is to be protected from rain.
TO BE INSTALLED ONLY BY AN AUTHORIZED
PERSON.
OPERATION, INSTALLATION AND MAINTENANCE MANUAL
Wall Mounted Radiant Gas Heater
TGH34WN (Natural Gas)
Do not store or use flammable liquids or vapors in the
vicinity of this appliance.
DANGER
! !
Table of Contents
Primary Safety Warnings.................................................................................................................3-5
Product Preview....................................................................................................................................6
Part Diagrams and Lists..............................................................................................................7-9
Installation Instructions..........................................................................................................................10
Use and Care Instruction.....................................................................................................................11
Lighting Instruction.................................................................................................................................12
Troubleshooting.....................................................................................................................................13
Cleaning and Maintenance..............................................................................................................13
Warranty Terms....................................................................................................................Back Cover
Important: Use only Thermofilm replacement parts. The use of any part that is not a Thermofilm replacement part
can be dangerous and void your product warranty. Keep this Instruction Manual for convenient referral and for part
replacement.
You need to contact Thermofilm Australia Pty Ltd
17 Johnston Court, Dandenong South, Victoria 3175, Australia
Telephone: (03) 9562 3455
8:30am-5:00pm Mon-Fri (EST)
Email: info@thermofilm.com.au
To obtain the correct replacement parts for your gas radiant heater, please refer to the part numbers in this parts
list. The following information is required to ensure you receive the correct parts:
1. Model and Serial Number (see label on the heater)
2. Part Number
3. Part Description
4. Quantity of parts needed
For the repair or replacement parts
2
1. This appliance must be used only for outdoor and
non-residential indoor use. This appliance must not be
installed or used in residential indoor areas.This appliance
shall only be used in an above ground open-air situation
with natural ventilation, without stagnant areas, where gas
leakage and products of combustion are rapidly dispersed
by wind and natural convection.
2. Any guard or other protective device removed for
servicing (conducted by an authorized person) must
be replaced before operating the heater.
3. Children and adults should be alerted to the
hazards of high surface temperatures and should
stay away to avoid burns or clothing ignition.
4. Children should be carefully supervised when they
are in the area of the heater.
5. Clothing or other flammable materials should not
be hung from the heater or placed on or near the
heater.
6. Do not perform maintenance until heater has been
turned off, and heater has cooled to room temperature.
7. Do not expose the burner to water or moisture. The
appliance must be protected from rain.
8. Do not use the heater if any of these parts are
exposed to water until the appliance is inspected or
repaired by an authorized service person.
9. The installer is to ensure that the requirements of
the local authority, local gas fitting regulations,
municipal building codes, and any other relevant
statutory regulations are carried out.
10. Certain materials or items, when stored under or
near the appliance, will be subjected to radiant heat
and could be seriously damaged.
11. All leak tests should be done with a soap
solution. Never use an open flame to check for leaks.
12. Do not use the heater until all visible gas
connections have been leak tested.Never test for
leaks with an open flame. Prior to first use, at the
beginning of each season.
13. The radiant heater is NOT intended to be
installed on recreational vehicles or boats.
14. Do not attempt to alter the unit in any manner.
15. Do not paint any surface of the heater or reflector.
WARNING
!!
16. Burner and circulation air passageways of the
heater must be kept clean. Frequent cleaning may be
required as necessary.
17. Check the heater immediately if any of the
following occurs:
- The heater does not reach temperature.
- The burner makes popping noise during use (a slight
noise is normal when the burner is ignited or
extinguished).
18. This appliance is not intended for use by young
or infirm person unless they have been adequately
supervised by a responsible person to ensure that
they can use the appliance safely.
19. Check for damage to the appliance regularly. If
damage to the appliance is suspected, discontinue
use immediately and contact the supplier or qualified
person for repair.
20. Avoid inhaling fumes emitted from the heater's
first use. Smoke and odour from the burning of oils
used in manufacturing will appear. Both the smoke
and odour will dissipate after approximately 30
minutes.
WARNING
!!
3
Grill Information Center:
FREE HELP
Thermofilm Australia Pty Ltd is the expert on
this product and trained to help you with:
17 Johnston Court, Dandenong South,
Victoria 3175, Australia
Telephone: (03) 9562 3455
8:30am-5:00pm Mon-Fri EST
Email: info@thermofilm.com.au
Assembly Questions
Heater Operation
Replacement of Damaged or Missing parts
Ÿ
Ÿ
Ÿ
Ÿ
Ÿ
Ÿ
IMPORTANT
!
READ THIS MANUAL CAREFULLY before
installing or operating this product.
Installation must be carried out by Authorized
person in accordance with AS/NZS 5601.1:2013
(or latest edition) Gas Installation Code.
Failure to comply with these instructions could
result in a fire or explosion that could cause
serious bodily injury, death or property damage.
!
APPENDIX
OUTDOOR AREAS SAFTY APPLIANCE LOCATIONS
4
This appliance is for outdoor and non-residential indoor use only.
This appliance must not be installed or used in residential indoor areas.
This appliance shall only be used in an above ground open-air situation with natural ventilation, without stagnant areas,
where gas leakage and products of combustion are rapidly dispersed by wind and natural convection.
Any enclosure in which the appliance is used shall comply with one of the following:
1. An enclosure with walls on all sides, but at least one permanent opening at ground level.
2. Within a partial enclosure that includes an overhead cover and no more than two walls.
3. Within a partial enclosure that includes an overhead cover and more that two walls, the following shall apply:
- At least 25% of the total wall area is completely open.
- At least 30% of the remaining wall area is open and unrestricted.
- In the case of balconies, at least 20% of the total wall area shall be and remain open and unrestricted.
The following diagrams are examples of outdoor areas.
These same principles apply to any other shaped area.
c
LPG CYLINDER USE AND SAFETY
FOR YOUR SAFTY
Ÿ
Ÿ
5
HOSE AND REGULATOR SAFETY
The regulator and hose assembly supplied
with the heater are suitable for natural gas.
Inspect the gas hose before each use and
when replacing the gas cylinder. If the hose
is cracked, cut, abraded or damaged in any
way, the heater must not be operated. The
hose must be replaced if damaged or when
statutory conditions require it. Contact your
place of purchase if uncertain.
DO NOT PLACE ARTICLES ON OR AGAINST THIS
APPLIANCE.
DO NOT USE OR STORE FLAMMABLE
MATERIALS NEAR THIS APPLIANCE.
DO NOT SPRAY AEROSOLS OR FLAMMABLE
MATERIALS IN THE VICINITY OF THIS APPLIANCE
WHILE IS IN OPERATION.
IMPORTANT
! !
NEVER OPERATE THE HEATER WITHOUT
A REGULATOR.
DO NOT ATTEMPT TO CONVERT THE LPG
HEATER FOR NATURAL GAS USE.
INDIVIDUAL GAS TYPES ARE FACTORY
MADE.
DO NOT BYPASS THE SAFETY DEVICES.
FAILURE TO COMPLY WITH THESE
INSTRUCTIONS COULD RESULT IN A FIRE
OR EXPLOSION WHICH COULD CAUSE
SERIOUS BODILY INJURY, DEATH ,OR
PERPERTY DAMAGE.
DANGER
! !
Ÿ
Ÿ
Ÿ
Ÿ
Loading...