Heat-N-Glo GRL-850-AU Installation And Operation Instructions Manual

INSTALLATION AND OPERATION

INSTRUCTIONS

MODEL: GRL-850-AU

AUSTRALIAN GAS ASSOCIATION APPROVED

Approval Number 5837

THIS MANUAL MUST BE USED FOR INST ALLATION AND RET AINED

BY HOMEOWNER FOR OPERA TION AND MAINTENANCE.

HEA T-N-GLO, a brand of Hearth & Home T echnologies Inc.

20802 Kensington Boulevard, Lakeville, MN 55044, U.S.A. • [phone]

This product is covered by one or more of the following patents: (United States) 4,1 12,913; 4,408,594; 4,422,426; 4,424,792; 4,520,791; 4,793,322; 4,852,548; 4,875,464;
5,000,162; 5,016,609; 5,076,254 5,191,877; 5,218,953; 5,328,356; 5,429,495; 5,452,708; 5,542,407; 5,613,487; (Australia) 543790; 586383; (Canada) 1,123,296; 1,297,746;
2,195,264; (Mexico) 97-0457; (New Zealand) 200265; or other U.S. and foreign patents pending.

2011-900D 4/04

1

2

INSTALLATION AND OPERATION INSTRUCTIONS

PLEASE READ THIS MANUAL BEFORE INSTALLING

AND USING THIS APPLIANCE.

MODEL GRL-850-AU IS AUSTRALIAN
GAS ASSOCIATION APPROVED FOR
NATURAL GAS OR PROPANE AS A
DECORATIVE GAS LOG.

Refer to the appliance data plates for gas
consumptions and pressures.

Installation of this appliance should only be
carried out by an authorized person in ac­cordance with the manufacturer's instruc­tions. All relevant codes and regulations laid
down by the gas piping authorities, munici­pal building regulations, electrical wiring
regulations and the requirements of the AGA
Gas Installation Code must be observed.

This appliance and its components are
tested and safe when installed in accor­dance with this Installation Manual. Report
to your dealer any parts damaged in ship­ment. Read all instructions before starting
installation and follow these instructions
carefully during installation to ensure maxi­mum benefit and safety. Failure to follow

them will void your warranty and may present
a fire hazard.

The Heat-N-Glo, a brand of Hearth & Home
Technologies Inc. warranty will be voided by,
and Heat-N-Glo, a brand of Hearth & Home
Technologies Inc. disclaims any responsibil­ity for the following actions:

• Installation of any damaged heater.

• Modification of the heater installation
other than as instructed by Heat-N-Glo,
a brand of Hearth & Home Technologies
In

c.

• Improper positioning of the gas logs.

• Installation and/or use of any component
part not manufactured or approved by
Heat-N-Glo, a brand of Hearth & Home
Technologies Inc., not withstanding any
independent testing laboratory or other
party approval of such component part
or accessory.

IMPORTANT: Read all instructions carefully before starting installation.
Failure to follow these installation instructions may result in a possible fire
hazard and will void the warranty. Save this Manual for future reference.

Copyright 2004
Heat-N-Glo, a brand of Hearth & Home Technologies Inc.
20802 Kensington Boulevard, Lakeville, MN 55044, U.S.A.
Printed in U.S.A.

3

Table of Contents

1.0 INTRODUCTION .........................................................................................................5

2.0 ASSEMBLY .................................................................................................................5

GAS LINE CONNECTION .........................................................................................6

u

u

LOG PLACEMENT ................................................................................................... 7

3.0 OPERATING GUIDELINES AND MAINTENANCE INSTRUCTIONS .................10

SAFETY INFORMATION..........................................................................................11

LIGHTING INSTRUCTIONS .....................................................................................12

u

4.0 REPLACEMENT PARTS:.......................................................................................13

WARRANTY POLICY...............................................................................................15

u = Contains updated information.

4

DEPTH

WIDTH

TOP VIEW - FIREPLACE AREA

ASSEMBLY

REAR

SURROUND

SURROUND

SIDE

SURROUND

NOTE: Unit must

be 33mm back from

fireplace front.

BURNER

PIEZO

IGNITOR

DECORATIVE

FRONT

CONTROL

ACCESS

COVER

FRONT

PILOT

ON/OFF
SWITCH

TOP VIEW

GAS

VALVE

FIREPLACE OPENING

Minimum Maximum

WIDTH: 850mm 1050mm
DEPTH: 300mm 460mm
HEIGHT: 425mm 540mm

33mm

MINIMUM

u

FIGURE 1

300mm
DEPTH

5

1.0 INTRODUCTION

Model GRL-850-AU Gas Log Sets are Decorative Gas
Appliances for Installation in a Solid-Fuel Burning Fire­place. Minimum fireplace size for GRL-850-AU: height
425mm, width 850mm, depth 300mm.

This log set is to be installed only in a solid-fuel burn­ing fireplace with a working flue and one constructed of
noncombustible material or into an approved Jetmaster
gas firebox. The minimum permanent vent opening pro­vided by the fireplace chimney damper to vent the flue
products must not be less than 40,000mm2. The chim­ney damper MUST be fixed in a fully opened position
and the fireplace must have a proper draft.

WARNING: OPEN THE CHIMNEY DAMPER TO

!

ITS FULLY OPEN POSITION WHEN BURNING
THIS GAS LOG SET.

WARNING: LOGS MUST NEVER BE BURNED

!

WITHOUT THE FLUE DAMPER IN THE FULL
OPEN POSITION. FAILURE TO DO SO IS DAN­GEROUS TO YOUR HEALTH AND VOIDS ALL
WARRANTIES.

WARNING: ALL GAS APPLIANCES PRO-

!

DUCE SOME CARBON MONOXIDE WHEN
OPERATED. CARBON MONOXIDE IS A COLOR­LESS, ODORLESS, POISONOUS GAS. ADE­QUATE PROVISIONS MUST BE MADE TO PRO­VIDE COMBUSTION AIR FOR THIS GAS LOG SET.
IF OUTSIDE AIR IS NOT INCLUDED IN THE FIRE­PLACE, IT MAY BE NECESSARY THAT AN ADDI­TIONAL COMBUSTION AIR SOURCE BE PROVIDED.

CAUTION: DO NOT PLACE ARTICLES ON OR
AGAINST THIS APPLIANCE.

CAUTION: DO NOT USE OR STORE FLAMMABLE
MATERIALS NEAR THIS APPLIANCE.

CAUTION: DO NOT SPRAY AEROSOLS IN THE VI­CINITY OF THIS APPLIANCE WHILE IT IS IN OP­ERA TION.

WARNING: THIS UNIT IS NOT FOR USE

!

WITH SOLID FUEL. SOLID FUELS SHALL
NOT BE BURNED IN A FIREPLACE WHERE A
DECORA TIVE APPLIANCE IS INSTALLED.

TO REDUCE THE RISK OF FIRE OR INJURY FROM
BURNS AND FOR THE PROTECTION OF YOUNG
CHILDREN OR THE INFIRM, A SECONDARY GUARD
IS RECOMMENDED.

2.0 ASSEMBLY

CAUTION: WHEN INSTALLING THIS LOG SET IN
A FACTORY BUILT FIREPLACE, BE CERTAIN TO
CONSULT THE FIREPLACE INSTALLATION
MANUAL. ALL KNOCKOUTS IN THE FIREPLACE
THROUGH WHICH THE GAS SUPPL Y LINE IS RUN
MUST BE RESEALED WITH INSULATION AFTER
THE GAS LINE IS IN PLACE.

Model GRL-850-AU contains complete gas-burner,
decorative front, and log components needed. Use cau­tion when handling logs to avoid damage. Position gas­burner assembly to the rear of the fireplace. Once fully
assembled slide access door into place.

WARNING: LOGS OTHER THAN THOSE

!

SUPPLIED WITH THIS UNIT MUST NOT BE
USED.

CAUTION: To minimize the possibility of spillage and

to maximize proper draft, position the log set as close
to the back of the fireplace as possible.

The installation, including provisions for combustion and
ventilation air, must conform with the AGA Gas Instal­lation Code.

Do not use this appliance if any part has been under
water. Immediately call a qualified service technician
to inspect the unit and to replace any part of the control
system and any gas control which has been underwater.