Hayward SP1091LX, SP1091WM Owner's Manual
IS1091LX Rev E
p
DYNA-SKIM™ AUTOMATIC SKIMMER
Owner’s Manual
MODELS: SP1091LX and SP1091WM
Contents
Pool Preparation…………………...1
Installation……….……………..……1
Product Warnings………….………2
Installation of SP1023….…..……4
Winterizing……………………………4
Replacement Parts………..………4
Your new Hayward Thru-Wall Skimmer makes pool maintenance easier and more convenient. Leaves, insects and
floating debris are pulled from the pool into the skimmer basket. Clean the basket regularly to keep your pool
sparkling clean and sanitary.
POOL PREPARATION
Fill the pool with approximately two (2) feet of water so the liner is under weight and stretched to the proper position prior to installing the
skimmer. Note: The liner cannot be shifted after the skimmer and return holes have been cut.
1. If the SP1091E, Wide mouth extension, is not installed on the body, it must be assembled to the body prior to attempting to install
the skimmer in the pool.
2. To install the wide mouth extension, insert four (4) pan head screws 1” long through the lip of the extension and four (4) through
the throat of the skimmer. Place the gasket between the extension and the skimmer body. Firmly tighten the screws.
1. From the outside of the pool install the face-plate double gasket at skimmer cutout in the wall. Reach over the top rail of the pool
and carefully press the face-plate and liner against the gasket and skimmer cutout in the wall. Punch out the two top corner holes
using a blunt object. Insert two self-threading flat head screws (provided) into the top corner holes of the face-plate.
2. Carefully push the screws through the holes that have been pierced in the liner and through the double gasket. From the outside
of the pool, align the skimmer body with these screws. Lightly tighten the two screws.
3. Using a blunt object, pierce the remaining holes in the liner. Insert and lightly tighten the remaining flat head screws through the
face-plate, liner, gasket and into the corresponding holes on the skimmer. Firmly tighten all screws evenly, alternately left and
right, top and bottom.
4. Using the skimmer face plate as a guide, use a razor knife to trim only the liner, being careful not to the gasket, in the large
skimmer opening.
SKIMMER ASSEMBY
SKIMMER INSTALLATION
IMPORTANT SAFETY INSTRUCTIONS
Basic safety precautions should always be followed, including the following: Failure to follow instructions can cause
severe injury and/or death.
This is the safety-alert symbol. When you see this symbol on your equipment or in this manual, look for one of the
following signal words and be alert to the potential for personal injury.
WARNING warns about hazards that could cause serious personal injury, death or major property damage and if
ignored presents a potential hazard.
CAUTION warns about hazards that will or can cause minor or moderate personal injury and/or property damage
and if ignored presents a potential hazard. It can also make consumers aware of actions that are unpredictable and
unsafe.
The NOTICE label indicates s
ecial instructions that are important but not related to hazards.
Hayward Pool Products, 620 Division Street, Elizabeth, NJ 07207
Phone: (908) 355-7995
www.hayward.com
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 1
R
t
R
s
a
t
u
e
Wbeap
e
ngu
n
R
u
R
a
R
a
T
d
o
p
e
g
n
n
m
a
c
h
a
b
e
w
v
e
e
e
c
r
i
i
o
e
o
w
v
u
p
s
n
o
e
a
c
e
o
s
O
o
n
m
n
a
e
e
a
t
e
n
p
c
c
e
s
e
m
r
g
s
m
t
m
n
I
i
e
A
r
w
m
o
a
r
n
y
a
o
e
m
o
m
a
m
o
o
o
e
o
.
e
d
a
c
p
a
f
a
b
e
r
o
A
N
t
m
.
t
b
o
c
m
w
s
m
a
e
p
a
e
t
t
m
r
s
t
c
t
m
m
t
v
n
d
d
w
t
o
g
u
i
s
o
i
s
w
s
s
n
m
r
p
e
p
i
e
t
e
R
r
n
a
k
s
a
i
i
E
o
.
n
o
e
e
u
u
t
o
s
l
s
D
o
g
y
e
e
n
n
a
f
u
i
r
p
u
a
t
o
e
r
f
e
m
o
e
o
p
n
t
t
e
i
o
s
r
e
d
WA
NING
-
Re
follow ins
Suction in
severe inju
Hair Entra
Limb Entr
cracked, m
Body Suc
Eviscerati
sump or s
disembow
Mechanic
opening of
suction o
material c
replaced
being use
on this pro
positioned
WA
WAR
o
o D
o D
o N
o R
o I
o I
WA
WA
WA
CAU
ructions can
NING
– Suc
uction outlets
ry and/or deat
pment
- Hair c
pment
- A lim
issing, or not s
ion Entrapm
on/ Disembo
ction outlet co
lment.
l Entrapmen
a suction outl
NING
ual suction fitt
ual suction fitt
ever use Pool
- To R
hen outlets ar
installed. Su
art, as measu
place damag
addition two
idelines, follo
stallation of a
NING
–
Fail
tlets can resu
NING
–
Fail
n result in an
NING
–
t least every s
ION
as means of
uct. Closely
to prevent chil
Suc
–
Com
d and foll
ause severe i
tion Entrap
and/or suctio
due to the fol
n become ent
inserted into
ecurely attach
nt
- A negative
elment
er which is, d
- There is pot
t cover resulti
duce the ris
small enough
tion outlets in
ed from near
ngs shall be pl
ngs shall not b
r Spa if any su
d, broken, cra
r more suction
all National,
acuum releas
re to remove
lt in an increa
ure to keep su
increase pot
tion outlet co
even years or
onents such
access to the
upervise child
dren from usin
w all inst
jury and/or d
ent Hazard.
outlet covers
lowing entrap
ngled in sucti
an opening of
d can result in
pressure appli
- A n
gative pressu
maged, broke
ntial for jewelr
g in mechanic
k of Entrapm
to be blocked
the same plan
oint to near po
aced in such l
e located on s
tion outlet co
ked, missing,
outlets per pu
State, and Loc
or vent syste
pressure test
e potential f
ction outlet c
ntial for sucti
ponents hav
if found to be
as the filtrati
pool by young
en at all times
them as a m
uctions
eath.
hich are, da
ent hazards:
n outlet cover
suction outle
a mechanical
d to a large p
e applied dire
, cracked, mis
, swimsuit, ha
l entrapment.
in
ent Hazards:
by a person, a
e (i.e. floor or
int.
cations and di
ating areas or
ponent is da
r not securely
p installed in
l codes applic
, which reliev
plugs and/or
r suction entr
mponents cl
n entrapmen
a finite life,
damaged, bro
n system, pu
children. To
Components
ans of access
his owner’s m
aged, broken,
sump or sucti
ind or swellin
rtion of the bo
tly to the intes
sing, or unsec
ir decorations,
minimum of tw
all), must be i
stances to avo
on the backre
aged, broken,
attached sucti
accordance w
able.
s entrapping
lugs used in
pment as de
ar of debris,
as described
he cover/grat
ken, cracked,
ps and heate
educe risk of i
such as the filt
o the pool.
anual and on
cracked, missi
on outlet cove
of the limb.
dy or limbs ca
tines through
red can result
finger, toe or
o functioning
nstalled a mini
d “dual block
t for such seat
cracked, miss
n outlet comp
th latest ASM
uction, is reco
interization
cribed above
uch as leaves
above.
e should be i
missing, or n
r must be pos
jury, do not p
ration system,
the equipmen
ng, or unsecur
that is damag
result in an e
n unprotected
in evisceratio
nuckle to be c
uction outlets
mum of three
ge” by a user.
ng areas.
ng, or not sec
onents immed
, APSP Standa
mmended.
f the pool/sp
, dirt, hair, pa
spected freq
t securely att
itioned so as
rmit children t
pumps, and h
t. Failure to
d can cause
d, broken,
trapment.
suction outlet
/
ught in an
per pump mus
eet (3’) [1 met
rely attached.
ately.
ds and CPSC
a from the
er and other
ently and
ched.
o prevent the
use or climb
aters must be
r]
r
WAR
start up, n
follow safe
and clamp
pool and s
be in open
back to th
open filter
is dischar
WAR
of pump a
servicing p
circulation
circulation
circulatio
air can cau
high volu
NING
ty and operati
due to pressur
manual air reli
ed.
NING
ool and spa cir
se component
– Haz
rmal operatio
a water circul
position. Befo
pool. Do not
– Sep
d/or filter com
system if a sys
system unless
system at m
e blower when
ardous Pres
, and after pu
n instructions
in the system
tion system, a
re starting sys
hange filter co
f valve. Do no
aration Haza
ponents. Strai
culation syste
tem compone
filter manual a
re than 50 PS
to explode, w
air purging th
USE
ure.
Pool an
p shut off. St
could result in
, which could
ll system and
em pump, all s
ntrol valve pos
t close filter m
rd.
Failure to
ner cover must
, filters manu
t is not assem
ir relief valve b
. Do not purg
th risk of seve
pump, filter,
NLY HAYW
spa water circ
nd clear of cir
violent separa
ause property
ump controls
ystem valves
ition while sys
nual air relief
ollow safety a
be properly se
l air relief valv
led properly,
ody is in locke
the system
e injury or dea
r piping.
RD GENUI
ulation system
ulation syste
ion of the pum
damage, seve
ust be in off
ust be set in a
em pump is ru
alve until a st
d operation in
cured to pump
e must be in o
amaged, or m
position in fil
ith compress
h to anyone n
E REPLAC
s operate und
equipment d
p housing and
e personal inj
osition and fil
position to all
nning. Before
ady stream of
structions cou
housing with
en position.
ssing. Do not
ter upper body
ed air. Purgin
arby. Use onl
EMENT PA
r hazardous p
ring pump sta
cover, and/or
ry, or death. B
er manual air r
w system wat
tarting syste
water (not air
d result in viol
trainer cover l
o not operate
perate pool a
. Never opera
the system wi
a low pressur
TS
essure during
rt up. Failure t
ilter housing
efore servicing
elief valve mu
r to return
pump, fully
r air and wate
nt separation
ck ring. Befor
ool and spa
d spa
e or test the
th compresse
e (below 5 PSI)
2
t
)
Loading...