Hathaway EXCALIBUR Assembly Instructions Manual
EXCALIBUR 54-IN. FOOSBALL TABLE
ASSEMBLY INSTRUCTIONS
Please Do Not Hesitate to
Contact Our Consumer Hotline
at
800-759-0977
with Any Questions That May
Arise During Assembly or
Use of This Product!
Ver. 0518
NG5030
THANK YOU!
Thank you for purchasing this product. We work around the clock and around the globe to ensure
that our products maintain the highest possible quality. However, in the rare case of issues during
assembly or use of this product, please contact our Consumer Hotline at 800-759-0977 for immediate
assistance before contacting your retailer. Please read the warranty information at the back of these
assembly instructions for further details.
ASSEMBLY TIPS
IMPORTANT! PLEASE READ THESE ASSEMBLY INSTRUCTIONS
IN ENTIRETY BEFORE ASSEMBLING YOUR PRODUCT.
1. Find a clean, level surface to begin the assembly of your game table. We recommend that two adults
work together to assemble this game. You may want to carefully cut or tear the four corners of the box
so that the bottom of the box can be used as your work surface.
2. Remove all of the contents from box and verify that you have all of the parts shown on the Parts
List before you begin assembly. Note: Some parts may be pre-installed or pre-assembled.
3. Some figures or drawings may not look exactly like product.
4. When installing parts that have more than one screw or bolt, hand tighten all screws or bolts
in place before final tightening with screwdriver or wrench.
5. Electric screwdrivers may be helpful during assembly; however, please set a low torque and use
extreme caution because screws may be stripped or overtightened, resulting in damaged parts, if the
electric screwdriver’s torque is set too high.
WARNINGS!
READ AND FOLLOW ALL ASSEMBLY, OPERATION AND SAFETY INSTRUCTIONS CAREFULLY.
CHOKE HAZARD - THIS ITEM MAY CONTAIN SMALL BALLS AND PARTS
NOT SUITABLE FOR CHILDREN UNDER 3 YEARS OF AGE.
1. This product is intended for INDOOR use ONLY.
2. Do NOT sit on table, or drag table when moving, as this will damage the legs. Do NOT lift table by rods.
4. Keep table covered when not in use. Remove dust on play surface and cabinet with vacuum or wipe
with a clean, soft cloth.
5. Occasionally wipe the rods with a clean, soft cloth and make sure the players are tight.
6. Do NOT spin rods too aggressively, as this may cause damage. We recommend the use of 100%
silicon to periodically lubricate the bushings, but from the outside of the table so you don’t drip on playfield.
CARE AND USE
2
Parts List
EXCALIBUR 54-IN. FOOSBALL TABLE - NG5030
PARTS
P1 NGP7330
C8
P11
P3
P9
C9
C4
C5
C1
C2
C3
P1
P8
P14
P10
P2
P6
P12,P13
P4
P5
P2 NGP7331 NGP7332 NGP7333 NGP7334 NGP7335
P3 P4 P5 P6 P7
P7
Illustrations Not to Scale
NGP7336
X2
SIDE PANEL
P8 NGP7337 P9 P10 P11 P12 P13 NGP7342
X8
HANDLE
NGP7344
C1 C2 C3 C4 C5 C8
X2 X4 X2
5 PLAYER ROD
END PANEL CROSS BAR
NGP7338 NGP7339 NGP7340 NGP7341
ROD END CAP
NGP7345 NGP7346
3 PLAYER ROD 2 PLAYER ROD
X2
PLAYFIELD
X8
2-PIECE BALL
LAUNCHER
X1
X2
X2
SLIDE SCORER
NGP7347
RUBBER BUMPER
LEG
X4
LEG BOARD
SUPPORT BRACE
NGP7348
X16
PLASTIC ROD
WASHER
X2
X3
THREADED ROD
C9
X16
(26.5”)
NGP7349
NGP7350
black white
PLAYERS
X13
each
HARDWARE PACK - NGP7351
BOLT
X20
X8
5/16” x 1-1/2”
BOLT
X2 X8 X6
1/4” x 2-1/2”
BOLT
X2 X4 X6
3/8” WASHER
5/16” WASHER
For attaching
players
H1 H2 H3 H4 H5
5/16” x 2”
H8 H9 H10 H11 C6 C7 A2
X22
X26
each
H6
1/4” WASHER
X1
LEG LEVELER
P14 NGP7343
X3
CORNER
NGP5807
A1
SOCCER BALL
X8
H7
1-3/4” FLAT HEAD
SCREW
ADDITIONAL EQUIPMENT
X3
REQUIRED:
X4
X4
X2
X4
1” FLAT HEAD
SCREW
5/18
5/8” ROUND HEAD
SCREW
For replacement parts please call 800-759-0977.
1/2” ROUND HEAD
SCREW
1/4” X 1/2”
FLAT NUT
5/32” x 1” BOLT
& LOCK NUT
TOOLS
PHILLIPS HEAD
SCREWDRIVER
3
ASSEMBLY INSTRUCTIONS
1.
2.
NOTE: Screw, H10, is for
attaching Corners, P14
3.
IMPORTANT: Make sure to carefully
center playfield over two end panels
before attaching with screws, H8.
When attaching playfield make sure
screws are close to end panels and tilt
slightlyaway from playfield to they don’t
damage or enter into playing area.
4
ASSEMBLY INSTRUCTIONS (CONT.)
4.
5.
NOTE: Two adults are required to turn table upright. Turn over using main table body only, NOT legs,
and place on all four feet on ground at same time.
5
Loading...