Hatco FS2HAC-4PT Part Manual

®

FLAV-R-SAVOR

Heated Air Curtain Cabinets

FS2HAC Series

Installation and Operating Manual

I&W #07.05.205.00

Do not operate this equipment unless
you have read and understood the
contents of this manual! Failure to follow
the instructions contained in this manual
may result in serious injury or death.
This manual contains important safety
information concerning the
maintenance, use, and operation of this
product. If you’re unable to understand
the contents of this manual, please bring
it to the attention of your supervisor.
Keep this manual in a safe location for
future reference.

No opere este equipo al menos que haya
leído ycomprendido el contenido de este
manual! Cualquier falla en el
seguimiento de las instrucciones
contenidas en este manual puede
resultar en un serio lesión o muerte. Este
manual contiene importante información
sobre seguridad concerniente al
mantenimiento, uso y operación de este
producto. Si usted no puede entender el
contenido de este manual por favor
pregunte a su supervisor. Almacenar
este manual en una localización segura
para la referencia futura.

© 2008 Hatco Corporation

NOTICE

CAUTION

WARNING

CONTENTS

Important Owner Information...............................i

Introduction...........................................................i

Important Safety Information..............................1

Model Designation...............................................2

Model Description................................................2

All Models........................................................2

Specifications.......................................................3

Plug Configurations .........................................3

Electrical Rating Chart.....................................3

Dimensions......................................................4

Installation............................................................5

General............................................................5

Operation..............................................................6

Maintenance .........................................................8

Troubleshooting Guide........................................9

Accessories........................................................11

Hatco Limited Warranty.....................................13

Authorized Parts Distributors...........Back Cover

IMPORTANT OWNER INFORMATION

Record the model number, serial number (located
on the top of the unit), voltage, and purchase date of
your Flav-R-Savor®Heated Air Curtain Cabinet in
the spaces below. Please have this information
available when contacting Hatco for service
assistance.

Model No. ________________________________
Serial No. ________________________________
Voltage __________________________________
Date of Purchase __________________________

Business 8:00 a.m. to 5:00 p.m.
Hours: Central Standard Time

Telephone: [phone]
Fax: [phone] (Parts and Service)

Leg Assembly ..................................................5

General............................................................6

Serving Instructions.........................................7

General............................................................8

Cleaning...........................................................8

(Summer Hours: June to September –
8:00 a.m. to 5:00 p.m. C.S.T.
Monday through Thursday
8:00 a.m. to 2:30 p.m. C.S.T. Friday)

[phone] (International)

24 Hour 7 Day Parts and Service

Assistance available in the
United States and Canada
by calling [phone].

INTRODUCTION

The patented Hatco Flav-R-Savor Heated Air
Curtain Cabinets are designed to hold prepared
foods for prolonged periods of time while
maintaining that “just-made” quality. Warm air is
forced downward through ducts in front of the
cabinet opening, creating and maintaining ideal
holding temperatures without the use of doors. The
heated air is slowly drawn to the center and sides of
the cabinet, warming the food as it flows to the
perforations on the cabinet walls. The Heated Air
Curtain cabinet allows for immediate access to food
products and provides the best environment for
wrapped or unwrapped sheet pan foods.

Hatco Flav-R-Savor HeatedAir Curtain Cabinetsare
products of extensive research and field testing. The
materials used were selected for maximum
durability, attractive appearance, and optimum
performance. Every unit is inspected and tested
thoroughly prior to shipment.

Additional information can be found by visiting our
web site at www.hatcocorp.com.

This manual provides the installation, safety, and
operating instructions for Flav-R-Savor Heated Air
Curtain Cabinets. Hatco recommends all
installation, operating, and safety instructions
appearing in this manual be read prior to installation
or operation of a Heated Air Curtain Cabinet

Safety information that appears in this manual is
identified by the following signal word panels:

WARNING indicates a hazardous situation
which, if not avoided, could result in death or
serious injury.

CAUTION indicates a hazardous situation
which, if not avoided, could result in minor or
moderate injury.

NOTICE is used to address practices not related
to personal injury.

i

Form No. FS2HACM-0608

IMPORTANT SAFETY INFORMATION

WARNING

NOTICE

CAUTION

WARNING

Read the following important safety information before using this equipment to avoid
serious injury or death and to avoid damage to equipment or property.

ELECTRIC SHOCK HAZARD:

• Plug unit into a properly grounded electrical
outlet of the correct voltage, size, and plug
configuration. If the plug and receptacle do
not match, contact a qualified electrician to
determine and install the proper voltage and
size electrical outlet.

• Units supplied without an electrical plug
require field installation of the proper plug.
Plug must be properly grounded and of the
correct voltage, size, and configuration for
the electrical specifications of the unit.
Contact a qualified electrician to determine
and install the proper electrical plug.

• Turn the power switch OFF, unplug the power
cord, and allow the unit to cool before
performing any maintenance or cleaning.

• DO NOT submerge or saturate with water.
Unit is not waterproof. Do not operate if unit
has been submerged or saturated with water.

• Unit is not weatherproof. Locate the unit
indoors where the ambient air temperature is
a minimum of 70°F (21°C).

• This unit is not “jet-proof” construction. Do
not use jet-clean spray to clean this unit.

• Do not steam clean or use excessive water
on the unit.

• Do not pull unit by power cord.

• Discontinue use if power cord is frayed or
worn.

• Do not attempt to repair or replace a
damaged power cord. The cord must be
replaced by Hatco, an Authorized Hatco
Service Agent, or a person with similar
qualifications.

• Use only Genuine Hatco Replacement Parts
when service is required. Failure to use
Genuine Hatco Replacement Parts may
subject operators of the equipment to
hazardous electrical voltage, resulting in
electrical shock or burn. Genuine Hatco
Replacement Parts are specified to operate
safely in the environments in which they are
used. Some aftermarket or generic
replacement parts do not have the
characteristics that will allow them to operate
safely in Hatco equipment.

FIRE HAZARD: Locate the unit a minimum of 1″
(25 mm) from combustible walls and materials.
If safe distances are not maintained,
discoloration or combustion could occur.

This unit has no “user-serviceable” parts. If
service is required on this unit, contact an
Authorized Hatco Service Agent or contact the
Hatco Service Department at 800-558-0607 or
414-671-6350; fax [phone]; or International
fax [phone].

BURN HAZARD: Some exterior surfaces on the
unit will get hot. Use caution when touching
these areas.

Locate the unit at the proper counter height in
an area that is convenient for use. The location
should be level to prevent the unit or its
contents from falling accidentally and strong
enough to support the weight of the unit and its
contents.

The National Sanitation Foundation (NSF)
requires that units over 36″ (914 mm) in length
or weighing more than 80 lbs. (36 kg) either be
sealed to or raised above the installation
surface. If this unit cannot be sealed at the point
of use, 4″ (102 mm) legs are included to allow
for proper cleaning access below the unit.

Use non-abrasive cleaners only. Abrasive
cleaners could scratch the finish of your unit,
marring its appearance and making it
susceptible to soil accumulation.

Do not lay unit on the side with the control panel
or damage to the unit could occur.

Form No. FS2HACM-0608

1

MODEL DESIGNATION

F S 2 H A C - X P T

Flav-R-Savor

Style

Heated

Air

Curtain

Full-Size Pan Capacity

Pass-Through

MODEL DESCRIPTION

Figure 1. Model Designation

All Models

Flav-R-Savor HeatedAir Curtain Cabinets consist of
an easy to clean stainless steel front panel and
black powdercoat painted body. Features include
easy-to-use digital controls, a lighted ON/OFF
switch, a metal sheathed heating element, and a 6'
(1829 mm) power cord with plug (FS2HAC-4PT CE
export models come equipped with a 6' [1829 m]
power cord, but may not have a plug, depending on
the configuration). The temperature range of the
Flav-R-Savor Heated Air Curtain Cabinets is
80°-200°F (27°-93°C).

FS2HAC-2PT Model

The FS2HAC-2PT is a two-pan, pass-through style
unit that allows for food product access from either
side. The unit is capable of holding two full-size
sheet pans.

FS2HAC-4PT Model

The FS2HAC-4PT is a four-pan, pass-through style
unit that allows for food product access from either
side. The unit is capable of holding four full-size
sheet pans.

Figure 3. FS2HAC-4PT Model

Figure 2. FS2HAC-2PT Model

2

Form No. FS2HACM-0608

Plug Configurations

WARNING

NEMA L14-20P

CEE 7/7 Schuko BS-1363

NEMA 6-15P

NEMA 6-20P

Units are supplied from the factory with an electrical
cord and plug installed (plugs are supplied
according to the applications). Some export units
may require field installation of the proper plug.

ELECTRIC SHOCK HAZARD:

• Plug unit into a properly grounded electrical
outlet of the correct voltage, size, and plug
configuration. If the plug and receptacle do
not match, contact a qualified electrician to
determine and install the proper voltage and
size electrical outlet.

• Units supplied without an electrical plug
require field installation of the proper plug.
Plug must be properly grounded and of the
correct voltage, size, and configuration for
the electrical specifications of the unit.
Contact a qualified electrician to determine
and install the proper electrical plug.

SPECIFICATIONS

Figure 4. Plug Configurations

NOTE: Receptacle not supplied by Hatco.

Electrical Rating Chart

Model Voltage Hertz Watts Amps Plug Configuration Shipping Weight

FS2HAC-2PT 120/208 60 2978 12.4 NEMA L14-20P 165 lbs. (75 kg)

120/240 60 2978 12.4 NEMA L14-20P 165 lbs. (75 kg)

220 60 2924 13.3 NEMA6-15P 165 lbs. (75 kg)

240 60 2948 12.3 NEMA6-15P 165 lbs. (75 kg)
220-230 (CE) 50 2924–3196 13.3–13.9 CEE 7/7 Schuko 165 lbs. (75 kg)
230-240 (CE) 50 2708–2948 11.8–12.3 BS-1363 165 lbs. (75 kg)

FS2HAC-4PT 120/208 60 3378 14.1 NEMA L14-20P 190 lbs. (86 kg)

120/240 60 3378 14.1 NEMA L14-20P 190 lbs. (86 kg)

220 60 3324 15.1 NEMA6-20P 190 lbs. (86 kg)

240 60 3348 14.0 NEMA6-20P 190 lbs. (86 kg)
220-230 (CE) 50 3324–3632 15.1–15.8 CEE 7/7 Schuko 190 lbs. (86 kg)
230-240 (CE) 50 3076–3348 13.4–14.0 None 190 lbs. (86 kg)

The shaded areas contain electrical information for Export models only.

NOTE: Shipping weight includes packaging.

Form No. FS2HACM-0608

3