Harrington Hoists NER, ER user guide

OWNER'S MANUAL SUPPLEMENT CORRECTION

"Electric Chain Hoist ER and NER Series"

HOISTS AND CRANES

8 Ton through 20 Ton Capacities

Manual Effective: December 3, 1998

The following paragraphs and figures replace in their entirety the corresponding
paragraphs and figures in the 8 to 20 Ton "Electric Chain Hoist ER and NER Series"
Owner's Manual Supplement:

3.2.2 When the hoist is used without a chain container, the free end of the chain is attached to the hoist body
as shown in Figure 3-2. Connect the “no load” end of the chain to Chain Guide A with an End Wire and
the pre-installed socket bolt and lock nut. Make sure the chain remains free of twists and the chain
Stopper is installed on the correct link. Refer to Table 3-2 for proper placement of Stopper.

Figure 3-2 Chain Springs and Stoppers

6.4.2 Load Chain Replacement for ER080S and ER100L:

4) For hoists without a chain container, remove the socket bolt, lock nut and End Wire that attach the no-

load side of the chain to Chain Guide A.

10) Connect the end link of the new chain to the chain holder with the Chain Pin and Snap Ring. Ensure

that the chain remains free of twists. Attach the remaining chain components to the chain referring to

Section 3.2 for the proper locations. For hoists without a chain container, attach the no-load side of the

chain to Chain Guide A with the End Wire, socket bolt and lock nut. See Figure 3-2.

6.4.3 Load Chain Replacement for ER100S, ER150S and ER200S:

4) For hoists without chain containers, remove the socket bolts, lock nuts and End Wire that attach the

end links of the chain to Chain Guide A on both hoist bodies.

12) For hoists without a chain container, attach the ends of the chain to Chain Guide A on each body with

an End Wire, socket bolt and lock nut (see Figure 3-2). Ensure that all chain parts remain free of twists
and correct any if found.

GENERAL USE

EDOC0083

Page 1 of 2 Rev. 0 1/4/98

HOISTS AND CRANES

http://www.harringtonhoists.com

Harrington Hoists, Inc. Western Factory Warehouse
401 West End Avenue 2341 Pomona Rincon Rd. #103
Manheim, PA 17545 Corona, CA 91720
Phone: [phone] Phone: [phone]
Toll Free: 800-233-3010 Toll Free: 800-317-7111
Fax: [phone] Fax: [phone]

GENERAL USE

EDOC0083

Page 2 of 2 Rev. 0 1/4/98