Service Parts
PF100 Pellet
Pellet Furnace
Beginning Manufacturing Date: N/A
Ending Manufacturing Date: Active
1-70-08100
3
2
1
4
5
6
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or
distributor.
model number and serial number when requesting service parts from your dealer or distributor.
ITEM Description COMMENTS PART NUMBER
10 Shaker Cover 2-00-73335-15S
Additional service parts on following page.
Hearth and Home T echnologies does not sell directly to consumers. Provide
1 Hopper Assembly
Hopper Lid Assembly - Swell latch Pre 004350582 or 008350087 1-10-73333A
2
Hopper Lid Assembly - Spring Latch Post 004350582 or 008350087 1-10-73491A
Swell latch 1-00-199110
Spring Catch 3-31-00927
Hopper Muffl er and Fittings 1 set 1-00-18186618
Hopper Lid Catch 2-00-72166B
Hinge, Hopper Lid 3-31-73325
Gasket, Hopper Lid 10 Ft 1-00-00248
3 Fan Control / High limit 3-20-23139
4 Combustion Blower 3-21-08639
Mounting Plate 1-10-73416
Grommets & Spacers Pkg of 25 1-00-960026
Fan Blade, Feed Motor Pkg of 3 3-20-09302-3
Fan Blade, 5" Single Paddle (Combustion Blower) 3-20-40985
Fan Blade, 5" Double (high altitude) 3-20-502221
Comb Blower Mounting Screws Pkg of 100 1-00-53483208
Comb Blower Heat Shield 2-00-73339
5 Toggle Switch - 3 Speed 3-20-70020
6 Filter box kit 1-00-20201
7 Bottom Cover
8 Ash Door 1-10-73323-15A
9 Top Cover
Shaker Weldment 1-10-73354
Chain, Shaker Set of 8 1-00-003027
10
9
8
7
Pre 004350582 or 008350087 1-10-73329
Post 004350582 or 008350087 1-10-08224A
Front 2-00-73338-15S
Rear 2-00-73340-15S
Front 2-00-73411-15S
Rear 2-00-73412-15S
Stocked
at Depot
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
11/13
Service Parts
#11 Feeder Assembly Pre SN 004350582 or 008350087
11.3
11.4
11.5
PF100 Pellet
Beginning Manufacturing Date: N/A
Ending Manufacturing Date: Active
11.2
11.1
11.6
11.12
11.11
11.7
11.8
11.9
11.10
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or
distributor.
model number and serial number when requesting service parts from your dealer or distributor.
ITEM Description COMMENTS PART NUMBER
1 1 Feeder Assembly 1-10-081 13A
11.1 Air Intake Damper Assembly 1-10-06466W
11.2 Air Intake Weldment 1-10-773843
11.3 Feeder Weldment 1-10-677150 Y
11.4 Slide Plate Assembly 1-10-08037 Y
1 1.5 Pusher Arm Assembly 1-10-08048 Y
11.6 Feed Cover and Gasket 2 Sets 1-00-677152 Y
1 1.7 Auger Assembly 3-50-00465 Y
11.8 Cam Bearing 3-31-3014 Y
11.9 Bearing Flange w/Hardware 1-00-04035
11.10 Bracket, Gear Motor Pkg of 2 1-00-01534 Y
11.11 Gear Motor, 6 RPM 3-20-09302 Y
11.12 Cast Cam Block 3-00-00153 Y
Additional service parts on following page.
Hearth and Home T echnologies does not sell directly to consumers. Provide
Stocked
at Depot
Pillow Block Pkg of 4 3-31-3614087-4
Feeder Repair Kit 1-00-677150 Y
Gasket Feeder Air Intake Pkg of 6 3-44-72224-6
Motor Bracket Grommets Pkg of 12 3-31-2761-12
Y
Y
Y
#12 Post Feeder Assembly
SN #004350582 or 008350087
Service Parts
PF100 Pellet
Beginning Manufacturing Date: N/A
Ending Manufacturing Date: Active
12.1
12.16
12.2
12.3
12.4
12.5
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or
distributor.
model number and serial number when requesting service parts from your dealer or distributor.
ITEM Description COMMENTS PART NUMBER
12.1
12.2
12.3
12.4
12.5
12.6
12.7
12.8
12.9
12.10
12.11
12.12
12.13
12.14
12.15
12.16
Hearth and Home T echnologies does not sell directly to consumers. Provide
Pellet Feeder Gear Motor, 10 RPM 3-20-02524
UL Feeder Cam 3-31-3014
Feeder Air Crossover Kit 1-00-67900
9MM Silicone Tube 5 Ft 1-00-511427
Pellet Air Intake Assembly 1-10-06810A
Gasket Feeder Air Intake Pkg of 6 3-44-72224-6
UL Feeder Air Intake 1-10-72222
Gasket Ultra Air Intake Pkg of 10 3-44-677160-10
Ultra Feeder Weldment 1-10-72226S
UL Feeder Pusher Arm 1-10-677187W
Pillow Block Pkg of 4 3-31-3614087-4
Fines Defl ector
Gasket, UL Feeder Cover 1-00-677122
Slide Plate Assembly 1-10-677121A
UL Feeder Auger Assembly 3-50-00565
Bearing Flange w/Hardware 1-00-04035
UL Feeder Gear Motor Bracket w/Grommet 1-00-247406
UL Feeder Cam Block 3-00-677154
12.15
12.14
12.13
12.7
12.6
No longer available
12.12
12.10
12.9
12.8
2-00-677138-10
12.11
Stocked
at Depot
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Gasket, Hopper Throat
Additional service parts on following page.
Pre 004350582 or
008350087
3-44-677185 Y
Service Parts
Beginning Manufacturing Date: N/A
Ending Manufacturing Date: Active
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or
distributor.
model number and serial number when requesting service parts from your dealer or distributor.
ITEM Description COMMENTS PART NUMBER
Additional service parts on following page.
Hearth and Home T echnologies does not sell directly to consumers. Provide
A/C double Pole relay 3-20-38056
Arrow Burn Pot Scraper Pkg of 10 2-00-773850-10
Ash Door Ash Slide 2-00-73371B
Ash Pan 1-10-73351
Blower Air Jacket 2-00-73334B
Blower Box, Access Side 2-00-73423B
Blower Box, Cover 2-00-73429B
Blower Box, Top or Bottom 2-00-73424B
Brick Ledge 1-10-73347W
Fire Brick 12 x 6 x 1.25" 3-40-86125
Burn Pot Weldment 1-00-73560
Ceramic Insert Pkg of 10 3-20-05238-10
Clean Out Cover 2 Sets 1-00-06623
Igniter Cradle Assembly, 3 Sets Pre 004351831 1-00-06620
Thumb Screw Pkg of 10 3-31-782108-10
Gasket, Ceramic Insert Plate Post 008350087 3-44-724114
Gasket, Burn Pot
Flame Guide 3-00-08534
Flame guide insulator 3-44-35263
Cable 2 Pair twisted cat 3 (50’ for wall control) 3-20-02583
Circuit Board w/Knobs & Shafts 1-00-05888
Circuit Plate, studded w/label 1-10-07330
Control Knob/ Shaft 25 Sets 1-00-015605
Fuse, 6 AMP Pkg of 5 3-20-49447-5
Circuit breaker 10 Amp (orange - on/off switch) 3-20-334110
Circuit breaker harness - to control board
Conduit, 3/8" Flexible 7 Ft 1-00-25043
Control Cover, Painted 2-00-73362B
Diagnostic Display Module 3-20-05401
DDM Replacement Cable 1-00-05402
Differential Pressure Switch 3-20-6866
Disconnects, Male Pkg of 25 1-00-00957
Disconnects, Female Pkg of 25 1-00-00959
Distribution Blower mounting bracket Qty 2 req 2-00-73430B
Distribution Blower (motor only) 1000 cfm 3-20-36648
Pre 008350087 1-00-07381
Post 008350087 3-44-724115
Pre 008350087 3-20-04947
Post 008350087 3-20-73369
PF100 Pellet
Stocked
at Depot
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Service Parts
Beginning Manufacturing Date: N/A
Ending Manufacturing Date: Active
PF100 Pellet
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or
distributor.
model number and serial number when requesting service parts from your dealer or distributor.
Hearth and Home T echnologies does not sell directly to consumers. Provide
ITEM Description COMMENTS PART NUMBER
Distribution Blower assembly 1000 Cfm 1-10-01006
Air fi lter - 20 x 20 x 1 Pkg of 12 3-40-20201-12
Blower assembly 1450 Cfm 1-00-00862
Blower assembly 1638 Cfm 3-21-19599
Draft Meter Assembly 1-00-00637
Draft Meter Bolt & Tube 1-00-04004
ESP (Exhaust Sensing Probe) Black wires 3-20-11744
ESP (Exhaust Sensing Probe) Red wires 3-20-00844
Feeder Cover, Painted 2-00-73327B
Feeder Cover Filler, Painted 2-00-73359B
Flex Connector, 3/8" Straight 3-20-1000
Gasket, Chain shaker Pkg of 2 3-44-08100-2
Heat exchanger baffl e - bottom 2-00-73314
Heat exchanger baffl e - top 1-00-73418
Ignition Air Pump (Pressure Igniton) Post 008350087 3-20-02679
Air Pump Bracket 2-00-853500B Y
Igniter Element
Igniter Element (Pressure Ignition) Post 008350087 1-00-10450
Inner Ash door Assembly 1-10-73321A
Gasket, 1/4" Rope Black w/PSA (Glass) 15 Ft 1-00-2312
Inner ash door gasket 10 Ft 1-00-00539
Inner ash door glass 3-40-5555
Inner Ash Door Hinge 1-10-08735W
Inner ash door spacer set w/gasket 1-00-232074
Junction box harness 3-20-04948
Labels, Caution & Danger Pkg of 10 1-00-200408541
Low fuel sensor 4-20-03835
Outside Air Vent Assembly 1-10-09542
Flex pipe 2-3/4” (12-1/2”) (use standard 3" Pipe) No longer available 2-00-08544
Flex pipe 2-3/4” (25’) (Use standard 3" pipe) No longer available 2-00-08545
Ring Terminal Pkg of 25 1-00-01003 Y
Silicone Tubing, 1/4" 5 Ft 1-00-5113521 Y
Silicone Tubing, 1/8" 5 Ft 1-00-5113574 Y
Sleeve Bushing, 3/8 OD x 5/16 OAL Pkg fo 5 3-50-08288-5 Y
Steel Box, 4 x 4 3-20-52171
Terminal block for power supply - 3 Position 3-20-03018
Thermostat (wall control) 3-20-08101
Thermostat extension 4 Pole 3-20-04946
Touchup Paint, Prepaint Aerosol 3-42-7737
Pre 008350087 3-20-677200
Pkg of 10 1-00-677200
Stocked
at Depot
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Loading...