Hamilton Beach Commercial HDC200S, HDC200B SERVICE MANUAL

840168503

www.commercial.hamiltonbeach.com

10/09

Single-Cup Coffeemaker Page 2

Cafetière à une tasse Page 9

Cafetera para una taza Pagina 16

READ BEFORE USE.

LIRE AVANT D’UTILISER.

LEA ANTES DE USAR.

840168503 ENv01.qxd:840168500 Ev01.qxd 10/20/09 10:04 AM Page 1

3

When using electrical appliances, basic safety precautions should
always be followed to reduce the risk of fire, electric shock, and/or
injury to persons, including the following:

1. Read all instructions.

2. Do not touch hot surfaces. Use handles or knobs. Care must

be taken, as burns can occur from touching hot parts or from
spilled, hot liquid.

3. To protect against electric shock, do not place cord, plug, or
coffeemaker in water or other liquid.

4. Close supervision is necessary when any appliance is used by
or near children.

5. Unplug from outlet when the coffeemaker is not in use and
before cleaning. Allow to cool before putting on or taking off
parts and before cleaning the appliance.

6. Coffeemaker must be operated on a flat surface away from the
edge of counter to prevent accidental tipping.

7. Do not operate any appliance with a damaged cord or plug, or
after the appliance malfunctions or has been damaged in any
manner. Call our toll-free technical service number for information
on examination or adjustment.

8. The use of accessory attachments not recommended by the
appliance manufacturer may result in fire, electrical shock, or
personal injury.

9. Do not use outdoors.

10. Do not let cord hang over edge of table or counter or touch hot

surfaces, including stove. Do not place on or near a hot gas or
electric burner, or in a heated oven.

11. Do not use appliance for other than intended use.

12. WARNING! To reduce the risk of fire or electric shock, do not

remove the bottom cover of the coffeemaker. There are no
user-serviceable parts inside. Repair should be done by
authorized service personnel only.

IMPORTANT SAFEGUARDS

2

SAVE THESE INSTRUCTIONS

OTHER CONSUMER SAFETY INFORMATION

WARNING! Shock Hazard: If the plug on this appliance does not fit

in your outlet, do not modify the plug and do not use an adaptor.
Have an electrician replace the obsolete outlet.

The length of the cord used on this appliance was selected to
reduce the hazards of becoming tangled in or tripping over a
longer cord. If a longer cord is necessary, an approved extension
cord may be used. The electrical rating of the extension cord must
be equal to or greater than the rating of the appliance and should
be a grounding-type, 3-wire cord. Care must be taken to arrange
the extension cord so that it will not drape over the countertop or
tabletop where it can be pulled on by children or accidentally
tripped over.

To avoid an electrical circuit overload, do not use a high-wattage
appliance on the same circuit with the coffeemaker.

NOTE: For best results, allow the coffeemaker to cool for one minute
between brewing cycles.

This appliance is not intended for use by persons (including children)
with reduced physical, sensory or mental capabilities, or lack of
experience and knowledge, unless they have been given supervision
or instruction concerning use of the appliance by a person responsible
for their safety.

Children should be supervised to ensure that they do not play with
the appliance.

If the supply cord is damaged, it must be replaced by the manufac­turer, its service agent, or similarly qualified persons in order to avoid
a hazard.

840168503 ENv01.qxd:840168500 Ev01.qxd 10/20/09 10:04 AM Page 2

54

How to Brew Coffee or Tea

This coffeemaker can be used with
pod-type coffee or tea pods. It is not
recommended for use with espresso
pods.

1. Plug in coffeemaker.

2. Lift reservoir lid and slide out brew

basket. Place ONE coffee or tea
pod into brew basket.

(Illus. 1.)

Make sure pod is centered and flat
in brew basket.

3. Fill serving cup 12 ounces (350 ml)
of cold water.

(Illus. 2.)

NOTE: Once the START button is
pressed, the unit will brew for one cycle.
If the START button has been pressed
with no water in the reservoir, allow the unit to complete one
brew cycle and the Power ON Indicator Light will go out. If
the brew cycle needs to be stopped during brewing, unplug
the unit.

Parts and Features

Automatic Shutoff: The coffeemaker will automatically shut

off after brew cycle is complete.

Reservoir

Permanent
Brew Basket

Coffee Tray

(optional accessory,

model #CT200B)

Cup Rest

Power ON
Indicator Light

(Illus. 1)

(Illus. 2)

Burn Hazard.

• Do not use more than 12 ounces (350 ml) of water.

• Fully insert cup under brew basket.

• Do not remove cup until light goes off.

Overflowing coffee and hot water are a burn hazard.

w WARNING

Start Button

840168503 ENv01.qxd:840168500 Ev01.qxd 10/20/09 10:04 AM Page 4

76

4. Pour water carefully into reservoir

(behind brew basket) and lower
reservoir lid.

(Illus. 3.)

5. Place serving cup under brew
basket.

(Illus. 4.)

6. Press START button. The Power ON
Indicator Light will light up to show
that coffeemaker is on. Coffeemaker
will shut off automatically and light
will go off when brew cycle is
completed.

(Illus. 5.)

7. After you have finished your coffee and
the coffeemaker has cooled, use the tab
on the front of the brew basket to slide
out brew basket and dispose of pod.

(Illus. 6.)

If using standard tea bags, follow all
directions except in step 2, remove brew
basket and brew water directly into cup.
Once hot water is brewed, steep tea bag
in cup until desired strength is reached.

NOTE:

For best results,

allow coffeemaker
to cool for one minute between brewing
cycles.

(Illus. 4)

(Illus. 5)

(Illus. 6)

(Illus. 3)

Care and Cleaning

TO CLEAN INSIDE OF COFFEEMAKER: To prolong the life

of your coffeemaker, monthly cleaning is recommended. In
areas with hard water, more frequent cleaning is necessary.

1. Pour 1⁄2 cup of plain white vinegar and 1⁄2 cup of cold water
into reservoir. Place cup on cup rest under brew basket.
A commercial coffee cleaner, such as CleanCaf™, may also
be used according to package directions.

2. Press START button once. After 30 seconds, turn OFF.

3.

Wait 30 minutes to allow vinegar to clean. Then turn ON
again. When brew cycle is finished, wait for unit to cool.

4. Empty cup and rinse. Pour one cup of cold tap water into
reservoir. Place cup under brew basket.

5. Press START button. When brew cycle is finished, empty cup.
Repeat this process with one more cup of cold tap water.

6. If necessary, repeat Step 5 to remove any remaining
vinegar taste.

7. Wash cup and brew basket before making a beverage.

TO CLEAN OUTSIDE OF COFFEEMAKER:

1. Unplug coffeemaker and allow to cool before cleaning.

2. Occasionally wipe water spreader area, above brew basket,

with a clean, damp cloth to remove oils and residues from
coffee.

3. Permanent brew basket may be washed in dishwasher.
Discard disposable brew baskets after each use.

4. To clean all other outside surfaces of coffeemaker, use a
clean, damp cloth.

840168503 ENv01.qxd:840168500 Ev01.qxd 10/20/09 10:04 AM Page 6

8

LIMITED WARRANTY

This warranty applies to products purchased in the U.S. and
Canada. This is the only express warranty for this product and
is in lieu of any other warranty or condition.

This product is warranted to be free from defects in material
and workmanship for a period of one (1) year from the date
of original purchase.

If you have a claim under this warranty please contact our

TECHNICAL SERVICES DEPARTMENT at 1-866-285-1087
or 910-693-4277. For faster service, locate the model, type,

and series numbers on your appliance.
This warranty does not cover glass, filters, wear from normal

use, use not in conformity with the printed directions, or damage
to the product resulting from accident, alteration, abuse, or mis­use. This warranty extends only to the original purchaser. Keep
the original sales receipt, as proof of purchase is required to
make a warranty claim or the warranty term will be based on
the date of manufacture plus one (1) year.

We exclude all claims for special, incidental, and consequential
damages caused by breach of express or implied warranty.
All liability is limited to the amount of the purchase price.

Every implied warranty, including any statutory warranty
or condition of merchantability or fitness for a particular
purpose, is disclaimed except to the extent prohibited by
law, in which case such warranty or condition is limited
to the duration of this written warranty. This warranty gives

you specific legal rights. You may have other legal rights that
vary depending on where you live. Some states or provinces do
not allow limitations on implied warranties or special, incidental,
or consequential damages, so the foregoing limitations may not
apply to you.

840168503 ENv01.qxd:840168500 Ev01.qxd 10/20/09 10:04 AM Page 8