Hamilton Beach 840148101 User Manual
840148101
Big Mouth™Juice Extractor
Centrifugeuse Big Mouth
™
Extractor de jugo Big Mouth
™
READ BEFORE USE
LIRE AVANT L’UTILISATION
LEA ANTES DE USAR
English.......................................................................................... 2
USA: 1-800-851-8900
Visit hamiltonbeach.com for delicious recipes and to register your product online!
Français ............................................................................................ 15
Canada : 1-800-267-2826
Consulter hamiltonbeach.ca pour des recettes délicieuses et pour
enregistrer votre produit !
Español ...................................................................................... 30
México: 01 800 71 16 100
Visite hamiltonbeach.com para recetas deliciosas y para
registrar su producto en línea.
Le invitamos a leer cuidadosamente este instructivo
antes de usar su aparato.
840148101 ENv02.qxd 4/14/08 11:12 AM Page 1
2
IMPORTANT SAFEGUARDS
SAVE THESE INSTRUCTIONS!
When using electrical appliances, basic
safety precautions should be observed,
including the following:
1. Read all instructions before operating.
2. To protect against risk of electrical
shock, do not immerse cord, plug, or
motor base in water or other liquid.
3. This appliance is not intended for use by
children. Close supervision is necessary
when this appliance is used near children.
Do not allow children to use this appliance.
4. Always turn appliance OFF and unplug
cord from outlet when not in use, before
putting on or taking off parts, and
before cleaning.
5. Avoid contacting moving parts. Keep
fingers out of feed chute.
6. Never feed food by hand – always use
the food pusher.
7. Always make sure the juice extractor is
properly and completely assembled
before the motor is turned on. The unit
will not turn ON unless properly assembled. Do not release safety locking arm
while juice extractor is in operation.
8. Never operate without pulp container
in place.
9. Be sure to turn switch to OFF position
after each use of your juice extractor.
Make sure the motor stops completely
before disassembling.
10. Do not put fingers or other objects into
the juice extractor feed chute while it is
in operation. If food becomes lodged in
the opening, use food pusher to push it
down. When this method is not possible, turn the motor off, unplug the cord
from the outlet, and disassemble juicer
to remove the remaining food.
11. Do not operate any appliance with a
damaged cord or plug, or after the
appliance malfunctions or is dropped
or damaged in any manner. Call our
toll-free customer service number for
information on examination, repair or
electrical or mechanical adjustment.
12. The use of attachments not
recommended or sold by the appliance
manufacturer may cause fire, electric
shock, or injury.
13. Do not use outdoors.
14. Do not let cord hang over edge of table
or counter, or touch hot surfaces,
including stove.
15. Do not leave juice extractor unattended
while it is operating.
16. Blades are sharp; handle carefully. Do
not touch the small cutting blades in the
base of the stainless steel strainer basket.
17. Keep hair, clothing, and jewelry, as well
as spatulas and other utensils, away
from feed chute during operation to
prevent the possibility of severe injury
to persons and/or damage to the
appliance.
18. Do not use the appliance if the rotating
strainer basket is damaged.
19. Always use the juice extractor on a dry,
level surface.
20. Any maintenance other than cleaning
should be performed by an authorized
service center.
21. To reduce the risk of personal injury
and/or damage to the appliance, do not
use bent, dented or otherwise damaged
strainer basket.
840148101 ENv02.qxd 4/14/08 11:12 AM Page 2
3
Other Consumer Safety Information
CAUTION: This appliance is not intended
for use by children.
WARNING! Shock Hazard: This appliance
has a polarized plug (one wide blade) that
reduces the risk of electric shock. The plug
fits only one way into a polarized outlet. Do
not defeat the safety purpose of the plug by
modifying the plug in any way or using an
adaptor. If the plug does not fit, reverse the
plug. If it still does not fit, have an electrician
replace the outlet.
The length of the cord used on this appliance
was selected to reduce the hazards of
becoming tangled in, or tripping over, a
longer cord. If a longer cord is necessary, an
approved extension cord may be used. The
electrical rating of the extension cord must be
equal to or greater than the rating of the
appliance. Care must be taken to arrange the
extension cord so that it will not drape over
the countertop or tabletop where it can be
pulled on by children or accidentally tripped
over.
The electrical rating of this appliance is
listed on the bottom panel of the unit.
The strainer basket is a delicate screen.
If bent or damaged, do not use, as it could
break into small pieces and cause personal
injury and/or damage the appliance. Call our
toll-free customer service number to order a
new basket. Replace basket when it shows
signs of wear.
This appliance is intended for household use only.
Cut or Crush Hazard.
Extra-wide feed chute. Do not place hands or fingers down
feed chute. Always use the food pusher.
Failure to follow this instruction can result in serious personal
injury.
w WARNING
840148101 ENv02.qxd 4/14/08 11:12 AM Page 3
4
Parts and Features
Micro Mesh Strainer Basket may fly apart during use if it is
damaged, resulting in the risk of cuts and bruises.
To reduce the risk of personal injury:
• Always inspect Micro Mesh Strainer Basket before each use.
• Never use a cracked, bent or damaged Micro Mesh Strainer
Basket.
w WARNING
Food Pusher
Stainless Steel
Micro Mesh
Strainer Basket
Extra-Wide
Feed Chute
Juicer Cover
Juice Spout
Strainer Bowl
Large Pulp
Container
Locking Latches
On/Off Switch
Locking Latches
Motor Base
Cleaning Brush
(with select
models)
Juice Cup
(with select
models)
840148101 ENv02.qxd 4/14/08 11:12 AM Page 4
5
How to Assemble
Read and follow instructions in “Before First Use.”
Place Strainer Bowl on top of the
Motor Base.
Place the Stainless Steel Strainer
Basket inside the Strainer Bowl. With
hands on outer edge, press Strainer
Basket down firmly to latch into
position.
Place the Juicer Cover over the
Strainer Bowl, positioning the Feed
Chute over the Strainer Basket and
lower into position.
1
2
(continued on next page)
4
Strainer Basket
Filter Bowl
3
Before First Use
After unpacking the juice extractor, remove cardboard from filter basket and wash
everything except the base in warm, soapy water. Rinse and dry immediately.
Never immerse the base in water or other liquids; wipe it with a damp sponge.
840148101 ENv02.qxd 4/14/08 11:12 AM Page 5
Place the Pulp Container into position
by tilting the Container slightly.
Place a glass or other container
under the Juice Spout.
6
Slide the Food Pusher down the
Feed Chute by aligning the groove in
the Food Pusher with the small
ridge on the inside of the top of
the Feed Tube.
8
6
7
Hint!
To minimize clean-up, place a plastic
grocery bag in the Pulp Container to
collect the pulp. (See page 7 for more
information.)
Small Ridge
Inside Feed
Chute
How to Assemble (cont.)
Raise the Locking Latches up to lock
into place.
5
840148101 ENv02.qxd 4/14/08 11:12 AM Page 6
7
How to Use
Wash fruits and vegetables.
NOTE: Most fruits and vegetables
such as apples, carrots, and cucumbers will
not need to be cut since they will fit into
Feed Chute whole. It is recommended that
fruits or vegetables, such as oranges, melons, or mangoes, are peeled before placing
in unit to minimize impact on juice flavor.
1
Ensure that unit is correctly
assembled (see pages 5 and 6)
and place a glass or container under
spout.
2
Plug cord into 120 volt AC outlet.
Turn ON/OFF Switch to ON.
3
With the motor running, place food down
the Feed Chute. Using Food Pusher, gently guide food down Feed Chute. To
extract the maximum amount of juice,
always push Food Pusher down slowly.
4
Laceration Hazard.
Never use fingers to push food down the Feed Chute or to clear
the Feed Chute. Always use the Food Pusher provided.
w WARNING
Juice will flow into glass and
separated pulp will accumulate
in Pulp Container.
NOTE: Pulp Container can be emptied
during juicing by turning juice extractor
OFF and then carefully removing Pulp
Container. (Replace empty Pulp
Container before continuing to juice.)
To minimize clean-up, place a plastic
grocery bag in Pulp Container to collect
pulp. When juicing is completed, simply
remove grocery bag containing pulp.
NOTE: Do not allow Pulp Container to
overfill as this may prevent correct
operation or damage the unit.
5
6
840148101 ENv02.qxd 4/14/08 11:12 AM Page 7
8
Turn juice extractor OFF and
unplug. Allow Strainer Basket
to stop turning.
How to Disassemble
Remove the Pulp Container by sliding
away from Motor Base.
Release Locking Latches.
Move the Locking Latches down.
Lift off the Strainer Bowl with the
Strainer Basket still in place.
1
5
2
3
Lift off the Cover.
4
6
7
To remove the Strainer Basket, turn
the Strainer Bowl upside down and
carefully remove the Strainer Basket.
(It is recommended to remove the
Strainer Basket over a sink.)
840148101 ENv02.qxd 4/14/08 11:12 AM Page 8
9
Care and Cleaning
• After disassembling the unit (see
page 8) all removable parts may
be washed in hot, soapy water.
• All plastic parts of the juice extractor
can be placed in the bottom or top
rack of the dishwasher. Do not place
the Motor Base in the dishwasher.
Some part distortion may occur if
your household dishwasher’s temperature is higher than normal or if the
parts are placed too close to the
heating element.
• Wipe the Motor Base with a damp
cloth.
• Discoloration of the plastic may occur
with some fruit and vegetables. To
help prevent this, wash all parts
immediately after use.
NOTE:
• To assist with cleaning, soak the
Strainer Basket in hot, soapy water
for approximately 10 minutes immediately after juicing is completed. If
pulp is left to dry on the basket it may
clog the fine pores of the filter mesh
thereby lessening the effectiveness of
the juice extractor.
CAUTION! Laceration Hazard.
The center of the strainer basket
contains small, sharp blades to
process fruits and vegetables
during the juicing function.
Do not touch blades when handling
the strainer basket.
• The cleaning brush included with the
unit is the most effective way to clean
the Strainer Basket. Using the brush,
hold the Strainer Basket under running water and brush inside and
outside of the basket. Always treat
the Strainer Basket with care; it can
be easily damaged.
Strainer Basket
Shock Hazard.
Do not immerse Motor Base in water
or any other liquid.
w WARNING
840148101 ENv02.qxd 4/14/08 11:12 AM Page 9
10
Troubleshooting
POSSIBLE PROBLEM
Machine will not work
when switched “ON.”
Motor appears to stall
when juicing.
Excess pulp building up
in the Micro Mesh
strainer basket.
Pulp is too wet and
insufficient juice is
produced.
Juice sprays out of spout.
Juice drips out of spout
immediately after juicing.
Machine vibrates
excessively.
EASY SOLUTION
The Locking Latches may not be correctly
engaged. Check to see if the Locking Latches
are properly positioned in the two grooves on
either side of the Juice Cover. Refer to pages
5 and 6, Steps 4 and 5.
The juicing action may be too vigorous. Try
slower juicing action by pushing the Food
Pusher down more slowly. Refer to page 7,
Step 4.
Wet pulp can build up under the Juicer Cover
or Pulp Container. Turn unit OFF and unplug.
Empty the Pulp Bin then clean Juice Cover
and Strainer Basket.
Turn OFF and unplug. Remove strainer basket
and clean mesh walls with a fine brush. This
will remove excess fiber build-up which could
be inhibiting the juice flow. Refer to pages 8
and 9.
Try a slower juicing action.
Turn OFF and unplug. Remove strainer basket
and clean mesh walls with a fine brush. This
will remove excess fiber build-up which could
be inhibiting the juice flow. Refer to pages 8
and 9.
Try a slower juicing action by pushing the
Food Pusher down more slowly. Refer to
page 7, Step 4.
With motor ON, raise and lower Food Pusher in
Feed Chute several times. The action forces
remaining pulp and juice out of Strainer Bowl.
Build up of pulp in mesh of strainer basket.
Turn unit OFF and unplug. Clean strainer basket. Refer to page 9. After cleaning, if machine
vibration continues this could be a sign of a
damaged Strainer Basket. Call our toll-free
Customer Service number to order a new
Strainer Basket.
840148101 ENv02.qxd 4/14/08 11:12 AM Page 10
11
Using The Pulp
• The remaining pulp left after juicing
fruits or vegetables is mostly fiber
and cellulose which, like the juice,
contains vital nutrients necessary for
the daily diet and can be used in
many ways. However, like the juice,
pulp should be used that day to
avoid loss of vitamins.
• There are a number of recipes that
use pulp. You can also use pulp to
thicken casseroles or soups.
• Pulp is great used in the garden
for compost.
Soy Milk, Almond Milk, and Rice Milk
Your juice extractor may be used to
make soy milk, almond milk and rice
milk. One cup of soybeans, almonds or
rice must be soaked in four cups of
water for 24-48 hours in the refrgerator.
Slowly pour one cup of the soaked
mixture at a time into the food chute.
The liquid extracted from the soaked
mixture is the “milk.”
NOTES:
• Almonds must be soaked 24-48
hours before juicing.
• Soy milk should be boiled to improve
the flavor.
• Vanilla, honey and sugar may be
added to enhance the flavor of each
milk type.
Juicing Tips and Techniques
Purchasing and Storing Fruits & Vegetables
• Always wash fruits and vegetables
before juicing.
• Always use fresh fruits and vegetables
for juicing.
• To save money and obtain fresher
produce, purchase fruits or vegetables
that are in season.
• Keep your fruits and vegetables ready
for juicing by washing them before
storing.
• Most fruits and hardier type vegetables can be stored at cool room
temperature. The more delicate and
perishable items such as tomatoes,
berries, leafy greens, celery, cucumbers and herbs should be stored in
the refrigerator until required.
Preparing Fruits & Vegetables
• It is recommended that fruits or vegetables, such as oranges, melons, or
mangoes, are peeled before placing in
juice extractor to minimize impact on
juice flavor.
• All fruits with pits and large seeds
such as nectarines, peaches, apricots, plums and cherries MUST be
pitted before juicing.
Hint!
Your juice extractor makes invigorating,
frothy orange juice. Simply peel the oranges
and juice. For best results, refrigerate
oranges before juicing.
840148101 ENv02.qxd 4/14/08 11:12 AM Page 11
1212
Recipes
The following drink recipes yield a single serving of 6 to 10 ounces (175-300 ml).
If sugar or honey is listed, add to juice after juicing.
Two Can Mango
1
⁄4-inch (6 mm) slice fresh ginger
1
⁄2 mango
1
⁄4 fresh pineapple, peeled
An Antioxidant a Day...
1
⁄2 cup (125 ml) cranberries
1
⁄2 cup (125 ml) raspberries
1
⁄2 cup (125 ml) strawberries
1
⁄2 cup (125 ml) white grapes
1 teaspoon (5 ml) honey
Mr. Bone’s
1
⁄4 small head cabbage
1 celery stalk
1 apple
Vitamin C Zing
3 oranges, peeled
1
⁄8-inch (3 mm) slice fresh ginger
Calcium Builder
1
⁄4 small head cabbage
1-2 fresh basil leaves
1 stalk broccoli
(3-4 flowerets with stalk)
1 celery stalk
1 apple
Teacher’s Pet
1 apple
1 tangerine, peeled
Healthy Women
2 broccoli flowerets with stalk
1
⁄4 green pepper
1 carrot
1 celery stalk
1 tomato
Tabasco sauce to taste
Y Zone
8 medium tomatoes
1 lemon, peeled
1 stalk celery
1 medium carrot
1 slice of onion
1 teaspoon (5 ml) Worcestershire
1
⁄2 teaspoon salt (2.5 ml)
Eye Opener
2 carrots
1 apple
1 tangerine, peeled
Winter Blue Zing
2 apples
1
⁄4 cup (60 ml) blueberries
1 orange, peeled
Good Morning!
1
⁄2 ruby red grapefruit, peeled
1 pear
1 banana, peeled
1 cup white grapes
Liquid Fire
1 medium tomato
1
⁄2 jalapeno pepper
1 handful parsley
1
⁄2 cucumber
840148101 ENv02.qxd 4/14/08 11:12 AM Page 12
1313
For Your Eyes Only
2 carrots
1
⁄2 yellow squash
1 pear
Healthy Men
1 medium tomato
3 sprigs of asparagus
1 stalk of celery
1
⁄2 yellow squash
X Zone
1 handful romaine lettuce
1 handful alfalfa sprouts
1 carrot
2 handfuls spinach
1 stalk celery
vitAmin
1 tomato
1
⁄2 cucumber
1
⁄2 bunch parsley
1 carrot
Orchard Blend
2 apples
2 pears
Vineyard Hop
1 cup (250 ml) grapes
1 pear
The Health Club
1
⁄2 of a 6-ounce (170 g) bag spinach
3 carrots
Passion Potion
1 pear
2 apples
Small piece gingerroot
Sour Grapes
1 lime, peeled
2 cups red grapes
The Fiber Press
2 apples
1
⁄2 lemon, peeled
840148101 ENv02.qxd 4/14/08 11:12 AM Page 13
1414
Customer Service
If you have a question about your juice extractor, call our toll-free customer
service number. Before calling, please note the model, type, and series numbers
and fill in that information below. These numbers can be found on the bottom
of your juice extractor. This information will help us answer your question much
more quickly.
MODEL: ______________ TYPE: _______________ SERIES: _________________
This warranty applies to products purchased in the U.S. or Canada.
LIMITED WARRANTY
This product is warranted to be free from defects in material and workmanship
for a period of one (1) year from the date of original purchase, except as noted
below. During this period, we will repair or replace this product at our option.
THE FOREGOING WARRANTY IS IN LIEU OF ANY OTHER WARRANTY OR
CONDITION, WHETHER EXPRESS OR IMPLIED, WRITTEN OR ORAL
INCLUDING, WITHOUT LIMITATION, ANY STATUTORY WARRANTY OR
CONDITION OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR
PURPOSE. ANY LIABILITY IS EXPRESSLY LIMITED TO AN AMOUNT EQUAL
TO THE PURCHASE PRICE PAID, AND ALL CLAIMS FOR SPECIAL,
INCIDENTAL AND CONSEQUENTIAL DAMAGES ARE HEREBY EXCLUDED.
There is no warranty with respect to the following, which may be supplied
with this product, including without limitation: glass parts, glass containers,
cutter/strainers, blades, seals, gaskets, clutches, motor brushes, and/or agitators,
etc. This warranty extends only to the original consumer purchaser and does not
cover a defect resulting from abuse, misuse, neglect including failure to clean
product regularly in accordance with manufacturer’s instructions, use for
commercial purposes, or any use not in conformity with the printed directions.
This warranty gives you specific legal rights, and you may also have other legal
rights which vary from state to state, or province to province. Some states or
provinces do not allow limitations on implied warranties or special, incidental or
consequential damages, so the foregoing limitations may not apply to you.
If you have a claim under this warranty, DO NOT RETURN THE APPLIANCE TO
THE STORE! Please call our CUSTOMER SERVICE NUMBER. (For faster service
please have model, series, and type numbers ready for operator to assist you.)
CUSTOMER SERVICE NUMBERS
In the U.S. 1-800-851-8900
In Canada 1-800-267-2826
hamiltonbeach.com
KEEP THESE NUMBERS FOR FUTURE REFERENCE!
840148101 ENv02.qxd 4/14/08 11:12 AM Page 14
Loading...