GVA Lighting HL-COVE Installation Manual
HL-COVE
Modular LED Cove Lighting System
INSTALLATION GUIDE
GVA Lighting, Inc. 3400 Ridgeway Drive, #14 Missisauga, Ontario L5L 0A2
Tel: + 1 905 569 6044 Email: info@gvalighting.com gvalighting.com
IG-HL-COVE, 16-11-21 | Page 1 / 9
HL-COVE
Modular LED Cove Lighting System
The HL-Cove is a modular LED lighting system designed for architectural cove lighting where long runs are necessary with a single power feed.
This guide contains important information on planning and installing your new HL-Cove LED fixture. For your protection, read it carefully and
save it for future reference.
WARNING
Do not attempt to install or use Luminaire until you read and understand this guide and
safety labels.
Luminaires must be installed by a qualified professional in accordance with all national and
local electrical and construction codes and regulations.
Ensure that main power supply is OFF before installing or wiring luminaire(s).
Do not exceed specified voltage and current input.
Do not use luminaires with a damaged lens, body, or cable.
Not heading cautions may result in a hazardous situation which can cause equipment and
property damage, personal injury, or death.
Do not exceed the specified voltage and current input.
Do not exceed the maximum number of specified fixtures in a light run. Doing so will result
in a current overload.
GVA Luminaires have no serviceable parts. Do not attempt to open the units.
Do not hot swap! Ensure power supply is off before connecting or disconnecting fixtures.
Do not stare into beam or view directly with optical instruments.
Unauthorized feild repairs will void warranty.
CAUTION
INSTALLATION GUIDE
1. MOUNTING BRACKET INSTALLATION
1.A. Mounting Track Adjustable Bracket Installation......................................................................................................
1.B. Single Adjustable Bracket Installation....................................................................................................................
1.C. Mounting Tray Installation......................................................................................................................................
NOTE: The mounting bracket's pivot feature should point towards the direction the light fixture will be aimed.
3
4
5
CORRECT
MOUNTING DIRECTION
INCORRECT
MOUNTING DIRECTION
Specifications are subject to change without notice. Every effort has been made to ensure that the information provided in this manual is accurate.
GVA Lighting Inc. is not responsible for printing or clerical errors. Refer to www.gvalighting.com for additional information.
GVA Lighting, Inc. 3400 Ridgeway Drive, #14 Missisauga, Ontario L5L 0A2
Tel: + 1 905 569 6044 Email: info@gvalighting.com gvalighting.com
IG-HL-COVE, 16-11-21 | Page 2 / 9
150mm
300mm
3/16in
150mm
300mm
HL-COVE
Modular LED Cove Lighting System
1.A. MOUNTING TRACK ADJUSTABLE BRACKET INSTALLATION
1.A.1. Using provided fasteners or mounting tape, install the Mounting Track following the hole pattern shown below.
WARNING
NOTE: For multiple continuous Mounting Track installations, place each assembly against each other to achieve even module spacing.
NOTE: Mounting tape may be used if tool access is difficult or impossible.
Use mounting hardware suitable for the mounting surface. If supplied hardware is not suitable, replace with similar sized hardware. Use of innappropriate hardware
may result in dismounting of the mounting profile and can result in equipment damage, injuries, and death.
(supplied)
(per 1200mm bracket)
2 x ST4.2 x 25MM
PAN HEAD SCREW
(per 2400mm bracket)
4 x ST4.2 x 25MM
PAN HEAD SCREW
MINIMUM COVE DIMENSIONSHARDWARE REQUIRED:
33.80mm
1.30in
36.50mm
1.43in
36.50mm
1.30in
54mm
2.13in
INSTALLATION GUIDE
1200MM MOUNTING TRACK MOUNTING PATTERN
11.8in
TYP.
11.8in
TYP.
4 x
2 x
4.76mm
4.76mm
3/16in
600mm
23.62in
TYP
600mm
23.62in
4 x FIXTURE BRACKETS
8 x FIXTURE BRACKETS
300mm
11.81in
300mm
11.81in
IG-HL-COVE, 16-11-21 | Page 3 / 9
5.9in
TYP.
5.9in
TYP.
300mm
300mm
11.81in
11.81in
10mm
0.39in
2400MM MOUNTING TRACK MOUNTING PATTERN
10mm
0.39in
Specifications are subject to change without notice. Every effort has been made to ensure that the information provided in this manual is accurate.
GVA Lighting Inc. is not responsible for printing or clerical errors. Refer to www.gvalighting.com for additional information.
GVA Lighting, Inc. 3400 Ridgeway Drive, #14 Missisauga, Ontario L5L 0A2
Tel: + 1 905 569 6044 Email: info@gvalighting.com gvalighting.com
Loading...