GuangZhou Walkera Technology TX624 Users Manual

™

Novus CP Specifi cations

Length: 10.7 in [272mm]
Width: 2 in [50mm]
Height: 3.74 in [95mm]
Rotor Span: 12 in [305mm]

Entire Contents © Copyright 2009 HMXE0804 Mnl 01

Flying Weight: 2.41 oz [68.4g]
(with supplied
fl ight battery)

IMPORTANT PRECAUTIONS

IMPORTANT PRECAUTIONS

● Only use the included charger with the included battery or replacement
battery (GPMP0408).

● Do not attempt to use this charger with NiCd or NiMH battery packs.

● Never charge in excess of 4.20V per cell.

● If the battery should become damaged, discard the battery. Do not

attempt to use a damaged battery.

● Do not leave the charger unattended while charging. Disconnect the
battery and remove input power from the charger immediately if either
becomes hot! However, it is normal for the charger to get warm.

● Disconnect the battery from the charger and carefully move the
battery to a fi reproof location if the battery begins to swell or smoke!

● Never charge at currents greater than 1C.

● Always charge in a fi reproof location.

● Never trickle charge.

● Never allow the battery temperature to exceed 140° F [60° C].

● Never disassemble or modify pack wiring in any way or puncture

cells.

● Never discharge below 2.75V per cell.

● Do not allow water, moisture or foreign objects into the charger.

● Do not block the air intake holes, which could cause the charger to

overheat.

● Do not place the charger or any battery on a fl ammable surface or
near a combustible material while in use.

● Do not charge on a carpet, cluttered workbench, paper, plastic, vinyl,
leather, wood, or inside an R/C model.

● Never charge inside a full-sized vehicle.

● Always disconnect the battery from the charger and the power supply

from the charger when not in use.

● Do not attempt to charge a battery if it is swollen or hot.

● ALWAYS KEEP OUT OF REACH OF CHILDREN.

2

WARRANTY

WARRANTY

Heli-Max™ guarantees this kit to be free from defects in both material and
workmanship at the date of purchase. This warranty does not cover any
component parts damaged by use or modifi cation. In no case shall Heli-Max’s
liability exceed the original cost of the purchased kit. Further, Heli-Max reserves
the right to change or modify this warranty without notice.

In that Heli-Max has no control over the fi nal assembly or material used for fi nal
assembly, no liability shall be assumed nor accepted for any damage resulting
from the use by the user of the fi nal user-assembled product. By the act of
using the user-assembled product, the user accepts all resulting liability.

If the buyer is not prepared to accept the liability associated with the use of this
product, the buyer is advised to return this kit immediately in new and unused
condition to the place of purchase.

To make a warranty claim, send the defective part or item to Hobby Services at
this address.

Hobby Services

3002 N. Apollo Dr., Suite 1
Champaign, IL 61822
USA

Include a letter stating your name, return shipping address, as much contact
information as possible (daytime telephone number, fax number, e-mail
address), a detailed description of the problem and a photocopy of the purchase
receipt. Upon receipt of the package the problem will be evaluated as quickly
as possible.

READ THROUGH THIS INSTRUCTION MANUAL FIRST. IT CONTAINS
IMPORTANT INSTRUCTIONS AND WARNINGS CONCERNING THE
ASSEMBLY AND USE OF THIS MODEL.

3

TABLE OF CONTENTS

TABLE OF CONTENTS

INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

SAFETY PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

ADDITIONAL ITEMS REQUIRED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

ORDERING REPLACEMENT PARTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

KIT INSPECTION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

KIT CONTENTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

ASSEMBLY INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

GET THE MODEL READY TO FLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

LITHIUM BATTERY HANDLING & USAGE . . . . . . . . . . . . . . . . . . . . . . . . 10

PREFLIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

CONTROLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

FLYING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

MAINTENANCE & REPAIR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

TRANSMITTER SETTINGS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

E-BOARD ADJUSTMENTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

EXPLODED VIEW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

PARTS LIST & OPTIONAL PARTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

INTRODUCTION

INTRODUCTION

Thank you for purchasing the Heli-Max™ Novus CP. We are certain you will get
many hours of enjoyment out of this model. If you should have any questions or
concerns please feel free to contact us at [e-mail]. For the
latest technical updates or manual corrections to the Novus CP visit the Heli­Max web site at:

www.helimax-rc.com

Open the “Helicopters” link, and then select the Novus CP link. If there is new
technical information or changes to this model a “tech notice” box will appear in
the upper left corner of the page.

SAFETY PRECAUTIONS

SAFETY PRECAUTIONS

● Failure to follow these safety precautions may result in severe injury to
yourself and others.

● Keep your face and body as well as all spectators away from the plane of
rotation of the rotors whenever the battery is connected.

4

● Keep these items away from the rotors: loose clothing, shirt sleeves, ties,
scarfs, long hair or loose objects such as pencils or screwdrivers that may
fall out of shirt or jacket pockets into the rotors.

● The spinning blades of a model helicopter can cause serious injury. When
choosing a fl ying site for your Novus CP Helicopter, stay clear of buildings,
trees and power lines. AVOID fl ying in or near crowded areas. DO NOT fl y
close to people, children or pets. Maintain a safe pilot-to-helicopter distance
while fl ying.

1.Your Novus CP Helicopter should not be considered a toy, but rather a

sophisticated, working model that functions very much like a full-size helicopter.
Because of its performance capabilities, the Novus CP Helicopter, if not
assembled and operated correctly, could possibly cause injury to yourself or
spectators and damage to property.

2. You must assemble the model according to the instructions. Do not alter or

modify the model, as doing so may result in an unsafe or unfl yable model. In a
few cases the instructions may differ slightly from the photos. In those instances
the written instructions should be considered as correct.

3. You must correctly install all R/C and other components so that the model

operates correctly on the ground and in the air.

4. You must check the operation of the model before every fl ight to insure that

all equipment is operating and that the model has remained structurally sound.
Be sure to check linkages or other connectors often and replace them if they
show any signs of wear or fatigue.

5. If you are not an experienced pilot or have not fl own this type of model before,

we recommend that you get the assistance of an experienced pilot in your
R/C club for your fi rst fl ights. If you’re not a member of a club, your local hobby
shop has information about clubs in your area whose membership includes
experienced pilots.

We, as the manufacturer, provide you with a top quality, thoroughly
tested helicopter and instructions, but ultimately the quality and flyability
of your finished model depends on how you build it; therefore, we cannot
in any way guarantee the performance of your completed model, and
no representations are expressed or implied as to the performance or
safety of your completed model.

Remember: Take your time and follow the instructions to build a safe and
enjoyable model.

5

ADDITIONAL ITEMS REQUIRED

ADDITIONAL ITEMS REQUIRED

Eight “AA” Alkaline Batteries for the Transmitter

(2) SANP3500 Sanyo AA Alkaline Battery (4 pack)

❏

ORDERING REPLACEMENT PARTS

ORDERING REPLACEMENT PARTS

Replacement parts for the Heli-Max Novus CP Helicopter are available using
the order numbers in the Parts List on page 27. The fastest, most economical
service can be provided by your hobby dealer.

To locate a hobby dealer, visit the Hobbico web site at www.hobbico.com.
Choose “Where to Buy” at the bottom of the menu on the left side of the page.
Follow the instructions provided on the page to locate a U.S., Canadian or
International dealer.

Parts may also be ordered directly from Hobby Services by calling (217) 398­0007, or via facsimile at [phone], but full retail prices and shipping
and handling charges will apply. Illinois and Nevada residents will also be
charged sales tax. If ordering via fax, include a Visa® or MasterCard® number
and expiration date for payment. Mail parts orders and payments by personal
check to:

Hobby Services

3002 N. Apollo Drive, Suite 1
Champaign, IL 61822

Be certain to specify the order number exactly as listed in the Parts List.
Payment by credit card or personal check only; no C.O.D.

If additional assistance is required for any reason contact:

Product Support

by e-mail at [e-mail],
or by telephone at [phone].

6

KIT INSPECTION

KIT INSPECTION

Before starting assembly, take an inventory of the Novus CP to make sure it is
complete, and inspect the parts to make sure they are of acceptable quality. If
any parts are missing or are not of acceptable quality, or if you need assistance
with assembly, contact Product Support. When reporting defective or missing
parts, use the part names exactly as they are written in the Kit Contents list.

Heli-Max Product Support

3002 N. Apollo Drive, Suite 1
Champaign, IL 61822

Telephone: [phone]
Fax: [phone]

E-mail: [e-mail]

KIT CONTENTS

KIT CONTENTS

1

1. Novus CP Helicopter

2. 3.7V LiPo Battery

3

2

4

3. 4-Channel 2.4GHz Transmitter

4. 110V Wall Charger

7

ASSEMBLY INSTRUCTIONS

ASSEMBLY INSTRUCTIONS

Remove the battery cover from the back of the transmitter and remove the

❏

battery box. Install eight (8) “AA” batteries into the battery box. Double-check the
polarity of each battery before placing the battery box back into the transmitter
and replacing the battery cover.

Turn on the transmitter using the power switch as shown above and verify

❏

that the indicator illuminates. Turn the transmitter off for now. If the indicator did
not illuminate, remove the battery box from the transmitter and verify that the
batteries were installed correctly.

8

GET THE MODEL READY TO FLY

GET THE MODEL READY TO FLY

Charging the Flight Battery

WARNING!! The charger supplied with the Heli-Max Novus CP Helicopter
contains protective circuitry. If you experience any diffi culties while
charging the battery, please disconnect the battery from the charger and
unplug the charger from the power source. Allow the battery and charger
to rest for two hours as this will allow the charge protection circuit to reset.
If this issue re-occurs during normal use, please contact technical support
for further assistance.

Plug the wall transformer into an AC outlet. The power indicator light on the

❏

wall transformer will be green and the charge indicator light will be solid red.

Charge Indicator Light

Fast Flashing Red

Green (Solid or Flashing)

*Slow Flashing Red

*Solid Red

with Battery Connected

Solid Red

without Battery Connected

The battery is being charged.

The battery is fully charged.

A time-out has occurred.

The battery voltage is too low
or the charger is not powered.

The charger is ready.

9

Once the battery

*

has been
disconnected
from the charger
contact technical
support for
further
assistance.

WARNING!! Do not leave the battery connected to the charger if the
charge indicator is solid red. This may over-discharge the battery, possibly
causing damage to the battery or the charger. Once the battery has been
disconnected from the charger, contact technical support immediately for
further assistance.

Plug the battery into the charger. The charge indicator light will start

❏

fl ashing red quickly; this indicates that the battery is being charged. Once the
battery is completely charged, the charge indicator light will turn green (solid
or fl ashing). Under normal operating conditions, the battery may take up to
one hour to recharge.

LITHIUM BATTERY HANDLING & USAGE

LITHIUM BATTERY HANDLING & USAGE

WARNING!! Read the entire instruction sheet included with this
battery. Failure to follow all instructions could cause permanent
damage to the battery and its surroundings, and may cause
bodily harm!

10