Grundfos NB, NBG, TP, TPD Installation And Operating Instructions Manual

GRUNDFOS INSTRUCTIONS
NB, NBG, TP, TPD
ATEX-approved pumps
Installation and operating instructions
2
NB, NBG, TP, TPD
ATEX-approved pumps
Οδηγίες εγκατάστασης και λειτουργίας 16
Installatie- en bedieningsinstructies 18 Monterings- och driftsinstruktion 20 Asennus- ja käyttöohjeet 22 Monterings- og driftsinstruktion 24 Instrukcja montażu i eksploatacji 26 Руководство по монтажу и эксплуатации 28 Szerelési és üzemeltetési utasítás 30 Navodila za montažo in obratovanje 32 Montažne i pogonske upute 34 Uputstvo za montažu i upotrebu 36 Instrucţiuni de instalare şi utilizare 38 Упътване за монтаж и експлоатация 40 Montážní a provozní návod 42 Návod na montáž a prevádzku 44
3
CONTENTS
Page
1. General information 4
2. Related installation and operating instructions 4
3. Scope of ATEX categories for NB, NBG, TP, TPD pumps 4
4. Identification 5
5. Before starting an ATEX-approved pump 5
Before beginning installation procedures, these instructions and the installation and operating instructions for the standard pump should be studied carefully. The installation and operation should also be in accordance with local regulations and accepted codes of good practice.
1. General information
For ATEX-approved Grundfos NB, NBG, TP, TPD pumps, these supplementary installation and operating instructions must be observed.
The NB, NBG, TP, TPD pumps have been approved according to the EC directive 94/9/EC, the so-called ATEX directive.
The pumps can be used in areas (zones) classified according to the directive 1999/92/EC. In case of doubt, please consult the above-mentioned directives or contact Grundfos.
2. Related installation and operating instructions
In addition to these instructions, the following installation and operating instructions must be observed:
- NB, NBG
- TP, TPD
- TP
3. Scope of ATEX categories for NB, NBG, TP, TPD pumps
Directive ATEX-approved NB, NBG, TP, TPD pumps
Group I Group II
94/9/EC
1999/92/EC NB, NBG, TP, TPD pumps None None None None
1) Important: The link between groups, categories and zones is
explained in 1999/92/EC. Please note that this is a minimum directive. Some EU countries might therefore have stricter local rules. The user or installer is always responsible for checking that the group and category of the pump correspond to the zone classification of the installation site.
2) Note: The risk assessment done by Grundfos on the NB,
NBG, TP, TPD pumps for category 3 G shows that the pump can be upgraded to category 2 G by installing an ATEX­approved dry-running protection.The dry-running protection must stop the pump if the minimum flow rate cannot be main­tained. Always check that the motor is marked for category 2 G. Make sure that the combination of “NB, NBG, TP, TPD” and “dry-running protection” is described in the Explosion Protec­tion Document according to the directive 1999/92/EC. The responsibility rests with the installer/owner. In case of doubt, please contact the local authorities.
1)
Category M Category 1 Category 2 Category 3
12GDG
Zone 0 Zone 20 Zone 1 Zone 21 Zone 2 Zone 22
2)
NB, NBG, TP,
TPD pumps
DG D
None
NB, NBG, TP,
TPD pumps
NB, NBG, TP,
TPD pumps
4
4. Identification
The nameplate on the pump head gives the following details:
• Data for the standard pump and
• data for the ATEX marking
- Technical file no.
- Serial no.
- Ex category
Type
NB 80-315/320 A-F-A-BAQE
Model
Q
127
p/t
16/120
II 3Gc120°C
A 96539056 P2 0426 0001
3
H
m /h
bar/°CMAX
33
Made in
Tech.file
m
n
96528409
1460
HUNGARY
min
-1
96561896
5. Before starting an ATEX-approved pump
Check list
This check list must be strictly observed:
1. Check that the ATEX rating of both motor and pump corre­sponds to the specified category.
See section 3. Scope of ATEX categories for NB, NBG, TP, TPD pumps
If the motor and pump categories differ, the lower rating is valid.
2. Check that the rubber parts of the pump are as ordered, see nameplates.
3. Check that the shaft can rotate freely. There must be no mechanical contact between impeller and pump housing.
4. Check that the pump has been filled with liquid.
TM03 4234 1906
The pump must never run dry.
5. Check the direction of rotation of the motor, see arrow on top of the fan cover.
6. Check that the liquid temperature never exceeds the maxi­mum liquid temperature (t
7. Avoid overheating of the pump. Operation against a closed discharge valve may cause over­heating. Install a bypass with a pressure-relief non-return valve.
8. The pump must be re-vented
- if the pump has been stopped for a period or
- if air has accumulated in the pump.
) stated on the nameplate.
max
Subject to alterations.
5
46
Denmark
GRUNDFOS DK A/S Martin Bachs Vej 3 DK-8850 Bjerringbro Tlf.: +45-87 50 50 50 Telefax: +45-87 50 51 51 E-mail: info_GDK@grundfos.com www.grundfos.com/DK
Argentina
Bombas GRUNDFOS de Argentina S.A. Ruta Panamericana km. 37.500 Lote 34A 1619 - Garin Pcia. de Buenos Aires Phone: +54-3327 414 444 Telefax: +54-3327 411 111
Australia
GRUNDFOS Pumps Pty. Ltd. P.O. Box 2040 Regency Park South Australia 5942 Phone: +61-8-8461-4611 Telefax: +61-8-8340 0155
Austria
GRUNDFOS Pumpen Vertrieb Ges.m.b.H. Grundfosstraße 2 A-5082 Grödig/Salzburg Tel.: +43-6246-883-0 Telefax: +43-6246-883-30
Belgium
N.V. GRUNDFOS Bellux S.A. Boomsesteenweg 81-83 B-2630 Aartselaar Tél.: +32-3-870 7300 Télécopie: +32-3-870 7301
Belorussia
Представительство ГРУНДФОС в Минске 220090 Минск ул.Олешева 14 Теле фон: (8632) 62-40-49 Факс: (8632) 62-40-49
Bosnia/Herzegovina
GRUNDFOS Sarajevo Paromlinska br. 16, BiH-71000 Sarajevo Phone: +387 33 713290 Telefax: +387 33 231795
Brazil
GRUNDFOS do Brasil Ltda. Rua Tomazina 106 CEP 83325 - 040 Pinhais - PR Phone: +55-41 668 3555 Telefax: +55-41 668 3554
Bulgaria
GRUNDFOS Pumpen Vertrieb Representative Office - Bulgaria Bulgaria, 1421 Sofia Lozenetz District 105-107 Arsenalski blvd. Phone: +359 2963 3820, 2963 5653 Telefax: +359 2963 1305
Canada
GRUNDFOS Canada Inc. 2941 Brighton Road Oakville, Ontario L6H 6C9 Phone: +1-905 829 9533 Telefax: +1-905 829 9512
China
GRUNDFOS Pumps (Shanghai) Co. Ltd. 22 Floor, Xin Hua Lian Building 755-775 Huai Hai Rd, (M) Shanghai 200020 PRC Phone: +86-512-67 61 11 80 Telefax: +86-512-67 61 81 67
Croatia
GRUNDFOS predstavništvo Zagreb Cebini 37, Buzin HR-10000 Zagreb Phone: +385 1 6595 400 Telefax: +385 1 6595 499
Czech Republic
GRUNDFOS s.r.o. Čapkovského 21 779 00 Olomouc Phone: +420-585-716 111 Telefax: +420-585-716 299
Estonia
GRUNDFOS Pumps Eesti OÜ Peterburi tee 44 11415 Tallinn Tel: + 372 606 1690 Fax: + 372 606 1691
Finland
OY GRUNDFOS Pumput AB Mestarintie 11 FIN-01730 Vantaa Phone: +358-3066 5650 Telefax: +358-3066 56550
France
Pompes GRUNDFOS Distribution S.A. Parc d’Activités de Chesnes 57, rue de Malacombe F-38290 St. Quentin Fallavier (Lyon) Tél.: +33-4 74 82 15 15 Télécopie: +33-4 74 94 10 51
Germany
GRUNDFOS GMBH Schlüterstr. 33 40699 Erkrath Tel.: +49-(0) 211 929 69-0 Telefax: +49-(0) 211 929 69-3799 e-mail: infoservice@grundfos.de Service in Deutschland: e-mail: kundendienst@grundfos.de
Greece
GRUNDFOS Hellas A.E.B.E. 20th km. Athinon-Markopoulou Av. P.O. B ox 71 GR-19002 Peania Phone: +0030-210-66 83 400 Telefax: +0030-210-66 46 273
Hong Kong
GRUNDFOS Pumps (Hong Kong) Ltd. Unit 1, Ground floor Siu Wai Industrial Centre 29-33 Wing Hong Street & 68 King Lam Street, Cheung Sha Wan Kowloon Phone: +852-27861706 / 27861741 Telefax: +852-27858664
Hungary
GRUNDFOS Hungária Kft. Park u. 8 H-2045 Törökbálint, Phone: +36-23 511 110 Telefax: +36-23 511 111
India
GRUNDFOS Pumps India Private Limited 118 Old Mahabalipuram Road Thoraipakkam Chamiers Road Chennai 600 096 Phone: +91-44 2496 6800
Indonesia
PT GRUNDFOS Pompa Jl. Rawa Sumur III, Blok III / CC-1 Kawasan Industri, Pulogadung Jakarta 13930 Phone: +62-21-460 6909 Telefax: +62-21-460 6910 / 460 6901
Ireland
GRUNDFOS (Ireland) Ltd. Unit A, Merrywell Business Park Ballymount Road Lower Dublin 12 Phone: +353-1-4089 800 Telefax: +353-1-4089 830
Italy
GRUNDFOS Pompe Italia S.r.l. Via Gran Sasso 4 I-20060 Truccazzano (Milano) Tel.: +39-02-95838112 Telefax: +39-02-95309290 / 95838461
Japan
GRUNDFOS Pumps K.K. 1-2-3, Shin Miyakoda Hamamatsu City Shizuoka pref. 431-21 Phone: +81-53-428 4760 Telefax: +81-53-484 1014
Korea
GRUNDFOS Pumps Korea Ltd. 6th Floor, Aju Building 679-5 Yeoksam-dong, Kangnam-ku, 135-916 Seoul, Korea Phone: +82-2-5317 600 Telefax: +82-2-5633 725
Latvia
SIA GRUNDFOS Pumps Latvia Deglava biznesa centrs Augusta Deglava ielā 60, LV-1035, Rīga, Tālr.: + 371 714 9640, 7 149 641 Fakss: + 371 914 9646
Lithuania
GRUNDFOS Pumps UAB Smolensko g. 6 LT-03201 Vilnius Tel: + 370 52 395 430 Fax: + 370 52 395 431
Malaysia
GRUNDFOS Pumps Sdn. Bhd. 7 Jalan Peguam U1/25 Glenmarie Industrial Park 40150 Shah Alam Selangor Phone: +60-3-5569 2922 Telefax: +60-3-5569 2866
México
Bombas GRUNDFOS de México S.A. de C.V. Boulevard TLC No. 15 Parque Industrial Stiva Aeropuerto Apodaca, N.L. 66600 Phone: +52-81-8144 4000 Telefax: +52-81-8144 4010
Netherlands
GRUNDFOS Nederland B.V. Postbus 104 NL-1380 AC Weesp Tel.: +31-294-492 211 Telefax: +31-294-492244/492299
New Zealand
GRUNDFOS Pumps NZ Ltd. 17 Beatrice Tinsley Crescent North Harbour Industrial Estate Albany, Auckland Phone: +64-9-415 3240 Telefax: +64-9-415 3250
Norway
GRUNDFOS Pumper A/S Strømsveien 344 Postboks 235, Leirdal N-1011 Oslo Tlf.: +47-22 90 47 00 Telefax: +47-22 32 21 50
Poland
GRUNDFOS Pompy Sp. z o.o. ul. Klonowa 23 Baranowo k. Poznania PL-62-081 Przeźmierowo Phone: (+48-61) 650 13 00 Telefax: (+48-61) 650 13 50
Portugal
Bombas GRUNDFOS Portugal, S.A. Rua Calvet de Magalhães, 241 Apartado 1079 P-2770-153 Paço de Arcos Tel.: +351-21-440 76 00 Telefax: +351-21-440 76 90
România
GRUNDFOS Pompe România SRL Bd. Biruintei, nr 103 Pantelimon county Ilfov Phone: +40 21 200 4100 Telefax: +40 21 200 4101 E-mail: romania@grundfos.ro
Russia
ООО Грундф ос Россия, 109544 Москва, Школьная 39 Тел. (+7) 095 737 30 00, 564 88 00 Факс (+7) 095 737 75 36, 564 88 11
E-mail grundfos.moscow@grundfos.com
Serbia
GRUNDFOS Predstavništvo Beograd Dr. Milutina Ivkovića 2a/29 YU-11000 Beograd Phone: +381 11 26 47 877 / 11 26 47 496 Telefax: +381 11 26 48 340
Singapore
GRUNDFOS (Singapore) Pte. Ltd. 24 Tuas West Road Jurong Town Singapore 638381 Phone: +65-6865 1222 Telefax: +65-6861 8402
Slovenia
GRUNDFOS PUMPEN VERTRIEB Ges.m.b.H., Podružnica Ljubljana Blatnica 1, SI-1236 Trzin Phone: +386 1 563 5338 Telefax: +386 1 563 2098 E-mail: slovenia@grundfos.si
Spain
Bombas GRUNDFOS España S.A. Camino de la Fuentecilla, s/n E-28110 Algete (Madrid) Tel.: +34-91-848 8800 Telefax: +34-91-628 0465
Sweden
GRUNDFOS AB Lunnagårdsgatan 6 431 90 Mölndal Tel.: +46-0771-32 23 00 Telefax: +46-31 331 94 60
Switzerland
GRUNDFOS Pumpen AG Bruggacherstrasse 10 CH-8117 Fällanden/ZH Tel.: +41-1-806 8111 Telefax: +41-1-806 8115
Taiwan
GRUNDFOS Pumps (Taiwan) Ltd. 7 Floor, 219 Min-Chuan Road Taichung, Taiwan, R.O.C. Phone: +886-4-2305 0868 Telefax: +886-4-2305 0878
Thailand
GRUNDFOS (Thailand) Ltd. 947/168 Moo 12, Bangna-Trad Rd., K.M. 3, Bangna, Phrakanong Bangkok 10260 Phone: +66-2-744 1785 ... 91 Telefax: +66-2-744 1775 ... 6
Turkey
GRUNDFOS POMPA San. ve Tic. Ltd. Sti. Gebze Organize Sanayi Bölgesi Ihsan dede Caddesi,
2. yol 200. Sokak No. 204 41490 Gebze/ Kocaeli Phone: +90 - 262-679 7979 Telefax: +90 - 262-679 7905 E-mail: satis@grundfos.com
Ukraine
ТОВ ГРУНДФОС Ук раина ул. Владимирская, 71, оф. 45 г. Киев, 01033, Украина, Тел. +380 44 289 4050 Факс +380 44 289 4139
United Arab Emirates
GRUNDFOS Gulf Distribution P.O. Box 16768 Jebel Ali Free Zone Dubai Phone: +971-4- 8815 166 Telefax: +971-4-8815 136
United Kingdom
GRUNDFOS Pumps Ltd. Grovebury Road Leighton Buzzard/Beds. LU7 8TL Phone: +44-1525-850000 Telefax: +44-1525-850011
U.S.A.
GRUNDFOS Pumps Corporation 17100 West 118th Terrace Olathe, Kansas 66061 Phone: +1-913-227-3400 Telefax: +1-913-227-3500
Usbekistan
Представительство ГРУНДФОС в Ташкенте 700000 Ташк ент ул.Ус мана Носира 1-й тупик 5 Телефон: (3712) 55-68-15 Факс: (3712) 53-36-35
Addresses revised 10.01.2007
Being responsible is our foundation
Thinking ahead makes it possible
Innovation is the essence
96528411 0207
Repl. 96528411 1006
www.grundfos.com
157
Loading...