grillsteram GSZIGGYG, GSZIGGYR, GSZIGGYBL Assembly And Operating Instructions Manual
Assembly and operating instructions for ZIGGY gas barbecues
GSZIGGYG, GSZIGGYR, GSZIGGYBL
Pictures are not to scale.
Specifications subject to change
without prior notice.
For outdoor use only. Not for commercial use.
•
Read instructions before using the appliance. Failure to follow instructions could
•
result in death, serious bodily injury, and/or property loss.
Warning: accessible parts may be very hot. Keep young children and pets away.
•
Do not move the appliance during use.
•
Any modification of the appliance, misuse, or failure to follow the instructions may be
•
dangerous and will invalidate your warranty. This does not effect your statutory rights.
Retain these instructions for future reference.
•
Leak test regularly, and whenever the gas bottle is removed or replaced. Check that the
•
the hose connections are tight and leak test each time you reconnect the gas bottle.
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open barbecue lid or hood.
4. If odour continues, discontinue use and contact
your local dealer.
0052-13
FOR YOUR SAFETY
1. Do not store or use petrol or other flammable
vapours or liquids in the vicinity of this or any
other appliance.
2. A gas bottle not connected for use must not be
stored in the vicinity of this or any other
appliance.
ZIGGY
WARNING INFORMATION
- Read this Operating Manual before use
- Ensure there is adequate clearance away from flammable materials
- This bbq is only to be used outdoors - NEVER take a lit BBQ into a tent,
caravan or cabin
- Do not allow children to operate the bbq
- Accessible parts may be very hot, keep children away
- Any modification of this bbq may be dangerous
- Do not move this bbq during use
- When you have finished cooking, turn off the gas cylinder before you turn off
the BBQ controls - this means any gas in the pipeline will be used up
- Parts sealed by the manufacturer or their agent must not be
manipulated by the user
- BBQ specifications can be found on the data label attached on the
side panel of the bbq frame
LOCATION OF YOUR BBQ
IMPORTANT - BBQS MUST BE INSTALLED IN ACCORDANCE WITH
THE MANUFACTURER’S INSTALLATION INSTRUCTIONS, LOCAL
GAS FITTING REGULATIONS AND MUNICIPAL BUILDING CODES.
Think carefully when deciding on a location where you are to use your
bbq. The bbq must not be installed under or on any combustible
material and must be a level surface.
Minimum clearance from any combustible materials on ALL sides is
250mm (10”). Minimum clearance from any combustible material from
the TOP of the bbq is 1500mm (59”). (Fig. 1)
- Do not store or use petrol or other flammable vapours and liquids
near the bbq
- Do not store empty or full spare gas cylinders under or near the bbq
- Keep the gas hose and any electrical cord away from hot surfaces
- Avoid unnecessary twisting of the gas hose
- Visually inspect hose prior to each use for cuts, cracks, excessive
wear or other damage
- The hose must be replaced if damaged and when National Conditions
require it
- Never light the bbq with the hood or lid closed
- Never lean over the cooking surface whilst lighting the bbq
- Use bbq tools with heat proof handles or good quality insulated oven
mitts when operating bbq
- Never alter or modify the regulator or gas supply assembly
1500mm Minimum
250mm
Minimum
250mm
Minimum
250mm
Minimum
- Not to be used in garages, porches, breezeways, sheds, or other
enclosed areas
- Not to be used on recreational vehicles
- Do not obstruct flow of combustion and vetilation air around the bbq
CONNECTING THE GAS CYLINDER
There are two different types of gas that can be used on your gas bbq
depending on where you live, that being either butane or propane gas.
Both are supplied in gas cylinders. The connection between the gas
cylinder and the bbq is made with a regulator. (Fig. 2)
(Fig. 2)
It is important that you use the correct regulator for the particular type
of gas you purchase. See your local gas dealer for information on
purchasing the correct regulator. Never operate this bbq without a gas
regulator.
THE HOSE AND REGULATOR ASSEMBLY (Fig. 3)
- Must be suitable for liquefied petroleum gas (LPG)
- Must withstand the above pressures
- Must not exceed 1000mm (39”) in length
- The bbq is supplied with a screw on hose that is suitable for direct
connection of a suitable regulator
- Before connecting inspect the hose, its fittings and rubber seals. If
there is any sign of cracking, splitting or wear, have the hose
replaced
- While in use, keep the hose unobstructed and free of kinks and
twisting
250mm
Minimu
m
(Fig. 1)
The following gas supply pressures are a guide only:
ITEM:BG1320C2&BG1320D2
0052-13
(5.2kw)
Country of destination Category/ies Type of gas Supply pressure (mbar)
AT - DE - CH
PL I3B/P 7313G/03G
FI - NO - SE - DK - NL
EE - LT - LV - CY - MT
RO - HU -SK - SI - SE
CZ- FR - BE - LU - GB
IE - LT - SK - GR - PT
ES - IT - CH
“Use outdoors only.”
“Read the instructions before using the appliance.”
“WARNING: accessible parts may be very hot. Keep young children away.”
GB
I3+
G30 – 378 g/h， G31 – 372 g/h；
I3B/P G30/G31
I3B/P 0313G/03G
I3+ 73/03-8213G/03G
G30/G31 28-30/
37mbar
50
NOTE: Hose and Regulator
picture for reference only.
(Fig. 3)
Exploded View
ZIGGY
21
22
1
5
6
4
13
15
28
18
19
2
27
12
11
10
23
3
7
9
8
4
1
16
17
20
26
Parts List
1. LID
2. LID HANDLE
LID PIN (2)
3.
4.
LID HANDLE PAD (2)
5.
THERMOMETER
LOGO
6.
HAIR PIN (2)
7.
8.
BODY
9.
BODY SUP (2)
KNOB ASSEM (2)
10.
KNOB SEAT(2)
11.
12.
CONTROL PANEL
13.
GRILLSTREAM COOKING GRILLS (4)
LEFT U BURNER ASSEM
14.
24
25
15.
RIGHT U BURNER ASSEM
16.
GAS TANK ISOLATION
17.
OIL CUP
18.
PF PAD (8)
19.
MAIN VALVE
BODY SUP BEAM (2)
20.
LEAD FIRE BOX
21.
ALUMINIUM FOIL CUP
22.
REGULATOR (IF SUPPLIED)
23.
VALVE PIPE FIXED
24.
IGNITION STICK ASSEM
25.
SIDE SHELF (2)
26.
GRILL RISER
27.
FLAME TAMER
28.
Pre-Assembled Component
Quantity varies according to model purchased. Specifications subject to change without prior notice.
Loading...