Green Transporter Q Pod Owner's Manual

Q Pod

Owners Manual

Q-Pod

FOREWORD

Thank you for choosing our Q-Pod. Before driving, please read this manual to know
your vehicle well.

All data referred in this manual is up to the minute. As we are constantly updating
our vehicles, this manual may be renewed without immediate notice.

Note: optional equipment are also described in this manual. So there may be
some explanations not applicable to your vehicle.

ATTENTION

1. Inspection before driving:

- if all the lamps are working well;

- if windshield and rear-view mirrors are clean;

- if the position of rear-view mirrors are right;

- check the tire pressure and tire abrasion condition;

2. Braking

- avoid vehicle sliding when the power flameout;

- the abrasion of the brake lining depends on working condition, and its replacing
frequency depends on the driver’s habit and braking mode;

- make sure parking brake has been drawn back before leaving the vehicle;

3. If any warning tell-tale lighting during driving, please park the vehicle and check
at once;

4. Electric appliance accessories

- all electric appliance accessories should be connected on the required position in
right way

5. Please maintain the vehicle according to the maintenance plan;

6. All the operations should conform to this manual. We are not responsible for
any direct or indirect damages resulting from incorrect operations;

7. No unauthorized refit should be made, especially with such essential parts as
electric appliances, braking, steering, suspensions and tire systems. We are free of
any responsibility for any direct or indirect damage due to unauthorized refits.

8. We beg your pardon for the vehicle is constantly updating, descriptions and
figures in this manual may be not conform to the vehicle completely.

Section 1 Important note

■ This signal note the best way to use your vehicle.

This signal with warning information, please read it carefully to avoid damaging

vehicle and for your and your family safety.

This signal is safety warning, means “can not”, “can not do that...” or “can not

make”.

Section 2 Vehicle instruction and dash board

Vehicle instruction Pic-1

1, Front windshield 2, Rearview Mirror 3, Wiper 4, Headlight 5, Left turning
light 6, Front wheel 7, Rear wheel 8, Door

Vehicle instruction Pic-2

1, Rear Window 2, Rear combination lamp 3, Rear glove box

Dash board Pic

1, Steering wheel 2, Left handle grip 3, Switch of headlight 4, Emergency lamp
5, Wiper switch 6, Door handle 7, Meter board 8, Gearshift switch 9,Right throttle
grip 10, Main switch 11, Brake pedal

Seat Pics

1, Rear seat
2, Front foldable seat
3, Brake handle
4, Seat adjustable handle

Section 3 Start and driving

1. Start note

■ Make sure the charger has been unplugged;

■ Key on motor, make sure every indicator and signal lamps are normal.

2. Start Procedure

(1) Turn on ignition switch, meter and indicator self-inspection;
(2) Shift to D or R position;
(3) Release parking handle, turn throttle grip gently.

Please don’t step on brake pedal heavily when start vehicle, please turn the

throttle grip gently to avoid damaging vehicle.

3. Stop vehicle

Please operate base on following step:

(1) Return throttle grip, stop the vehicle,then pull parking handle tight then turn

off vehicle;

(2) If stop vehicle on steep slope, please turn wheel to side walk and jam the

wheel by stone or block, if long time to leave the vehicle, please press emergency
switch and cut off main power.

(3)Don’t put key at “ ON” position to avoid battery discharge. And remember pull

the key out, press emergency button.

(4) Don’t let the children stay in the car alone, and pull the key out and take the

keys away if you leave the vehicle.

4. Parking

(1) Pull up parking lever, don’t press the button.
(2) Before driving, make sure release parking lever completely. The concrete
procedure is: press button then pull up lever then release lever down.

If parking brake is not release completely, will make brake parts overheat,

effect the brake performance and wear out brake parts

Make sure pull parking lever up tight especially when park the vehicle on steep

slope.

(3) Parking note:

A. When park the vehicle on uphill, please shift to D gear, and turn the wheel

to sidewalk.

B. When park the vehicle downhill, please shift to D gear, and turn the wheel to

sidewalk, jam the wheel by stone or block.

C. Please take keys away if leave the vehicle, press emergency switch and

lock all doors, please try to park your vehicle on lighting place.

5. Brake system

(1) All of brake system parts are safety parts, so please maintain your vehicle
in after-sale service center.
(2) Brake system use hydraulic brake, the braking effect is more clear, effective.
Please stop your vehicle if brake system has the faults, and contact nearby
service center immediately.
(3) When driving in the rain, through large puddles, or after washing, the brake
discs can form a layer of water film, it will influence the normal braking

effect,

if

this happens, please driving slowly and check brake performa nce, till ensure

no problems then driving normally.

■ Specially note: please replace the brake tube in repairing it to ensure the seal.

6. Shift using

Please stop vehicle before shifting, shift to D gear,

vehicle will run forward, shift to R gear, vehicle will run
backward. Please note , must stop vehicle, then can
shift to D or R gear as controller has the protect function

to ensure the service life of the motor.

7. Economy speed

Please drive the vehicle in constant speed to maximum the range. Driver can
adjust the speed base on vehicle condition and loading.

8. Preparation before driving

(1) Ensure safety, please inspect seat, brake, environment etc.
(2) Please make sure that has locked side doors, inspect rearview mirrors.
(3) Inspect all of indicators on meter are ok.
(4)Check the tire tread and the degree of wear. Pay attention to whether the
stone, nails, glass or other sharp objects on tread, whether a drum kit, scratch,
abrasion and other deficiencies. Once found, please replace the tire
immediately, and inspect the causes of abnormal wear. Check the tire nuts and
tighten degree, tire pressure is appropriate or not.
(5) Please check side turning lamp, turning signal and other indicators on
meter are ok or not.
(6) Step on the brake pedal many times, should can feel a little resistance. If