perating Instructions
O
for 10M Rod Kits
DR10 & GR10 (Luminescent)
SAFETY
PLEASE NOTE -
Fibreglass is a mild irritant to those
ith sensitive skin. Wearing gloves is
w
recommended when using the rods.
If you have a reaction (redness or
ild itching) wash your hands
m
throughly. If the reaction persists for
longer than 48 hours consult a doctor.
INSTRUCTIONS
To maintain the integrity and flexibility
of this product it is essential to keep the
threaded parts fully mated. Failure to
do so may cause the threads to snap
and invalidate the warranty.
Keep threads free of dust and debris.
Regularly clean them with a stiff brush.
Do not lubricate the threads as this will
attract debris and/or allow rods to
easily unscrew.
If the rods get caught on an
obstruction do not force them. Gently
ease the rods back and forth. If the
rods meet an obstruction e.g. a joist, try
‘flicking’ them to make the end
‘jump’ over.
REPAIRS
Cleanly cut off damaged part of rod.
If necessary carefully drill/ream out
any fibreglass and/or residual glue
from the metal end.
Glue the metal end onto the rod with
a good quality super glue.
All Rod measurements are nominal.
We reserve the right to change the
design and specification to improve
quality and enhance performance.
RECOMMENDED MINIMUM
BEND RADIUS OF JOINED RODS
If joined rods are bent beyond the
following recommended rates of
bend, the rod and/or brass fitting may
be damaged as a result of bending.
)
m
m
0
2
adius
R
(2
SHORT RODS
Shorter rods will flex to the same bend
radius as above but greater care
must be taken because of the
increased stiffness caused by metal
end fittings.
WARNING -
DAMAGE CAN BE CAUSED BY OVER
BENDING RODS
TIPS AND TRICKS
When drilling a hole through to a
restricted cavity, angle the hole in the
direction you want the rods to go. It
will reduce the bending load and
minimise the chance of the rod end
catching.
Always rotate connected rods
clockwise to avoid them unscrewing
in use.
Use the most appropriate cable
handling accessory.
A flexi lead should be employed to
help ease rods round corners.
The way in which you use your rods is
limited only by your imagination!
PLEASE KEEP THESE INSTRUCTIONS
SAFE FOR FUTURE REFERENCE
GUARANTEE
Your Norslo Draw Rod Kit
is guaranteed for 1 year from
This is in addition to your statutory rights.
the date of purchase.
WEST ROAD . HARLOW
ESSEX . CM20 2BG . UK
info@greenbrook.co.uk
www.greenbrook.co.uk
Issue no: 705305
Loading...