Green CIR-UB7000-G Owner's Manual

Owner's Manual

Full Commercial Upright Bike

Full Commercial Light Commercial

Install Date: _________________________ Serial Number: ________________________

www.GreenSeriesFitness.com ©June 2015 Call Toll free at [phone]

CIR-UB7000-G

CIR-UB7000-G Revision 1.1

TABLE OF CONTENTS

SAFETY PRECAUTIONS …………………………………………………………………..2-3

Important voltage information, grounding instructions, how often you exercise,
how hard you exercise, how long you exercise, beginner treadmill program,
target heart rate zone.

TECHNICAL SPECIFICATIONS …………………………………………………………….4

UNPACKING & ASSEMBLY …………………………………………………………..…5-14

Parts, hardware kit and assembly drawing

WARM UP & COOL DOWN …………………………………………………………….…..15

PANEL CONTROL & PROGRAM ……………………………………………………...16-24

Control panel function and programs

CARE & MAINTENANCE …………………………………………………………….....25-26

WARRANTY …………………………………………………………………………..…..27-30

www.GreenSeriesFitness.com ©June 2015 Call Toll free at [phone]

CIR-UB7000-G Revision 1.1

1

SAFETY PRECAUTIONS

Dear Customer,

Thank you for your purchasing our products. This product has been designed and manufactured for full
commercial use, even though we go to great efforts to ensure the quality of each product, occasional
error, and/or omissions do occur. In any event should you find this product to be defective or missing
parts please contact us.

IMPORTANT: Read all instructions and warnings before assembly and operation.

‧‧‧‧

Only one person at a time should use this equipment. If dizziness, nausea, chest pains, or any

other abnormal symptoms are experienced while using this upright bike, stop the workout at once.

‧‧‧‧

Warning: incorrect/ excessive training can cause health injuries. Stop using the upright bike when

feeling uncomfortable.

‧‧‧‧

Consult your physician before starting a workout or training program. Have your doctor review your

training and diet programs to advise you of a workout routine you should adopt.

‧‧‧‧

Always use this upright bike on a clear and level surface. Do not use outdoors or near water.

‧‧‧‧

Don't insert any object into any openings.

‧‧‧‧

Before using this equipment to exercise, always do stretching exercises to properly warm up.

‧‧‧‧

Replace defective components immediately and keep the equipment out of use until repair.

‧‧‧‧

This product is designed for adults. Please ensure that children only use it under the supervision of

an adult.

‧‧‧‧

Make sure that all bolts and nuts are tightened when equipment is in use. Periodic maintenance is

required on all exercise equipment to keep it in good condition.

‧‧‧‧

Close supervision is necessary when this appliance is used by, on, or near children,

invalids, or disabled persons.

‧‧‧‧

Use this appliance only for its intended use as described in this manual. Do not use attachments,

not recommended by the manufacture.

‧‧‧‧

Never operate the appliance with the air openings blocked. Keep the air openings free of lint, hair,

and the like.

‧‧‧‧

Never drop or insert any object into any opening.

‧‧‧‧

Do not use outdoors.

‧‧‧‧

The appliance is intended for commercial use.

‧‧‧‧

Maximum user weight: 500Ibs (227 kg).

www.GreenSeriesFitness.com ©June 2015 Call Toll free at [phone]

CIR-UB7000-G Revision 1.1

2

SAFETY PRECAUTIONS

before starting any exercise program consult your physician. This is especially

CONSULT A PHYSICIAN IMMEDIATELY

Warning:

important for individuals over the age of 35 or persons with preexisting health problems. Read
all instructions before using any fitness equipment. We assume no responsibility for personal
injury damage sustained by or through the use of this treadmill.

U

How often you exercise:

You should exercise three to four times a week to improve your cardiovascular and muscle fitness.

U

How hard you exercise:

Intensity of exercise is reflected in your heart rate. Exercise must be sufficiently rigorous to strengthen
your heart muscle and condition your cardiovascular system.
Only your doctor can prescribe the target training heart range for you. Before starting any exercise
program consult your physician.

U

How long you exercise:

Sustained exercise conditions your heart, lungs and muscles. The longer you are able to sustain
exercise within your target heart range, the greater the aerobic benefits. To begin maintain 2~3
minutes of steady, rhythmic exercise, then check your heart rate.

www.GreenSeriesFitness.com ©June 2015 Call Toll free at [phone]

CIR-UB7000-G Revision 1.1

3

TECHNICAL SPECIFICATIONS

SPECIFICATIONS:

Length: 41” (104 cm)
Width: 27” (69cm)
Height: 58” (147 cm)
Weight of product: 135lbs (61kgs)

Program：9 programs, 4 HRC
Standard features: 6 LED+8x32 dot matrix HR receive

Resistance System：Electromagnet
Power source：Built-in generator & rechargeable battery 12V-1.2AH

www.GreenSeriesFitness.com ©June 2015 Call Toll free at [phone]

CIR-UB7000-G Revision 1.1

4

UNPACKING & ASSEMBLY

Parts

Main frame / 1pc

Console upright Tube /

#4-19 #4-11 #4-10 #4-9 #4-14

Console set X 1pc Handlebar X 1pc Pedal set X 1set Upper water bottle

Lower water bottle
holder cover X1pc

Rear stabilizer cover

www.GreenSeriesFitness.com ©June 2015 Call Toll free at [phone]

#2-1 #4-1 #4-2

Front stabilizer X 1pc

1pc

#4-5 #4-8 #4-7

Upright tube cover, right

x1pc

CIR-UB7000-G Revision 1.1

/ left x1 set

Rear stabilizer X 1pc

holder cover X1pc

5

Hardware kit

#4-3

M8x20mm

UNPACKING & ASSEMBLY

#4-12

M8x65mm

#4-13

M8 curve

#4-6

X 1

(handlebar)

#4-17

M4x20mm

(lower water bottle

X 2

holder cover)

(handlebar)

Allen wrench

(6mm)

X 2

X 1

(handlebar)

Allen wrench

(5mm)

X 2

X 1

X 2

(rear stabilizer)

M15/M15 M4x12mm

X 1

www.GreenSeriesFitness.com ©June 2015 Call Toll free at [phone]

CIR-UB7000-G Revision 1.1

6

UNPACKING & ASSEMBLY

Unpacking your bike where will be using it. Being careful not to damage. Place your bike on a level flat

surface. It is recommended that you place a protective covering on your floor.

1

Step1: Assembling Front/Rear Stabilizer with main frame.

1).Using (2) M8x20mm screw and Washer，fixing front stabilizer with main frame.

2).Using (2) of M8x20mm screw and washer，fixing rear stabilizer with main frame.

#4-1

X1

#4-2

#4-3

M8x20mm

#4-4

M8

X1

X 4

X 4

www.GreenSeriesFitness.com ©June 2015 Call Toll free at [phone]

CIR-UB7000-G Revision 1.1

7

UNPACKING & ASSEMBLY

2

Step2: Assembling Rear Stabilizer cover with main frame.

1).Using (2) of M4x12mm screw, fixing rear Stabilizer cover with main frame.

#4-5

X1

M4x12mm

#4-6

X 2

www.GreenSeriesFitness.com ©June 2015 Call Toll free at [phone]

CIR-UB7000-G Revision 1.1

8

UNPACKING & ASSEMBLY

3

Step3: Assembling upright tube cover, right / left with handle bar post

1).Using wrench, fixing pedal set with crank set.

#4-10 #4-9

X1 set

www.GreenSeriesFitness.com ©June 2015 Call Toll free at [phone]

CIR-UB7000-G Revision 1.1

9