Gravely ZT 2250, Zero Turn 2250, 992041 Owner's And Operator's Manual
ZT 2250
Owner/Operator Manual
Models
992041 - Zero Turn 2250
US Patent 6,301,864
ENGLISH
FRANÇAIS
ESPAÑOL
08494000A 12/01
Supersedes 08494000
Printed in USA
Figure 1
OF3200
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
ENGLISH
1. Mower Deck with Chute
Deflector
2. Fuel Shut Off Valve
3. Parking Brake
4. Battery
5. Height of Cut Indicator
6. Hydraulic Oil Reservoir
7. Cylinder Stops
8. Fuel Tanks and Caps
9. Choke Control
10. Throttle Lever
11. Ignition Switch
12. Power Take Off (PTO)
Switch
13. Steering Levers
14. Mower Lift Lever
15. Seat Adjustment Lever
16. Cylinder Stop Storage Post
FRANÇAIS
1. Carter de coupe avec
déflecteur
2. Robinet de carburant
3. Frein de stationnement
4. Batterie
5. Indicateur de hauteur de
coupe
6. Réservoir d’huile
hydraulique
7. Butées de vérin
8. Réservoirs de carburant et
bouchons
9. Starter
10. Manette des gaz
11. Contacteur de démarrage
12. Contacteur de régime de la
PdF
vérin
13. Leviers de direction
14. Levier de relevage de la tondeuse
15. Levier de réglage du siège
16. Montant de remisage de butées de
CONTROLS AND FEATURES
ESPAÑOL
1. Plataforma de corte
2. Válvula de cierre de combustible
3. Freno de estacionamiento
4. Batería
5. Altura del indicador de corte
6. Depósito de aceite hidráulico
7. Topes de cilindro
8. Tapas y depósitos de combustible
9. Control de aire
10. Palanca de ralentí
11. Interruptor de encendido
12. Interruptor de la toma de fuerza
(TDF)
13. Palancas de dirección
14. Palanca de elevación del
cortacésped
15. Palanca de ajuste del
asiento
16. Poste de almacenamiento
del tope del cilindro
2
WARNING
The engine exhaust from this product
contains chemicals known to the State
of California to cause cancer, birth
defects or other reproductive harm.
OL4030
TABLE OF CONTENTS
Controls and Features . . . . . . . . . . . . . . . . . . . . . 2
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Service and Adjustments . . . . . . . . . . . . . . . . . . 14
INTRODUCTION
THE MANUAL
Before operation of unit, carefully and completely read
your manuals. The contents will provide you with an
understanding of safety instructions and controls during
normal operation and maintenance.
All reference to left, right, front, or rear are given from
operator sitting in the operation position and facing the
direction of forward travel.
MODEL AND SERIAL NUMBERS
Transfer
model & serial
number
label from
product
registration
here.
• Record Unit Model and Serial numbers here.
• Record Engine Model and Serial numbers here.
When ordering replacement parts, or
making service inquiries, know the
Model and Serial numbers of your unit
and engine.
Numbers are located on the product
registration form in the unit literature
package. They are printed on a serial
number label, located on the frame of
your unit (Figure 2).
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Service Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . .20
Specifications. . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
UNAUTHORIZED REPLACEMENT PARTS
Use only Gravely replacement parts. The replacement of
any part on this equipment with anything other than an
Gravely authorized replacement part may adversely affect
the performance, durability, and safety of this unit and may
void the warranty. Gravely disclaims liability for any claims
or damages, whether regarding warranty, property
damage, personal injury or death arising out of the use of
unauthorized replacement parts.
DISCLAIMER
Gravely reserves the right to discontinue, change, and
improve its products at any time without public notice or
obligation to the purchaser. The descriptions and
specifications contained in this manual were in effect at
printing. Equipment described within this manual may be
optional. Some illustrations may not be applicable to your
unit.
DELIVERY
Customer Note: If you have purchased this product
without complete assembly and instruction by your
retailer, it is your responsibility to:
1. Read and understand all assembly instructions in
this manual. If you do not understand or have
difficulty following the instructions, contact your
nearest GravelyDealer for assistance. Make sure all
assembly has been properly completed and safety
interlock system works properly.
NOTE: To locate your nearest Gravely Dealer, call
1-800-472-8359 or go to www.gravely.com on the internet.
Serial Number Label
Figure 2
OF1615
GB - 3
WARNING: Improper assembly or
adjustments can cause serious injury.
2. Understand all Safety Precautions provided in the
manuals.
3. Review control functions and operation of the unit.
Do not operate unit unless all controls function as
described in this manual.
4. Review recommended lubrication, maintenance,
and adjustments.
© Copyright 2001 Ariens Company
5. Fill out Original Purchaser Registration Card and
return the card to Gravely Company.
SAFETY
SAFETY ALERT SYMBOL
These are safety alert symbols. They
mean:
• ATTENTION!
OL1253
OL3900
The safety alert symbols above and signal words below
are used on decals and in this manual.
Read and understand all safety messages.
DANGER: IMMINENTLY HAZARDOUS
SITUATION! If not avoided, WILL RESULT in
death or serious injury.
WARNING: POTENTIALLY HAZARDOUS
SITUATION! If not avoided, COULD RESULT in
death or serious injury.
• YOUR SAFETY IS INVOLVED!
When you see this symbol:
• BECOME ALERT!
• OBEY THE MESSAGE!
PRACTICES AND LAWS
Practice usual and customary safe working precautions,
for the benefit of yourself and others. Understand and
follow all safety messages. Be alert to unsafe conditions
and the possibility of minor, moderate, or serious injury or
death. Learn applicable rules and laws in your area.
REQUIRED OPERATOR TRAINING
Original purchaser of this unit was instructed by the seller
on safe and proper operation. If unit is to be used by
someone other than original purchaser (loaned, rented or
sold), ALWAYS provide this manual and any needed
safety training before operation.
CAUTION: POTENTIALLY HAZARDOUS
SITUATION! If not avoided, MAY RESULT in
minor or moderate injury. It may also be used to
alert against unsafe practices.
NOTATIONS
NOTE: General reference information for proper opera-
tion and maintenance practices.
IMPORTANT: Specific procedures or information
required to prevent damage to unit or attachment.
GB - 4
1.
SAFETY DECALS AND LOCATIONS
ALWAYS replace missing or damaged Safety Decals.
Refer to Figure 3 for Safety Decal locations.
5
• Avoid injury - Stay clear of rotating parts.
• Risque de blessures - ne pas s’approcher des pièces en
mouvement.
• Evitar lesiones - Mantenerse alejado de las piezas giratorias.
5
• Avoid injury - Stay clear of rotating parts.
• Risque de blessures - ne pas s’approcher des pièces en
mouvement.
• Evitar lesiones - Mantenerse alejado de las piezas giratorias.
DANGER / PELIGRO
DANGER / PELIGRO
07735200C
07735200C
2
DANGER/PELIGRO
07731400D
4
077541
3
WARNING/AVERTISSEMENT/ADVERTENCIA
07742300B
Do not operate mower
unless guards are in
operating position or
bagger is attached.
Ne jamais utiliser
la tondeuse sans
protecteur sur le
canal d'ejection ou
sans le bac monte.
No operar segadora a
menos que las defensas
esten en posicion de
operacion o el
recogedor este fijo.
2
DANGER/PELIGRO
07731400D
DANGER! TO AVOID SERIOUS INJURY OR DEATH
Read Owner/Operator Manual.
OL1801
Keep children and others away from unit while
operating.
Figure 3
DANGER / PELIGRO
TO AVOID SERIOUS INJURY OR DEATH POUR EVITER LES BLESSURES GRAVES OU LA MORT PARA EVITAR DAÑOS SERIOS O LA MUERTE
• Read the operator's manual.
• Keep children and others away from unit while
operating.
• Never direct discharge toward other people.
Thrown objects can cause injury.
• Look down and behind before and while backing.
• Never carry children.
• Go up and down slopes, not across.
• If machine stops going uphill, stop blade and
back down slowly.
• Avoid sudden turns.
• Keep safety devices (guards, shields, switches,
etc.) in place and working.
• Check interlock system per manual before use.
• Understand location and function of all controls.
• Never allow operation by untrained persons.
• Lire le manuel d'utilisation.
• Éloigner les engants et tout autre personne pendant le fonctionnement de la
machine.
• Ne jamais décharger directement en direction de quelqu’un. Des particules
projetées peuvent provoquer des blessures.
• Regardez derriere et sur les cotes lorsque vous reculez.
• Ne transportez jamais dénfant.
• Tondez toujours de haut en bas et inversement jamais le long des pentes.
• Si la machine sárrete en montee. Debrayez la lame et redescendez
doucement.
• Evitez les virages brusques.
• Maintenez toujours en place tous les elements de securite (protecteurs,
interrupteurs, etc.).
• Controlez le bon fonctionnement des interrupteurs de securité avant
utilisation tel q'uindiqué dans le manuel d'utilisation.
• Comprenez bien la fonction et la situation de chacun des leviers et boutons
de commande.
• Never allow operation by untrained persons.
• Leer el manual del operador.
• Mantenga la unidad alejada de los niños u otras personas
cuando esté en funcionamiento.
• Nunca dirija la descarga hacia otras personas, ya que los
objetos lanzados pueden provocar lesiones.
• Antes y durante retroceso mirar hacia abajo y detras.
• Nunca monten niños.
• Suba y baje pendientes, no transversalmente.
• Si la maquina se detiene subiendo cuesta, desactive la
cuchilla y baje lentamente.
• Evite viradas subitas.
• Mantenga artefactos de seguridad (defensas, protectores,
interruptores, etc.) en su lugar y trabajando.
• Verifique en el manual el sistema de engranar antes de usar.
• Tenga conocimiento de funciones y localizaciones de todos
los controles.
• Never allow operation by untrained persons.
Never direct discharge toward other people.
Thrown objects can cause injury.
OL0910
Look down and behind before and while
backing.
OL4460
17
1
MAX
07734700D
OF1624
OL4370
Keep children out of work area and under
watchful care of a responsible adult.
OL4470
GB - 5
NEVER CARRY CHILDREN.
OL4480
DO NOT operate on slopes over 17˚.
Go up and down slopes, not across.
MAX
17°
OL4450
• If machine stops going uphill, stop blade and back
down slowly.
• Avoid sudden turns.
• Keep safety devices (guards, shields, switches, etc.)
in place and working.
• Check interlock system per manual before use.
• Understand location and function of all controls.
• Never allow operation by untrained persons.
2. DANGER! ROTATING PARTS
Always keep feet and hands away from
rotating parts.
OL3030
Always stand clear of discharge area. Do not
direct discharge toward other people.
OL0910
Keep people away from unit while operating.
OL3292
Shut off engine, remove key, read manual
before you adjust or repair unit.
OL4010
NO STEP! Always keep feet away from
rotating parts.
OL4420
3. WARNING! Do not operate mower unless guards are
in operating position or bagger is attached.
Always stand clear of discharge area.
OL4430
Do not operate mower unless bagger is
attached or guards are in operating position.
OL3320
4. HOT SURFACES!
DO NOT touch parts which are hot from
operation. ALWAYS Allow parts to cool.
OD0061
5. DANGER!
AVOID INJURY. Stay clear of rotating parts.
OL4730
SAFETY RULES
Operation
Read, understand, and follow all instructions in the
manual and on the machine before starting:
• How to operate all controls
• The functions of all controls
• How to stop in an emergency
• Braking and steering characteristics
• Turning radius and clearances
• Speed ranges
ALWAYS keep protective structures, guards, and panels
in good repair, in place and securely fastened.
Complete a walk-around inspection of the unit and work
area.
Before starting engine: disengage PTO and set parking
brake.
Start and operate unit only when seated in operator’s
position. Steering control levers must be in neutral, PTO
disengaged and parking brake set when starting engine.
ALWAYS disengage PTO, stop unit and engine, remove
key, engage parking brake and allow moving parts to stop
before leaving operator’s position.
ALWAYS remove key to prevent unauthorized use.
Check for weak spots on dock, ramps or floors. Avoid
uneven work areas and rough terrain.
Dust, smoke, fog, etc. can reduce vision and cause an
accident. Mow only in daylight or good artificial light.
Watch for traffic when operating near or crossing
roadways.
Only allow responsible adults who are trained and
familiar with the instructions to operate the machine.
Training includes actual operation.
Clear the area of objects such as tree branches, rocks,
toys, wire, etc., which could be picked up and thrown by
the blades. Tall grass can hide obstacles.
Be sure the area is clear of people before mowing. Stop
machine if anyone enters the area.
GB - 6
Use extra care when approaching blind corners, shrubs,
trees, or other objects that may obscure vision.
Watch for holes, ruts, or bumps. Uneven terrain could
overturn the machine.
Do not mow in reverse unless absolutely necessary.
Always look down and behind before and while backing.
Be aware of the mower discharge direction and do not
point it at anyone. Always stand clear of discharge area.
DO NOT operate at too fast a rate.
DO NOT change engine governor settings or over-speed
engine. Slow down before turning.
Disengage PTO when attachment is not in use. ALWAYS
turn off power to attachment when transporting, crossing
driveways, etc.
Stop engine before removing grass catcher or unclogging
chute.
Do not operate mower unless bagger is attached or
guards are in operating position.
If you cannot back up a slope or you feel uneasy on it, do
not mow it.
Operate up and down slopes, not across slopes. DO
NOT operate on slopes of more than 17˚. Keep all
movement on slopes slow and gradual. DO NOT make
sudden changes in speed or direction. Use a slow speed
to avoid stops or shifts on slopes. Avoid starting or
stopping on a slope. Use of a Roll Over Protection
System (ROPS) is recommended for slope operation.
Use slow speed on any slope. Choose a low gear so that
you will not have to stop or shift while on the slope.
Use extra care with grass catchers or other attachments.
These can change the stability of the machine. Use only
approved hitch points.
Keep all movements on the slope slow and gradual . Do
not make sudden changes in speed or direction.
Avoid starting or stopping on the slope. If tires lose
traction, disengage the blades and proceed slowly
straight down the slope.
Do not mow near dropoffs, ditches, or embankments. The
mower could suddenly turn over if a wheel is over the
edge of a cliff or ditch, or if an edge caves in.
Do not mow on wet grass. Reduced traction could cause
sliding.
Do not try to stabilize the machine by putting your foot on
the ground.
Do not use grass catcher on steep slopes.
Do not park on slopes unless necessary. When parking
on slope always chock or block wheels. Always set
parking brake.
Know the weight of loads. Limit loads to those you can
safely control and the unit can safely handle.
Use only attachments or accessories designed for your
unit.
Check attachment components frequently. If worn or
damaged, replace with manufacturer’s recommended
parts.
Personal
Never carry passengers.
Always wear safety glasses or eye shields while
operating your tractor or performing any adjustments or
repairs. We recommend a wide vision safety mask over
eye glasses, or standard safety glasses.
Protect eyes, face and head from objects that may be
thrown from unit. Wear appropriate hearing protection.
NEVER wear open sandals or canvas shoes during
operation. Wear adequate safety gear, protective gloves
and footwear.
Avoid slippery surfaces. Always be sure of your footing.
Keep all nonskid surfaces clean. Replace safety treads if
worn, damaged, or missing.
Always keep hands and feet away from rotating parts. Do
not step on mower deck when mounting, operating or
dismounting tractor.
Stay away from moving parts.
NEVER operate the machine after or during the use of
medication, alcohol or drugs. Safe operation requires
your complete and unimpaired attention at all times.
NEVER allow anyone to operate this unit when their
alertness or coordination is impaired.
Do not touch parts which are hot from operation.
ALWAYS allow parts to cool.
Always keep hands away from all pinch points.
NEVER place your hands or any part of your body or
clothing inside or near any moving part while unit is
running.
DO NOT wear loose clothing or jewelry. Tie back hair that
may get caught in rotating parts.
Always stand clear of discharge area.
Keep people away from unit while operating.
Shut off engine, remove key, read manual before you
unplug, adjust or repair unit.
DO NOT run engine in an enclosed area. Always provide
good ventilation. Fumes from engine exhaust can cause
injury or death.
Data indicates that operators, age 60 and above, are
involved in a larger percentage of riding mower related
injuries. These operators should evaluate their ability to
operate the riding mower safely enough to protect
themselves and others from serious injury.
Keep children out of the mowing area and under the
watchful care of another responsible adult.
Be alert and turn off machine if children enter the area.
Before and when backing up, look behind and down for
small children.
GB - 7
Loading...