Granite 97011-4 Owner's Manual

595 E. Lugbill Rd.

Archbold, OH 43502

419.445.4733 or 877.447.2648
Fax [phone]

Electric Power Cart

Owners Manual

97011-4

595 E. Lugbill Rd.

Archbold, OH 43502

419.445.4733 or 877.447.2648
Fax [phone]

Carts, excluding any finishes, casters and wheels are warranted for three (3) years from date of
original purchase.

Power unit components are warranted for 90 days from date of original purchase.

WARRANTY

We will repair, without charge, any defect due to faulty material or workmanship. These
warranties do not cover failures due to abuse, misuse, improper installation, accidental damage
or when repairs or modifications have been made or attempted to be made by anyone other
than Granite Industries. Any defective products that meet warranty specifications and Granite
Industries approval, may be returned to the factory to be repaired or replaced free of charge.
(Granite Industries will pay to ship replacement item(s) to the customer; however the customer
is responsible for shipment of products to the factory.)

This remedy is the sole remedy in contact, tort or otherwise, and Granite Industries is not liable
for incidental, consequential or special damages.

These warranties give you specific legal rights, and you may have other rights which vary from
state to state. Should you have any questions, contact Granite Industries (Proof of purchase
may be required).

2

595 E. Lugbill Rd.

Archbold, OH 43502

419.445.4733 or 877.447.2648
Fax [phone]

OPERATION & MAINTENANCE

How long do the batteries last on a single charge?
It is completely dependent upon how much weight is being carried, the type of terrain, and
the softness or hardness of the surface. We estimate a range from a minimum of two hours
of continuous use, up to six hours of continuous use. PLEASE NOTE: Most use is not
continuous, so actual use time is typically much longer.

How long will the batteries last before needing to be replaced?
The batteries are designed to last for 300-500 charge/discharge cycles, which translate into
approximately 1-2 years. The batteries are common, and can be purchased from Granite or at
your local hardware store.

Will tipping the unit hurt the batteries, electronics, or drive system?
No. Batteries, electronics, and drives can operate in any orientation.

What is the maximum speed?
All Power Carts can operate from approximately 0 to 3 miles per hour forward, and 0-3.0 miles
per hour in reverse.

While pushing my Power Cart, it suddenly decelerates aggressively. What causes this?
There is a safety feature on your Power Cart called “Push Too Fast.” It is designed to prevent
the cart from running away when the brake is manually disengaged.

Why does my Power Cart lose traction when one wheel is off the ground?
The drive system is an open differential that allows the machine to efficiently make turns
without skidding the tires. The drawback is that if one of the drive tires leaves the ground, it
will simply spin until all tires are back on the ground.

Is a balanced load important to the performance?
Yes. Balancing the load so that it is not top-heavy or side-loaded, will allow much safer
operation. Furthermore, most of the load should be located over top of the drive wheel(s) for
better traction.

How do I clean my Power Cart?
Simply remove all debris, hose it down with soapy water, and towel dry. We do not
recommend using a pressure washer.

What maintenance is required?
Not much, really! Simply remember to always recharge when not in use. If storing for an
extended period of time, leave the unit on charge – especially in cold climates. The drive
system is sealed for life, thus no lubrication is required. Keep the unit dry to enhance its life
and appearance. It is recommended that the batteries be replaced once every 12 months.

3

595 E. Lugbill Rd.

Archbold, OH 43502

419.445.4733 or 877.447.2648
Fax [phone]

BATTERY REPLACEMENT

24v 12amp

Replacement Battery Specs: 12v, 12 amp/hr lead acid sealed, AGM type. Universal Battery model UB12120
or equivalent. Two (2) Batteries required.

1. Remove the battery pack from the cart.

2. Remove the four (4) #10 screws holding the lid in place.

3. Carefully remove the batteries, and disconnect the spade terminals. RECYCLE YOUR OLD BATTERIES.

4. Reconnect the battery and circuit breaker wires to the new batteries as shown. It is helpful to make the
connections with the batteries outside the box first. The batteries are wired in SERIES, not PARALLEL.

5. Place Battery A into the box first, then Battery B making sure the wires are nested in between. The fit is
designed to be tight.

6. Replace the box lid and secure with four (4) #10 screws.

4

595 E. Lugbill Rd.

Archbold, OH 43502

419.445.4733 or 877.447.2648
Fax [phone]

BATTERY REPLACEMENT

24v 12amp

5

595 E. Lugbill Rd.

Archbold, OH 43502

419.445.4733 or 877.447.2648
Fax [phone]

BATTERY REPLACEMENT

24v 22amp

Replacement Battery Specs: 12v, 22 amp/hr lead acid sealed, AGM type. Universal Battery model UB12220
or equivalent. Two (2) Batteries required.

1. Remove the batter pack from the cart.

2. Remove the four (4) #10 screws holding the lid in place.

3. Carefully remove the batteries, and disconnect the spade terminals. RECYCLE YOUR OLD BATTERIES.

4. Reconnect the battery and circuit breaker wires to the new batteries as shown. It is helpful to make the
connections with the batteries outside the box first. The batteries are wired in SERIES, not PARALLEL.

5. Place Battery A into the box first, then Battery B making sure the wires are nested in between. The fit is
designed to be tight.

6. Replace the box lid and secure with four (4) #10 screws.

6

595 E. Lugbill Rd.

Archbold, OH 43502

419.445.4733 or 877.447.2648
Fax [phone]

BATTERY REPLACEMENT

24v 22amp

7

595 E. Lugbill Rd.

Archbold, OH 43502

419.445.4733 or 877.447.2648
Fax [phone]

CHARGING SYSTEM

24v Chargers

The battery charger is designed to charge any type of lead acid battery to full charge. The charger can be left connected to

the batteries after full charge (green light) without harming the batteries. The charger uses minimum power in this standby-mode
(after battery is fully charged), maintains the batteries at full charge and extends battery life.

The CHARGING light is normally Red, Yellow or Orange which changes to Green when the battery is fully charged. It is a
good idea to leave the charger connected until battery is ready to use. It will give a long battery life.

Note: 5amp charger CANNOT be used to charge the 24v 12amp battery packs. The 2amp charger can be used to charge either pack.

Complete Charger Pack

2amp 70138
5amp 70135

5amp PI-11-0191 2amp PI-11-0027

Individual chargers:

Charger Pack

Mounted on Cart

8