Grand Hall 89795 User Manual

Owner's Manual

fle_16 Ce_n|ro|RrepiL byeram_hm|

Remote Control Liquid Propane Gas Patio Fireplace

For Outdoor Installation & Operation
Model 89795

US

,/_ WARNING:

Read this Owner's Manual carefully and be sure
your patio fireplace is properly assembled, installed

and maintained. Failure to follow these instructions
could result in serious bodily injury and/or property

damage. This patio fireplace is not intended to be
installed in or on recreational vehicles or boats.

Note to installer: Leave this Owner's Manual

with the consumer after delivery and/or installation.

Note to Consumer: Leave this Owner's
Manual in a convenient place for future reference.

1 PC3611000L- Rev: 2004/2/13

I, I.3F.X;JI[m

Warranty ................................ 2

Safety Instructions ................................ 2

Contents for Hardware Pack & Packing List ...........5

Parts Diagram ................................. 6

Parts List for Replacement ................................. 7

Assembly & Installation Instructions .................... 8

Checking for Gas Leaks .............................. 11

Reading the Manifold Pressure .............................. 11

Operating Instructions .............................. 11

Maintenance .............................. 12

Error Messages .............................. 12

Electric Wire & Block Diagram ................. 13

Specifications & Dimensions ............................... 14

m;l vvu ]iliL 3 A

Full 1-Year Warranty on fireplace
For one year from the date of purchase Grand Hall
Enterprise Co., Ltd. will repair or replace, at our option,
any patio fireplace parts(except for paint loss, rusting
and Replacement Batteries) that is defective in material

or workmanship. You will be charged for shipping and
handling. This warranty does not cover labor charges.

This warranty does not include:

• Batteries of controller and remote.

• Reshaping or dents in Reflector that may be
caused by, but not limited to, falling debris.

Warranty Service
Warranty service is available by calling 1-888-317-7642

8am - 8pm CST, Monday through Friday.

Warranty Restrictions

• This warranty applies to the original purchaser only.

e

This warranty is void if patio fireplace is used for

commercial or rental purposes.

e

This warranty isvoid ifthe Burner orValve assembly

has been altered or disassembled.

e

This warranty applies only if this patio fireplace is

used in the United States.

e

This patio fireplace is for use with Liquid

Propane(LP) gas only. Any attempt to convert this

fireplace to natural gas is dangerous and will void

your product warranty.

This warranty gives you specific legal rights, and you

may also have other rights which vary from state to state.

I, 1 1illmetm.-mmp/ll lml'mm

This appliance has been tested to and complies with IAS
4-96 "IAS REQUIREMENTS FOR OUTDOOR GAS

FIREPLACES". Installation must conform with local
building codes, or in the absence oflocat building codes,

with the National Fuel Gas Code, ANSI Z223.1 NFPA 54

or CAN/CGA-B149.1, Natural Gas and Propane
Installation Code.

WARNING: Improper installation, adjustment,
alteration, service or maintenance can cause injury,
death or property damage and will void your product

warranty. Read the installation, operation and
maintenance instructions thoroughly before
installingor servicing this equipment.

/_ WARNING

Failure to comply with these instructions could result
in a fire or explosion that could cause serious bodily
injury, death or property damage.

A strong gas smell, or the hissing sound of gas
indicates aserious problem with your fireplace or LP

tank. Failure to immediately follow the steps listed
below could result in a fire or explosion which could
cause serious bodily injury, death or property
damage.

WHAT TO DO IFYOU SMELLGAS:

Do not try to light any appliance.
Do not touch any electrical switch; do not use the

phone in your building.

Immediately call your gas supplier from a

neighbor's phone. Follow the gas supplier's
instructions.

If you cannot reach your gas supplier, call the fire

department.

Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.

Z_ WARNING

Do not use this fireplace to burn solid fuels or trash.
Never place matches, paper, garbage, or any other

material on top of logs or into the flame.

Z_ WARNING

Do not use this fireplace if any part of the control
system has been under water. Immediately call a

qualified service technician to inspect the fireplace
and to replace the parts of the control system and
gas control which has been under water.

Z_ WARNING

Very hot while in operation

Never lean over the fireplace while using your
fireplace. Do not touch Lid or Screen while the
fireplace is in operation, or until the fireplace has

cooled down after use.

Failure to comply with these instructions
may result in serious bodily injury.

WARNING: Installation and service must be

performed by a qualified installer, service

agency orthe gas supplier,

/_ WARNING: For outdoor use only

2

//_ WARNING

(a) Do not store a spare LP-gas cylinder near this

fireplace.

(b) Never fill the cylinder beyond 80 percent full.

(c) Ifthe information in"(a)" and "(b)" is not followed

exactly, a fire causing death or serious injury may
occur.

FOR YOUR SAFETY

1. Do not store or use gasoline or other flammable
material and liquids in the vicinity of this fireplace or
other appliance.

2. ALP cylinder not connected for use must not be
stored inthe vicinity of this or any other appliance.

IMPORTANT; This fireplace isonly for use with LP
type of gas as equipped from the manufacturer and

is not convertible for use with other gases.

IMPORTANT; This fireplace may not be used for
preparing food. Gases and/or food particles may fall

into the appliance and inhibit proper operation.

Important safety rules:

YOUNG CHILDREN should be carefully
supervised when they are in the area of the
fireplace.
NEVER hang anything including clothes or

other flammable items on the fireplace.
The screens installed in this fireplace must be in
place at all times when in operation to prevent
foreign objects from entering the unit.
For proper ventilation around the unit, do not

obstruct the upper and lower vent louvers.
The fireplace should be inspected before first
use and at least annually by a qualified service
person. More frequent cleaning may be required
depending on area conditions.
Keep burner and control compartment clean.

See installation and operating instructions.

1 Clearance from combustibles:

Proper clearance from combustible materials must
be maintained at all times (See Fig 1 for minimum

clearance)
Combustible materials include wood, compressed
paper, plant fibers, plastic, plexiglass or other
materials capable of being ignited and burned.

Such materials shall be considered combustible
even though flameproof, fire-retardant treated or

plastered. Additional clearance may be required for
glass, painted surfaces and other materials which
may be damaged by radiant or convection heat.

Unit to walls: 24 Inches
Unit to ceiling: 24 Inches

Fig 1 Minimum clearance from combustibles.

24inches

2. The gas inlet supply and normal operating manifold
pressure for fireplace is as follows. For gas supply

line pressures in excess of 14 "W.C., consult with
your representative or the factory.

Type of Gas Liquid Propane
Maximum inlet pressure 14 "W.C.

Minimum inlet pressure 11 "W.C.
Manifold pressure 9 "W.C.
Gas Rating 41,000 BTU/hr

3. The fireplace must be inspected before each use
and annually by aqualified service person.

AIt gas connections should be checked for leaks
utilizing a soap solution. Never use a flame for

this purpose.
The flame pattern should be visually checked
whenever the fireplace isoperated.
Yourfireplace area must be kept clear and free of
combustible materials, gasoline and other

flammable vapors and liquids.

Clean your fireplace only with noncombustible,
non-corrosive cleaning agents.

4. Your fireplace has been designed with several safety

features as follows.

A thermal fuse for overheating cut-off protection.
Flame failure shut off.

Automatic ignition.
Safety combination valve shut off.

The operating condition is controlled and
diagnosed by a micro processor.

The micro processor is an advanced feature which also
makes it easy for one touch operation with remote
control or manual push button.

Any modification to the fireplace not described in the
installation instructions may compromise the safety of
this fireplace and will void the warranty.

3

IMPORTANT; Your Homestead patio fireplace cannot
be converted to use Natural Gas. Attempting to do so is

extremely hazardous and wilt also void the warranty.

Correct LP Gas Tank Use

The patio fireplace is designed for use with a standard

20 lb. Liquid Propane Gas (LP Gas) tank, not included in
box. Never connect your fireplace to an LP gas tank
directly without regulator that exceeds this capacity. A

tank of approximately 12 inches in diameter by 18-1/2

inches high is the maximum size LP gas tank to use. You
must use an "OPD" gas tank which offers a listed
Overfill Protection Device. This safety feature

prevents tank from being overfilled which can cause
malfunction of LP gas tank, regulator and/or fireplace.

The LP gas tank must be connected and marked in

accordance with the specification for LP-gas cylinders
of the U.S. Department of Transportation (D.O.T) or the

National Standards of Canada, CAN/CSA-B339,
Cylinder, Spheres and Tubes for Transportation of
Dangerous Goods, and Commission, as applicable.

1.The LP gas tank has a shutoffvalve, terminating in an
LP gas supply tank valve outlet, that is compatible with

type 1 tank connection device. The LP gas tank must
also have a safety relief device that has a direct
connection with the vapor space of the tank.

2. The tank supply system must be arranged for vapor
withdrawal.

3. The LP gas tank used must have a collar to protect the
tankvalve.

LP gas tanks must be stored outdoors in a well-
ventilated area and out of the reach of children.

Disconnected LP gas tanks must not be stored in a
building, garage or any other enclosed area.

When your fireplace is not in use the gas must be
turned off at the gas tank.
The regulator with hose assembly can be seen
when you open the doors. It should be inspected
before each use of the fireplace. If there is

excessive wear or any abrasions, or if the hose is
cut, it must be replaced prior to the fireplace being

used.
Keep the gas regulator hose away from hot surface.

Avoid unnecessary twisting of hose. Visually
inspect hose prior to each use for cuts, cracks,
excessive wear or other damage. If the hose
appears damaged do not use the fireplace. Call

1-888-317-7642 for an authorized replacement

hose.
Never allow children to play near your fireplace.

This patio fireplace isnot intended to be installed inor on

recreational vehicles and!or boats.

Never connect an unregulated LP gas tank to your

fireplace. The gas regulator assembly supplied with

your fireplace is adjusted to have an outlet pressure
of 11" water column(W.C.) for connection to an LP
gas tank.
Only use the regulator with hose assembly supplied

with your fireplace. Replacement regulator with

hose assembly must be those specified by
manufacturer.

Have your LP gas tank filled by a reputable propane
gas dealer and visually inspected and re-qualified at
each filling.
Never fill the gas tank beyond 80 percent full. Have
your propane gas dealer check the release valve

after every filling to ensure that it remains free of
defects.

Always keep LP gas tanks in upright position. Do not

store(or use) gasoline or other flammable vapors
and liquids in vicinity of this fireplace.
LP gas tanks not connected for use must NOT be

stored inside of fireplace or in the vicinity of this or
any other gas appliance.
Do not subject the LP gas tank to excessive heat.
Never store an LP gas tank in the garage or other

indoor location. Always disconnect the LP gas tank

first and store itsafety outside.

4

Thefollowingtableillustratesa breakdownofthehardwarepack.Ithighlightswhichcomponentsareusedinthe
variousstagesofassembly.

Ref. No. Component Qty. Usage
$115G03082 Screw, 3/16"-24 UNC 4

$115G03082 Screw, 3/16"-24 UNC 4
$115G03082 Screw, 3/16"-24 UNC 16
$313G03062 Nut, 3/16"-24 UNC 16

Screw, 3/16"-24 UNC
Qty. 24

Parts # $115G03082

Assemble the Screen onto Base
Assemble the Lid onto Screen

Assemble Screen
Assemble Screen

©

Nut, 3/16"-24 UNC
Qty. 16

Parts # $313G03062

For complete installation and assembly you should have:

1.Base including Burner, Controller, Regulator with Hose

2. Screen

3. Lid

4. Log set (3 pieces)

5. Clinker (30 pieces) and Ember glow (1 pack)

6. Remote control

7. Battedes/D (4pieces)

5