GRAFTON Plumbworld Ultraflow Macerator Instruction Manual

plumbw

I

rid

C>Grafton

Ultraflow

Instruction

Please

Group

keep

this

instruction

PLC Page 1

Macerator

Manual

manual

for

future

reference.

of20

INDEX

UL

TRAFLOW MACERATOR

1. Declaration

of

Conformity

2. Specification

3. Safety Instructions

4. Product Description

5. Operating Principle

6. Parts Listing

7. Installation

8. Troubleshooting

9. Clearing Blockages

10. Clearing a Pressure Tap Chamber Blockage

11. Replacing the

Air

Switch

12. Appliance Disposal

C>Grafton

Group

PLC Page

2of20

1. DECLARATION OF CONFORMITY

We www.plumbworld.co.uk declare that the Ultraflow Macerator product is
following directives

The

Low

Voltage

EMC

Directive (Directive

CE

Marking

to

specification under which conformity is declared.

Directive

(Directive

89/336/EEC)

Directive (Directive

2006/95/EC)

98/37/

EC)

in

conformity with the

C>Grafton

Group

PLC Page 3

of

20

2. SPECIFICATION

Water temperature 1 degree centigrade (minimum) / 90 degrees

Voltage 220v-240v

Amperage

Motor Power

Thennal Safety Device 135 degrees centigrade

Discharge head

Capacitor

Water Ingress Protection

Flow rate

Maximum discharge height

Maximum discharge horizontal length

*Product compliant with standard EN 12050-3

tAllow
see

at

a reduction

Fig

A for example.

pump output

of

0.5m per bend introduced,

centigrade (maximum)

3Amps

600Watts

6mws

10uF/450 Volts

IP

X4

270

litres/

minute

5.5

metrest

60

metrest

j

~

C>Grafton

Group

PLC

E

"'

0 -

@,

<I\

0

w

m

N

'

E

"?

"'

Fig A

i

:§,

..,

..c

~

E
E

"?

.,,

II

l

~

.

!.Al

..,

..c

~

E
E

"?

"'

1,

Page4of20

3.

SAFETY INSTRUCTIONS

Prior

to

installation

• Ensure the entire contents

of

this instruction manual are read.

• Ensure the package contains all component parts listed in this instruction manual.

• Ensure the two check valves stored inside the rubber chamber

• Ensure all packaging material is removed and disposed

of

correctly.

of

the

appliance are removed.

Installation

• Electrical installation

of

the appliance must only be carried

out

by

a qualified person.

• The appliance must be installed in accordance with the installation instructions specified in
this document.

• Always ensure the macerator is connected

to

mains power before water enters the unit.

Prior to use

• Before using the macerator, clean water must be flushed through

the

appliance several

times. This will ensure the macerator is correctly installed.

Daily use

• The appliance

• The appliance

toilet paper only. Failure

• Products not

is

suitable for domestic, indoor use only.

is

suitable for the discharge

to

comply with this will invalidate the warranty.

to

be

discharged using the appliance include but are not exclusive to: kitchen

of

domestic faecal matter, waste water and

towels, wet wipes, cotton wool, condoms and sanitary towels.

Servicing and maintenance

• Before servicing the appliance, always ensure the electrical supply

• Troubleshooting, maintenance and servicing
person who

is

competent to do so.

of

the appliance must only be carried out by a

is

fully disconnected.

• To maintain optimum performance, it is recommended that the appliance is serviced and
cleaned at least once every 6 months.

•

For

hygiene reasons, rubber gloves should be worn at all times when servicing the

appliance.

WARNING: This appliance must only be used with a 32mm

the soil stack. It is not suitable for use with 22mm
incorrectly sized waste

C>Grafton

Group

PLC Page

may

result in a leaking unit.

or

25mm pipework. Using the macerator with an

or

40mm waste pipe from the outlet to

5of20

INVALIDATION OF WARRANTY

Please

note that any

one

of

the

following

situations will invalidate the product warranty:

• Failure to install the appliance

in

accordance with the installation instructions contained

this document.

• Electrical installation of the appliance

• Discharge of materials other than

faecal

appliance.

• Failure to carry

out

regular maintenance

instructions.

4. PRODUCT DESCRIPTION

The

Ultraflow Macerator is designed for the purposes

waste, waste water
It is compatible for

and

use

with a

toilet paper

maximum

in

accordance with the relevant regulations.

of three

• 1 x basin

• 1 x shower

• 1 x toilet

OR

it can

be

used

• 1 X

to discharge waste

bath

from

• 1 x kitchen sink

• 1 x

washing

machine

by

an

unqualified

matter, waste water

and

servicing of the appliance as detailed

bathroom

any

one

person

and

of

discharging

items, including:

of the following:

.

toilet paper through

normal

in

domestic faecal

in

the

these

• 1 x dishwasher

C>Grafton

Group

PLC Page

6of20

5. OPERATING PRINCIPLE

The

macerator comprises a tank that holds waste

The

pump

is controlled

discharge action is triggered

by

an

automatic

when

the

pressure

flushing

before

switch

system

it

is

discharged,

and

an

electric

. As with a conventional toilet, the

is actuated.

pump

.

• Domestic

•

The
pressure switch

•

The

• Domestic

CONTROL COMPONENTS:

D -

Pressure

waste

is

air chamber

(B)

(D)

pressure switch

waste

is

Switch

collected

records the air

.

(D)

discharged through

in

the tank

pressure

trips the motor (

(A)

.

E).

the

outlet (G).

flowing

through

The

motor drives the turbine

the

outlet pipe (C)

(F)

to

the

.

MECHANISM COMPONENTS:

E - Electric Motor
F-Turbine

CONTROL COMPONENTS AND SAFETY DEVICES:

G -

Check

Valve

H -

Manual

C>Grafton

Override

Group

Switch

PLC Page 7

of20