Gotham PDRG Trim Semi User Manual

INSTALLATION INSTRUCTIONS

PDRG Trim

Semi-Recessed Glass

Upon receipt, thoroughly inspect for any
freight damage which should be brought
to the attention of the delivery carrier.
Compare the catalog description listed on
the packing slip with the label on the
carton to ensure that you have received
the correct merchandise.

SAVE THESE INSTRUCTIONS

New Installation

1. Slide both trim mounting brackets under lanced up tabs on the mounting frame
(Figure 1). Brackets may be secured to the mounting frame by screws or rivets
(supplied by others). NOTE: REMOVE AND DISCARD FRICTION CLIPS FROM

MOUNTING FRAME IF PRESENT.

2. Remove upper trim from glass by loosening two screws and disengaging them
from key hole slots ( Figure 2).

3. For HID and Incandescent products: Loosen two screws attaching socket
spring to socket cup. Grip socket and pull down, locating socket in lowest
possible position in the socket cup (Figure 3). Re-tighten screws. Attach
socket cup to the top of upper trim by aligning spring in socket cup with slots
in trim. For Compact Fluorescent products: Attach socket cup to top of upper
trim by aligning spring clip with alignment mark on upper trim (Figure 4). Slide
socket cup onto upper trim and turn until spring locks into place.

4. Push upper trim with socket cup attached through mounting frame opening
and align keyhole slots with screws in trim mounting brackets. Rotate upper
trim to engage in slots and tighten screws until trim flange is snug to ceiling
(DO NOT OVER-TORQUE) (Figure 5).

5. Install glass reflector to upper trim by lining up key hole slots with screws
located on bottom of upper trim (Figure 2). Rotate glass reflector to engage in
slots and tighten until screw heads are snug (DO NOT OVER-TORQUE).Tighten
safety screw until snug (Figure 2).

6. Install lamp. (Ensure that correct lamp type and wattage are used).

Trim Mounting
Bracket

Trim Screw Heads
Shown in theProper
Slot Position

IMPORTANT SAFETY INFORMATION

For Your Protection, Read Carefully

WARNING - Risk of fire. Do not install insu­lation within 3 inches of fixture sides or
wiring compartment, nor above the fixture
in such a manner as to entrap heat.

1. Electric current can cause painful
shock or serious injury unless handled
properly. For your safety, always re­member the following:

· Turn off the power supply.

· Ground the fixture to avoid poten-

tial electrical shocks.

· Do not handle an energized fixture

or energize any fixture with wet
hands, when standing on a wet or
damp surface, or in water.

· Double check all electrical connections

to be sure they are tight and correct.

2. Specific safety information concern­ing lamps:

· Match wattage of fixture and lamp

exactly.

· Do not remove or insert lamp when

power is on.

· Do not scratch glass or subject lamp

to undue pressure as either may
cause lamp breakage.

· Protect operating lamp from sources

of moisture.

· I f lamp is marked it contains mercury.

Hg

Follow disposal laws. See:
www.lamprecycle.org.

Figure 1

Screw in Lowest
Socket Position

Figure 3

ivynarofkcehC

motpmySesuaCelbissoPnoitcAevitcerroC

OTSLIAFPMAL

THGIL

TUOSEOGPMAL

GNITHGILRETFA

DNA

NOSELCYCPMAL

FFO

TRAHCGNITOOHSELBUORT

omrotiucricnirorregniriW·

pmalytluaF·

tuptuotsallabroeniL·

tsallabytluaF·

pmalytluaF· naht

wolooterutarepmettneibmA·

erutxifotesolcootsinoitalusnI·

hgihootegattawpmaL·

wolegatlovtuptuotsallaB·

Insert Screws Into
Trim Slots and Tighten

.snoitcaevitcerrocdnasesuacelbissopfotsilgniwollofeht

dezigrenetonerutxifehtgnideeftiucriC·

noitcennocelud

ehC·

Secure Locking Screw
After Trim Screws are
Secured and Tightened

Figure 2

Align Socket Clip
with "V" Locator Mark
on Refector Shoulder

Figure 4

Ceiling

Figure 5

.tcerroc

ilotnwonksitahteno

.enowenahtiw

.ytiunitnoctiucrickc

rehtarmotpmyssihttibihxelliwpmalayllanoisaccO·

.pmalwenaetutitsbuS.thgilotgniliafylpmis

rfnoitalusnievomeR·

enilkcehC·

)"3tsaelta(eludomdnuoramo

.gnisuohnideificepsegattawpmalllatsnI·

Part No. CJ520718

©2007, ©2009 Acuity Brands Lighting, Inc.

All Rights Reserved

Rev. D 11/09

nimelborpehtetacol,noitidnocdoognimeesyehtfI.eludomni-emarfropmalehtotegamadelbis

.dezig

renesitiucrictahterusneotesufrorekaerbtiucrickcehC·
erasnoitcennoctahterusneotxobecilpserutxifenimaxE·

ylbareferp,pmalrehtonaetutitsbusdnapmalytluafehtevomeR·

lanigiroehtecalper,sthgilpmalehtfI.thg

.egatlovtiucricnepokcehC.erutxiftaegatlovenilkcehC·

.snoitidnoclatnemnorivnegnitsixetsniagagnitartsallabkcehC·

.egatlovtiucricnepokcehC.erutxifehttaegatlov