Gorilla Playsets 04-0019 Assembly Manual
(04-0019)
Babysitter Swing
-FOR RESIDENTIAL USE ONLY-
ASSEMBLY MANUAL
All Rights Reserved
Latest Revision: April 28, 2017
TABLE OF CONTENTS
2
Warranty and Safety Guidelines……………………………………….......…….....Pages 3-7
Tool List and Kit Contents…………..……………………………………….................Page 8
Dimensions, Hardware and Lumber Checklist...………………………......…......Pages 9-11
Seat to Back Assembly……………………..………...…............................................ Step 1
Armrest Assemblies……………………...………………………….................……..... Step 2
Armrest Assemblies to Seat Back...……………….…………...…............................. Step 3
Eyebolts...............................………………...…..……..……...…...................……..... Step 4
Quick Links............................................................................................................... Step 5
Chains...................................................................................................................... Step 6
Swing Hanging Methods……………..…….............................................................. Step 7
PLEASE READ OWNER’S MANUAL CAREFULLY
BEFORE STARTING ASSEMBLY!
Page 2
IMPORTANT – PLEASE READ
3
This product is made from premium white cedar. Premium white cedar may still be slightly damp
when you receive your swing. If the wood is damp lay all the parts out on a table and leave
them in a covered area to air dry before staining or painting. Stain should be rated for outdoor
use such as the stain used for outdoor decks and outdoor furniture. Paint should also be rated
for outdoor use. Maintaining the nish will slow the natural aging process of the wood and
reduce surface checking.
It is important that all instructions are read before beginning construction. BE SURE TO READ
THE CHAIN MANUFACTURERS WARNING/INSTALLATION CARD LOCATED IN THE CHAIN
PACKAGE BEFORE BEGINNING! DO NOT HANG THE SWING WITHOUT READING AND
FOLLOWING THE INSTRUCTIONS ON THIS CARD.
WARNING! Be sure the chain manufacturer’s instructions are followed when installing the lag
swing hangers. The lag swing hangers should only be used with a 1/4” pilot hole drilled to a
depth of 1-1/2” as described in the chain manufacturer’s installation instructions. Be sure to
completely tighten lag swing hangers 1/4” past the last thread by using a screwdriver through
the triangular shaped top section. Applying bar soap or wax on the threads can make installation
easier. Turn the lag swing hangers so that the hook swings in the same direction as the swing.
INSTALL LAG SWING HANGERS SO THAT THEY ARE AS CLOSE TO PERPENDICULAR
TO THE SWING BEAM AS POSSIBLE. MAKE SURE THE LAG SWING HANGERS ARE
INSTALLED IN A SOUND WOOD BEAM THAT WILL SUPPORT 4 TIMES ITS INTENDED
LOAD CAPACITY. NEVER USE PLAIN “EYE” BOLTS FROM THE HARDWARE STORE TO
SUPPORT A SWING AS THESE BOLTS DO NOT HAVE A BEARING TO REDUCE FRICTION
ON THE CHAIN AS IT MOVES. USING A PLAIN “EYE” BOLT COULD CAUSE THE CHAIN
TO WEAR AND FAIL CAUSING SERIOUS INJURY. THE HOOK OF THE LAG SWING
HANGER SHOULD BE CLOSED SHUT AFTER THE HEIGHT OF THE SWING HAS BEEN
DETERMINED.
WARNING!
• Inspect each loop of chain before using. Each loop should be securely wrapped
around the center wire. If it is not, call the number on the chain warning tag to obtain a
replacement chain.
• Bolts on the swing should be checked often and tightened as needed.
• Be sure both short and medium chains are seated in the bottom of the “s-hook” and
that the chain is not twisted before using. If twisting is found then remove the chain from
the quick link and untwist the chain; then reinstall in the quick link.
• Never stand or allow children to stand in this swing! Do not allow anyone under or
behind the swing when it is in motion.
• Weight Capacity: 200 lbs
• FOR RESIDENTIAL USE ONLY! NOT FOR USE AS A STORE DISPLAY.
• When disposing swing DO NOT BURN. Dispose of in a landll.
Page 3
Limited Manufacturers Warranty
4
The “seller” warrants this product to be free from defects in workmanship and materials, under
normal use and conditions at its original installation, for one year.
Cosmetic defects or natural defects of wood (e.g., warping, seasonal checking or cracking,
knots, or knot holes, etc.) that do not affect the structural integrity of the product are not covered
by this warranty. Defects that develop because the product is exposed to extreme climate
conditions, excessive water exposure, lumber that has been damaged by wood boring bees, or
defects that develop as a result of faulty or improper installation of the product, are not covered
by this warranty. Fading or discoloration or molding of any wood parts are not considered
defects in material as long as they do not affect the functionality or structural integrity of the part
or component.
It is the owner’s responsibility to properly maintain the product. Imperfections or defects that
develop because of a failure to properly maintain the play set are not covered by this warranty.
The “seller” will repair or, at its discretion, replace any part within the stated warranty period
that is defective in workmanship or materials. This decision is subject to verication of the
defect, which, at the “seller’s” discretion, may be accomplished by submitting photographs or by
delivery of the defective part to the “seller”. Any warranty claim must include proof of purchase,
including the date of purchase. In addition, within the rst 30 days from the date of purchase,
the “seller” will replace any parts discovered to be missing from or damaged in the original
packaging.
This warranty is valid only if the product is used for the purpose for which it was designed and
installed at a residential, single-family dwelling. This warranty is void if the product is used
in a commercial or institutional setting. This warranty does not cover (a) products that have
been damaged by acts of God, negligence, misuse, or accident, or that have been modied or
repaired by unauthorized persons; (b) the cost of labor; or (c) the cost of shipping the product,
any part, or any replacement product or part.
The “seller” DISCLAIMS ALL OTHER REPRESENTATIONS AND WARRANTIES OF ANY
KIND, EXPRESS, IMPLIED, STATUTORY, OR OTHERWISE, INCLUDING THE IMPLIED
WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE.
PLAYNATION WILL NOT BE LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIAL
DAMAGES. This warranty is valid only in the United States of America, is nontransferable
and does not extend to the owners of the product subsequent to the original purchaser. Some
states do not allow limitations on implied warranties or exclusion of incidental or consequential
damages, so these restrictions may not be applicable to you. This warranty gives you specic
legal rights. You may also have other rights which vary from state to state.
Page 4
Important Safety Guidelines
5
This product is intended for residential use only and not intended for use in any public
setting. A safety surface such as mulch or recycled tire should be used under the
product to prevent injury from falls.
As with any home project, good judgment and respect for power tools will greatly reduce
the risk of injury. We recommend you follow all tool manufacturers’ safety guidelines.
Always wear eye protection and safety gloves to prevent injury. While this swing is being
constructed, please keep children away until the project is complete. Bolts and screw
heads should be checked regularly for tightness.
The “seller” shall not be liable for incidental, indirect or consequential damages or
injuries that result from the building and/or playing on this product. Adult supervision is
recommended anytime this product is being used.
THE WEIGHT LIMIT FOR THIS PRODUCT IS 200 LBS
The weight limit must for this swing must not be exceeded. Failure to adhere to these
and other safety guidelines could result in damage to the swing and injury to the user.
NOTE: Your children’s safety is our #1 concern. Observing the following statements and
warnings reduces the likelihood of serious or fatal injury. Please review these safety
rules regularly with your children.
• On-site adult supervision is required.
• Teach children not to walk close to, in front of, behind, or between moving swings or
other moving playground equipment.
• Teach children to sit in and never stand on swings.
• Teach children not to twist the chains and ropes and not to loop them over the swing
beam, since this may reduce the strength of the chain or rope.
• Teach children not to jump from swings or other playground equipment in motion.
• Teach children not to push empty seats. The seat may hit them and cause serious
injury.
• Teach children to sit in the center of the swings with their full weight on the seats.
• Teach children not to use the equipment in a manner other than intended.
• Parents should have children dress appropriately with well-tting shoes. Loose
clothing such as scarves and ponchos should not be worn. Always take off, tie up or
tuck in cords and drawstrings on children’s clothing. These things can get caught on
playground equipment and strangle a child.
• Verify that any suspended climbing ropes, chains, or cables are secured at both ends.
• Teach children not to attach items to the playground equipment that are not specically
designed for use with the equipment, such as, but not limited to, jump ropes, clothesline,
pet leashes, cables and chain as they may cause a strangulation hazard.
• Teach children to never wrap their legs around swing chain.
• Teach children to never slide down the swing chain.
WARNING: Children must NOT use this product until unit has been
completely assembled and inspected by an adult.
Page 5
Important Safety Guidelines (Continued)
6
This product should be inspected on a regular basis. If any of the following conditions
are noted, they should be removed, corrected, or repaired immediately to prevent
injuries:
• Hardware that is loose, worn or that has protrusions or projections.
• Scattered debris, litter, rocks, or tree roots.
• Splinters, large cracks, and decayed wood components.
• Deterioration and corrosion on structural components.
• Missing or damaged equipment components.
• Check all nuts and bolts frequently during the usage season and tighten as required.
(But not so tight that you crack the wood)
• Oil all metallic moving parts monthly during the usage period.
• Check all coverings for bolts and sharp edges twice monthly during usage season to
be certain they are in place. Replace when necessary. It is especially important to do
this at the beginning of each new season.
• Check swing seat and chains monthly during usage season for evidence of
deterioration. Replacement should be made of any item if excessive wear is found.
Contact the “seller” for warranted replacement parts.
• Inspect wood parts monthly. The grain of the wood sometimes will lift in the dry season
causing splinters to appear. Light sanding may be necessary to maintain a safe playing
environment. If you are treating your product with stain regularly, it will help prevent
severe checking/splitting and other weather damage.
• Once or twice a year, depending on your climate conditions, you must apply some type
of protection (sealant) to the wood of your product. Prior to the application of sealant,
lightly sand any “rough” spots on your set. Please note this is a requirement of your
warranty.
• The swing area should be free from obstacles such as yard toys, etc. when in use.
• The swing should have a fall zone extending a minimum of 6’ from the outer edge of
the support structure on each side. A “fall zone” in front and back of the swing should
extend out a minimum distance of twice the height of the swing as measured from the
ground to the top of the swing support structure.
Page 6
Loading...