Gold Medal Products 2033DC Operators Manual
Jumbo 360
Instruction Manual
Model No. 2033BG, 2033EX, 2033DC
10700 Medallion Drive, Cincinnati, Ohio 45241-4807 USA
© 2016 Gold Medal Products Co.
Part No. 74103
DANGER
DANGER
DANGER
DANGER
DANGER
Jumbo 360 Model No. 2033BG, 2033EX, 2033DC
SAFETY PRECAUTIONS
Gas is safe when used properly, but can be very dangerous when used
improperly. We suggest that installation be carefully made by qualified
personnel only. Gas companies have competent service personnel to
provide safe installation.
DO NOT use a match or flame to check for gas leaks – you may cause a fire
or explosion!
001_010914
003_010914
Never add water to hot oil. When water is added to hot oil a stream explosion
may ensue spattering hot oil resulting in serious burns or more seriously hot
oil in someone’s eyes.
024_010914
Hot oil is dangerous – severe burns can result when hot oil contacts the skin.
Hot oil is flammable – keep open flames away from hot oil and its vapors.
Keep a fire extinguisher near this unit.
Instruct personnel on what to do if there is a grease fire. DO NOT USE
WATER ON A GREASE FIRE! Use only fire extinguishers approved for
grease, oil, and electric fire.
002_102214
Machine must be properly grounded to prevent electrical shock to personnel.
Failure to do so could result in serious injury, or death.
DO NOT immerse any part of this equipment in water.
DO NOT use excessive water when cleaning.
Keep cord and plug off the ground and away from moisture.
Always unplug the equipment before cleaning or servicing.
Make sure all machine switches are in the OFF position before plugging the
equipment into the receptacle.
008_051514
Page 2
gmpopcorn.com
DANGER
WARNING
WARNING
WARNING
WARNING
WARNING
WARNING
Jumbo 360 Model No. 2033BG, 2033EX, 2033DC
SAFETY PRECAUTIONS (continued)
Improper installation, adjustment, alteration, service, or maintenance can
cause property damage, injury, or death. Any alterations to this equipment
will void the warranty and may cause a dangerous condition. This appliance
is not intended to be operated by means of an external timer or separate
remote-control system. NEVER make alterations to this equipment. Read the
Installation, Operating, and Maintenance Instructions thoroughly before
installing, servicing, or operating this equipment.
DO NOT store or use gasoline, or other flammable vapors and liquids, in the
vicinity of this equipment.
014_020416
004_010914
Instructions on what to do when a user smells gas can be obtained from the
local gas supplier. These instructions must be posted in a prominent location
where the unit is to be operated.
005_010914
To avoid burns, DO NOT touch the kettle or any heated surface.
DO NOT place or leave objects in contact with heated surfaces.
013_092414
ALWAYS wear safety glasses when servicing this equipment.
010_010914
No user serviceable parts inside. Refer servicing to qualified service
personnel.
011_051514
Read and understand operator’s manual and all other safety instructions
before using this equipment. To order copies of the operator’s manual go to
gmpopcorn.com or write to Gold Medal Products Co., 10700 Medallion Drive,
Cincinnati, OH 45241 USA 1-(800)-543-0862
Page 3
gmpopcorn.com
022_060215
WARNING
WARNING
Jumbo 360 Model No. 2033BG, 2033EX, 2033DC
SAFETY PRECAUTIONS (continued)
DO NOT allow direct contact of this equipment by the public when used in
food service locations. Only personnel trained and experienced in the
equipment operation may operate this equipment.
Carefully read all instructions before operation.
This machine is NOT to be operated by minors.
Note: Improvements are always being made to Gold Medal’s equipment. This
information may not be the latest available for your purposes. It is critical that
you call Gold Medal’s Technical Service Department at 1-800-543-0862 for any
questions about your machine operations, replacement parts, or any service
questions. (Gold Medal Products Co. does not assume any liability for injury due
to careless handling and/or reckless operation of this equipment.)
012_010914
007_010914
Page 4
gmpopcorn.com
Perforated
Jet Scoop
1/4 Cup Measure
36 oz. Corn
Jumbo 360 Model No. 2033BG, 2033EX, 2033DC
INSTALLATION INSTRUCTIONS
Inspection of Shipment
After unpacking, check thoroughly for any damage which may have occurred in transit. Claims
should be filed immediately with the transportation company. The warranty does not cover
damage that occurs in transit, or damage caused by abuse, or consequential damage due to the
operation of this machine, since it is beyond our control (reference warranty in back of manual).
Manual
Read and understand the operator’s manual and all other safety instructions before using this
equipment. To order copies of the operator’s manual go to gmpopcorn.com or write to Gold
Medal Products Co., 10700 Medallion Drive, Cincinnati, OH 45241 USA 1-(800)-543-0862.
Model Description
2033BG: 36 oz. Jumbo 360 Popper, LP Gas, utilizes an electric kettle drive motor.
2033EX: Export, 36 oz. Jumbo 360 Popper, LP Gas, utilizes an electric kettle drive motor.
2033DC: 36 oz. Jumbo 360 Popper, LP Gas, utilizes a DC powered kettle drive motor
(battery is not included with this unit).
Items Included with this Unit
Measure
Tank Regulator
Page 5
Tank Hose
gmpopcorn.com
Counterweight Assembly
1/4-20 Hex Head bolt
Counterweight
Knob
Set Screw
Counterweight Bar
Kettle
Jumbo 360 Model No. 2033BG, 2033EX, 2033DC
Setup
This unit has been tested at the factory.
1. Remove all packaging and tape prior to operation.
2. This unit is for outdoor use only.
3. Place popper on a level, sufficiently stable base or counter that is strong enough to
safely support it when in use. This unit is certified for use on combustible surfaces.
4. Observe the following clearances to ensure proper air supply and maintenance:
• Minimum of 10 inches clearance on each side of unit.
• Minimum of 30 inches clearance for the front, back, and top of unit.
5. Bolt the popper to the counter to secure it from tipping.
6. Attach the counterweight assembly per illustration below.
7. After setup, the unit should be cleaned prior to use (see Care and Cleaning section of
this manual).
Page 6
gmpopcorn.com
DANGER
CAUTION
Jumbo 360 Model No. 2033BG, 2033EX, 2033DC
Gas Installation Instructions
DO NOT connect the unit to a power source before gas connection is complete.
Gas Requirements
Converting the unit to an alternate fuel source will void the warranty and may cause a dangerous
condition.
2033BG, 2033EX, and 2033DC: Propane Gas, 33,500 BTU/HR
NOTE: For outdoor use only.
Gas Installation
Gas is safe when used properly, but can be very dangerous when used
improperly. We suggest that installation be carefully made by qualified
personnel only. Gas companies have competent service personnel to
provide safe installation.
001_010914
When installing this gas unit in the United States, you must conform with local codes, or in the
absence of local codes, with National Fuel Gas Code, ANSI Z223.1 (latest edition).
NOTE: Some local codes may require ventilation hoods or automatic fire systems. During
any pressure testing of the gas supply piping system at pressure equal to or less
than 1/2 psig (3.45 kPa), the appliance must be isolated from the gas supply piping
system by closing its individual manual shutoff valve.
After installation, all gas connections must be checked for leaks with a soap
solution (see Checking for Gas Leaks section of this manual).
Be sure to observe all clearances for this unit. Refer to the Setup Section of
this manual to ensure proper air supply and adequate clearance for servicing
and installation of this gas unit.
033_042814
Page 7
gmpopcorn.com
DANGER
DANGER
Jumbo 360 Model No. 2033BG, 2033EX, 2033DC
Important Fire Safety Notice
Consult your local fire protection agency for your area’s requirements. Check local fire protection
requirements regularly to ensure compliance with local codes and proper operation. Have a fire
extinguisher near the unit. (Use only fire extinguishers approved for grease, oil, and electrical fires.)
Hot oil is dangerous – severe burns can result when hot oil contacts the skin.
Hot oil is flammable – keep open flames away from hot oil and its vapors.
Keep a fire extinguisher near this unit.
Instruct personnel on what to do if there is a grease fire. DO NOT USE
WATER ON A GREASE FIRE! Use only fire extinguishers approved for
grease, oil, and electric fire.
002_102214
Checking For Gas Leaks
After making any gas connection, or after performing any work on the gas train, ALWAYS check
ALL gas connections for leaks with a soap solution.
DO NOT use a match or flame to check for gas leaks – you may cause a fire
or explosion! When gas connections are complete, have a qualified
professional wire the unit to a power source which will carry the current
specified on the unit’s data plate.
034_042814
1. Apply SOAP BUBBLES to all connections and pressurize the gas line to check for leaks.
Perform this test outdoors away from any flames or sparks.
DO NOT use a flame to check for gas leaks.
2. It is recommended to check your flexible gas lines and gas fittings for wear and tear on
a frequent basis. Stop using the appliance immediately if damage is found, and contact
a qualified professional to inspect and correct any issue.
3. Securely route all gas lines away from flames and high temperature areas.
4. Contact Gold Medal Technical Support, or a qualified Gas Service Technician with any
questions.
Gas Pressure
We have determined that optimum popping occurs when the gas pressure is adequate. For
propane gas, we recommend a manifold pressure setting of 10 inches of water column. The
pressure is measured at the appliance when the main burner is ignited.
Lighting and Shutdown Instructions
When gas installation is complete, the unit must be connected to a power source prior to lighting
the unit (reference the Electrical Installation Instruction section). For pilot and burner lighting
and shutdown instructions, refer to the Operating Instruction section of this manual.
Page 8
gmpopcorn.com
Jumbo 360 Model No. 2033BG, 2033EX, 2033DC
Page 9
gmpopcorn.com
Jumbo 360 Model No. 2033BG, 2033EX, 2033DC
Page 10
gmpopcorn.com
Jumbo 360 Model No. 2033BG, 2033EX, 2033DC
Page 11
gmpopcorn.com
Loading...