Gold Medal 2488, Super 88, 2488EX, 2489EX, 2489 Instruction Manual

Super 88

Instruction Manual

Model No. 2488, 2489, 2488EX, 2489EX

Part No. 49555

10700 Medallion Drive, Cincinnati, Ohio 45241-4807 USA

cause property damage, injury, or death. Any alterations to this equipment will

Super 88 Model No. 2488, 2489, 2488EX, 2489EX

SAFETY PRECAUTIONS

DANGER

Machine must be properly grounded to prevent electrical shock to personnel.
Failure to do so could result in serious injury, or death.
DO NOT immerse any part of this equipment in water.
DO NOT use excessive water when cleaning.
Keep cord and plug off the ground and away from moisture.
Always unplug the equipment before cleaning or servicing.
Make sure all machine switches are in the OFF position before plugging the
equipment into the receptacle.

DANGER

Improper installation, adjustment, alteration, service, or maintenance can

void the warranty and may cause a dangerous condition. NEVER make
alterations to this equipment. Read the Installation, Operating, and
Maintenance Instructions thoroughly before installing, servicing, or operating
this equipment.

008_051514

014_051514

WARNING

To avoid burns, DO NOT touch the kettle or any heated surface.
DO NOT place or leave objects in contact with heated surfaces.

013_092414

WARNING

ALWAYS wear safety glasses when servicing this equipment.

010_010914

WARNING

No user serviceable parts inside. Refer servicing to qualified service
personnel.

011_051514

WARNING

Read and understand operator’s manual and all other safety instructions
before using this equipment. To order copies of the operator’s manual go to
gmpopcorn.com or write to Gold Medal Products Co., 10700 Medallion Drive,
Cincinnati, OH 45241 USA 1-(800)-543-0862

022_060215

Page 2

gmpopcorn.com

Super 88 Model No. 2488, 2489, 2488EX, 2489EX

SAFETY PRECAUTIONS (continued)

WARNING

DO NOT allow direct contact of this equipment by the public when used in
food service locations. Only personnel trained and experienced in the
equipment operation may operate this equipment.
Carefully read all instructions before operation.

WARNING

This machine is NOT to be operated by minors.

Note: Improvements are always being made to Gold Medal’s equipment. This

information may not be the latest available for your purposes. It is critical that
you call Gold Medal’s Technical Service Department at 1-800-543-0862 for any
questions about your machine operations, replacement parts, or any service
questions. (Gold Medal Products Co. does not assume any liability for injury due
to careless handling and/or reckless operation of this equipment.)

012_010914

007_010914

Page 3

gmpopcorn.com

Super 88 Model No. 2488, 2489, 2488EX, 2489EX

INSTALLATION INSTRUCTIONS

Inspection of Shipment

After unpacking, check thoroughly for any damage which may have occurred in transit. Claims
should be filed immediately with the transportation company. The warranty does not cover
damage that occurs in transit, or damage caused by abuse, or consequential damage due to the
operation of this machine, since it is beyond our control.

Setup

Your new Popper was assembled and tested at the factory. Remove all packing material and tape
before starting operation.

Accessories Included With Your Machine

Corn Measure Cup
Flavacol Cup
Stamped Aluminum Scoop
Oil Measure Cup.

Page 4

gmpopcorn.com

Super 88 Model No. 2488, 2489, 2488EX, 2489EX

Electrical Requirements

The following power supply must be provided for your machine:

2488: 120V, 1525W, 60Hz
2489: 120V, 1605W, 60Hz
2488EX: 230V, 1562W, 50Hz
2489EX: 230V, 1570W, 50Hz

DANGER

Machine must be properly grounded to prevent electrical
shock to personnel. Failure to do so could result in serious
injury, or death.

Do NOT immerse any part of this equipment in water.
Do NOT use excessive water when cleaning.
Keep cord and plug off the ground and away from

moisture.
Always unplug the equipment before cleaning or servicing.

Your electrician must furnish sufficient power for proper machine operation. We recommend
this popper be on a dedicated and protected circuit. Failure to wire properly will void the
warranty and may result in damage to the machine. It is Gold Medal Products Company’s
recommendation that this machine be plugged directly into a wall outlet. The use of extension
cords is not recommended due to safety concerns, and may cause sacrificed and/or reduced
performance.

Before You Plug In Machine

1. Make sure all machine switches are in the OFF position before plugging the equipment

into the receptacle.

2. Make sure the wall outlet can accept the grounded plugs (where applicable) on the

power supply cord.

3. The wall outlet must have the proper polarity. If in doubt, have a competent

electrician inspect the outlet and correct if necessary.

4. DO NOT use a grounded to un-grounded receptacle adapter.

5. Install the unit in a level position.

Page 5

gmpopcorn.com

Light and

Warmer Switch

Kettle Motor

Switch

Kettle Heat

Switch

Super 88 Model No. 2488, 2489, 2488EX, 2489EX

OPERATING INSTRUCTIONS

Controls and their Functions

LIGHT AND WARMER SWITCH

Turns on the heat to the bottom corn pan and heat light.

KETTLE MOTOR SWITCH

Turns on the motor which drives the kettle agitator.

KETTLE HEAT SWITCH

Supplies power to the thermostat controlled kettle.

Amount of Popcorn and Oil

Your new Popper is equipped with a corn measuring cup. Popcorn popped in coconut oil stays
fresher longer. Coconut oil does not leave black deposits in your kettle like other oils.

Corn charge – 8.0 oz.
Oil charge – 2.0 oz.
Flavacol – 1 tablespoon

Popping Instructions

1. Turn the Kettle Heat and Kettle Motor Switch on.

2. Make a test pop with 3 kernels of corn and 2.0 oz. of oil.

3. Turn on the kettle and let it pre-heat for 5 to 8 minutes.

4. Load pre-measured popcorn and oil into kettle.

5. When corn has finished popping, dump the kettle.

6. Repeat cycle starting with #4.

7. Turn kettle heat and motor off when finished popping corn.

Page 6

gmpopcorn.com

Super 88 Model No. 2488, 2489, 2488EX, 2489EX

Care and Cleaning

DANGER

Machine must be properly grounded to prevent electrical shock to personnel.

DO NOT immerse in water.

Always unplug the equipment before cleaning or servicing.

WARNING

To avoid serious burns, DO NOT touch the kettle while it is hot!

Good sanitation practice demands that all food preparation equipment be cleaned regularly (only
use non-toxic, food grade cleaners). A clean looking, well-kept machine is one of the best ways of
advertising your product.

025_020314

028_082715

Note: It is extremely important to follow all of the cleaning procedures, otherwise

parts damage and equipment failure will result. The warranty does not cover
parts that are damaged due to improper cleaning.

Daily Kettle Cleaning Instructions

CAUTION: A hot kettle will cause burns if you touch it with your hand. Allow kettle to

cool at least 1 hour before attempting to clean. DO NOT use ice or water to
cool down a hot kettle! Severe kettle damage will result!

1. When cool, wipe the outside of the kettle with a clean, soft cloth. DO NOT use oven

cleaners or abrasive materials as they will damage the kettle.

2. Every night, mix Gold Medal’s Heat’n Kleen solution (Item No. 2095), 2 tablespoons

per gallon of water. It is not necessary to use the entire gallon at once; only use
enough to fill the kettle 1/2 inch deep.

3. Turn the kettle heat ON. When the water starts to boil, turn the kettle heat OFF.

4. Allow to cool for at least 1 hour, then dump the solution into a bucket and wipe the

inside of the kettle with a clean cloth. Make sure all of the solution goes into the
bucket; do not spill any in the interior of the machine.

For extra dirty kettles, the process may be repeated; or, after turning the kettle heat
OFF, allow solution to sit in the kettle overnight. The next morning, dump the solution
into a bucket and wipe the inside of the kettle with a clean cloth.

5. With the unit OFF and unplugged, wipe the kettle lead cord with a clean SLIGHTLY damp

cloth. DO NOT get moisture into the kettle lead-in cord, severe damage will result.

Page 7

gmpopcorn.com