Gold Medal Dogeroo, Super Dogeroo, 8103EX, 8102EX, Mini Dogeroo Instruction Manual

Dogeroo, Super Dogeroo,

Instruction Manual

and Mini Dogeroo

Model No. 8102EX, 8103EX, 8108EX

Part No. 87793EX

10700 Medallion Drive, Cincinnati, Ohio 45241-4807 USA

Dogeroo, Super Dogeroo
and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX

SAFETY PRECAUTIONS

Page 2

gmpopcorn.com

Dogeroo, Super Dogeroo

1 inch Dial Thermometer

9 inch Plastic Tongs

and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX

INSTALLATION INSTRUCTIONS

Inspection of Shipment

After unpacking, check thoroughly for any damage which may have occurred in transit. Claims
should be filed immediately with the transportation company. The warranty does not cover
damage that occurs in transit, or damage caused by abuse, or consequential damage due to the
operation of this machine, since it is beyond our control.

Setup

1. Your machine is fully assembled and tested at the factory. Carefully remove the

machine from the shipping cartons. Remove all packing material and tape.

2. If the optional sneeze guard has been purchased, place it over the corner posts.

3. Be sure to place your Dogeroo where the revolving hot dogs will attract the most

attention.

Accessories Included With Your Machine

Page 3

gmpopcorn.com

Dogeroo, Super Dogeroo
and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX

Electrical Requirements

The following power supply must be provided:

8102EX: 230Volts, 1495 Watts, 50Hz.
8103EX: 230Volts, 1748 Watts, 50Hz.
8108EX: 230Volts, 1035 Watts, 50Hz.

DANGER

Machine must be properly grounded to prevent electrical
shock to personnel. Failure to do so could result in serious
injury, or death.

Do NOT immerse any part of this equipment in water.
Do NOT use excessive water when cleaning.
Keep cord and plug off the ground and away from

moisture.
Always unplug the equipment before cleaning or servicing.

Your electrician must furnish sufficient power for proper machine operation. We recommend
this equipment be on a dedicated and protected circuit. Failure to wire properly will void the
warranty and may result in damage to the machine. It is Gold Medal Products Company’s
recommendation that this machine be plugged directly into a wall outlet. The use of extension
cords is not recommended due to safety concerns, and may cause sacrificed and/or reduced
performance.

Before You Plug In Machine

1. Make sure all machine switches are in the OFF position before plugging the equipment

into the receptacle.

2. Make sure the wall outlet can accept the grounded plugs (where applicable) on the

power supply cord.

3. The wall outlet must have the proper polarity. If in doubt, have a competent

electrician inspect the outlet and correct if necessary.

4. DO NOT use a grounded to un-grounded receptacle adapter.

5. Install the unit in a level position.

Page 4

gmpopcorn.com

Dogeroo, Super Dogeroo

On/Off switch

Heat Control

and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX

OPERATING INSTRUCTIONS

Controls and Their Functions

ON/OFF SWITCH

Flipping the lever of this switch to the "ON" position will energize the drive motor which
rotates the rotisserie. It also lights the bulb behind the front glass and completes the
circuit to the heat control.

HEAT CONTROL

The infinite heat control allows you to vary the operating temperature of the heating
element. When this control is in any position other that "OFF", the red pilot light will be
on. When the control is set at the "HI" position, the heating element is energized
continually.

Page 5

gmpopcorn.com

Dogeroo, Super Dogeroo

Dogeroo

Super Dogeroo

Mini Dogeroo

and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX

Specifications for Each Machine

Model 8102

Model 8103

Model 8108

Hot Dogs 56 84 14

Buns 28 42 14

Operating Procedure

1. Pour 1 ½ quarts of water into the water pan (about 5/8" deep). This will keep the

buns moist and warm. Use hot water to speed the process. Do NOT overfill! Overfilling
will result in too much steam.

2. Place buns in the bun warmer basket.

3. Note: Some buns collect more moisture than others due to their texture.

4. Place the hot dogs on the rotisserie.

5. When ready to start cooking, move the toggle switch to the "ON" position. This will

rotate the rotisserie clockwise and light the bulb behind the silk screened sign.

6. The time required to broil the hot dogs will vary, depending upon size and

temperature (35-37° F refrigerated) of the hot dogs when placed in the Dogeroo.

With the heat control set on "HI" and using average size hot dogs, it will take from 10-15 minutes
to have the hot dogs ready for 145° F cook temperature. Watch the dogs carefully the first
several times you cook to avoid blistering or burning the hot dogs.

After the hot dogs are cooked, reduce the heat control setting to one which will keep the hot dogs
at the 140° F minimum serving temperature. Hot dogs can be kept on the rotisserie for several
hours without shriveling or loss of flavor, if the heat control is properly set.

Page 6

gmpopcorn.com