Page 1
No. GSL20190802009E
Date: Aug. 08,2019
Page 1 of
Report no.
:
Applicant
:
:
:
Address
Product Name
Composition/Ingredient
of The Sample
Summary
:
:
GSL20190802009E
Nantong DFORCE powertools Co., Ltd.
No.18 Haosheng Road, Zhengyu Town Haimen
Charging Drill DF1802/DF1803 Set Built-in lithium battery pack
PT176213302 20V 4000mAh 80Wh
See Section 3 on the SDS
As per request, the contents and formats of the SDS are prepared
in accordance with Regulation (EC) No 1907/2006, 1272/2008,
Regulation (EU) No 2015/830 and are provided per attached.
SDS REPORT
Remark: This sample is likely to be classified as article and is out of scope of a SDS as set out in
Regulation (EC) No 1907/2006. This SDS is generated for client’s reference only.
Greatesting Service Shanghai Co.,Ltd.
上海量远检测技术有限公司
This report is only for reference of scientific research and education, or internal quality control.
Unless otherwise stated, the results shown in this test report refer only to the sample(s) received and tested in laboratory, and such sample(s) are retained for 30days only.
The ole responsibility of Greatesting Service (Shanghai) Co., Ltd is to ensures that this job has been performed according to our Quality System and complying contract and
legal conditions. This company bear only limited liability such as within 5 times of the cost of the test item and do not undertake any joint liability caused by this document.
Reproduction of this document is only valid if it is done completely and under the written permission of Greatesting Service (Shanghai) Co., Ltd.
If you happen to have any complaints, please do it by sending email to info@greatesting.com and referring to this report number.
10/F, 1# Building, No.2899 South Lianhua Road , Minhang District, Shanghai, China
上海市闵行区莲花南路 2899 号莲谷科技园 1 号楼 10 层
t (86-21)64788791
f (86-21)64788792
Http://www.greatesting.com
info@greatesting.com
Page 2
No. GSL20190802009E
Date: Aug. 08,2019
Page 2 of
SECTION 1: Identification of the substance/mixture and of the company/undertaking
·
1.1 Product identifier
·
Trade name: Charging drill DF1802/DF1803 SET(Built-in battery)4000mAh Built-in battery pack DF20V1901 2000mAh
·
1.2 Relevant identified uses of the substance or mixture and uses advised against on
·
Application of the substance/ mixture: Charging drill
·
1.3 Details of the supplier of the safety data sheet
·
Manufacturer/Supplier:Nantong DFORCE powertools Co., Ltd.
·
No.18 Haosheng Road, Zhengyu Town Haimen
Tel: 13584067210
Email: zhaodapeng@strofin.com
·
Only Representative/other EU contact point: No specific country, data not available.
·
Further information obtainable from: Nantong DFORCE powertools Co., Ltd.
·
1.4 Emergency telephone number
General in EU
Tel: 112 (Available 24 hours a day)
In China:
Zhao Da Peng Tel: 13584067210(8:00 to 18:00)
SECTION 2: Hazards identification
·
2.1 Classification of the substance or mixture
Classification according to regulation (EC) 1272/2008: The product is not classified according to CLP Regulation.
Remark: The battery is sealed with metal and plastic, will not leak. If the sealed container broken, the electrode will present the
following hazards: Toxic if swallowed; Causes severe skin burns and eye damage; May cause cancer; May damage fertility or the
unborn child; Causes damage to organs; May cause an allergic skin reaction.
·
Classification system:
The classification is according to the latest edition of Regulation 1272/2008, and extended by company and literature data.
·
2.2 Label elements
·
Labeling according to Regulation (EC) No 1272/2008: Not applicable
·
Hazard pictograms: Not applicable
·
Signal word: Not applicable
·
Hazard statements: Not applicable
·
Precautionary statement: Not applicable
·
2.3 Other hazards
·
Results of PBT and vPvB assessment
PBT: Not applicable
vPvB: Not applicable
Greatesting Service Shanghai Co.,Ltd.
上海量远检测技术有限公司
This report is only for reference of scientific research and education, or internal quality control.
Unless otherwise stated, the results shown in this test report refer only to the sample(s) received and tested in laboratory, and such sample(s) are retained for 30days only.
The ole responsibility of Greatesting Service (Shanghai) Co., Ltd is to ensures that this job has been performed according to our Quality System and complying contract and
legal conditions. This company bear only limited liability such as within 5 times of the cost of the test item and do not undertake any joint liability caused by this document.
Reproduction of this document is only valid if it is done completely and under the written permission of Greatesting Service (Shanghai) Co., Ltd.
If you happen to have any complaints, please do it by sending email to info@greatesting.com and referring to this report number.
10/F, 1# Building, No.2899 South Lianhua Road , Minhang District, Shanghai, China
上海市闵行区莲花南路 2899 号莲谷科技园 1 号楼 10 层
t (86-21)64788791
f (86-21)64788792
Http://www.greatesting.com
info@greatesting.com
Page 3
No. GSL20190802009E
Date: Aug. 08,2019
Page 3 of
SECTION 3: Composition/information on ingredients
·
3.1 Chemical characterization: Mixture
·
Description: Mixture of the substances listed below with nonhazardous additions.
·
Component:
CAS No.: 182442-95-1
EC No.: 695-690-9
Cobalt lithium manganese nickel oxide
25%~30%
CAS No.: 7782-42-5
EC No.: 231-955-3
Graphite
15%~20%
CAS No.: 24937-79-9
EC No.: 607-458-6
Polyvinylidene fluoride
2%~5%
CAS No.: 7440-50-8
EC No.: 231-159-6
Copper
5%~10%
CAS No.: 7429-90-5
EC No.: 231-072-3
Aluminium
5%~10%
CAS No.: 21324-40-3
EC No.: 244-334-7
Lithium Hexafluorophosphate
CAS No.: 96-49-1
EC No.: 202-510-0
Ethylene carbonate
CAS No.: 616-38-6
EC No.: 210-478-4
Index No.: 607-013-00-6
Dimethyl carbonate
CAS No.: 623-53-0
EC No.: 433-480-9
Ethyl methyl carbonate
CAS No.: 105-58-8
EC No.: 203-311-1
Diethyl carbonate
0.5%~3%
CAS No.: 9003-07-0
EC No.: 618-352-4
Polypropylene
1%~2%
CAS No.: 7440-02-0
EC No.: 231-111-4
Nickel
0.7%~1%
SECTION 4: First aid measures
·
4.1 Description of first aid measures
General advice: No special immediate medical attention or special treatment required normally; if the exposure to electrode ,
immediately call a POISON CENTER or doctor/physician
After inhalation: No special measures required normally; If inhale the electrode, remove person to fresh air and keep comfortable
for breathing. Immediately call a POISON CENTER or doctor/physician.
After skin contact: No special measures required normally; If the electrode contact with skin, Take off immediately all contaminated
clothing. Rinse skin with water/ shower. Immediately call a POISON CENTER or doctor/physician.
After eye contact: No special measures required normally; If the electrode contact with eyes, Rinse cautiously with water for several
minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a POISON CENTER or
doctor/physician.
After swallowing: No special measures required normally; If swallow the electrode, rinse mouth. Do NOT induce vomiting.
Immediately call a POISON CENTER or doctor/physician.
·
4.2 Most important symptoms and effects, both acute and delayed: There are not any known symptoms and effects normally
·
4.3 Indication of any immediate medical attention and special treatment needed: No further relevant information available.
Greatesting Service Shanghai Co.,Ltd.
上海量远检测技术有限公司
This report is only for reference of scientific research and education, or internal quality control.
Unless otherwise stated, the results shown in this test report refer only to the sample(s) received and tested in laboratory, and such sample(s) are retained for 30days only.
The ole responsibility of Greatesting Service (Shanghai) Co., Ltd is to ensures that this job has been performed according to our Quality System and complying contract and
legal conditions. This company bear only limited liability such as within 5 times of the cost of the test item and do not undertake any joint liability caused by this document.
Reproduction of this document is only valid if it is done completely and under the written permission of Greatesting Service (Shanghai) Co., Ltd.
If you happen to have any complaints, please do it by sending email to info@greatesting.com and referring to this report number.
10/F, 1# Building, No.2899 South Lianhua Road , Minhang District, Shanghai, China
上海市闵行区莲花南路 2899 号莲谷科技园 1 号楼 10 层
t (86-21)64788791
f (86-21)64788792
Http://www.greatesting.com
info@greatesting.com
Page 4
No. GSL20190802009E
Date: Aug. 08,2019
Page 4 of
SECTION 5: Fire-fighting measures
·
5.1 Extinguishing media
·
Suitable extinguishing agents: CO₂ , chemical dry powder, water spray or alcohol resistant foam.
·
5.2 Special hazards arising from the substance or mixture: May produce corrosive vapor/ dust under fire.
·
5.3 Advice for firefighters
Protective equipment: Wear fully protective suit and mouth respiratory protective device.
SECTION 6: Accidental release measures
·
6.1 Personal precautions, protective equipment and emergency procedures:
Cut off leakage source and collect spillage timely if safe do it; Ensure adequate ventilation; Wear protective gloves/protective
clothing/eye protection/face protection; Avoid contact with eyes and skin; Avoid release to the environment.
·
6.2 Environmental precautions:
Do not allow large quantities of the product to enter sewers/surface or ground water.
Inform respective authorities in case of seepage into water course or sewage system.
·
6.3 Methods and material for containment and cleaning up:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust); Do not use water to flush the
leakage; Dispose contaminated material as waste according to item 13.
·
6.4 Reference to other sections:
See section 7 for information on safe handing; See section 8 for information on personal protection equipment; See section 13 for
disposal in formation.
SECTION 7: Handling and storage
·
7.1 Precautions for safe handling: No special precaution required normally.
·
Information about fire and explosion protection: Normal measures for preventive fire protection.
·
7.2 Conditions for safe storage, including any non-compatibility
·
Requirements to be met by storerooms and receptacles: Store in a well-ventilated place. Keep cool.
·
Information about storage in one common storage facility: Store in the original container.
·
Further information about storage conditions: Store locked up.
·
7.3 Specific end use(s): Charging drill
Greatesting Service Shanghai Co.,Ltd.
上海量远检测技术有限公司
This report is only for reference of scientific research and education, or internal quality control.
Unless otherwise stated, the results shown in this test report refer only to the sample(s) received and tested in laboratory, and such sample(s) are retained for 30days only.
The ole responsibility of Greatesting Service (Shanghai) Co., Ltd is to ensures that this job has been performed according to our Quality System and complying contract and
legal conditions. This company bear only limited liability such as within 5 times of the cost of the test item and do not undertake any joint liability caused by this document.
Reproduction of this document is only valid if it is done completely and under the written permission of Greatesting Service (Shanghai) Co., Ltd.
If you happen to have any complaints, please do it by sending email to info@greatesting.com and referring to this report number.
10/F, 1# Building, No.2899 South Lianhua Road , Minhang District, Shanghai, China
上海市闵行区莲花南路 2899 号莲谷科技园 1 号楼 10 层
t (86-21)64788791
f (86-21)64788792
Http://www.greatesting.com
info@greatesting.com
Page 5
No. GSL20190802009E
Date: Aug. 08,2019
Page 5 of
Country
Limit value - Eight hours
Limit value - Short term
7782-42-5 Graphite
Belgium
2 mg/m
3
- Denmark
2.5 mg/m3 Respirable aerosol
5 mg/m3 Respirable aerosol
Finland
2 mg/m
3
- France
2 mg/m3 Respirable aerosol
-
Germany (DFG)
4 mg/m3 Inhalable aerosol; 1.5 mg/m3 Respirable aerosol
-
Ireland
10 mg/m3Inhalable fraction; 4 mg/m3 Respirable fraction
- Latvia
2 mg/m
3
- Spain
2 mg/m3 Inhalable aerosol
- Sweden
5 mg/m3 Respirable aerosol
- United Kingdom
10 mg/m3Inhalable fraction; 4 mg/m3 Respirable fraction
-
SECTION 8: Exposure controls/personal protection
·
8.1 Control parameters
·
Ingredients with limit values that require monitoring at the workplace:
·
DNELs: Data not available.
·
PNECs: Data not available.
·
Additional information: The lists valid during the marking were used as basis.
·
8.2 Exposure controls
·
Based on the composition shown in section 3, the following measures are suggested for occupational safety measure.
·
Appropriate engineering controls:
Handle in accordance with good industrial hygiene and safety practice; Wash hands and face before breaks and at the end of work;
See section 7 for information about design of technical facilities.
·
Personal protective equipment
·
Respiration protection: Dust mask is necessary.
·
Protection of hands:
Protective gloves
Gloves made from butyl rubber Neoprene™ rubber, nitrile rubber (thickness> 0.3mm; breakthrough times up to 480 minutes).
·
Eye protection:
Safety glasses
Protective goggles with side-shields.
·
Environmental exposure controls:
Control measures must be made in accordance with Community environmental protection legislation.
This report is only for reference of scientific research and education, or internal quality control.
Unless otherwise stated, the results shown in this test report refer only to the sample(s) received and tested in laboratory, and such sample(s) are retained for 30days only.
The ole responsibility of Greatesting Service (Shanghai) Co., Ltd is to ensures that this job has been performed according to our Quality System and complying contract and
legal conditions. This company bear only limited liability such as within 5 times of the cost of the test item and do not undertake any joint liability caused by this document.
Reproduction of this document is only valid if it is done completely and under the written permission of Greatesting Service (Shanghai) Co., Ltd.
Greatesting Service Shanghai Co.,Ltd.
上海量远检测技术有限公司
If you happen to have any complaints, please do it by sending email to info@greatesting.com and referring to this report number.
10/F, 1# Building, No.2899 South Lianhua Road , Minhang District, Shanghai, China
上海市闵行区莲花南路 2899 号莲谷科技园 1 号楼 10 层
t (86-21)64788791
f (86-21)64788792
Http://www.greatesting.com
info@greatesting.com
Page 6
No. GSL20190802009E
Date: Aug. 08,2019
Page 6 of
SECTION 9: Physical and chemical properties
·
9.1 Information on basic physical and chemical properties
·
Appearance:
Form
Solid
Color
Not available
Odor
Odorless
Odor threshold
Not applicable
·
pH-value
Not determined
·
Change in condition
Melting point/melting range
Not determined
Boiling point and boiling range
Not determined
·
Freezing point
Not determined
·
Flash point
Not determined
·
Flammability
Not flammable solid
·
Decomposition temperature
Not determined
·
Self-ignition
Product is not self-igniting.
·
Danger of explosion
Product does not present an explosion hazard
.
·
Explosion limits
Lower:
Not determined
Upper:
Not determined
·
Oxidizing properties
Not determined
·
Vapor pressure
Not determined
·
Density
Not determined
·
Relative density
Not determined
·
Vapor density
Not determined
·
Evaporation rate
Not determined
·
Solubility in/Miscibility with
Water
Not determined
·
Partition coefficient (n-octanol/water)
Not determined
·
Viscosity
Dynamic
Not applicable
Kinematic
Not applicable
·
9.2 Other information
Data not available
SECTION 10: Stability and reactivity
·
10.1 Reactivity: No decomposition if used according to specification.
·
10.2 Chemical stability: Stable under recommended storage conditions.
·
10.3 Possibility of hazardous reactions: No further relevant information available.
·
10.4 Conditions to avoid: High temperature.
·
10.5 Incompatible materials: Strong oxidizing agent and strong acid.
·
10.6 Hazardous decomposition products: No known hazardous decomposition products.
Greatesting Service Shanghai Co.,Ltd.
上海量远检测技术有限公司
This report is only for reference of scientific research and education, or internal quality control.
Unless otherwise stated, the results shown in this test report refer only to the sample(s) received and tested in laboratory, and such sample(s) are retained for 30days only.
The ole responsibility of Greatesting Service (Shanghai) Co., Ltd is to ensures that this job has been performed according to our Quality System and complying contract and
legal conditions. This company bear only limited liability such as within 5 times of the cost of the test item and do not undertake any joint liability caused by this document.
Reproduction of this document is only valid if it is done completely and under the written permission of Greatesting Service (Shanghai) Co., Ltd.
If you happen to have any complaints, please do it by sending email to info@greatesting.com and referring to this report number.
10/F, 1# Building, No.2899 South Lianhua Road , Minhang District, Shanghai, China
上海市闵行区莲花南路 2899 号莲谷科技园 1 号楼 10 层
t (86-21)64788791
f (86-21)64788792
Http://www.greatesting.com
info@greatesting.com
Page 7
No. GSL20190802009E
Date: Aug. 08,2019
Page 7 of
SECTION 11: Toxicological information
·
11.1 Information on toxicological effects
·
Acute toxicity: Based on available data, the classification criteria are not met.
·
LD/LC50 values relevant for classification: No animal test has been done for this product.
·
Skin corrosion/irritation: Based on available data, the classification criteria are not met.
·
Serious eyes damage/ irritation: Based on available data, the classification criteria are not met.
·
Respiratory or skin sensitization: Based on available data, the classification criteria are not met.
·
Germ cell mutagenicity: Based on available data, the classification criteria are not met.
·
Carcinogenicity: Based on available data, the classification criteria are not met.
·
Reproductive toxicity: Based on available data, the classification criteria are not met.
·
STOT-single exposure: Based on available data, the classification criteria are not met.
·
STOT-repeated exposure: Based on available data, the classification criteria are not met.
·
Aspiration hazard: Based on available data, the classification criteria are not met.
SECTION 12: Ecological information
·
12.1 Toxicity
·
Aquatic toxicity: Not hazardous to aquatic organism normally.
·
12.2 Persistence and degradability: Data not available.
·
12.3 Bio-accumulative potential: Data not available.
·
12.4 Mobility in soil: Data not available.
·
12.5 Results of PBT and vPvB assessment
PBT: Not applicable
vPvB: Not applicable
·
12.6 Other adverse effects: No further relevant information available.
·
12.7 Additional ecological information
·
General notes: Water hazard class 1 (German Regulation) (self-assessment): Slightly hazardous for water.
Do not allow large quantities of the product to reach ground water, water course or sewage system.
SECTION 13:Disposal consideration
·
13.1 Waste treatment methods
·
Recommendation: Must not be disposed together with household garbage.
·
13.2 Un-cleaned packaging
·
Recommendation: Dispose of contents/container in according to the local regulation.
Greatesting Service Shanghai Co.,Ltd.
上海量远检测技术有限公司
This report is only for reference of scientific research and education, or internal quality control.
Unless otherwise stated, the results shown in this test report refer only to the sample(s) received and tested in laboratory, and such sample(s) are retained for 30days only.
The ole responsibility of Greatesting Service (Shanghai) Co., Ltd is to ensures that this job has been performed according to our Quality System and complying contract and
legal conditions. This company bear only limited liability such as within 5 times of the cost of the test item and do not undertake any joint liability caused by this document.
Reproduction of this document is only valid if it is done completely and under the written permission of Greatesting Service (Shanghai) Co., Ltd.
If you happen to have any complaints, please do it by sending email to info@greatesting.com and referring to this report number.
10/F, 1# Building, No.2899 South Lianhua Road , Minhang District, Shanghai, China
上海市闵行区莲花南路 2899 号莲谷科技园 1 号楼 10 层
t (86-21)64788791
f (86-21)64788792
Http://www.greatesting.com
info@greatesting.com
Page 8
No. GSL20190802009E
Date: Aug. 08,2019
Page 8 of
SECTION 15: Regulatory information
·
15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture
·
MAK (German Maximum Workplace Concentration):
·
Directive 2012/18/EU
·
Named dangerous substances-ANNEX I: None of the ingredients is listed.
·
National regulations.
·
Water hazard class: Water hazard class 1 (German Regulation) (self-assessment): Slightly hazardous for water.
·
Other regulations, limitations and prohibitive regulations
·
SVHC Candidate list of REACH Regulation Annex XIV Authorization: None of the ingredients is listed.
·
REACH Regulation Annex XVII Restriction:
·
REACH Regulation Annex XIV Authorization List: None of the ingredients is listed.
·
15.2 Chemical safety assessment: A Chemical Safe Assessment has not been carried out.
SECTION 14: Transport information
The article is not subject to other provisions of IMO IMDG Code according to special provision 188. The package has passed the
1.2m drop test, meet the requirements of each applicable test in the UN Manual of Tests and criteria, Part III, sub-section 38.3.
The detail information please refer to Certification for Safe Transport of Chemical Goods, (No.: 2119080376)
·
14.1 UN-Number
IMDG
Not regulated as dangerous transport goods, not applicable
·
14.2 UN proper shipping name
IMDG
Not applicable
·
14.3 Transport hazard class (es)
IMDG
Class
Not applicable
Label
Not applicable
·
14.4 Packing group
IMDG
Not applicable
·
14.5 Marine pollution
No · 14.6 Special precautions for user
Not applicable
·
14.7 UN “Model Regulation”
-
7440-02-0
Nickel
1
7440-02-0
Nickel
Entry no. 27
Greatesting Service Shanghai Co.,Ltd.
上海量远检测技术有限公司
This report is only for reference of scientific research and education, or internal quality control.
Unless otherwise stated, the results shown in this test report refer only to the sample(s) received and tested in laboratory, and such sample(s) are retained for 30days only.
The ole responsibility of Greatesting Service (Shanghai) Co., Ltd is to ensures that this job has been performed according to our Quality System and complying contract and
legal conditions. This company bear only limited liability such as within 5 times of the cost of the test item and do not undertake any joint liability caused by this document.
Reproduction of this document is only valid if it is done completely and under the written permission of Greatesting Service (Shanghai) Co., Ltd.
If you happen to have any complaints, please do it by sending email to info@greatesting.com and referring to this report number.
10/F, 1# Building, No.2899 South Lianhua Road , Minhang District, Shanghai, China
上海市闵行区莲花南路 2899 号莲谷科技园 1 号楼 10 层
t (86-21)64788791
f (86-21)64788792
Http://www.greatesting.com
info@greatesting.com
Page 9
No. GSL20190802009E
Date: Aug. 08,2019
Page 9 of
SECTION 16: Other information
The contents and format of this SDS are in accordance with Regulation (EC) No 1907/2006, 1272/2008 and Regulation (EU) No
2015/830.
DISCLAIMER OF LIABILITY:
The information in this SDS was obtained from sources which we believe are reliable. However, the information is provided without
any warranty, express or implied, regarding its correctness. The conditions or methods of handling, storage, use or disposal of the
product are beyond our control and may be beyond our knowledge. For this and other reasons, we do not assume responsibility and
expressly disclaim liability for loss, damage or expense arising out of or in any way connected with the handling, storage, use or
disposal of the product. This SDS was prepared and is to be used only for this product. If the product is used as a component in
another product, this SDS information may not be applicable.
***********************************************************************************************************
·
Abbreviations and acronyms:
ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International Carriage of Dangerous Goods
by Road).
IMDG: International Maritime Code for Dangerous Goods.
IATA: International Air Transport Association.
GHS: Globally Harmonized System of Classification and Labeling of Chemicals
CAS: Chemical Abstracts Service (division of the American Chemical Society)
DNEL: Derived No-Effect Level (REACH)
PNEC: Predicted No-Effect Concentration (REACH)
PBT: Persistent, Bio accumulative and Toxic
SVHC: Substance of Very High Concern
LD50: Lethal dose, 50 percent
LC50: Lethal concentration, 50 percent
*************************************************************************************************************************************
End of safety data sheet
Greatesting Service Shanghai Co.,Ltd.
上海量远检测技术有限公司
This report is only for reference of scientific research and education, or internal quality control.
Unless otherwise stated, the results shown in this test report refer only to the sample(s) received and tested in laboratory, and such sample(s) are retained for 30days only.
The ole responsibility of Greatesting Service (Shanghai) Co., Ltd is to ensures that this job has been performed according to our Quality System and complying contract and
legal conditions. This company bear only limited liability such as within 5 times of the cost of the test item and do not undertake any joint liability caused by this document.
Reproduction of this document is only valid if it is done completely and under the written permission of Greatesting Service (Shanghai) Co., Ltd.
If you happen to have any complaints, please do it by sending email to info@greatesting.com and referring to this report number.
10/F, 1# Building, No.2899 South Lianhua Road , Minhang District, Shanghai, China
上海市闵行区莲花南路 2899 号莲谷科技园 1 号楼 10 层
t (86-21)64788791
f (86-21)64788792
Http://www.greatesting.com
info@greatesting.com
Loading...