Page 1
Safety Data Sheets (SDSs)
Report No:
SA2004052S 03001
Preparation Date:
April 09, 2020
Total number of pages:
10
Revision Date:
N/A
Reviewed by:
Vincent Liu
Approved by:
Bruce Yu
Testing laboratory:
Dongguan Anci Electronic Technology Co., Ltd.
Testing Address:
1-2 Floor, Building A, No.11, Headquarters 2 Road,
Songshan Lake Hi-tech Industrial, Development Zone,
Dongguan City, Guangdong Pr. China
Applicant’s name:
TVX Clean Equipment Co., Ltd
Address:
Building 8, Phase 2, Zifeng R&D Center, NO.121 BaiHe
Road, Pukou District, Nanjing
Product name:
Lead Acid Battery
Model /Type reference:
6-EVF-150A
Trademark
Product Specification
12V 150AH
Version Number
V1.0
For
TVX Clean Equipment Co., Ltd
Building 8, Phase 2, Zifeng R&D Center, NO.121 BaiHe Road, Pukou District, Nanjing
and for their product
Dongguan Anci Electronic Technology Co., Ltd.
Address：1-2 Floor, Building A, No.11, Headquarters 2 Road, Songshan Lake Hi-tech Industrial, Development Zone, Dongguan City, Guangdong Pr. China
Tel：0769-85075888 Fax：0769-58075898
E-mail:ada@anci.com Web: www.anci.com.cn
Page 2
Report No：SA2004052S 03001
Page2of
10
Product name:
Lead Acid Battery
Product description
Model:
6-EVF-150A
Trade mark:
Product Specification
12V 150AH
Recommended Use
Used in not portabl electronic equipments
Uses advidsed against:
a)
Do not dismantle, open or shred secondary cells or batteries.
b)
Do not expose cells or batteries to heat or fire. Avoid storage in direct
sunlight.
c)
Do not short-circuit a cell or a battery. Do not store cells or batteries
haphazardly in a box or drawer where they may short-circuit each other
or be short-circuited by other metal objects.
d)
Do not remove a cell or battery from its original packaging until required
for use.
e)
Do not subject cells or batteries to mechanical shock.
f)
In the event of a cell leaking, do not allow the liquid to come in contact
with the skin or eyes. If contact has been made, wash the affected area
with copious amounts of water and seek medical advice.
g)
Do not use any charger other than that specifically provided for use with
the equipment.
h)
Observe the plus (+) and minus (–) marks on the cell, battery and
equipment and ensure correct use.
i)
Do not use any cell or battery which is not designed for use with the
equipment.
j)
Do not mix cells of different manufacture, capacity, size or type within a
device.
k)
Battery usage by children should be supervised.
l)
Seek medical advice immediately if a cell or a battery has been
swallowed.
m)
Always purchase the battery recommended by the device manufacturer
for the equipment.
n)
Keep cells and batteries clean and dry.
o)
Wipe the cell or battery terminals with a clean dry cloth if they become
dirty.
p)
Secondary cells and batteries need to be charged before use. Always
1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE
COMPANY/UNDERTAKING
Product Identifier
Other means of identification
Recommended use of the chemical and restrictions on use
Dongguan Anci Electronic Technology Co., Ltd.
Address：1-2 Floor, Building A, No.11, Headquarters 2 Road, Songshan Lake Hi-tech Industrial, Development Zone, Dongguan City,
Guangdong Pr. China
Tel：0769-85075888 Fax：0769-58075898
E-mail:ada@anci.com Web: www.anci.com.cn
Page 3
Report No：SA2004052S 03001
Page3of
10
use the correct charger and refer to the manufacturer’s instructions or
equipment manual for proper charging instructions.
q)
Do not leave a battery on prolonged charge when not in use.
r)
After extended periods of storage, it may be necessary to charge and
discharge the cells or batteries several times to obtain maximum
performance.
s)
Retain the original product literature for future reference.
t)
Use only the cell or battery in the application for which it was intended.
u)
When possible, remove the battery from the equipment when not in use.
v)
Dispose of properly.
Applicant
TVX Clean Equipment Co., Ltd
Applicant Address
Building 8, Phase 2, Zifeng R&D Center, NO.121
BaiHe Road, Pukou District, Nanjing
Company Emergency Phone Number:
18005187289
E-mail address:
sourcing@tvxclean.com
Manufacturer
Chaowei Power Co., Ltd
Manufacturer Address
No.18 Xinxing Industrial Park South Road, Changxing
County, Zhejiang Province
Telephone number of the supplier:
13655826686
E-mail address:
947844975@qq.com
Details of the supplier and Manufacturerof the safety data sheet:
Dongguan Anci Electronic Technology Co., Ltd.
Address：1-2 Floor, Building A, No.11, Headquarters 2 Road, Songshan Lake Hi-tech Industrial, Development Zone, Dongguan City,
Guangdong Pr. China
Tel：0769-85075888 Fax：0769-58075898
E-mail:ada@anci.com Web: www.anci.com.cn
Page 4
Report No：SA2004052S 03001
Page4of
10
Common Chemical Name
Concentration (%)
CAS Number
Lead
60-80
7439-92-1
Diluted Sulfuric Acid
5-20
7664-93-9
Acrylonitrile/Butadiene/Styrene
Resin(ABS)
5-10
9003-56-9
AGM Fiberglass Separator
1-5
65997-17-3
Epoxy Resin
0.1-1
--
Eye Contact
Rinse immediately with plenty of water, also under the eyelids, for at least
15 minutes. Keep eye wide open while rinsing. Do not rub affected area.
Remove contact lenses, if present and easy to do. Continue rinsing. Seek
immediate medical attention/advice.
Skin Contact
Wash off immediately with soap and plenty of water while removing all
contaminated clothes and shoes. Immediate medical attention is
required. May cause an allergic skin reaction.
Inhalation
Remove to fresh air. If breathing has stopped, give artificial respiration.
Get medical attention immediately. Do not use mouth-to-mouth method if
2. HAZARDS IDENTIFICATION
Hazards Identification:
The battery is valve regulated type. It isNOT restricted to IATA DGR according to special
provision A67 and is NOTrestricted to IMDG CODE according to special provision 238.
Emergency Overview:
The internal battery materials may cause severe irritation to eyes and skin. Causes burns.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Chemical characterixation: Mixtures
Description:
Product: Consisting of the following components.
Note: CAS number is Chemical Abstract Service Registry Number.
4. FIRST-AID MEASURES
First aid measures
First aid is upon rupture of sealed battery.
Dongguan Anci Electronic Technology Co., Ltd.
Address：1-2 Floor, Building A, No.11, Headquarters 2 Road, Songshan Lake Hi-tech Industrial, Development Zone, Dongguan City,
Guangdong Pr. China
Tel：0769-85075888 Fax：0769-58075898
E-mail:ada@anci.com Web: www.anci.com.cn
Page 5
Report No：SA2004052S 03001
Page5of
10
victim ingested or inhaled the substance; give artificial respiration with the
aid of a pocket mask equipped with a one-way valve or other proper
respiratory medical device. If breathing is difficult, (trained personnel
should) give oxygen. Delayed pulmonary edema may occur. Get medical
attention immediately if symptoms occur.
Ingestion
Do NOT induce vomiting. Rinse mouth immediately and drink plenty of
water. Never give anything by mouth to an unconscious person. Call a
physician or poison control center immediately.
Self-protection of the
first cider
Avoid contact with skin, eyes or clothing. Use personal protective
equipment as required. Wear personal protective clothing (see section 8).
Notes to Physician
Product is a corrosive material. Use of gastric lavage or emesis is
contraindicated. Possible perforation of stomach or esophagus should be
investigated. Do not give chemical antidotes. Asphyxia from glottal
edema may occur. Marked decrease in blood pressure may occur with
moist rates, frothy sputum, and high pulse pressure. May cause
sensitization of susceptible persons.
Treat symptomatically.
Most important symptoms and effects, both acute and delayed
Itching. Coughing and/ or wheezing. Burning sensation.
Indication of any immediate medical attention and special treatment needed
5. FIRE-FIGHTING MEASURES
Suitable Extinguishing Media
Dry chemical, Sandy soil, Carbon dioxide or appropriate foam.
Specific Hazards Arising from the Chemical
Under fire conditions, batteries may burst and release hazardous decomposition products when
exposed to a fire situation.
Formation of toxic gases is possible during heating or in case of fire.
In case of fire, the following can be released:
Carbon monoxide(CO)
Carbon dioxide
Other irritating and toxic gases.
Protective Equipment and Precautions for Firefighters
Firefighters must wear fire resistant protective equipment and appropriate breathing apparatus. The
staff must equip with filtermask (full mask) or isolated breathing apparatus. The staff must wear the
clothes which can defense the fire and the toxic gas. Put out the fire in the upwind direction. Remove
Dongguan Anci Electronic Technology Co., Ltd.
Address：1-2 Floor, Building A, No.11, Headquarters 2 Road, Songshan Lake Hi-tech Industrial, Development Zone, Dongguan City,
Guangdong Pr. China
Tel：0769-85075888 Fax：0769-58075898
E-mail:ada@anci.com Web: www.anci.com.cn
Page 6
Report No：SA2004052S 03001
Page6of
10
Personal Precautions
Attention!Corrosive material. Avoid contact with skin, eyes or clothing.
Ensure adequate ventilation. Use personal protective equipment as
required. Evacuate personnel to safe areas. Keep people away from and
upwind of spill/leak.
Other information
Refer to protective measures listed in Sections 7 and 8.
Methods for Containment
prevent further leakage or spillage if safe to do so.
Methods for Cleaning up
Use personal protective equipment. Dam up. Cover liquid spill with
sand, earth or other Non combustible absorbent material. Pick up and
transfer to properly labeled containers. Clean contaminated surface
thoroughly.
Handling
Handle in accordance with good industrial hygiene and safety
practice. Avoid contact with skin, eyes and clothing. Wear personal
protective equipment.
Wash thoroughly after handling. Use this material with adequate
ventilation.
The product is not explosive.
the container to the open space as soon as possible. Spray water on the containers in the fireplace
to keep them cool until finish extinguishment.
6. ACCIDENTAL RELEASE MEASURES
Personal precautions, protective equipment and emergency procedures
Environmental precautions
Refer to protective measures listed in Sections 7 and 8. Prevent further leakage or spillage if safe to
do so. Should not be released into the environment. Do not allow to enter into soil/subsoil. Prevent
product from entering drains.
Methods and material for containment and cleaning up
7. HANDLING AND STORAGE
Precautions for safe handling
Conditions for safe storage, including any incompatibilities
Do not storage Battery haphazardly in a box or drawer where they may short-circuit each other or be
short-circuited by other metal objects.
Keep out of reach of children.
Do not expose Lithium-ion Polymer Battery to heat or fire. Avoid storage in direct sunlight.
Do not store together with oxidizing and acidic materials.
Keep ignition sources away- Do not smoke.
Store in cool, dry and well-ventilated place.
Dongguan Anci Electronic Technology Co., Ltd.
Address：1-2 Floor, Building A, No.11, Headquarters 2 Road, Songshan Lake Hi-tech Industrial, Development Zone, Dongguan City,
Guangdong Pr. China
Tel：0769-85075888 Fax：0769-58075898
E-mail:ada@anci.com Web: www.anci.com.cn
Page 7
Report No：SA2004052S 03001
Page7of
10
Physical
State
Form: Prismatic
Color: --
Odour: Odourless
Odor Threshold: No information available
Change in condition:
pH, with indication of the concentration
Not determined.
Melting point/freezing point
Not determined.
Initial boiling point and Boiling range:
Not determined.
Flash Point
Not determined.
Evaporation rate
Not determined.
Flammability (solid, gas)
Not determined.
Upper/lower flammability or explosive limits
Not determined.
Incompatible Products None known.
8. EXPOSURE CONTROLS AND PERSONAL PROTECTION
(a) Engineering Controls
Use local exhaust ventilation or other engineering controls to control sources of dust, mist, fumes
and vapor. Keepaway from heat and open flame. Store in a cool, dry place.
(b) Personal Protective Equipment
Respiratory Protection: Not necessary under normal conditions.Skin and body Protection: Not
necessary under normal conditions, Wear neoprene or nitrile rubber gloves ifhandling an open or
leaking battery.
Hand protection: Wear neoprene or natural rubber material gloves if handling an open or leaking
battery.
Eye Protection: Not necessary under normal conditions, wear safety glasses if handling an open or
leaking battery.
(c) Other Protective Equipment
Have a safety shower and eye wash fountain readily available in the immediate work area.
(d) Hygiene Measures
Do not eat, drink, or smoke in work area. Maintain good housekeeping.
9. PHYSICAL AND CHEMICAL PROPERTIES
Dongguan Anci Electronic Technology Co., Ltd.
Address：1-2 Floor, Building A, No.11, Headquarters 2 Road, Songshan Lake Hi-tech Industrial, Development Zone, Dongguan City,
Guangdong Pr. China
Tel：0769-85075888 Fax：0769-58075898
E-mail:ada@anci.com Web: www.anci.com.cn
Page 8
Report No：SA2004052S 03001
Page8of
10
Vapor Pressure:
Not determined.
Vapor Density:
Not determined.
relative density:
Not determined.
Solubility in Water:
Not determined.
Solubility in other solvents
Not determined.
n-octanol/water partition coefficient
Not determined.
Auto-ignition temperature
Not determined.
Decomposition temperature
Not determined.
Odout threshold
Not determined.
Evaporation rate
Not determined.
Viscosity
Not determined.
Other Information
No further relevant information available.
LD/LC50 values relevant for classification:
Not available.
10. STABILITY AND REACTIVITY
Reactivity: Stable under recommended storage and handling conditions (see section 7, Handling
and storage).
Chemical stability: Stable under normal conditions of use, storage and transport.
Thermal decomposition/conditions to be avoided: No decomposition if used according to
specifications.
Possibility of Hazardous Reactions: None under normal processing.
Hazardous Polymerization: Hazardous polymerization does not occur.
Conditions to avoid: Strong heating, fire, Incompatible materials.
Incompatible materials: Strong oxidizing agents. Strong acids.Base metals.
Hazardous Decomposition Products:Carbon oxides, Other irritating and toxic gases.
11. TOXICOLOGICAL INFORMATION
Acute toxiciy: No data available.
Skin corrosion/irritation: No irritant effect.
Serious eye damage/irritation: Cause serious eye irritation.
Respiratory or skin sensitization: No sensitizing effects known.
Specific target organ system toxicity: No information available.
CMR effects(carcinogenity, mutagenicity and toxicity for reproduction): No information
available.
Dongguan Anci Electronic Technology Co., Ltd.
Address：1-2 Floor, Building A, No.11, Headquarters 2 Road, Songshan Lake Hi-tech Industrial, Development Zone, Dongguan City,
Guangdong Pr. China
Tel：0769-85075888 Fax：0769-58075898
E-mail:ada@anci.com Web: www.anci.com.cn
Page 9
Report No：SA2004052S 03001
Page9of
10
Acquatic toxicity:
No further relevant information available.
12. Ecological Information
Toxicity:
Persistence and degradability: No further relevant information available.
Bioaccumulative potential: No further relevant information available.
Mobility in soil: No further relevant information available.
Results of PBT and vPvB assessment
PBT: Not applicable.
vPvB: Not applicable.
Other adverse effects: No information available.
13 DISPOSAL CONSIDERATIONS
Waste treatment methods
Recommendation: Must not be disposed together with household garbage.
Do not allow product to reach sewage system
Uncleaned packaging:
Recommendation: Disposal must be made according to official regulations.
14.TRANSPORT INFORMATION
The battery has passed the vibration test, pressure differential test and leakage test at
55℃according to Recommendations on the IMOIMDG CODE. This substance is NOT subject
to IMO IMDG CODE according to Special Provision 238.
IATA: Proper Shipping Name: --
UN Number: --
Hazard Class: --
IMO: Proper Shipping Name: --
UN Number: --
Hazard Class: --
Packing Group:--
Dongguan Anci Electronic Technology Co., Ltd.
Address：1-2 Floor, Building A, No.11, Headquarters 2 Road, Songshan Lake Hi-tech Industrial, Development Zone, Dongguan City,
Guangdong Pr. China
Tel：0769-85075888 Fax：0769-58075898
E-mail:ada@anci.com Web: www.anci.com.cn
Page 10
Report No：SA2004052S 03001
Page10of
10
Preparation and revision information
Date of previous revision
Date of this revision
Revision summary
Not applicable
/
The first New SDS
15. REGULATORY INFORMATION
EU Additional Classification:
S 36/37
Safety Statements: Wear suitable protective clothing and gloves.
16. OTHER INFORMATION
This information is based on our present knowledge. However, this shall not constitute a
guarantee for any specific product features and shall not establish a legally valid contractual
relationship.
Photo
Dongguan Anci Electronic Technology Co., Ltd.
Address：1-2 Floor, Building A, No.11, Headquarters 2 Road, Songshan Lake Hi-tech Industrial, Development Zone, Dongguan City,
Guangdong Pr. China
Tel：0769-85075888 Fax：0769-58075898
E-mail:ada@anci.com Web: www.anci.com.cn
*****************End of SDS******************
Loading...