Glen Dimplex Home Appliances Ltd BEL MW60G User Manual

BEL MW60G

Microwave Instruction Manual

Read the Instructions carefully and Keep for Future Reference

SPECIFICATIONS

2

Power consumption:

230V~50Hz, 1450W

Output:
Grill Heater:
Operating Frequency:
Outside Dimensions:
Oven Cavity Dimensions:
Oven Capacity:
Unpacked Weight:

BEFORE YOU CALL FOR SERVICE

1. If the oven will not perform at all, the display does not
appear or the display disappears:
a) Check to ensure that the oven is plugged in securely. If it
is not, remove the plug from the outlet, wait 10 seconds
and plug it in again securely.
b) Check the premises for a blown circuit fuse or a tripped
main circuit breaker. If these seem to be operating properly,

900W
1200W
2,450MHz
520mm(W) X 430mm(D) X 290mm(H)
350mm(W) X 372mm(D) X 232mm(H)
30litres
Approx. 17.5kg

test the outlet with another appliance.

2. If the microwave power does not function:
a) Check to see whether the timer is set.
b) Check to make sure that the door is securely closed to
engage the safety interlocks. Otherwise, the microwave
energy will not flow into the oven.

IF NONE OF THE ABOVE RECTIFIES THE SITUATION, THEN CONTACT THE AUTHORIZED SERVICE AGENT.

Note:
The appliance is for household use for heating food and beverages using elect romagnetic energy and for indoor
use only.

RADIO INTERFERENCE

Microwave oven may cause interference to your radio, TV, or similar equipment. When interference occurs, it may be
eliminated or reduced by the following procedures.
a. Clean the door and sealing surface of the oven.
b. Place the radio, TV, etc. as far away from your microwave oven as possible.
c. Use a properly installed antenna for your radio, TV, etc. to get a strong signal reception.

3

INSTALLATION

1. Make sure all the packing materials are removed from
the inside of the door.

2. Inspect the oven after unpacking for any visual
damage such as:
Misaligned Door
Damaged Door
Dents or Holes in Door Window and Screen
Dents in Cavity
If any of the above are visible, DO NOT use the

oven.

WARNING-THIS APPLIANCE MUST BE EARTHED.

1. The plug socket should be within easy reach
of the power cord

2. This oven requires 1.5 KVA for its input.
consultation with service engineer is
suggested when installing the oven.

3. This Microwave Oven weighs 17.5 kg and must be
placed on a horizontal surface strong enough to

support this weight.

4. The oven must be placed away from high temperature
and steam.

5. DO NOT place anything on top of the oven.

6. DO NOT remove the turn -table drive shaft.

7. As with any appliance, close supervision is necessary

when used by children.

CAUTION: This oven is protected internally by
ac 250V,10 Amp Fuse.

IMPORTANT

The wires in this mains lead are coloured in accordance with the following code:

Green-and-yellow : Earth
Blue : Neutral
Brown : Live

As the colours of the wires in the mains leads of the appliance may not correspond with the coloured markings
identifying the terminals in your plug, proceed as follows:

The wire which is coloured green-and-yello w must be connected to the terminal in the plug which is marked with the
letter E or by the earth symbol coloured green of green-and-yellow.

The wire which is coloured blue must be connected to the terminal which is marked with the letter N or c oloured black.

The wire which is coloured brown must be connected to the terminal which is marked with the letter L or coloured red.

4

IMPORTANT SAFETY INSTRUCTIONS

-WARNING: When the appliance is operated in the combination mode, children should onl y use the ov en under adult
supervision due to the temperatures generated; (Only for the model with grill function)

-WARNING: If the door or door seals are damaged, the oven must not be operated until it has been repaired by a

competent person;

-WARNING: It is hazardous for anyone other than a competent person to carry out any service or repair operation
that involves the removal of a cover which gives protection against exposure to microwave energy;

-WARNING: liquids and other foods must not be heated in sealed containers since they are liable to explode.

-WARNING: Only allow children to use the oven without supervision when adequate instructions have been given
so that the child is able to use the oven in a safe way and understands the hazards of improper use;

- The oven must have sufficient air flow. Keep 10 cm space at back;15 cm at both sides and 30cms from top of the
oven. Don't remove oven's feet, do not block air events of the oven.

- Only use utensils that are suitable for use in microwave ovens.

- When heating food in plastic or paper containers, keep an eye on the oven due to the possibility of ignition;

- If smoke is observed, switch off or unplug the appliance and keep the door closed in order to stifle any flames;

- Microwave heating of beverages can result in delayed eruptive boiling, therefore care must be taken when handl ing

the container;

- The contents of feeding bottles and baby food jars shall be stirred or shaken and the temperature checked before
consumption, in order to avoid burns;

- Eggs in their shell and whole hard-boiled eggs should not be heated in microwave ovens since they m ay explode,
even after microwave heating has ended;

- When cleaning surfaces of door, door seal, cavity of the oven, use only mild, nonabrasive soaps, or detergents
applied with a sponge or soft cloth.

- The oven should be cleaned regularly and any food deposits removed;

- Failure to maintain the oven in a clean condition could lead to deterioration of the surface that could adversely affect
the life of the appliance and possibly result in a hazardous situation;

- If the supply cord is damaged, it must be replaced by the manufacturer, its service agent or
similarly qualified persons in order to avoid a hazard.

SAFETY INSTRUCTIONS FOR GENERAL USE
Listed below are, as with all appliances, certain rules to follow and safeguards to assure top performance from

this oven:

1. Always have the glass tray, roller arms, coupling and roller track in place when operating the oven.

2. Do not use the oven for any reason other than food preparation, such as for drying clothes, paper, or any
other non-food items, or for sterilizing p urposes.

3. Do not operate the oven when empty. This could damage the oven.

4. Do not use the oven cavity for any type of storage, such a papers, cookbooks, etc.

5.Do not cook any food surrounded by a membrane, such as egg yolks, potatoes, chicken livers, etc without
first being pierced several times with a fork.

5

6. Do not insert any object into the openings on the outer
case.

7. Do not at any time remove parts from the oven such as
the feet, coupling, screws, etc.

8. Do not cook food directly on the glass tray. Place food
in/on proper cooking utensil before placing in the oven.

9. IMPORTANT-COOKWARE NOT TO USE IN YOUR
MICROWAVE OVEN
Do not use metal pans or dishes with metal handles.
Do not use anything with metal trim.
Do not use paper covered wire twist-ties on plastic bags.
Do not use melamine dishes as they contain a material
which will absorb microwave energy. This may cause
the dishes to crack or char and will slow down the
cooking speed.
Do not use Centura Tableware. The glaze is not suitable
for microwave use. Corelle Livingware closed handle
cups should not be used.
Do not cook in a container with a restricted opening,
such as a pop bottle or salad oil bottle, as they may
explode if heated in a microwave oven.
Do not use conventional meat or candy thermometers.

There are the thermometers available specifically for

microwave cooking. These may be used.

10. Microwave utensils should be used only in
accordance with manufacturer's instructions.

11. Do not attempt to deep-fry foods in this oven.

12. Please remember that a microwave oven only
heats the liquid in a container rather than the
container itself. Therefore, even though the lid
of a container is not hot to the touch when

FEATURE DIAGRAM

1 2

5 3

4

6

1

7

removed from the oven, please remember that
the food/liquid inside will be releasing the same
amount of steam and/or spitting when the lid is
removed as in conventional cooking.

13. Always test the temperature of cooked food
yourself especially if you are heating or cooking
food/liquid for babies. It is advisable never to
consume food/liquid straight from the oven but
allow it to stand for a few minutes and stir food/
liquid to distribute heat evenly.

14. Food containing a mixture of fat and water,
e.g. stock, should stand for 30-60 seconds in the
oven after it has been turned off. This is to allow
the mixture to settle and to prevent bubbling when
a spoon is placed in the food/liquid or a stock cube
is added.

15. When preparing/cooking food/liquid and remember
that there are certain foods, e.g. Christmas
puddings, jam and mincemeat, which heat up very
quickly. When heating or cooking foods with a high
fat or sugar content do not use plastic containers.

16. Cooking utensil may become hot because of heat
transferred from the heated food. This is especially
true if plastic wrap has been covering the top and
handles of the utensil. Potholders may be nee ded
to handle the utensil.

17.To reduce the risk of fire in the oven cavity:
(a)Do not overcook food. Carefully attend microwave
oven if paper, plastic, or other combustible materials
are placed inside the oven to facilitate cooking.
(b)Remove wire twist-ties from bags before placing
bag in oven.
(c)If materials inside the oven should ignite, keep oven
door closed, turn the oven off at the wall switch, or
shut off power at the fuse or circuit breaker panel.

(1) Door Safety Lock System
(2) Oven Window
(3) Oven Air Vent
(4) Roller Ring
(5) Glass Tray
(6) Control Panel
(7) Grill rack

6

COMPUTER CONTROL PANEL

Micro/

Grill/Combi

1) Micro/Grill/Combi

2) Auto Menu

Start/Reset

5) Start/Reset

m

i

T

e

/

S

t

s

o

r

f

e

D

Clock/TimerAuto Menu

3) Clock/Timer

4) Display Menu

e

t

t

i

n

g

6) Defrost/Time Setting

Operating Instructions

7

1. Single button Heating
With a simple press of a button you can start simple cooking, it is quick and easy to heat items;
Example: To heat a glass of milk
a) Put a glass of milk onto the glass turntable and close the door.
b) Press the “Start/Reset” Button, the microwave will then work on 100% power for 1 minute.
c) You will hear 5 beeps when the cooking is completed.

2. Microwave Heating

This Function has 2 options;

1) Quick Microwave Heating (100% Power)
Example: To heat food on 100% for 5 minutes;
a) Set time to 5:00
b) Press Start/Reset

2) Manual Operation Microwave Heating
Example: To heat food on 70% for 10 minutes
a) Press “Micro/Grill/Combi” button, select 70% power.
b) Set time to 10 Minutes
c) Press Start/Reset

There are 5 power levels and the longest heating time is 60 minutes

Times to Touch Microwave Power Display

1 100% P100
2 70% P70
3 50% P50
4 30% P30
5 10% P10

3. Auto weight defrost
Select the food weight, it will automatically help you to adjust the power level and time.

Example: defrost 0.5kg frozen meat.
a) Rotate the knob left "Defrost/Time Setting" to set the weight 0.5kg
b) Press "Start/Reset".
The weight of meat must be less than 2 kg.

4.Auto-Menu
You only need to select the food type and weight, it will help you to automatically adjust
the power and time.
Example: Auto cooking 0.4 kg fish
a) Press "Auto Menu" button until "A-5"displayed.
b) Rotate the knob "Defrost/Time Setting" to set the weight 0.4kg.
c) Press "Start/Reset"

Touching

8

Weight

Times

1
2
3
4
5
6
7
8
9

10

Menu Rice

(A-1)

0.1

0.2

0.3

0.4

0.5

Vegetable

(A-2)

0.1

0.2

0.3

0.4

0.5

0.6

Meat

(A-3)

0.2

0.3

0.4

0.5

0.6

0.8

1.0

Spaghetti

(A-4)

1.0

2.0

Fish

(A-5)

0.1

0.2

0.3

0.4

0.5

0.6

0.8

0.9

1.0

Chicken

(A-6)

0.2

0.4

0.6

0.8

1.0

1.2

1.4

1.6

1.8

2.0

5. Grill

This function has two patterns, you may press "Micro/Grill/Combi" to select such functions: (the longest cooking time is

60 minutes).

kg

Pattern 1: 85% grill power, display G-1
Pattern 2: 50% grill power, display G-2
Example: Cooking food with grill for 20 minutes

A) Press "Micro/Grill/Combi" until the LED displayed "G-1".

B) Set cooking time "20:00"

C) Press "Start/Reset"
When grilling, the food isn't heated by microwave, heat is radiated from the metal heater at the top of the oven.
When grill is working, the cooking time has 2 stages, after the 1st half of the cooking, the program will automatically
pause and sound 2 beeps, indicating you to open the oven and turn food over, close the door after turn the food over,
press "Start/Reset" button, the cooking will continue for the 2nd half. If you do not want to turn the food over, the oven
will re-start after 1 min pause.

6 Combination Cooking

This appliance offers you a choice of two methods of combination cooking.

Option 1: Combination cooking (55% microwave + 45% grill)

It will display "C-1"

Option 2 : Combination cooking (30% microwave + 70% grill)

It will display "C-2".

Example : Cooking food using option 2 for 15 minutes.
a) Press "Micro/Grill/Combi" until the LED displayed "C-

2"

b) Set cooking time for "15:00"

c) Press "Start/Reset"

9

7.Clock
The oven has a 24-hour digital clock,

To input the time, for example to 4:30pm:

a) Press "Clock/Timer", the display will flash, adjust the hour with buttons "Defrost/Time Setting"
b) Press "Clock/Timer" again, adjust the minute with buttons "Defrost/Time Setting".
c) Press "Clock/Timer" again and the clock will be set.
e) If you want to change the time, repeat above procedure.

8.Timer

This allows you to set the microwave oven start and finish cooking at pre-set time.

The clock must be set before you use this feature.
Example: The current time is 16:30 and you want to start cooking at 18:15 on 70% power for 10minutes:
a) Rotate the knob "defrost/Time Setting", set the time to "18:15"(same procedure as setting clock)
b) Press "Micro/Grill/Combi" to select 70% power.
c) Set cooking time for 10 minutes.
d) Press "Start/Reset"
If you do not set the power and cooking time and directly press the start button once you have programmed
the time, the appliance will only work as a clock.

At 18:15 there will be 10 bleeps and the appliance will be switched off.

9. Child-safety-lock.

To activate the child safety lock, press "Auto menu" and "Clock/Timer" at the same time for 2 seconds.

Press "Auto menu" and "clock/Timer" at the same time for 2 seconds again, it will unlock the machine.

10. Start/Reset

a) In the course of operation, pressing "Start/Reset" button will stop operation.
b) If any program was set before pressing start, pressing this button will cancel the entire set program.

10

CARE OF YOUR MICROWAVE OVEN

1.Turn the oven off and remove the power plug from the wall socket before cleaning.

2.Keep the inside of the oven clean. When food splatters or spilled liquids adhere to oven walls, wipe with a
damp cloth. The use of harsh detergent or abrasives is not recommended.

3.The outside oven surface should be cleaned with a damp cloth. To prevent damage to the operating parts
inside the oven, water should not be allowed to seep into the ventilation openings.

4.Do not allow the Control Panel to become wet. Clean with a soft, damp cloth, Do not use detergents,
abrasives or spray-on cleaners on the control Panel.

5.If steam accumulates inside or around the outside of the oven door, wipe with a soft cloth. This may occur
when the microwave oven is operated under high humidity conditions and in no way indicates malfunction

of the unit.

6.It is occasionally necessary to remove the glass tray for cleaning. Wash the tray in warm sudsy water or in

a dishwasher.

7.The roller ring and oven cavity floor should be cleaned regularly to av oid excessive noise. Simply wipe the
bottom surface of the oven with mild detergent, water or window cleaner and dry. The roller ring may be
washed in mild sudsy water or dish washer. Cooking vapour collect during repeated use but in no way
affect the bottom surface or roller ring wheels.
When removing the roller ring from cavity floor for cleaning, be sure to replace it in the proper position.

8.Remove odours from your oven by combining a cup of water with the juice and skin of one lemon in a
deep microwaveable bowl. Microwave for 5 minutes, wipe thoroughly and dry with a soft cloth.

9.When it becomes necessary to replace the oven light, please consult a dealer to have it replaced.

( DOOR OPENED,COOK OFF CONDITION)

L

C3

C2

N

NEL

L

N

F1

C1

NOISE FILTER

L

R1

SCHEMATIC DIAGRAM

SWA

FU

L

FM

TM

SWC

H

TRANSFORMER

SH

SO

C

F2

MAGNETRON

FA
F

D

R4-1

R4-2

P( OUT)

H( OUT)

T( IN)

SW2

RY

RY

RY

K2 GNDK3 D_ SW

K4

CONTROLLER

JP1-2

JP1-1

SWB

R3D1R2

C4

RY

D2

SWA: PRIMARY INTERLOCK SWITCH
SWB: SECONDARY INTERLOCK SWITCH
SWC: THE MONITOR INTERLOCK SWITCH

*CIRCUIT SUBJECT TO CHANGE WITHOUT NOTICE

L: LAMP
FM: FAN MOTOR

TM: TURNTABLE MOTOR
H: HEATER

BELLING CUSTOMER CARE

In case of difficulty within the UK, please call

Belling Customer Care Centre Helpline on

08

44 815 3746

When you dial this number you will hear a recorded message and be given a

number of options.

This indicates that your call has been accepted and is being held in a queue.

Calls are answered in strict rotation as our Customer Care Representatives

become available.

Enter appliance numbers here for future reference:

Model No

Serial No

Please ensure you ha

when calling Belling Customer Care. They are essential when booking your call.

ve the above details (Model No and serial No) to hand

Stoney Lane, Prescot, Merseyside, L35 2XW