GinSan Clean Pet Vac Service Manual

Clean Pet Vac

Service Manual 1.0

Table of Contents

Warranty ....................................................................................................................2

Safety Instructions ....................................................................................................3

Unpacking Unit ..........................................................................................................4

Technical Specifications .............................................................................................5

Electrical Requirements .............................................................................................6

Site Preparation .........................................................................................................7

Installation .................................................................................................................8

Final Installation .........................................................................................................9

Testing & Operation .................................................................................................10

General Operation ...................................................................................................10

Maintenance ............................................................................................................11

Trouble Shooting ......................................................................................................12

Technical Sheet / Wiring Diagram ...........................................................................13

Replacement Parts ..................................................................................................14

1

Limited Warranty

GinSan Pet Wash may be eligible for repair or replacement if the claim is deemed to be due
to a failure in either material or workmanship within one year of purchase. The replacement
of defective products is made at the discretion of GinSan, and is based on the results of an
analysis of the returned products by our warranty administrator. Products submitted for Lim­ited Warranty consideration will be inspected by our Warranty/Repair Dept. Replacement
will be based upon GinSan uniform limited warranty procedure and/or the result of the Tech­nical evaluation. Charges for damages and/or labor costs cannot be accepted by GinSan.
We believe our products should provide good service under proper operating conditions, and
this attitude will be reflected in our consideration of items returned for examination.

The GinSan Limited Warranty Program does not constitute, in any way, a product guarantee,
and GinSan does not hereby assume any obligations of any kind whatsoever beyond repair­ing or sending a free replacement of the product when covered by the Limited Warranty.

There are no warranties, expressed or implied (including any warranty of merchantability or
fitness), which extend beyond this Limited Warranty. The loss of use of the product, loss of
time, inconvenience, commercial loss, incidental or consequential damages is not covered.
The manufacturer reserves the right to change the design of the product without assuming
any obligation to modify any product previously manufactured or to replace warranted prod­uct other than with redesigned product.

This Limited Warranty gives you special legal rights. You may also have other rights from
state to state. Some states do not allow limitations on how long an implied warranty lasts.
Some states do not allow the exclusion or limitation of incidental or consequential damages.
Therefore, the above limitation(s) or exclusion(s) may not apply to you.

To be eligible for Limited Warranty consideration, contact GinSan Customer Service at 800­446-7267. Upon issuance of a RETURNED MATERIAL AUTHORIZATION (RMA) NUMBER,
return the failed product, freight prepaid to GinSan, 3611 3 Mile Rd. NW, Grand Rapids,
Michigan 49534 to the attention of the Warranty/Repair Dept.

Any product covered under the terms of the respective Limited Warranty will be repaired or
replaced with another like product at the discretion of GinSan and will be sent directly to the
original consumer/purchaser only.

The consumer/ purchaser may request a written report on any product submitted for war­ranty evaluation that is not covered under the respective Limited Warranty.

2

Safety Instructions

SAVE THESE INSTRUCTIONS!

IMPORTANT!

Please read all the warnings & suggestions, along with the safety, installation, set-up, op­eration and maintenance instructions before you install and operate this vacuum system.

WARNING:

To reduce the risk of fire, electrical shock, or injury, install and operate this system only as
described in this manual. Use only manufacture’s options, attachments, and replacement
parts. Do not put any objects into the openings. Do not operate if any opening is blocked or
restricted. Keep hoses, intake tubes, and filters free of dust, dirt, hair, lint, or anything else
that may reduce air flow. Keep hair, jewelry, loose clothing, and body parts away from open­ings and moving parts. Do not pick up anything that is burning or smoking such as ciga­rettes, matches, or hot ashes. Do not pick up any flammable or combustible liquids or use in
an area where such liquids or fumes are present.

NOTICE:

This equipment must be installed in full compliance with all applicable local, regional, state,
and national electrical and building codes, standards and rules

DANGER:

This system is designed to work with such equipment that incorporates parts such as switch­es, motors, or the like that tend to produce arcs or sparks which can ignite flammable liquids
and fumes. If such equipment is located nearby, check all codes and regulations regarding
the installation of non-explosion proof electrical devices in and around flammable liquids and
fumes.

3

3

Unpacking Unit

Upon opening the containers, take a moment to inspect the shipping cartons for any damage
that may have been inflicted during transportation. If any damage is present, stop and take
pictures of the carton and contact the shipping company or your distributor immediately. If
no damage is present, or you have reported possible damage, then carefully remove all com­ponents and packaging material from the carton. Again, inspect all components for possible
shipping damage. If any of the components are damaged, return everything to the carton
and contact the shipping company and/or your distributor and make a Damaged Freight
Claim. If none of the items are damaged and all components are removed from the carton,
use the checklist below to make sure you have received everything:

Separator tank with Intake tubes (Quantity 1)

1 1/4” X 25’ Vacuum Hose (Quantity 1)

1 1/4” Swivel Hose Cuffs (Quantity 3)

Rubber Grooming Brush/Tool with Adapter (Quantity 1)

Separator Tank Dolly (Quantity 1)

Wall Mountable Wet/Dry Vacuum Unit (Quantity 1)

Strainer Basket (Quantity 1)

Relay Activated/Controlled 120 VAC Remote Mount Outlet Assem­bly with 6’ cord (Quantity 1)

Verify that you have all the listed components. If you are missing any of the listed parts,
please contact your Clean Pet Vac Distributor or call GinSan at 616-791-8100 for further as­sistance.

PLEASE NOTE: GinSan is not responsible for any damage that is caused during the ship­ment of the Clean Pet Vac system. All shipments are sent FOB GinSan and are insured
per customer’s instructions. GinSan is not responsible for any freight damage and it is the
receiver’s responsibility to file the appropriate claims with the shipping company or their dis­tributor.

4

4

Technical Specifications

SEPARATION TANK:

• 15 gallon steel tank with lever latch ring

• Removable lid with Intake/Output tubes

• Tank Dolly with caster wheels

• Two steel handles

VACUUM HOSE:

• 1 1/4” X 25” high flex vinyl

• Crush resistant construction

GROOMING TOOL:

• Pliable rubber construction with attached soft bristle brush

• Swivel attachment cuff so tool spins on hose

REMOTE OUTLET CONTROL:

• Remote mountable outlet with 6’ cord

• Outlet controlled via 24 VAC relay

• Allows remote activation of vacuum unit

HAIR/WATER STRAINING BASKET:

• Perforated metal construction

• Built in handle for easy removal from tank

• Catches the hair and allows water to collect in bottom of tank

WALL MOUNTABLE VACUUM UNIT:

• 4.5 HP Wet/Dry vacuum with 5 gallon tank

5