Giga-tronics 3000-32, 3000-32C, 3000-32S, 3000-32i/opt 1, 3000-32i/opt 5 User Manual

Manual 07500340 Model 3000-32
Model 3000-32, 32C, 32S, 32i/opt 1, opt 5
4(1x8) & 8(1x4) & 8(1x2)
Coaxial Multiplexer
Page 1
Operation Manual
Manual 07500340 Model 3000-32
Warranty
Giga-tronics Series 3000 Switching Modules are warranted against defective materials and workmanship for three years from date of shipment, or as detailed in the warranty section of this manual. Giga-tronics will, at its
option, repair or replace products that are proven defective during the warranty period. This warranty DOES NOT cover damage resulting from improper use, nor workmanship other than Giga-tronics service. There is no implied warranty of fitness for a particular purpose, nor is Giga-tronics liable for any consequential damages. Specification and price change privileges are reserved by Giga-tronics.
All technical data and specifications in this publication are subject to change without prior notice and do not represent a commitment on the part of Giga-tronics, Incorporated.
© 2011 Giga-tronics Incorporated. All rights reserved. Printed in the U.S.A.
CONTACT INFORMATION
Giga-tronics, Incorporated
4650 Norris Canyon Road San Ramon, California 94583 Telephone: 800.726.4442 (only within the United States)
925.328.4650
Fax: 925.328.4700 On the Internet: www.gigatronics.com
Page 2
Operation Manual
Manual 07500340 Model 3000-32
89/336/EEC and 73/23/EEC
EMC Directive and Low Voltage Directive
EN61010-1 (1993)
Electrical Safety
EN61326-1 (1997)
EMC – Emissions and Immunity
Manufacturer’s Name:
Manufacturer’s Address
Giga-tronics, Incorporated
4650 Norris Canyon Road San Ramon, California 94583 U.S.A.
Type of Equipment:
Model Series Number
Switching Module
3000-32
Regulatory compliance information
This product complies with the essential requirements of the following applicable European Directives, and carries the CE mark accordingly.
Declaration of Conformity on file. Contact Giga-tronics at the following;
Giga-tronics, Incorporated
4650 Norris Canyon Road San Ramon, California 94583 Telephone: 800.726.4442 (only within the United States)
925.328.4650
Fax: 925.328.4700
Page 3
Operation Manual
Manual 07500340 Model 3000-32
TPCI
Number
TPCI Issue
Date
Date Entered
Comments
Record of Changes to This Manual
Use the table below to maintain a permanent record of changes to this document. Corrected replacement pages are issued as Technical Publication Change Instructions (TPCI). When you are issued a TPCI, do the following:
1. Insert the TPCI at the front of the manual binder.
2. Remove the pages from the manual binder that are noted in the TPCI.
3. Replace the page(s) removed in the previous step with the corrected page(s).
4. Record the changes in the table below.
Page 4
Operation Manual
Manual 07500340 Model 3000-32
Revision History
Revision
Description of Change
Chg Order #
Approved By
A
Initial Release
B
Updated
C
Reformatted 3/12
RCW
Page 5
Operation Manual
Manual 07500340 Model 3000-32
Contents
Contents ........................................................................................................................................................ 6
Chapter 1 Introduction ................................................................................................................................. 7
1.1 Safety and Manual Conventions ......................................................................................................... 7
1.1.1 Product Reference ....................................................................................................................... 7
1.1.2 Personal Safety Alert ................................................................................................................... 7
1.1.3 Equipment Safety Alert ............................................................................................................... 7
1.1.4 Notes ........................................................................................................................................... 7
1.1.5 Electrical Safety Precautions ....................................................................................................... 7
Chapter 2 Configuration Table ...................................................................................................................... 8
Chapter 3 Functional Description ................................................................................................................. 9
3.1 Introduction ........................................................................................................................................ 9
3.2 General Description ............................................................................................................................ 9
Chapter 4 Block Diagram ............................................................................................................................ 10
4.1 VXI Logical Address ........................................................................................................................... 15
4.2 LEDs................................................................................................................................................... 15
4.2.1 “BUS” LED .................................................................................................................................. 15
4.2.2 “PWR” LED ................................................................................................................................. 15
Chapter 5 Internal Settings ......................................................................................................................... 16
5.1 Fuse .................................................................................................................................................. 16
5.2 VXI
Interrupt Level Selection......................................................................................................... 16
bus
Chapter 6 Specifications ............................................................................................................................. 17
Chapter 8 Register Map .............................................................................................................................. 18
8.1 Model 3000-32S ................................................................................................................................ 18
8.2 Model 3000-32C ............................................................................................................................... 22
8.3 Model 3000-32 Option 1 .................................................................................................................. 33
8.4 Model 3000-32 (Standard Model) .................................................................................................... 36
8.5 3000-32 Option 5 .............................................................................................................................. 39
Page 6
Operation Manual
Manual 07500340 Model 3000-32
WARNING
CAUTION
Chapter 1 Introduction
1.1 Safety and Manual Conventions
This manual contains conventions regarding safety and equipment usage as described below.
1.1.1 Product Reference
Throughout this manual, the term “Common Core Switching Platform, Series 8800” refers to all models of within the series, unless otherwise specified.
1.1.2 Personal Safety Alert
WARNING: Indicates a hazardous situation which, if not avoided, could result in death or serious injury.
1.1.3 Equipment Safety Alert
CAUTION: Indicates a situation which can damage or adversely affect the product or associated equipment.
1.1.4 Notes
Notes are denoted and used as follows:
NOTE: Highlights or amplifies an essential operating or maintenance procedure, practice, condition or statement.
1.1.5 Electrical Safety Precautions
Any servicing instructions are for use by service-trained personnel only. To avoid personal injury, do not perform any service unless you are qualified to do so.
For continued protections against fire hazard, replace the AC line fuse only with a fuse of the same current rating and type. Do not use repaired fuses or short circuited fuse holders.
Page 7
Operation Manual
Manual 07500340 Model 3000-32
DESCRIPTION
TOP ASSY PCA
DATA SHEET DESIGNATION
DESIGNATION
4(1x8), 8(1x4), 8(1x2)
90400290-001 85004060-001
(STANDARD )
3000-032
16(1x4), 8(1x2)
90400290-002 85004060-002
3000-032C NEW / CASS L.M. FL
1(1x24), 1(1x32) w/ terminators
90400290-003 85004060-003
3000-032S NEW / SANDERS
20(1x4)
90400290-004 85004060-004
OPTION 01
3000-032i ICRC
4(1x8), 8(1x4), 8(1x2)
90400290-005 85004060-005
OPTION 05
3000-32 Opt 5
Chapter 2 Configuration Table
ALL PCA’S WOULD HAVE THEIR OWN SCHEMATIC SHOWING THE CONFIGURATION.
Page 8
Operation Manual
Manual 07500340 Model 3000-32
Chapter 3 Functional Description
3.1 Introduction
This manual provides the necessary information for the operation and maintenance of the Model 3000­32 General Purpose VXI Switch Module.
3.2 General Description
Missing
Page 9
Operation Manual
Manual 07500340 Model 3000-32
Chapter 4 Block Diagram
4.1 3000-32 (Standard), 4(1x8), 8(1x4), 8(1x2)
Page 10
Operation Manual
Manual 07500340 Model 3000-32
4.2 3000-32C, 16(1x4), 8(1x2)
Page 11
Operation Manual
Manual 07500340 Model 3000-32
4.3 3000-32S 1(1x24), 1(1x32) w/terminators
Page 12
Operation Manual
Manual 07500340 Model 3000-32
4.4 3000-32i, Option 1, 20(1x4)
Page 13
Operation Manual
Manual 07500340 Model 3000-32
3000-32, Option 5, 4(1x8), 8(1x4)
Page 14
Operation Manual
Manual 07500340 Model 3000-32
Controls and Indicators
The following controls and indicators are provided to select and display the functions of the ASCOR 3000-8 Module’s operating environment.
4.5 VXI Logical Address
The Logical Address Switch is dual circular switches, D1 and D2 which are located at the rear of the module. The address can be set to any value between 1 and 255 (decimal) or 1 and FF (hexadecimal), (address 0 is reserved for the resource manager). However, the Module fully supports Dynamic Configuration as defined in Section F of the VXI specification, address 255 (FF) should be selected only if the Resource Manager also supports Dynamic Configuration.
4.6 LEDs
The following LEDs are visible at the Module’s front panel to indicate the
status of the module’s operation:
4.6.1 “BUS” LED
This green color LED is normally off and will flash on when the module is addressed by the system.
4.6.2 PWR” LED
This red color LED is normally on when the Module is Powered up.
Page 15
Operation Manual
Manual 07500340 Model 3000-32
Chapter 5 Internal Settings
The following items are inside the module and can be reached by removing the side cover.
5.1 Fuse
The ASCOR VXI 3000-32 uses a 10 Amp fuse in the +5 Volt line and is located on
the Mother Board (MB) assembly.
5.2 VXI
The VXIbus interrupt level is set with three bits in the “3Eh” register.
See the section on “A16 ADDRESS SPACE REGISTER DESCRIPTION”.
The interrupt level is factory set to “no interrupt”.
Interrupt Level Selection
bus
Page 16
Operation Manual
Manual 07500340 Model 3000-32
Chapter 6 Specifications
SPDT relays: 48
Electrical:
Switching Voltage 277V AC, 110 V DC
Switching Current 5 Amps
Power Rating 625VA, 150 W
Life Expectancy 10,000,000 Mechanical
Contact resistance: < 0.400 ohms
Mechanical:
Thickness: 1.200 inches Width: 10.317 inches Length: 13.78 inches Weight: 3 lbs.
Connectors: (J1-J4) 50 Pos, SMPL Series
Positronic SMPL50MOTOLB
Mate: 50 Pos, SGMC Series Positronic Industries, SGMC5OF0E1OOJO
Installation Kit: Installation Kit, 89800340 , available on request
Environmental Specifications
Temperature:
Operating: 0º to 55ºC
Storage: - 40º to 75ºC
Relative Humidity:
Operating: 0 to 90% non-condensing
Storage: 0 to 95% non-condensing
Page 17
Operation Manual
Manual 07500340 Model 3000-32
Chapter 8 Register Map
8.1 Model 3000-32S
This section provides the register map for Model 3000-32S The following register map shows the signal name and register assignments for the Model
3000-32. A16 Registers Offset Value 00h CFB5h 7 = Register Based, A16/A24 Module FB5 = VXI Manufacturer ID, ASCOR 02h 7F20h 7 = A24 space requirement F20 = Model Number for this module 04h FFFCh Bit 0, reset, is supported. Toggling this bit will clear all relay registers. 06h (assigned by Resource Manager)
Control Bit
3Eh 0 Low true output enable to the relay coil driver IC’s. 1 When low enables read back of relay coil state When high enables read back of data registers 2 High true EEPROM write enable 3-15 Don’t Care
Page 18
Operation Manual
Manual 07500340 Model 3000-32
Bit
Pin
SW
Section
0
J1-A
K-1 1 1
J1-B
K-2 1 2
J1-C
K-3 1 3
J1-D
K-4 1 4
J1-E
K-5 2 5
J1-F
K-6 2 6
J1-H
K-7
2
7
J1-J
K-8
2
8
J1-K
K-9 1 9
J1-L
K-10 1 10
J1-M
K-11
1
11
J1-N
K-12
1
12
J1-P
K-13 2 13
J1-R
K-14 2 14
J1-S
K-15 2 15
J1-T
K-16
2
Bit
Pin
SW
Section
0
J2-A
K-17 3 1
J2-B
K-18 3 2
J2-C
K-19 3 3
J2-D
K-20 3 4
J2-E
K-21
4
5
J2-F
K-22
4
6
J2-H
K-23 4 7
J2-J
K-24 4 8
N/C
K-25
N/A
9
N/C
K-26
N/A
10
N/C
K-27
N/A
11
N/C
K-28
N/A
12
N/C
K-29
N/A
13
N/C
K-30
N/A
14
N/C
K-31
N/A
15
N/C
K-32
N/A
1 X 24
Address offset 40h
1 X 24
Address offset 42h
Page 19
Operation Manual
Manual 07500340 Model 3000-32
Bit
Pin
SW
Section
0
J3-A
K-33 1 1
J3-B
K-34 1 2
J3-C
K-35 1 3
J3-D
K-36 1 4
J3-E
K-37
2
5
J3-F
K-38
2
6
J3-H
K-39 2 7
J3-J
K-40 2 8
J3-K
K-41 1 9
J3-L
K-42 1 10
J3-M
K-43 1 11
J3-N
K-44 1 12
J3-P
K-45 2 13
J3-R
K-46 2 14
J3-S
K-47
2
15
J3-T
K-48
2
Bit
Pin
SW
Section
0
J4-A
K-49 3 1
J4-B
K-50 3 2
J4-C
K-51 3 3
J4-D
K-52 3 4
J4-E
K-53 4 5
J4-F
K-54 4 6
J4-H
K-55 4 7
J4-J
K-56 4 8
J4-K
K-57
3
9
J4-L
K-58
3
10
J4-M
K-59 3 11
J4-N
K-60 3 12
J4-P
K-61 4 13
J4-R
K-62 4 14
J4-S
K-63 4 15
J4-T
K-64
4
1 X 32 with Terminators
Address offset 44h
32 X 1 with Terminators
Address offset 46h
Page 20
Operation Manual
Manual 07500340 Model 3000-32
Bit
SW
Function
0
K-77
1X32 Section 3
1
N/C
2
K-73
1X32 2K ohm termination
3
K-75
1X32 Section 2
4
K-68
1x24 Section 3
5
N/C
6
N/C
7
K-70
1X24 Section 2
8
K-78
1X32 Section 4
9
K-80
1X32 0 ohm termination
10
K-74
1X32 100 ohm termination
11
K-76
1X32 Section 1
12
K-67
1X24 Section 4
13
N/C 14
N/C
15
K-69
1X24 Section 1
Address offset 48h
1 X 24 Common J1-AA 1 X 32 Common J3-BB
Page 21
Operation Manual
Manual 07500340 Model 3000-32
8.2 Model 3000-32C
This section provides the register map for Model 3000-32C A16 Registers
Offset Value 00h CFB5h 7 = Register Based, A16/A24 Module FB5 = VXI Manufacturer ID, ASCOR 02h 7F20h 7 = A24 space requirement F20 = Model Number for this module 04h FFFCh Bit 0, reset, is supported. Toggling this bit will clear all relay registers. 06h (assigned by Resource Manager)
Control Bit
3Eh 0 Low true output enable to the relay coil driver IC’s.
1 When low enables read back of relay coil state When high enables read back of data registers 2 High true EEPROM write enable 3-15 Don’t Care
Page 22
Operation Manual
Manual 07500340 Model 3000-32
BIT
SW
PIN#
RELAY
0
A1
J1-A
K-1
1
A2
J1-B
K-2
2
E1
J1-K
K-3
3
E2
J1-L
K-4
4
B1
J1-E
K-5 5 B2
J1-F
K-6
6
F1
J1-P
K-7 7 F2
J1-R
K-8
8
A3
J1-C
K-9
9
A4
J1-D
K-10
10
E3
J1-M
K-11
11
E4
J1-N
K-12
12
B3
J1-H
K-13
13
B4
J1-J
K-14
14
F3
J1-S
K-15
15
F4
J1-T
K-16
16-1x4, 8-1x2
REG 40h 1x4’s
SWITCH COMMON
A - J1-Y B - J1-Z E - J1-U
F - J1-Y
Page 23
Operation Manual
Manual 07500340 Model 3000-32
BIT SW
PIN#
RELAY
0
I1
J2-A
K17
1
I2
J2-B
K18
2
J1
J2-C
K19
3
J2
J2-D
K20
4
K1
J2-E
K21
5
K2
J2-F
K22
6
L1
J2-H
K23
7
L2
J2-J
K24
8
I3
J2-K
K25
9
I4
J2-L
K26
10
J3
J2-M
K27
11
J4
J2-N
K28
12
K3
J2-P
K29
13
K4
J2-R
K30
14
L3
J2-S
K31
15
L4
J2-T
K32
16-1X4, 8-1X2
REG 42h 1X4’s
SWITCH COMMON
I - J1-CC J - J1-DD K - J2-CC L - J2-DD
Page 24
Operation Manual
Manual 07500340 Model 3000-32
Bit
SW
Pin#
RELAY
0
C1
J3-A
K33
1
C2
J3-B
K34
2
G1
J3-K
K35
3
G2
J3-L
K36
4
D1
J3-E
K37
5
D2
J3-F
K38
6
H1
J3-P
K39
7
H2
J3-R
K40
8
C3
J3-C
K41
9
C4
J3-D
K42
10
G3
J3-M
K43
11
G4
J3-N
K44
12
D3
J3-H
K45
13
D4
J3-J
K46
14
H3
J3-S
K47
15
H4
J3-T
K48
16-1X4, 8-1X2
Reg 44h 1X4’s
SWITCH COMMON
<R>C - J1-AA <R>D - J1-BB
<R>G - J1-W
<R>H - J1-X
Page 25
Operation Manual
Manual 07500340 Model 3000-32
Bit
SW
Pin#
RELAY
0
M1
J4-A
K49
1
M2
J4-B
K50
2
N1
J4-C
K51
3
N2
J4-D
K52
4
O1
J4-E
K53
5
O2
J4-F
K54
6
P1
J4-H
K55
7
P2
J4-J
K56
8
M3
J4-K
K57
9
M4
J4-L
K58
10
N3
J4-M
K59
11
N4
J4-N
K60
12
O3
J4-P
K61
13
O4
J4-R
K62
14
P3
J4-S
K63
15
P4
J4-T
K64
16-1X4, 8-1X2
Reg 46h 1X4’s
SWITCH COMMON
M - J3-CC N - J3-DD
O - J4-CC P - J4-DD
Page 26
Operation Manual
Manual 07500340 Model 3000-32
Bit
SW
Pin#
RELAY
0
Q2
J4-U
K77
1
U2
J4-Y
K79
2
R2
J4-V
K73
3
V2
J4-Z
K75
4
S2
J4-W
K68
5
W2
J4-AA
K66
6
T2
J4-X
K72
7
X2
J4-BB
K70
8
Q1
J2-U
K78
9
U1
J2-Y
K80
10
R1
J2-V
K74
11
V1
J2-Z
K76
12
S1
J2-W
K67
13
W1
J2-AA
K65
14
T1
J2-X
K71
15
X1
J2-BB
K69
16-1X4, 8-1X2
Reg 48h 1X2’s
SWITCH COMMON
Q - J3-U
U - J3-Y R - J3-V V - J3-Z
S - J3-W
W - J3-AA
T - J3-X
X - J3-BB
Page 27
Operation Manual
Manual 07500340 Model 3000-32
Pin#
Switch
Offset
Bit
Relay
J1-K
E1
40h
2
K3
J1-L
E2
40h
3
K4
J1-M
E3
40h
10
K11
J1-N
E4
40h
11
K12
Pin#
Switch
Offset
Bit
Relay
J1-P
F1
40h 6 K7
J1-R
F2
40h
7
K8
J1-S
F3
40h
14
K15
J1-T
F4
40h
15
K16
Pin#
Switch
Offset
Bit
Relay
J3-K
G1
44h
2
K35
J3-L
G2
44h
3
K36
J3-M
G3
44h
10
K43
J3-N
G4
44h
11
K44
Pin#
Switch
Offset
Bit
Relay
J3-P
H1
44h
6
K7
J3-R
H2
44h
7
K8
J3-S
H3
44h
14
K15
J3-T
H4
44h
15
K16
16-1X4, 8-1X2
SWITCH `E’ 1x4
COMMON J1-U
Address Data
SWITCH `F’ 1x4
COMMON J1-V
Address Data
SWITCH `G’ 1x4
COMMON J1-W
Address Data
SWITCH `H’ 1x4
COMMON J1-X
Address Data
Page 28
Operation Manual
Manual 07500340 Model 3000-32
Pin#
Switch
Offset
Bit
Relay
J2-A
I1
42h
0
K17
J2-B
I2
42h
1
K18
J2-K
I3
42h
8
K25
J2-L
I4
42h
9
K26
Pin#
Switch
Offset
Bit
Relay
J2-C
J1
42h
2
K19
J2-D
J2
42h
3
K20
J2-M
J3
42h
10
K27
J2-N
J4
42h
11
K28
Pin#
Switch
Offset
Bit
Relay
J2-E
K1
42h
4
K17
J2-F
K2
42h
5
K18
J2-P
K3
42h
12
K25
J2-R
K4
42h
13
K26
Pin#
Switch
Offset
Bit Relay
J2-H
L1
42h
6
K23
J2-J
L2
42h
7
K24
J2-S
L3
42h
14
K31
J2-T
L4
42h
15
K32
16-1X4, 8-1X2
SWITCH `I’ 1x4
COMMON J1-CC
Address Data
SWITCH `J’ 1x4
COMMON J1-DD
Address Data
SWITCH `K’ 1x4
COMMON J2-CC
Address Data
SWITCH `L’ 1x4
COMMON J2-DD
Address Data
Page 29
Operation Manual
Manual 07500340 Model 3000-32
Pin#
Switch
Offset
Bit
Relay
J4-A
M1
46h
0
K49
J4-B
M2
46h
1
K50
J4-K
M3
46h
8
K57
J4-L
M4
46h
9
K58
Pin#
Switch
Offset
Bit
Relay
J4-C
N1
46h
2
K51
J4-D
N2
46h
3
K52
J4-M N3
46h
10
K59 J4-N
N4
46h
11
K60
Pin#
Switch
Offset
Bit
Relay
J4-E
O1
46h
4
K53
J4-F
O2
46h
5
K54
J4-P
O3
46h
12
K61
J4-R
O4
46h
13
K62
Pin#
Switch
Offset
Bit
Relay
J4-H
P1
46h
6
K55
J4-J
P2
46h
7
K56
J4-S
P3
46h
14
K63
J4-T
P4
46h
15
K64
16-1X4, 8-1X2
SWITCH `M’ 1x4
COMMON J3-CC
Address Data
SWITCH `N’ 1x4
COMMON J3-DD
Address Data
SWITCH `O’ 1x4
COMMON J4-CC
Address Data
SWITCH `P’ 1x4
COMMON J4-DD
Address Data
Page 30
Operation Manual
Manual 07500340 Model 3000-32
Pin#
Switch
Offset
Bit
Relay
J2-U
P1
48h
8
K78
J4-U
P2
48h
1
K77
Pin#
Switch
Offset
Bit
Relay
J2-V
P1
48h
10
K74
J4-V
P2
48h
2
K73
Pin#
Switch
Offset
Bit
Relay
J2-S
P1
48h
12
K67
J4-S
P2
48h
4
K68
Pin#
Switch
Offset
Bit
Relay
J2-X
P1
48h
14
K71
J4-X
P2
48h
6
K72
Pin#
Switch
Offset
Bit
Relay
J2-Y
P1
48h
9
K80
J4-Y
P2
48h
1
K79
16-1X4, 8-1X2
SWITCH Q 1x2
COMMON J3-U
Address Data
SWITCH R 1x2
COMMON J3-V
Address Data
SWITCH S 1x2
COMMON J3-S
Address Data
SWITCH T 1x2
COMMON J3-X
Address Data
SWITCH U 1x2
COMMON J3-Y
Address Data
Page 31
Operation Manual
Manual 07500340 Model 3000-32
Pin#
Switch
Offset
Bit
Relay
J2-Z
P1
48h
11
K76
J4-Z
P2
48h
3
K75
Pin#
Switch
Offset
Bit
Relay
J2-AA
P1
48h
13
K65
J4-AA
P2
48h
5
K66
Pin#
Switch
Offset
Bit
Relay
J2-BB
P1
48h
15
K69
J4-BB
P2
48h
7
K70
SWITCH V 1x2
COMMON J3-Z
Address Data
SWITCH W 1x2
COMMON J3-AA
Address Data
SWITCH X 1x2
COMMON J3-BB
Address Data
Page 32
Operation Manual
Manual 07500340 Model 3000-32
PIN
PIN
RELAY
BIT
ADDRESS
J1-A
J1-Y
K1 1 0x200040
J1-B
J1-Y
K2 2 0x200040
J1-C
J1-Z
K3 4 0x200040
J1-D
J1-Z
K4 8 0x200040
J1-E
J1-AA
K5
10
0x200040
J1-F
J1-AA
K6
20
0x200040
J1-H
J1-BB
K7
40
0x200040
J1-J
J1-BB
K8
80
0x200040
J1-K
J1-Y
K9
100
0x200040
J1-L
J1-Y
K10
200
0x200040
J1-M
J1-Z
K11
400
0x200040
J1-N
J1-Z
K12
800
0x200040
J1-P
J1-AA
K13
1000
0x200040
J1-R
J1-AA
K14
2000
0x200040
J1-S
J1-BB
K15
4000
0x200040
J1-T
J1-BB
K16
8000
0x200040
J2-A
J2-Y
K17 1 0x200042
J2-B
J2-Y
K18 2 0x200042
J2-C
J2-Z
K19 4 0x200042
J2-D
J2-Z
K20 8 0x200042
J2-E
J2-AA
K21
10
0x200042
J2-F
J2-AA
K22
20
0x200042
J2-H
J2-BB
K23
40
0x200042
J2-J
J2-BB
K24
80
0x200042
J2-K
J2-Y
K25
100
0x200042
J2-L
J2-Y
K26
200
0x200042
J2-M
J2-Z
K27
400
0x200042
J2-N
J2-Z
K28
800
0x200042
J2-P
J2-AA
K29
1000
0x200042
J2-R
J2-AA
K30
2000
0x200042
J2-S
J2-BB
K31
4000
0x200042
J2-T
J2-BB
K32
8000
0x200042
8.3 Model 3000-32 Option 1
P/N 85004060-004
OPTION 1 (20 ) 1x4 Mux
Page 33
Operation Manual
Manual 07500340 Model 3000-32
PIN
PIN
RELAY
BIT
ADDRESS
J3-A
J3-Y
K33 1 0x000044
J3-B
J3-Y
K34 2 0x000044
J3-C
J3-Z
K35 4 0x000044
J3-D
J3-Z
K36 8 0x000044
J3-E
J3-AA
K37
10
0x000044
J3-F
J3-AA
K38
20
0x000044
J3-H
J3-BB
K39
40
0x000044
J3-J
J3-BB
K40
80
0x000044
J3-K
J3-Y
K41
100
0x000044
J3-L
J3-Y
K42
200
0x000044
J3-M
J3-Z
K43
400
0x000044
J3-N
J3-Z
K44
800
0x000044
J3-P
J3-AA
K45
1000
0x000044
J3-R
J3-AA
K46
2000
0x000044
J3-S
J3-BB
K47
4000
0x000044
J3-T
J3-BB
K48
8000
0x000044
J4-A
J4-Y
K49 1 0x000046
J4-B
J4-Y
K50 2 0x000046
J4-C
J4-Z
K51 4 0x000046
J4-D
J4-Z
K52 8 0x000046
J4-E
J4-AA
K53
10
0x000046
J4-F
J4-AA
K54
20
0x000046
J4-H
J4-BB
K55
40
0x000046
J4-J
J4-BB
K56
80
0x000046
J4-K
J3-Y
K57
100
0x000046
J4-L
J3-Y
K58
200
0x000046
J4-M
J3-Z
K59
400
0x000046
J4-N
J3-Z
K60
800
0x000046
J4-P
J4-AA
K61
1000
0x000046
J4-R
J4-AA
K62
2000
0x000046
J4-S
J4-BB
K63
4000
0x000046
J4-T
J4-BB
K64
8000
0x000046
P/N 85004060-004
OPTION 1 ( 20 ) 1x4 Mux
Page 34
Operation Manual
Manual 07500340 Model 3000-32
PIN
PIN
RELAY
BIT
ADDRESS
J1-U
J1-CC
K77
0001
0x200048
J2-V
J1-CC
K79
0002
0x200048
J3-W
J1-CC
K78
0100
0x200048
J4-X
J1-CC
K80
0200
0x200048
J1-U
J2-CC
K73
0004
0x200048
J2-V
J2-CC
K75
0008
0x200048
J3-W
J2-CC
K74
0400
0x200048
J4-X
J2-CC
K76
0800
0x200048
J1-U
J3-CC
K68
0010
0x200048
J2-V
J3-CC
K66
0020
0x200048
J3-W
J3-CC
K67
1000
0x200048
J4-X
J3-CC
K65
2000
0x200048
J1-U
J4-CC
K72
0040
0x200048
J2-V
J4-CC
K70
0080
0x200048
J3-W
J4-CC
K71
4000
0x200048
J4-X
J4-CC
K69
8000+
0x200048
85004060-004
OPTION 1 ( 20 ) 1x4 Mux
Page 35
Operation Manual
Manual 07500340 Model 3000-32
J1-A
J1-U
K1 1 0x200040
J1-B
J1-U
K2 2 0x200040
J1-C
J1-U
K3 4 0x200040
J1-D
J1-U
K4 8 0x200040
J1-E
J1-V
K5
10
0x200040
J1-F
J1-V
K6
20
0x200040
J1-H
J1-V
K7
40
0x200040
J1-J
J1-V
K8
80
0x200040
J1-K
J1-U
K9
100
0x200040
J1-L
J1-U
K10
200
0x200040
J1-M
J1-U
K11
400
0x200040
J1-N
J1-U
K12
800
0x200040
J1-P
J1-V
K13
1000
0x200040
J1-R
J1-V
K14
2000
0x200040
J1-S
J1-V
K15
4000
0x200040
J1-T
J1-V
K16
8000
0x200040
J3-A
J1-W
K33 1 0x200044
J3-B
J1-W
K34 2 0x200044
J3-C
J1-W
K35 4 0x200044
J3-D
J1-W
K36 8 0x200044
J3-E
J1-X
K37
10
0x200044
J3-F
J1-X
K38
20
0x200044
J3-H
J1-X
K39
40
0x200044
J3-J
J1-X
K40
80
0x200044
J3-K
J1-W
K41
100
0x200044
J3-L
J1-W
K42
200
0x200044
J3-M
J1-W
K43
400
0x200044
J3-N
J1-W
K44
800
0x200044
J3-P
J1-X
K45
1000
0x200044
J3-R
J1-X
K46
2000
0x200044
J3-S
J1-X
K47
4000
0x200044
J3-T
J1-X
K48
8000
0x200044
8.4 Model 3000-32 (Standard Model)
P/N 85004060-001 STANDARD MODEL 1x8 Switches 4 Ea.
Page 36
Operation Manual
Manual 07500340 Model 3000-32
J2-A
J1-CC
K17 1 0x000042
J2-B
J1-CC
K18 2 0x000042
J2-C
J1-DD
K19 4 0x000042
J2-D
J1-DD
K20 8 0x000042
J2-E
J2-CC
K21
10
0x000042
J2-F
J2-CC
K22
20
0x000042
J2-H
J2-DD
K23
40
0x000042
J2-J
J2-DD
K24
80
0x000042
J2-K
J1-CC
K25
100
0x000042
J2-L
J1-CC
K26
200
0x000042
J2-M
J1-DD
K27
400
0x000042
J2-N
J1-DD
K28
800
0x000042
J2-P
J2-CC
K29
1000
0x000042
J2-R
J2-CC
K30
2000
0x000042
J2-S
J2-DD
K31
4000
0x000042
J2-T
J2-DD
K32
8000
0x000042
J4-A
J3-CC
K49 1 0x000046
J4-B
J3-CC
K50 2 0x000046
J4-C
J3-DD
K51 4 0x000046
J4-D
J3-DD
K52 8 0x000046
J4-E
J4-CC
K53
10
0x000046
J4-F
J4-CC
K54
20
0x000046
J4-H
J4-DD
K55
40
0x000046
J4-J
J4-DD
K56
80
0x000046
J4-K
J3-CC
K57
100
0x000046
J4-L
J3-CC
K58
200
0x000046
J4-M
J3-DD
K59
400
0x000046
J4-N
J3-DD
K60
800
0x000046
J4-P
J4-CC
K61
1000
0x000046
J4-R
J4-CC
K62
2000
0x000046
J4-S
J4-DD
K63
4000
0x000046
J4-T
J4-DD
K64
8000
0x000046
85004060-001
STANDARD MODEL 1x4 Switches 8 Ea.
Page 37
Operation Manual
Manual 07500340 Model 3000-32
J2-U
J3-U
K78
0100
0x200048
J4-U
J3-U
K77
0001
0x200048
J2-V
J3-V
K74
0400
0x200048
J4-V
J3-V
K73
0004
0x200048
J2-W
J3-W
K67
1000
0x200048
J4-W
J3-W
K68
0010
0x200048
J2-X
J3-X
K71
4000
0x200048
J4-X
J3-X
K72
0040
0x200048
J2-Y
J3-Y
K80
0200
0x200048
J4-Y
J3-Y
K79
0002
0x200048
J2-Z
J3-Z
K76
0800
0x200048
J4-Z
J3-Z
K75
0008
0x200048
J2-AA
J3-AA
K65
2000
0x200048
J4-AA
J3-AA
K66
0020
0x200048
J2-BB
J3-BB
K69
8000
0x200048
J4-BB
J3-BB
K70
0080
0x200048
85004060-001
STANDARD MODEL 1x2 Switches 8 Ea.
Page 38
Operation Manual
Manual 07500340 Model 3000-32
J1-A
J1-U
K1 1 0x200040
J1-B
J1-U
K2 2 0x200040
J1-C
J1-U
K3 4 0x200040
J1-D
J1-U
K4 8 0x200040
J1-E
J1-V
K5
10
0x200040
J1-F
J1-V
K6
20
0x200040
J1-H
J1-V
K7
40
0x200040
J1-J
J1-V
K8
80
0x200040
J1-K
J1-U
K9
100
0x200040
J1-L
J1-U
K10
200
0x200040
J1-M
J1-U
K11
400
0x200040
J1-N
J1-U
K12
800
0x200040
J1-P
J1-V
K13
1000
0x200040
J1-R
J1-V
K14
2000
0x200040
J1-S
J1-V
K15
4000
0x200040
J1-T
J1-V
K16
8000
0x200040
J3-A
J1-W
K33 1 0x200044
J3-B
J1-W
K34 2 0x200044
J3-C
J1-W
K35 4 0x200044
J3-D
J1-W
K36 8 0x200044
J3-E
J1-X
K37
10
0x200044
J3-F
J1-X
K38
20
0x200044
J3-H
J1-X
K39
40
0x200044
J3-J
J1-X
K40
80
0x200044
J3-K
J1-W
K41
100
0x200044
J3-L
J1-W
K42
200
0x200044
J3-M
J1-W
K43
400
0x200044
J3-N
J1-W
K44
800
0x200044
J3-P
J1-X
K45
1000
0x200044
J3-R
J1-X
K46
2000
0x200044
J3-S
J1-X
K47
4000
0x200044
J3-T
J1-X
K48
8000
0x200044
8.5 3000-32 Option 5
P/N 85004060-005 FOUR(4) 1x8 Switches
Page 39
Operation Manual
Manual 07500340 Model 3000-32
J2-A
J1-CC
K17 1 0x000042
J2-B
J1-CC
K18 2 0x000042
J2-C
J1-DD
K19 4 0x000042
J2-D
J1-DD
K20 8 0x000042
J2-E
J2-CC
K21
10
0x000042
J2-F
J2-CC
K22
20
0x000042
J2-H
J2-DD
K23
40
0x000042
J2-J
J2-DD
K24
80
0x000042
J2-K
J1-CC
K25
100
0x000042
J2-L
J1-CC
K26
200
0x000042
J2-M
J1-DD
K27
400
0x000042
J2-N
J1-DD
K28
800
0x000042
J2-P
J1-CC
K29
1000
0x000042
J2-R
J1-CC
K30
2000
0x000042
J2-S
J1-DD
K31
4000
0x000042
J2-T
J1-DD
K32
8000
0x000042
J4-A
J3-CC
K49 1 0x000046
J4-B
J3-CC
K50 2 0x000046
J4-C
J3-DD
K51 4 0x000046
J4-D
J3-DD
K52 8 0x000046
J4-E
J4-CC
K53
10
0x000046
J4-F
J4-CC
K54
20
0x000046
J4-H
J4-DD
K55
40
0x000046
J4-J
J4-DD
K56
80
0x000046
J4-K
J3-CC
K57
100
0x000046
J4-L
J3-CC
K58
200
0x000046
J4-M
J3-DD
K59
400
0x000046
J4-N
J3-DD
K60
800
0x000046
J4-P
J4-CC
K61
1000
0x000046
J4-R
J4-CC
K62
2000
0x000046
J4-S
J4-DD
K63
4000
0x000046
J4-T
J4-DD
K63
8000
0x000046
85004060-005 EIGHT(8) 1x4 Switches
-6-
Page 40
Operation Manual
Loading...