Genesis Advanced Technologies Gas Grill User Manual
®
®
GENESIS
GENESIS
SILVER–A
SILVER–A
Gas Grill
Owners Guide
m DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid
4. If odor continues, keep away from the
appliance and immediately call your
gas supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
Natural Gas
®
®
m WARNING
1. Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2. Do not store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
m WARNING: Follo w all leak-check procedures carefully in this manual prior to
barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions must be left with the owner and the
owner should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
B
E
E
R
W
W
E
R
B
E
YOU MUST READ THIS OWNERS GUIDE
m W ARNING: Do not try to light this appliance without reading the “Lighting” Instructions section of this manual
BEFORE
OPERA TING YOUR GAS GRILL
A030.b
B002.b
C001.b
D113.a
55142 02/28/00
®
m DANGER
Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual
may result in serious bodily injury or death, or in a fire or an explosion causing damage
to property.
m W ARNINGS
m Do not store a spare or disconnected liquid propane cylinder under or near this barbecue.
m Improper assembly may be dangerous. Please carefully follow the assembly instructions in
this manual.
m After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas
leaks and burner obstructions before use. See instructions in this manual for correct procedures.
m Do not operate the Weber gas barbecue if there is a gas leak present.
m Do not use a flame to check for gas leaks.
m Combustible materials should never be within 24 inches of the top, bottom, back or sides of
your Weber gas barbecue.
m Do not put a barbecue cover or anything flammable on, or in the storage area under the
barbecue.
m Your Weber Gas Barbecue should never be used by children. Accessible parts of the barbecue may be very hot. Keep young children away while it is in use.
m You should exercise reasonable care when operating your Weber gas barbecue. It will be hot
during cooking or cleaning and should never be left unattended, or moved while in operation.
m Should the burners go out while in operation, turn all gas valves off. Open the lid and wait five
minutes before attempting to relight, using the lighting instructions.
m Do not use charcoal or lava rock in your Weber gas barbecue.
m Never lean over open grill or place hands or fingers on the front edge of the cooking box.
m Should a grease fire occur, turn off all burners and leave lid closed until fire is out.
m Do not enlarge valve orifices or burner ports when cleaning the valves or burners.
m The Weber Gas Barbecue should be thoroughly cleaned on a regular basis.
m Liquid propane gas is not natural gas. The conversion or attempted use of natural gas in a
liquid propane unit or liquid propane gas in a natural gas unit is dangerous and will void your
warranty.
m Do not attempt to disconnect any gas fitting while your barbecue is in operation.
m Use heat-resistant barbecue mitts or gloves when operating barbecue.
LIQUID PROPANE GAS UNITS ONLY:
m Use the regulator that is supplied with your Weber Gas Barbecue.
m Do not attempt to disconnect the gas regulator or any gas fitting while your barbecue is in
operation.
m A dented or rusty liquid propane cylinder may be hazardous and should be checked by your
liquid propane supplier. Do not use a liquid propane cylinder with a damaged valve.
m Although your liquid propane cylinder may appear to be empty, gas may still be present, and
the cylinder should be transported and stored accordingly.
m If you see, smell or hear the hiss of escaping gas from the liquid propane cylinder:
1. Move away from liquid propane cylinder.
2. Do not attempt to correct the problem yourself.
3. Call your fire department.
A-2
Warranty
Weber-Stephen Products Co. (Weber) hereby warrants
to the ORIGINAL PURCHASER of this Weber Gas Grill
that it will be free of defects in material and workmanship from the date of purchase as follows:
Aluminum Castings, lifetime 1 year paint
Porcelain Hood Section 25 years
Burners 10 years
Igniter 3 years
Cooking Grates 5 years against
manufacturer defects
Flavorizer Bars 1 year no rust through
Thermoplastic/
Thermoset Parts 10 years
Excluding fading
All Remaining Parts 5 years
when assembled and operated in accordance with the
printed instructions accompanying it.
Weber may require reasonable proof of your date of
purchase. THEREFORE, YOU SHOULD RETAIN
YOUR SALES SLIP OR INVOICE.
This Limited Warranty shall be limited to the repair or
replacement of parts that prove defective under normal
use and service and which on examination shall
indicate, to Weber’s satisfaction, they are defective.
Before returning any parts, contact the Customer
service representative in your region using the contact
information sheet provided with your manual. If Weber
confirms the defect and approves the claim, Weber will
elect to replace such parts without charge. If you are
required to return defective parts, transportation
charges must be prepaid. Weber will return parts to the
purchaser, freight or postage prepaid.
This Limited Warranty does not cover any failures or
operating difficulties due to accident, abuse, misuse,
alteration, misapplication, vandalism, improper installation or improper maintenance or service, or failure to
perform normal and routine maintenance, including but
not limited to damage caused by insects within the
burner tubes, as set out in this owner’s manual.
Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes or tornadoes, discoloration due to exposure to chemicals either
directly or in the atmosphere, is not covered by this
Limited Warranty.
There are no other express warrants except as set forth
herein and any applicable implied warranties of merchantability and fitness are limited in duration to the
period of coverage of this express written Limited
Warranty. Some regions do not allow limitation on how
long an implied warranty lasts, so this limitation may not
apply to you.
Weber is not liable for any special, indirect or consequential damages. Some regions do not allow the
exclusion or limitation of incidental or consequential
damages, so this limitation or exclusion may not apply
to you.
Weber does not authorize any person or company to
assume for it any other obligation or liability in connection with the sale, installation, use, removal, return, or
replacement of its equipment; and no such representations are binding on Weber.
This Warranty applies only to products sold at retail.
WEBER-STEPHEN PRODUCTS CO.
Customer Service Center
250 South Hicks Road
Palatine, IL 60067-6241
USA
A-3
Danger & Warnings................................ A-2
Warranty................................................. A-3
General Instructions ............................... A-5
Exploded View........................................ A-6
Parts List ................................................ A-9
Assembly Instructions ............................ B-1
Installing Features.................................. C-1
Operating ............................................... D-1
Lighting................................................... D-1
Manual Lighting...................................... D-2
Cooking .................................................. D-3
Storage and/or Nouse ............................ D-3
Cleaning ................................................. D-3
Cast Iron Cooking Grates Care.............. D-4
Annual Maintenance .............................. D-5
General Maintenance............................. D-6
Replacing Main Burners......................... D-7
Crossover Ignition System Operations... D-8
Troubleshooting .....................................D-9
Contents
A-4
General Instructions
Your Weber Gas Barbecue is a portable outdoor
cooking appliance. With the Weber Gas Barbecue you
can grill, barbecue, roast and bake with results that are
difficult to duplicate with indoor kitchen appliances.
The closed lid and Flavorizer® Bars produce that
“outdoor” flavor in the food.
The Weber Gas Barbecue is portable so you can
easily change its location in your yard or on your patio.
Portability means you can take your Weber Gas
Barbecue with you if you move.
The natural gas supply is easy to use and gives you
more cooking control than charcoal fuel.
• These instructions will give you the minimum
requirements for assembling your Weber Gas
Barbecue. Please read the instructions carefully
before using your Weber Gas Barbecue. Improper
assembly can be dangerous.
• Not for use by children.
• If there are local codes that apply to portable gas
grills, you will have to conform to them. If there are
no local codes, you must conform to the latest
edition of the National Fuel Gas Code: ANSI Z
223.1.
• This Weber Gas Barbecue is designed for natural
(piped in city) gas only. Do not use liquid propane
(LP) bottled gas. The valves, orifices and hose are
for natural gas only.
• Do not use with charcoal fuel.
• Check that the area under the control panel and
the bottom tray are free from debris that might
obstruct the flow of combustion or ventilation air.
For Installation in Canada
These instructions, while generally acceptable, do not
necessarily comply with the Canadian Installation
codes, particularly with piping above and below
ground. In Canada the installation of this appliance
must comply with local codes and/or Standards CAN/
CGA-B149.1 (Installation Code for Natural Gas
Burning Appliances and Equipment).
Storage
• The gas must be turned OFF at the natural gas
supply when the Weber Gas Barbecue is not in
use.
• When the Weber Gas Barbecue is stored indoors,
the gas supply must be disconnected.
Operating
m WARNING: Only use this barbecue outdoors in a
well-ventilated area. Do not use in a garage,
building, breezeway or any other enclosed area.
m WARNING: Never use your Weber Gas Barbecue
under an unprotected combustible roof or overhang.
m WARNING: Your Weber Gas Barbecue is not
intended to be installed in or on recreational
vehicles and/or boats.
m WARNING: Do not use combustible materials
within 24 inches of the top, bottom, back or sides
of the grill.
m WARNING: The entire cooking box gets hot
when in use. Do not leave unattended.
m WARNING: Keep any electrical supply cord and
the fuel supply hose away from any heated surface.
m WARNING: Keep the cooking area clear of
flammable vapors and liquids, such as gasoline,
alcohol, etc., and combustible materials.
Gas Supply Testing
• Disconnect your Weber Gas Barbecue when the
gas supply is being tested at high pressures. This
appliance and its individual shutoff valve must be
disconnected from the gas supply piping system
during any pressure testing of that system at test
pressures in excess of 1/2 psig (3.5 kPa).
• Turn OFF your Weber Gas Barbecue when the
gas supply is being tested at low pressures. This
appliance must be isolated from the gas supply
piping system by closing its individual manual
shutoff valve during any pressure testing of the
gas supply piping system at the pressure equal to
or less than 1/2 psig (3.5 kPa).
A-5
1
Genesis Silver-A NG
10
11
12
2
3
4
5
6
7
8
9
24
25
26
27
28
29
30
31
32
33
34
35
13
14
15
16
17
18
19
20
21
22
23
36
37
38
39
29
40
41
42
43
44
45
A-6
1. Hinge Pin
2. Left Endcap
3. Shroud
4. Handle
5. Warming Rack
6. Cooking Grates
7. Flavorizer Bars
8. Cooking Box
9. 1/4-20 keps nut
10. Slide Out Bottom Tray
11. Catch pan holder
12. Left Trim Piece
13. Work Surface
14. 1/4-20 x 1 3/4 inch bolts
15. Left Frame
16. 1/4-20 x 1/2 inch bolts
17. Nylon Washers
18. Leg Frame
19. 1/4-20 x 2 inch bolts
20. Frame Connector
21. Bottom Shelf
22. Wheels
23. Hubcap
24. Hair Pin Cotter
25. Thermometer
26. Right Endcap
27. Burner Control Knobs
28. Control Panel
29. Control Panel Hardware
30. Ignitor Button
31. Crossover Tube
32. Burners
33. Manifold Hardware
34. Manifold
35. Manifold Support Bracket
36. Spider Stopper Guards
37. Catch Pan
38. Disposable Drip Pan
49. Right Frame
40. Control Panel Trim Piece
41. Right Trim Piece
42. Igniter
43. Wheel Frame
44. Axle Rod
45. Hose
A-7
© 1999 Weber-Stephen Products Co., Weber , the silhouette, and the kettle configuration are registered trademarks
®
of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL, 60067-6266, U.S.A. This product is covered by
one or more United States patents and patents in other nations globally . Printed in the U.S.A.
A-8
Screwdriver
Phillips screwdriver
Hammer
7/16 open-end or an adjustable wrench
Pliers
Left Frame - 1
Right Frame -1
Wheel Frame - 1
Block of wood
Lid - 1
Cooking Box - 1
Leg Frame - 1
Frame Connectors - 1
®
®®®®
Left Trim Piece - 1
Right Trim Piece - 1
Work Surface - 1
Cooking grates - 2
Control panel - 1
Bottom Shelf - 1
Hose - 1
A-9
Loading...