General ABHA30LB, ABHA30LBT, AOHA30LBTL, ABHA36LB, ABHA36LBT Technical Manual

...

R410A

D2D_AB025E/01

2008.01.24

1. CEILING

TYPE :

AB A30LBT AB A36LBT

INDOOR UNIT

- (01 - 01) -

1. FEATURE

FEATURES

MODEL : AB A30LBT / AO A30LBTL AB A36LBT / AO A36LBTL

Energy saving rank A

European energy ranking rank A achieved by all DCization and optimization of the refrigerant cycle.

Quiet operation

Air flow mode can be set in 4 steps and more detailed air flow setting is possible. 30 type: 32 dB / 36 type: 32 dB at operation in the Quiet mode.

Filter sign

Dirtying of filter is detected by air conditioner operating time and the user is informed.

Economy operation

Operation that suppresses maximum power consumption is performed.

Wired/wireless simultaneous use possible

Wired remote controller and wireless remote controller can be simultaneously used.

Combination of up/down and right/left air direction swing allows three-dimensional air direction control. Since up/down air direction flaps operate automatically, according to the operating mode of the unit, it is possible to set the air direction based on the operating mode.

Double auto swing

VERTICAL HORIZONTAL

SWING

Installation

OPEN SPACE CONCEALED WALL MOUNTED

(for high-ceilinged room)

CEILING TYPE AB A30-36L

- (01 - 02) -

Filter sign operating time (Standard/long/short/no display)

Filter sign display time interval and filter sign no display can be selected.

Ceiling height (standard/high ceiling)

Air conditioner operation capacity (air flow) switching is possible as response to height of installation ceiling.

Cooling room temperature correction (Standard/low control)

Air conditioner control temperature can be switched to a little low as response to installation conditions.

Heating room temperature correction (Standard/low/slightly high/high control)

Air conditioning control temperature can be slightly adjusted as response to installation conditions.

Auto restart (ON/OFF)

ON/OFF of the function which automatically resets operation to the operation state before the power interruption at power recovery when there was a power interruption during operation can be selected.

Room temperature sensing function (ON/OFF) only at wired remote controller connection

Sensor which controls the room temperature can be selected in two types: "Indoor sensor only" or "Indoor sensor or wired remote controller sensor can be switched by remote controller operation".

Fresh-air intake

OUTDOOR

INDOOR

CEILING TYPE AB A30-36L

FUNCTION SETTING

- (01 - 03) -

Setting of the air conditioner selection function is performed by remote controller.

Simple function setting

FEATURES

Cooling operation/dry operation

60min.

1 °C

2 °C

When the sleep timer is set, the set temperature automatically rises 1 °C every hour. The set temperature can rise up to a maximum of 2 °C.

Heating operation

When the sleep timer is set, the set temperature automatically drops 1 °C every 30 minutes. The set temperature can drop to a maximum of 4 °C.

1 °C

30min.

60min.

90min.

2 °C

3 °C

4 °C

Timer setting

• Code selector switch eliminates unit being wrongly switched. (Up to 4 codes can be set.)

A B C D

A B

Mixed-up

After code change

•Wide and precise transmitting range.

A B C D

1. Press the MODE button for more than five seconds to start the code change.

3. Press the MODE button again to end the code change.

2. Press the or button to select the desired code.

Four kinds of timer setup (ON / OFF / PROGRAM / SLEEP) are possible.

Easy to change transmission code (4 patterns) by button operation.

Four kinds of timers. Easy operation.

Select from four different timer programs (On/Off/Program/Sleep).

Built-in timers

The program timer operates the ON and OFF timer once within a 24 hour period.

Program timer

The sleep timer function automatically corrects the temperature thermostat setting according to the time setting to prevent excessive cooling and heating while sleeping.

Sleep timer

Simultaneously operation

1 2

2. REMOTE CONTROLLER

WIRELESS REMOTE CONTROLLER

CEILING TYPE AB A30-36L

- (01 - 04) -

Display panel

FUNCTIONS

SPECIFICATION

SIZE (H x W x D mm) 170 x 56 x 19

WEIGHT ( g ) 85 (w/o batteries)

ACCESSORY Holder

MODE button

Selects the operating mode (AUTO, HEAT, FAN, COOL, DRY). /Start / end R.C. custom code change. (Max 4 types)

Filter reset button

Sleep button

Pressed to select sleep timer.

Fan button

Selects the fan speed (AUTO, QUIET, LOW, MED, HIGH).

START/STOP button

Pressed to start and stop operation.

Set button (Vertical)

Air flow direction vertical set button.

Set button (Horizontal)

Air flow direction horizontal set button.

Economy display

Sleep display

Transmit indicator

Fan speed display

Swing display

Timer mode display

Clock display

Operating mode display

Temperature set display

Economy button

Set temp. button ( / )

Set remote controller custom code buttons

Sets the indoor temp./ Sets R.C. custom code.

Swing button

Air flow direction swing button.

Timer set ( / ) button

Sets the current time and on-off time.

Timer mode button

Pressed to select the timer mode. (OFF TIMER, ON TIMER, PROGRAM TIMER, TIMER RESET)

Test run button

Used when testing the air conditioner after installation.

Signal transmitter

Reset button

Used when replacing batteries.

Clock adjust button

Sets the current time.

CEILING TYPE AB A30-36L

- (01 - 05) -

3. SPECIFICATIONS

AB A30LBT AB A36LBT

Cooling A A

Heating A A

kW 8.50 9.40

BTU/h 29000 32100

kW 2.80 - 10.00 2.80 - 11.20

BTU/h 9500 - 34100 9500 - 38200

kW 10.00 11.20

BTU/h 34100 38200

kW 2.70 - 11.20 2.70 - 12.70

BTU/h 9200 - 38200 9200 - 43300

2.65 2.93

3.88 4.56

2.77 3.02

3.88 4.56

11.6 12.8

17.0 20.0

12.2 13.2

17.0 20.0

EER 3.21 3.21

COP 3.61 3.71

l/h (pints/h) 2.5(5.3) 3.0 (6.3)

High 1660 1900

Med 1500 1500

Low 1200 1200

Quiet 1000 1000

High 1660 1900

Med 1500 1500

Low 1200 1200

Quiet 1000 1000

Type × Q'ty

Motor output W 120 120

High 45 47

Med 43 43

Low 37 37

Quiet 32 32

High 45 47

Med 43 43

Low 37 37

Quiet 32 32

Dimensions (H × W × D) 252 × 1350 × 39.9 252 × 1350 × 39.9

Fin pitch 1.45 1.45

Rows x Stages 3 × 12 3 × 12

Pipe type

Fin type

Material

Colour

Net

Gross

Net 46 ( 101 ) 46 ( 101 )

Gross 58 ( 128 ) 58 ( 128 )

Liquid

9.52 ( 3 / 8 in.) 9.52 ( 3 / 8 in.)

Gas

15.88 ( 5 / 8 in.) 15.88 ( 5 / 8 in.)

Method Flare Flare

°C 18 to 32 18 to 32

%RH 80 or less 80 or less

Heating °C 16 to 30 16 to 30

Note : Specifications are based on the following conditions. Cooling : Indoor temperature of 27 °CDB / 19 °CWB.and outdoor temperature of 35 °CDB/24 °CWB. Heating : Indoor temperature of 20 °CDB / 15 °CWB.and outdoor temperature of 7 °CDB/6 °CWB. Pipe length : 5 m, Height difference : 0 m.(Outdoor unit - Indoor unit) The maximum current and the maximum input value are the maximum value when operated within the operation range(temperature)

European energy label

ABS

Outer diameter : 26.0 / Inner diameter : 21.5

Airflow rate

Cooling

Heating

m3/h

Cooling

White

240 × 1660 × 700

318 × 1800 × 790

Wireless

Sirocco × 4

Copper

Aluminium

ABS

CEILING MODEL

INVERTER HEATPUMP

230V 50Hz

198-264V 50Hz

Operation range Cooling

kg(lb.)

Connection pipe Size

Remote controller type

Drain pipe Material

Size

Dimensions ( H× W × D )

Weight

Heat exchanger type

Enclosure

Fan

Current

Cooling

Heating Rated

*Max.

Rated

*Max.

kW/kW

Heating Rated

*Max.

Rated

*Max.

Heating

Sound pressure level

Heating

Rated

Min. - Max.

Rated

Min. - Max.

Heating

Input power

Cooling

dB(A)

Type Model name

Power source

Available voltage range

Capacity

Cooling

Moisture removal

Cooling

CEILING TYPE AB A30-36L

- (01 - 06) -

4. DIMENSIONS

Top view

Side view

Rear view

MODEL : AB A30L, AB A36L

(Unit : mm)

1 2 3

30 30

Suspension bolt pitch

1,600

INDOOR UNIT (Top view)

Dimensions (Space Required

for Installation)

10 155

300

INDOOR UNIT

Suspension bolt should extend outward 30 to 75.

Refrigerant piping flare connection (Gas)

Refrigerant piping flare connection (Liquid)

Drain piping connection

Knock out hole for fresh air

Knock out hole for refrigerant piping

Hole for lifting bolt (Use M10 screw bolt)

141

Ø200

114

373

Ø200

CEILING TYPE AB A30-36L

- (01 - 07) -

MOUNTING POSITION

80 or over 150 or over

10 or over

2300 or over

1000 or over

INDOOR UNIT

Ceiling

INDOOR UNIT

Ceiling panel

Obstruction

Floor

Ceiling panel

80 or over 150 or over

10 or over

(Unit : mm)

2300 or over

1000 or over

Obstruction

Floor

CEILING TYPE AB A30-36L

- (01 - 08) -

5. WIRING DIAGRAMS

MODEL : AB A30L, AB A36L

CEILING TYPE AB A30-36L

- (01 - 09) -

6. CAPACITY TABLE

6-1. COOLING CAPACITY

This table is created using the maximum capacity.

MODEL : AB A30L

MODEL : AB A36L

AFR : Air flow rate (m3/min) TC : Total capacity (kW) SHC : Sensible Heat capacity (kW) PI : Power Input (kW)

°CDB

°CWB

TC SHC PI TC SHC PI TC SHC PI TC SHC PI TC SHC PI TC SHC PI TC SHC PI

8.60 6.53 1.32 9.59 6.57 1.35 9.91 7.14 1.35 10.57 7.17 1.37 10.89 7.74 1.37 11.55 7.71 1.39 12.20 8.21 1.40

8.38 6.44 1.71 9.33 6.48 1.73 9.65 7.05 1.74 10.28 7.07 1.76 10.60 7.64 1.77 11.24 7.61 1.79 11.87 8.10 1.80

7.96 6.33 2.19 8.87 6.37 2.23 9.17 6.92 2.24 9.77 6.94 2.26 10.08 7.50 2.27 10.68 7.47 2.29 11.29 7.96 2.32

7.85 6.17 2.24 8.75 6.21 2.28 9.04 6.75 2.29 9.64 6.77 2.31 9.94 7.32 2.33 10.54 7.29 2.35 11.13 7.76 2.37

7.82 6.27 2.27 8.71 6.31 2.30 9.00 6.86 2.31 9.60 6.88 2.34 9.89 7.43 2.35 10.49 7.40 2.37 11.08 7.89 2.39

8.20 6.31 2.47 9.13 6.35 2.51 9.44 6.90 2.52 10.07 6.92 2.54 10.38 7.48 2.56 11.00 7.45 2.58 11.62 7.93 2.61

9.45 6.90 3.00 10.53 6.94 3.05 10.89 7.55 3.06 11.61 7.57 3.09 11.97 8.18 3.11 12.68 8.14 3.14 13.40 8.67 3.17

9.12 6.77 3.34 10.16 6.81 3.39 10.51 7.40 3.41 11.20 7.42 3.44 11.55 8.02 3.46 12.24 7.99 3.49 12.93 8.51 3.53

8.71 6.67 3.35 9.70 6.71 3.40 10.03 7.30 3.42 10.69 7.32 3.45 11.02 7.91 3.47 11.68 7.88 3.51 12.34 8.39 3.54

7.90 6.31 3.36 8.80 6.34 3.41 9.10 6.90 3.43 9.70 6.92 3.47 10.00 7.47 3.48 10.60 7.44 3.52 11.20 7.93 3.55

6.03 5.20 2.98 6.72 5.23 3.03 6.95 5.68 3.04 7.41 5.70 3.07 7.63 6.16 3.09 8.09 6.13 3.12 8.55 6.53 3.15

5.39 5.10 2.92 6.01 5.13 2.97 6.21 5.58 2.99 6.62 5.59 3.02 6.82 6.04 3.03 7.23 6.02 3.06 7.64 6.41 3.09

-15

232518

AFR

27.7

Indoor temperature

Outdoor temperature

°CDB

-10

272932

231921

°CDB

°CWB

TC SHC PI TC SHC PI TC SHC PI TC SHC PI TC SHC PI TC SHC PI TC SHC PI

8.73 6.97 1.32 9.72 7.02 1.34 10.05 7.63 1.35 10.72 7.65 1.36 11.05 8.26 1.37 11.71 8.23 1.39 12.37 8.77 1.40

8.49 6.76 1.71 9.46 6.80 1.74 9.78 7.39 1.75 10.43 7.41 1.77 10.75 8.01 1.78 11.40 7.97 1.79 12.04 8.49 1.81

8.15 6.72 2.20 9.08 6.76 2.24 9.39 7.35 2.25 10.01 7.37 2.27 10.31 7.96 2.28 10.93 7.93 2.31 11.55 8.45 2.33

8.04 6.54 2.24 8.95 6.58 2.28 9.26 7.16 2.29 9.87 7.18 2.31 10.17 7.75 2.33 10.78 7.72 2.35 11.39 8.23 2.37

8.01 6.65 2.26 8.92 6.69 2.30 9.22 7.28 2.31 9.83 7.30 2.33 10.13 7.88 2.35 10.74 7.85 2.37 11.35 8.37 2.39

8.43 6.70 2.47 9.39 6.74 2.50 9.71 7.33 2.52 10.35 7.35 2.54 10.67 7.94 2.56 11.31 7.90 2.58 11.95 8.42 2.61

9.82 7.34 3.00 10.94 7.38 3.05 11.31 8.03 3.06 12.06 8.05 3.10 12.43 8.69 3.11 13.18 8.66 3.14 13.92 9.23 3.17

9.38 7.13 3.34 10.45 7.18 3.39 10.80 7.80 3.41 11.52 7.83 3.44 11.87 8.45 3.46 12.59 8.42 3.49 13.30 8.97 3.53

9.20 7.05 4.06 10.25 7.09 4.13 10.60 7.71 4.15 11.30 7.74 4.19 11.65 8.36 4.21 12.35 8.32 4.25 13.05 8.86 4.30

8.85 7.03 4.05 9.86 7.08 4.11 10.19 7.69 4.13 10.86 7.72 4.17 11.20 8.33 4.19 11.87 8.30 4.24 12.54 8.84 4.28

6.61 5.89 3.07 7.37 5.93 3.12 7.62 6.44 3.14 8.12 6.46 3.17 8.37 6.98 3.18 8.87 6.95 3.22 9.38 7.41 3.25

5.95 5.91 2.95 6.62 5.94 2.99 6.85 6.46 3.01 7.30 6.48 3.04 7.53 7.00 3.05 7.98 6.97 3.09 8.43 7.42 3.12

-15

232518

AFR

31.7

Indoor temperature

Outdoor temperature

°CDB

-10

272932

231921

CEILING TYPE AB A30-36L

6-2. HEATING CAPACITY

This table is created using the maximum capacity.

MODEL : AB A30L

MODEL : AB A36L

AFR : Air flow rate (m3/min) TC : Total capacity (kW) PI : Power Input (kW)

- (01 - 10) -

TC PI TC PI TC PI TC PI TC PI

9.17 3.97 8.95 4.05 8.73 4.13 8.51 4.22 8.29 4.30

9.88 4.02 9.65 4.10 9.41 4.19 9.18 4.27 8.94 4.35

10.56 4.04 10.31 4.12 10.06 4.21 9.81 4.29 9.56 4.38

11.81 4.06 11.53 4.15 11.25 4.23 10.97 4.32 10.69 4.40

12.95 3.97 12.64 4.05 12.33 4.14 12.02 4.22 11.72 4.30

13.34 3.46 13.02 3.53 12.70 3.61 12.38 3.68 12.07 3.75

13.75 3.34 13.42 3.41 13.09 3.47 12.77 3.54 12.44 3.61

12.18 2.59 11.89 2.65 11.60 2.70 11.31 2.76 11.02 2.80

12.17 2.28 11.88 2.33 11.59 2.38 11.30 2.43 11.01 2.46

12.71 2.26 12.41 2.31 12.10 2.36 11.80 2.40 11.50 2.44

AFR

°CDB

31.7

-16

-11

-7

Outdoor temperature

151820

-15

-2

-10

-5

°CDB

°CWB

Indoor temperature

161820

TC PI TC PI TC PI TC PI TC PI

8.22 3.38 8.02 3.45 7.83 3.52 7.63 3.59 7.44 3.67

8.79 3.39 8.58 3.46 8.37 3.53 8.16 3.60 7.95 3.67

9.54 3.40 9.31 3.47 9.08 3.54 8.86 3.61 8.63 3.69

10.11 3.41 9.87 3.48 9.63 3.55 9.39 3.62 9.15 3.69

11.22 3.37 10.96 3.44 10.69 3.51 10.42 3.58 10.16 3.65

11.76 3.34 11.48 3.41 11.20 3.48 10.92 3.55 10.64 3.62

12.12 3.27 11.83 3.34 11.54 3.40 11.25 3.47 10.97 3.54

10.86 2.56 10.60 2.61 10.34 2.67 10.08 2.72 9.82 2.76

10.85 2.26 10.59 2.30 10.33 2.35 10.07 2.40 9.81 2.43

11.31 2.27 11.04 2.31 10.77 2.36 10.50 2.41 10.23 2.45

AFR

°CDB

27.7

-16

-11

-7

Outdoor temperature

151820

-15

-2

-10

-5

°CDB

°CWB

Indoor temperature

161820

CEILING TYPE AB A30-36L

- (01 - 11) -

7. FAN PERFORMANCE AND AIR FLOW

7-1. AIR VELOCITY DISTRIBUTION

MODEL : AB A30L

(m)

Unit : m/s

TOP VIEW VERTICAL : UPWARD HORIZONTAL : CENTER

(m)

SIDE VIEW VERTICAL : CENTER HORIZONTAL : CENTER

(m)

TOP VIEW VERTICAL : UPWARD HORIZONTAL : RIGHT AND LEFT

(m)

4 3 2 1 0 1 2 3 4

0 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

0 1 2 3 4 5 6 7 8 9 10 11 12 13 14

4 3 2 1 0 1 2 3 4

0 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

SIDE VIEW VERTICAL : DOWNWARD HORIZONTAL : CENTER

0 1 2 3 4 5 6 7 8 9 10 11 12 13 14

SIDE VIEW VERTICAL : UPWARD HORIZONTAL : CENTER

0 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Note :

Condition

Fan speed : High Operation mode :FAN

2 1 0.5 0.25

0.5

0.25

0.5

0.25

0.5

0.25

0.5

0.25

CEILING TYPE AB A30-36L

+ 25 hidden pages