GE ZGG24L20BSS Installation Guide

GE Monogram ®

24" Outdoor
Cooking Center

MOdal

Z(.(.24I,

Before you begin-- Read these instructions completely and carefully.
IMPORTANT: Save these instructions for local inspector's use.

IMPORTANT: OBSERVE ALL GOVERNING CODES AND ORDINANCES.
NOTE TO INSTALLER: Be sure to leave these instructions with the Consumer.
NOTE TO CONSUMER: Keep these instructions with your Use and Care Book for future reference.

If you received a damaged cooking center, you should
contact your dealer.

Insta!latian of this cooking center requires basic
mechanica! skills. Proper installation is the responsibility

of the installer.

ForMonegram local service in veur area,
1=800-444-!845,

ForMueagram service in Caeada,!-888-880-3030.
ForMonogram PartsandAccessories, call

1=800-626-2002.

FORYOURSAFETY:
Do not usecooking center in aspace where gasoline or

other liquids having flammable vapors are stored or
used=

CAUTION:

• For outdoor use only. Use this cooking center only in
the manner intended by the manufacturer.

• This outdoor cooking gas appliance is not intended to
be installed in or on recreational vehicles and/or

boats.

®Do not use the grill in an explosive atmosphere. Keep

the grill away from areas where gasoline or other
flammable liquids and vapors are stored or being used.

®Observe proper clearances to combustible materials at

all times.

Do not use a rusty or damaged LPtank.

• Never substitute gases (natural for LP or LP for
natural).

®This grill is factory set for liquid propane gas. A natural

gas conversion kit must be installed before using
natura! gas.

®When storing the grill indoors, disconnect the LP tank.

Store the tank outdoors in a well ventilated area.

• Do not store additional LP tanks in or near the gas grill.

• Follow the guidelines on the LP tank for proper storage,
transport and handling.

®Tested in accordance wkh ANSI Z21.58 latest edition

standard for outdoor cooking gas appliances. This grill

Inthe gommonwealtl_ of Massachusetts:

This product must be installed by alicensed

plumber or gasfitter.

•When using bail type gas shut off valves, they
shall beT-handletype.

oAflexible gas connector, when used, must not

exceed 3 feet.

[FYOU SMELL GAS:

Shut off gas to appliance.

Extinguish any open flame.
Open lid.

if odor continues, immediately call ,/our gas supplier.

is for outdoor use only. Check local building codes for
the proper methodof installation in the absence of local
codes,this unit should beinstalled in accordance with

the National Fue!GasCodeNo.Z223latest edition and
the National Electrical CodeANSI/NFPA No.70-19%

CALiFORNiA PROPOSiTiON 65 -WARNING
The burning of gas cooking fue! generates some by

products that are on the list of substances which are
known by the State of California to cause cancer or

reproductive harm. California law requires businesses to
warn custorners of potential exposure to such
substances. To minimize exposure to these substances,

always operate this unit according to the use and care
manual, ensuring you provide good ventilation when
cooking with gas.

INSECT WARM N6[
Spiders and insects can nest in the burners of this and

any other grill, and cause the gas to flow from the front of
the burner. This is a very dangerous condition which can

cause a fire to occur behind the valve panel, thereby
damaging the grill and making it unsafe to operate.
Inspect the grill twice a year or immediately if an,/
symptoms appear.

Desiga [efarmatiee

Model ................................................................................. 3

Product Dimensions & Clearances .............................. 3

Accessories ...................................................................... 3

Advance Planning ............................................................ 3

Choosing the Location .................................................... 4

Tools & Materials Required ........................................... 4

Step 1: Remove the Packaging ..................................... 4

Step 2: Provide Support,

Insta!lation on a Cart ......................................... 4

[estallatiee
Step 2: Provide Support,

Built-in installations .......................................... 5

Step 3: Provide Gas & E[ectrica! Supply ..................... 6

Step 4: Test for Leaks ...................................................... 7

Step 5: Lighting the Grill .................................................. 7

Step 6: Adiusting the Burners ....................................... 8

Finalize Installation .......................................................... 9

install Rotisserie .............................................................. 9

ZXADYSS, ZXSDBSS, Optional Access Doors ........... 9

ZX24NGB, Natural Gas Conversion Kit ...................... 10

Design In%rmathm

24" O_ddoo*' Cookh_g" (.'e,ter

Modal

Pro&tct
Di me'++sio'Y+,s

ZGG24120 SS

The Monogram 24" ()indoor" Cooking (_ente1"
is f_( to_'v set R)_"LP gas and can be convex'ted

to natm'a] gas. O_'de_"ZX24N (;B Natm'a] gas
conve_'si on k]t _ hen n at m'a] gas is ava]]ab] e.

24-3/4"

0

24" (Cutout)

This g_il] may be h]stalled on a pox'table g_il]

cm't oi" bllih into an e]]ch)sm'e.

Endosmes ca]] be consti'ucted o{ non-combus-

tible (mnsom'y) mnte1"ia] oi" of combustible

material such as _oo(L Insulated jackets a_'e
_'e(pfi_'ed fo_" h_stallation into combustible

e_] c] osHI"es.

* ZX24CTBSS, grill can't

" ZX24JBSS_]nsl_lated jacket J_b_"a combustible

en closm'e.

"12" Min. to Combustibles

4" Min. for Lid Clearance

9"

_4" ForLid Clearancewhen installed

into a non-combustibleenclosure,
Allow 12"rain clearance to
combustible vertical surfaces.

o ZX24TKBSS is _wai]ab]e to conceal the gap

betwee]] the cook] m]_.{cen te_" m]d the
eli c] osm'e.

* ZX24CV'C_ tol_gh vinyl on the oms]de_ felt

]im]ed im]shie with elastic to hold the cove_" hi
place. Fits g_'ill i_stalled on a cm't o_" M_en

b_fi]t-in,

* ZXS])BSS - Stai_]]ess Steel Single Access Doo_"

ZXADYSS - Stahi]ese Steel Dol_b]e Access

Manifold
Pipe 34/2"

Door's- Optional at cesso_'ies to cove_" the

access openh_g m_de_" the g_il] in a b_fih-in
in sta]]atiom

* ZXI J_Y;IJ _ gas ta_k.

Advance

* This Monog_'am Outdoor" C_ooking Center" is

desig_led to be h_stalled on a g_ill cm't o_" hm)

;m e_]closm'e.

* h_ a mm-comb_,st]b]e (mas(m_'y) e_]c]osm'e_

the g_'i]](h'ope into the opening. A ]edge on

each side is _'eqld_'ed ibm"s_qq_<>rt.
A]] h]su]atedjacket is available to a]]o_ the

g_']]] to be i_]sta]]ed in a combustible

eli c] osm'e. The hi s_]ated,ja( ket m _st be
suppo_'ted by a ]edge o]] each side.

* If _si n g a backsp]ash o_" _'ea_" _ a]], locate the

electrical se_'vice fb_" the _'otisse_ie on the

_'igh t s] de.

* T_'] m kit ZX24TKBSS is awfi]ab] e to con cea]

the gap bet_een cook]_]___ tel'item" mid the bark

a_] d s]des of m] eli c] osm'e.

C_ea!oances
* Allo_ 4" at the _'em" fkn" lh] cleam_]ce.
* Allo_ at least 12" cleam_]ce at the back of the

g_'ill whe_] exha_st is dh'ected to a wi_]dow o_"
a sin'{hoe that is diil]c_*h to c]eam

* A]]o_ at least 6" c]em'm]ce ()1] each side to

an]v non-combustible matelia] Mcated above
the cooking sm'ihce %_" com]te_'space. This 6"

cl era'an ce _ ill all o_ }b_" placem en t an d
h a_] d]h] g of the _'ot] see_'i e m o to_" a_] d sk,e_ e_'.

* A]]o_ at least 12" c]em'm]ce ()1] ea(h side and

] 2" m hi. c] era'an ce at _'em" to corn b_ st] b]e

ve_'ti ca] mate_'ia]s.

Desigl_ I1Kbrmatkm

24" Outdoor Cookin£ (/e_/ter

CTtoosir_,g
the Locatio'n

7bets

St@ l

Remove the

Pa&(_#i'n,g

* This cooki_lg cem]ter is designed for ol_tdoor

use on]v. Do not locate the grill in a

building, garage or other endosed area.
* En slate th at {}'esh air ve_ ti]ati o_ is adeq Irate.
* ( onsider exposure to _qnd and proxh_ity to

* The clearances to combustib]es

m'N?llstbe maim]taimled at air times.

* Phillips head scre_driver
* Pipe _ ten ch

* I _eve]
* Fiat blade screv, driver (3/32" blade)

*P]iers

* Open the box and remove packaging.
* Opel] the gr'i]] rid and r'emo_,e ]_ardv, ar'e

accessor_ car'ton. CJ/eck c(mte]]ts.

Motor

* Do m)t h]sta]] a gr]]] be]o_ overhead

m_protected combllstib]e co]/struction.

* The installatio_ midst conform to local codes

or h_ the abse_ce of local codes, with the
national fuel gas code, ANSI Z223 latest

edition.

2 Grill Grates

St@2

Provide

Ot_,a,(,a,'_t

Spit Forks

2 Ceramic BricluetteTrays

RotisserieRodand Handle

The Ol_tdoor C(_okim_g (}enter can be h_sta]]ed

on a ZX24CTBSS cart M_ich is desig_ed
specifically fin" this mode]. Fo]]o_ the i_]sta]]a-
tio_] h]structio_s provided _ith the cart to

i_sta]L Proceed to Gas s_app]?, Step 3, to

complete the i_sta]]ation.

Type1 Acme,

20 Lb LPTankwith Overfill

Protection Device.(not supplied)

LPRegulator

Requiredfor Grill CartInstallation

*A]]ow at ]east 12" c]ear'a_ce at the back of the

gri]] _]]el] exhm_st is directed to a _in(]o_ of
a sm'JB/ce that is difticll]t to dean.

OrderZXLPY