GE ZEK957, ZEK937 User Manual

Installation

27” Built In Wall Oven

JKP15, JKP18, JKP27, JKP45, JKP56 JKS05, ZEK937, ZEK957

Instructions

“If you have questions, call 800-GE-CARES or visit our website at:

www.GEAppliances.com”

Before you begin

Read these instructions carefully and completely

• IMPORTANT-Save these instructions for

local inspector’s use.

• IMPORTANT-Observe all governing

codes and ordinances.

• Note to Installer- Be sure to leave these instructions with the consumer.

• OWNER- Keep these instructions for future reference.

• ATTENTION INSTALLER!! All electric wall ovens must be hard wired

(direct wired) into an approved junction box. A “plug and receptacle” is NOT permitted on these products

• NOTE- This appliance must be properly grounded.

Parts Included

Bottom Trim

Single Ovens 4 flat head screws (side trim) 3 pan head screws (bottom trim) Double Ovens 8 flat head screws (side trim) 3 Pan head screws (bottom trim)

Tools You Will Need

Materials Needed

Wire Nuts

Strain Relief Clamp for 1/2” conduit

Junction Box

36” of String

1/8” Drill Bit & Electric or Hand Drill

Pub. No. 31-10473

229C4053P452

Phillips Screwdriver

Installation Instructions

IMPORTANT SAFETY INSTRUCTIONS

For Your Safety

• Be sure your oven is installed properly by a qualified installer or service technician.

• Be sure the oven is securely installed in a cabinet that is firmly attached to the house structure. Weight on the oven door could cause the oven to tip and result in injury. Never allow anyone to climb, sit, stand or hang on the oven door.

• Make sure the cabinets and wall coverings around the oven can withstand the temperatures (up to 200°F.) generated by the oven.

CAUTION: The electrical power to the oven supply line must be shut off while line connections

are being made. Failure to do so could result in serious injury or death.

Electrical Requirements

This appliance must be supplied with the proper voltage and frequency, and connected to an individual properly grounded branch circuit, protected by a circuit breaker or fuse having amperage as noted on rating plate. (Rating Plate is located on oven side trim.)

We recommend you have the electrical wiring and hookup of your oven connected by a qualified electrician. After installation, have the electrician show you where your main oven disconnect is located.

Check with your local utilities for electrical codes which apply in your area. Failure to wire your oven according to governing codes could result in a hazardous condition. If there are no local codes, your range must be wired and fused to meet the requirements of the National Electrical Code, ANSI/NFPA No. 70-Latest Edition. You can get a copy by writing:

National Fire Protection Association

Battery March Park

Quincy, MA 02269

Effective January 1, 1996, the National Electrical Code requires that new, but not existing, construction utilize a 4 conductor connection to an electric range. When installing an electric range in new construction, follow the instructions in the section on NEW CONSTRUCTION AND FOUR CONDUCTOR BRANCH CIRCUIT CONNECTION.

You must use a three-wire, single-phase A.C. 208Y/120 Volt or 240/120 Volt, 60 hertz electrical system. If you connect to aluminum wiring, properly installed connectors approved for use with aluminum wiring must be used.

Installation Instructions

Pre- Installation Checklist

Door Removal is not a requirement for

ALL INSTALLATION INFORMATION ON THE FOLLOWING PAGES IS TO BE USED FOR SINGLE AND DOUBLE OVEN INSTALLATION!

installation of the product, but is an added

convenience.

Open the oven door as far as it will go.

Remove packaging materials. Check behind hinges, and under false bottom. Remove labels on the outside of the door, plastic on trims and panel, and all tape around oven.

Oven Racks

EASY INSTALLATION OF YOUR NEW

30" WALL OVEN

Before you begin-Read these instructions completely and carefully.

Before you begin-Read these instructions completely and carefully. IMPORTANT- Save these instructions for local inspector's use.

IMPORTANT- Save these instructions for local inspector's use.

30" WALL OVEN

IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES.

Note to Installer- Be sure to leave these instructions with the consumer.

Note to Installer- Be sure to leave these instructions with the consumer. OWNER- Keep these instructions for future reference.

OWNER- Keep these instructions for future reference.

Before you begin-Read these instructions completely and carefully.

Note- This appliance must be properly grounded (if applicable).

IMPORTANT- Save these instructions for local inspector's use.

IMPORTANT- Save these instructions for local inspector's use. IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES.

IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES.

IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES. Note to Installer- Be sure to leave these instructions with the consumer.

Note to Installer- Be sure to leave these instructions with the consumer.

Note to Installer- Be sure to leave these instructions with the consumer. OWNER- Keep these instructions for future reference.

OWNER- Keep these instructions for future reference.

FOR YOUR SAFETY

Note- This appliance must be properly grounded (if applicable).

Before you begin-Read these

Before you begin-Read these instructions completely and

instructions completely and

carefully.

FOR YOUR SAFETY

ELECTRICAL REQUIREMENTS

FOR YOUR SAFETY

ELECTRICAL REQUIREMENTS

IMPORTANT- Save these

ELECTRICAL REQUIREMENTS

ELECTRICAL REQUIREMENTS instructions for local inspector's use.

instructions for local inspector's use.

Before you begin-Read these

IMPORTANT- OBSERVE ALL

Before you begin-Read these

instructions completely and

GOVERNING CODES AND ORDIANCES.

instructions completely and

carefully.

Note to Installer- Be sure to leave

carefully.

IMPORTANT- Save these

these instructions with the consumer.

IMPORTANT- Save these

instructions for local inspector's use.

OWNER- Keep these instructions

instructions for local inspector's use.

IMPORTANT- OBSERVE ALL

for future reference.

IMPORTANT- OBSERVE ALL

GOVERNING CODES AND ORDIANCES.

Note- This appliance must be

GOVERNING CODES AND ORDIANCES.

Note to Installer- Be sure to leave

properly grounded (if applicable).

Note to Installer- Be sure to leave

Literature

Before you begin-Read these

Broiler Pan and Grid

IMPORTANT- OBSERVE ALL

IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES.

GOVERNING CODES AND ORDIANCES.

GOVERNING CODES AND ORDIANCES. Note to Installer- Be sure to leave

Note to Installer- Be sure to leave

Note to Installer- Be sure to leave these instructions with the consumer.

these instructions with the consumer.

these instructions with the consumer. OWNER- Keep these instructions

OWNER- Keep these instructions

for future reference.

Note- This appliance must be

Note- This appliance must be properly grounded (if applicable).

properly grounded (if applicable).

Before you begin-Read these instructions completely and

instructions completely and

carefully.

IMPORTANT- Save these

IMPORTANT- Save these instructions for local inspector's use.

instructions for local inspector's use.

instructions for local inspector's use. IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES. Note to Installer- Be sure to leave

these instructions with the consumer.

these instructions with the consumer. OWNER- Keep these instructions

OWNER- Keep these instructions

OWNER- Keep these instructions for future reference.

for future reference.

for future reference. Note- This appliance must be

Note- This appliance must be

Note- This appliance must be properly grounded (if applicable).

properly grounded (if applicable).

properly grounded (if applicable). Before you begin-Read these

Before you begin-Read these

Before you begin-Read these instructions completely and

instructions completely and

instructions completely and carefully.

carefully.

carefully. IMPORTANT- Save these

IMPORTANT- Save these

IMPORTANT- Save these instructions for local inspector's use.

instructions for local inspector's use.

instructions for local inspector's use. IMPORTANT- OBSERVE ALL

IMPORTANT- OBSERVE ALL

IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES.

GOVERNING CODES AND ORDIANCES.

GOVERNING CODES AND ORDIANCES. Note to Installer- Be sure to leave

Note to Installer- Be sure to leave

Note to Installer- Be sure to leave these instructions with the consumer.

these instructions with the consumer.

these instructions with the consumer. OWNER- Keep these instructions

OWNER- Keep these instructions

OWNER- Keep these instructions for future reference.

for future reference.

for future reference. Note- This appliance must be

Note- This appliance must be

Note- This appliance must be properly grounded (if applicable).

properly grounded (if applicable).

instructions for local inspector's use.

instructions for local inspector's use. IMPORTANT- OBSERVE ALL

IMPORTANT- OBSERVE ALL

IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES.

GOVERNING CODES AND ORDIANCES.

GOVERNING CODES AND ORDIANCES. Note to Installer- Be sure to leave

Note to Installer- Be sure to leave

Note to Installer- Be sure to leave these instructions with the consumer.

these instructions with the consumer.

OWNER- Keep these instructions

for future reference.

for future reference. Note- This appliance must be

Note- This appliance must be

Note- This appliance must be properly grounded (if applicable).

properly grounded (if applicable).

these instructions with the consumer.

these instructions with the consumer. OWNER- Keep these instructions

OWNER- Keep these instructions

OWNER- Keep these instructions for future reference.

for future reference.

for future reference. Note- This appliance must be

Note- This appliance must be

Note- This appliance must be properly grounded (if applicable).

properly grounded (if applicable).

properly grounded (if applicable). Before you begin-Read these

Before you begin-Read these

Before you begin-Read these instructions completely and

instructions completely and

instructions completely and carefully.

carefully.

carefully. IMPORTANT- Save these

IMPORTANT- Save these

IMPORTANT- Save these instructions for local inspector's use. IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES.

these instructions with the consumer.

these instructions with the consumer. OWNER- Keep these instructions

OWNER- Keep these instructions

OWNER- Keep these instructions for future reference.

for future reference.

for future reference. Note- This appliance must be

Note- This appliance must be

Note- This appliance must be properly grounded (if applicable).

properly grounded (if applicable).

Before you begin-Read these

Before you begin-Read these instructions completely and

instructions completely and

instructions completely and carefully.

carefully.

carefully. IMPORTANT- Save these

IMPORTANT- Save these

IMPORTANT- Save these instructions for local inspector's use.

instructions for local inspector's use.

instructions for local inspector's use. IMPORTANT- OBSERVE ALL

IMPORTANT- OBSERVE ALL

IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES.

GOVERNING CODES AND ORDIANCES.

GOVERNING CODES AND ORDIANCES. Note to Installer- Be sure to leave

Note to Installer- Be sure to leave

Note to Installer- Be sure to leave these instructions with the consumer.

these instructions with the consumer.

these instructions with the consumer. OWNER- Keep these instructions

OWNER- Keep these instructions

OWNER- Keep these instructions for future reference.

for future reference.

for future reference. Note- This appliance must be

Note- This appliance must be

Note- This appliance must be properly grounded (if applicable).

properly grounded (if applicable).

Pack

Open oven door and remove literature pack, broiler pan and grid, and oven racks.

Remove Installation Instructions from literature pack and read them carefully before you begin.

Be sure to place all literature, Use and Care, Installations, etc. in a safe place for future reference.

Push both hinge locks down toward the door frame, to the unlocked position. This may require a flat blade screwdriver.

Place hands on both sides of the door, close the oven door to the removal position this is half way between the broil stop and fully closed..

Lift door up and out until the hinge arms clear the slots.

Hinge

Slot

Hinge

Arm

Hinge Clears

Slot

Hinge

Unlocked

Position

EASY INSTALLATION OF YOU NEW

30" WALL OVEN

Before you begin-Read these instructions completely and carefully.

Before you begin-Read these instructions completely and carefully. IMPORTANT- Save these instructions for local inspector's use.

IMPORTANT- Save these instructions for local inspector's use.

IMPORTANT- Save these instructions for local inspector's use. IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES.

IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES.

IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES. Note to Installer- Be sure to leave these instructions with the consumer.

Note to Installer- Be sure to leave these instructions with the consumer.

Note to Installer- Be sure to leave these instructions with the consumer. OWNER- Keep these instructions for future reference.

OWNER- Keep these instructions for future reference.

OWNER- Keep these instructions for future reference. Note- This appliance must be properly grounded (if applicable).

Note- This appliance must be properly grounded (if applicable).

FOR YOUR SAFETY

ELECTRICAL REQUIREMENTS

Before you begin-Read these

instructions completely and

carefully.

IMPORTANT- Save these

instructions for local inspector's use.

IMPORTANT- OBSERVE ALL

GOVERNING CODES AND ORDIANCES.

Note to Installer- Be sure to leave

these instructions with the consumer.

OWNER- Keep these instructions

for future reference.

Note- This appliance must be

properly grounded (if applicable).

Before you begin-Read these

instructions completely and

carefully.

IMPORTANT- Save these

instructions for local inspector's use.

IMPORTANT- OBSERVE ALL

GOVERNING CODES AND ORDIANCES.

Note to Installer- Be sure to leave

these instructions with the consumer.

OWNER- Keep these instructions

for future reference.

Note- This appliance must be

properly grounded (if applicable).

(Continued on following page)

Installation Instructions

Pre- Installation Checklist cont.

Place the oven on a table or platform even with the cutout opening. (Platform must support 150 lbs. single, 275 lbs. double.)

Remove the bottom trim from the top of the oven. It will be installed at the end of installation. The trim is wrapped separately and taped to the top of the unit.

Bottom

Trim

Conduit

Side Trim

+ 8 hidden pages