GE ZMC1090WV, ZMC1090BV, ZEM200WV, ZEK757WW, ZEK737WW User Manual
...
GE Monogram
Installation
Instructions
®
27" Built-In Ovens
Models
ZEK757WW
ZEK757BW
ZEK737WW
ZEK737BW
CAUTION
WARNING
Before you begin—Read these instructions completely and carefully.
IMPORTANT: Save these instructions for local inspector’s use.
IMPORTANT: OBSERVE ALL GOVERNING CODES AND ORDINANCES.
NOTE TO INSTALLER: Be sure to leave these instructions with the
Consumer.
NOTE TO CONSUMER: Keep these instructions with your Use and Care
Book for future reference.
This appliance must be properly grounded. See “Electrical Supply”, page 16.
Contents
2
If you have questions concerning the installation of this product, call the GE Answer
®
Center
800.626.2000, 24 hours a day, 7 days a week.
If you received a damaged oven, you should
contact your dealer.
CAUTION:
• This oven should be installed by a qualified
• Never use the oven for warming or heating a
Consumer Information Service at
installer or service technician.
room. Prolonged use of the oven without
adequate ventilation can be hazardous.
Proper installation is the responsibility of the
installer. Product failure due to improper installation
is not covered under the GE Appliance Warranty. See
the Use & Care Guide for warranty information.
Check with local utilities for electrical codes which
apply in your area. Local codes vary. Installation,
electrical connections and grounding must comply
with applicable codes. In the absence of local codes,
the oven should be installed in accordance with
National Electrical Code ANSI/NFPA 70-1990.
Design Information
Models Available..................................................................................................................................3
Dimensions and Clearances ...............................................................................................................3
Cabinet Style Options .........................................................................................................................4
Installation Options ............................................................................................................................5
Side-by-side Installation Option .........................................................................................................5
Cabinetry
Tools and Materials required .............................................................................................................6
Framed Cabinet, Double Oven ..........................................................................................................6
Framed Cabinet, Single Oven ............................................................................................................7
Recessed Installation: Front framed cabinets with inset doors and drawers..................................8
Frameless Cabinets..............................................................................................................................9
Single Oven Installed Below a Microwave Oven.............................................................................10
Single Oven Installed Below a Countertop...................................................................................... 11
Cabinetry Modification Suggestions
Provide Oven Supports .....................................................................................................................12
Install Oven Supports........................................................................................................................12
Determine Need for Filler Panels.....................................................................................................13
Filler Panel Construction ..................................................................................................................13
Cut Rail for Filler Panel ....................................................................................................................14
Cut Appearance Panel ......................................................................................................................14
Determine Location of Cleats...........................................................................................................14
Cut and Secure Cleats to Filler Panel...............................................................................................15
Secure Rail to Appearance Panel .....................................................................................................15
Secure Assembled Filler Panel to Cabinet .......................................................................................15
Installation
Tools and Materials Required ..........................................................................................................16
Electrical Locations ...........................................................................................................................16
Finalize Installation ...........................................................................................................................17
Route Cable Through Cutout...........................................................................................................17
Secure Oven to Cabinet ....................................................................................................................18
Replace the Oven Door.....................................................................................................................18
Connect Electrical .............................................................................................................................18
Design Information
Built-In Ovens
Models
available
ZEK757WW
White double convection oven
ZEK757BW
Black double convection oven
ZEK737WW
White single convection oven
ZEK737BW
Black single convection oven
With both single and double built-in styles, contemporary Monogram ovens of fer an array of choices for the
custom kitchen:
• Built-in double convection ovens
• Built-in single convection ovens
• Monogram built-in ovens are available in sophisticated black or glistening white.
Dimensions
and clearances
Double oven
A - 20" (508 mm)
B - 23-1/2" (597 mm)
C - 26-13/16" (681 mm)
D - 50-3/4" (1289 mm)
E - 26-3/16" (665 mm)
F - 1-3/4" (44 mm)
G - 15/16" (24 mm)
H - 49-5/8" (1260 mm)
J - 1/4" (6 mm)
K - 7/8" (22 mm)
Single oven
A - 20" (508 mm)
B - 23-1/2" (597 mm)
C - 26-13/16" (681 mm)
D - 28-9/16" (725 mm)
E - 26-3/16" (665 mm)
F - 1-3/4" (44 mm)
G - 15/16" (24 mm)
H - 27-7/16" (697 mm)
J - 1/4" (6 mm)
K - 7/8" (22 mm)
3
Cabinet style
options
Design Information
Built-In Ovens
Front Framed Partial Overlay Door
Monogram ovens are installed directly into a wall or
wall oven cabinetry, 27" minimum width. The front
surface of the ovens will be nearly flush with surrounding cabinetry. To obtain optimal appearance,
cabinet cutouts must be exact. The examples shown
here illustrate typical styles of 27" cabinets and oven
fit. Installation instructions for each of these basic
cabinetry styles are provided in this section.
Designer Note:
possible, align the oven with
cabinetry details such as
drawers, doors and reveals.
Whenever
Front Framed Full Overlay Door
Frameless
Monogram ovens can be recessed into front framed
cabinets with inset flush doors. This installation
requires 26-7/8" wide and 24-1/2" deep cutout. See
page 6 for details.
Recessed Installation In
Front Framed Inset Flush Door
Note:
This installation requires
26-7/8" wide, 24-1/2" deep
cutout.
4
Design Information
Built-In Ovens
Installation
options
Single Oven Installed Below A
ZMC1090WV/ZMC1090BV Microwave Oven
• Install a single oven alone or below any Monogram
microwave oven.
• For an integrated look, install a single oven below
the ZMC1090BV and ZMC1090WV built-in style
microwave ovens. No trim kits required.
• Install a single oven below a ZEM200WV microwave
oven. JX827WN trim kit required.
Single Oven Installed Below A
ZEM200WV Microwave Oven
Side-by-side
installation
option
Install single ovens side-by-side. Minimum spacing
allowed:
• 5" minimum separation between cabinet openings—
any type oven.
5
Cabinetry
Built-In Ovens
Tools and
materials
required
Framed cabinet
double oven
• 2" x 4" lumber for runners
• Saw
• Level
• Phillips screwdriver and wood screws or other hardware for
installing runners or shelf to support oven.
Front Framed
Partial Overlay Door
DIMENSIONS
A Cabinet Width 27" Min.
B Cutout Width 25 " Min.
C Cutout Height 49-11/16" Min./50-1/8" Max.
D Cutout Depth 23-5/8" Min.
E Cutout Location 13-1/4" Min.
H Overall Height 50-3/4"
W Overall Width 26-13/16"
Front Framed Full
Overlay Door
Ovens are designed for installation in a cabinet 27" min. wide.
• Cut 2" x 4" runners of appropriate length or solid shelf to
support oven.
• Attach runners or solid shelf in opening as shown.
• Runners must be level and rigidly mounted.
Use the information in this dimension drawing for
typical framed cabinets. The front face of the oven
will be flush with cabinetry doors or drawers.
• Installing 13-1/4" from floor will place base of upper
oven at countertop level.
–May be more than 13-1/4" from floor, depending
upon user preference.
Order a double oven cabinet.
Rough opening for double oven must be:
• Depth—23-5/8" min. from inside back to front of
cabinet frame.
• All Monogram ovens require 7/8" overlap to
both sides and bottom. Allow 1/4" min. for top
overlap.
• Oven overlaps will conceal all raw edges.
• Width—25" min.
• Height—49-11/16" min. 50-1/8" max.
6
Loading...