GE JT930, ZET3038, JT980, ZET3058 User Manual

1

31-10663

1-07 JR

Installation

30” Built-In Trivection

™

Instructions

Wall Oven

JT930, JT980, ZET3038, ZET3058

BEFORE YOU BEGIN

Read these instructions completely and carefully.

•

IMPORTANT — Save these

instructions for local inspector’s use.

•

IMPORTANT — Observe all

governing codes and ordinances.

• Note to Installer – Be sure to leave these instructions with the Consumer.

• Note to Consumer – Keep these instructions for future reference.

• Skill level – Installation of this appliance requires basic mechanical and advanced electrical skills.

• Completion time – 1 to 3 hours

• Proper installation is the responsibility of

the installer.

• Product failure due to improper installation is not covered under the Warranty.

WARNING

— This appliance must

be properly grounded.

•

ATTENTION INSTALLER

All electric wall ovens must be hard wired (direct wired) into an approved junction box. A plug and receptacle is NOT permitted on these products.

FOR YOUR SAFETY:

• Be sure your oven is installed properly by a qualified installer or service technician.

• Be sure the oven is securely installed in a cabinet that is firmly attached to the house structure. Weight on the oven door could cause the oven to tip and result in injury. Never allow anyone to climb, sit, stand or hang on the oven door.

• Make sure the cabinets and wall coverings around the oven can withstand the temperatures (up to 200°F) generated by the oven.

WARNING: The electrical power to

the oven supply line must be shut off while line connections are being made. Failure to do so could result in serious injury or death.

• To prevent damage to the door and to prevent excessive microwave leakage, do NOT remove the door on the single wall oven or the upper oven door on the double wall oven.

Questions? Call 800.GE.CARES (800.432.2737) or Visit our Website at: ge.com

2

Installation Instructions

PREPARE TO INSTALL THE OVEN

TOOLS YOU WILL NEED

MATERIALS YOU MAY NEED

Wire NutsJunction Box

60” of String for Single Ovens 96” of String for Double Ovens

Adjustable Wrench

(for 1-7/16” Nut)

Level

Phillips Screwdriver

Drill with 1/8” Bit

(Extension may be

required)

Tape Measure

Hand or Sabre Saw

Pencil

Safety Glasses

Gloves

Straight Edge or

Square

PARTS INCLUDED

12 Screws

Strain Relief Clamp for 1/2” conduit

Metal Bottom Trim

Plastic Bottom Trim

Metal Bottom Trim Assembly

OR

3

Installation Instructions

PRE-INSTALLATION

All installation information on the following pages is to be used for SINGLE and DOUBLE oven installation!

Remove packaging materials. Check behind hinges. Remove plastic on trims and panel, all tape around the oven, and any shipping screws securing the oven to the base pad. Use caution when lifting the oven forward; the ovens are front heavy.

Open oven door and remove literature pack, broiler pan and grid, and oven racks.

Remove Installation Instructions from literature pack and read them carefully before you begin.

Be sure to place all literature, Owner’s Manual, Installation Instructions, etc. in a safe place for future reference.

D

C

B

A

1

PRE-INSTALLATION (

CONT.)

NOTE: To prevent damage to the door and

to prevent excessive microwave leakage, do NOT remove the door on single wall oven models or the upper oven door on double wall oven models.

The lower oven door on the double wall oven may be removed as an added convenience during installation. See Step 4.

DO NOT LIFT THE OVEN BY THE HANDLE!

Place the oven on a table or platform even with the cutout opening. (Platform must support 225 lbs. single, 375 lbs. double.)

Remove the bottom trim from the top of the oven. It will be installed at the end of the installation process.

G

F

E

1

Oven Racks

Literature Pack

Broiler Pan and Grid

E

A

S

Y

I

N

S

T

A

L

A

T

EASY INSTALLATION OF YOUR NEW

I O

B

3

e

N

f

f o

o

0

r

r e

e

"

O

y

o

o I

I

W

F

M

u

P

b

b O

O

e

A

Y

g

30" WALL OVEN

R

i

i n

n

T

O

L

-

A

R

R I

I

I M

M

N

L

U

e

T

T P

P

a

-

- d

d

O

R

O

S

S R

R

t

t a

a

h

T

v

e

V

A

e

N

e

s

s N

N

e

t

t o

o

E

h

T

E

i

i t

t

n

e

-

e

s

N

s

s O

O

t

W

e

t

o

r

r B

B

u

u i

i

I

n

S

S n

n

c

c O

O

s

s E

E

t

t s

s

i

t

t W

W

R

R t

t

o

o r

r

Before you begin-Read these instructions completely and carefully.

a

u

n

n V

V

N

l

c

c l

l

s

s E

E

e

e E

E

t

t i

i

i r

r

c

c R

R

o

A

-

- o

o

n

-

- L

L

B

m

m N

N

s

s K

K

L

L e

e

p

p o

o

e

f

f G

G

s

o

IMPORTANT- Save these instructions for local inspector’s use.

l

l t

t

e

u

r

O

O p

p

t

-

- r

r

e

l

l V

V

e

o

T

t

l

l h

h

E

y

y c

c

h

t

t e

e

o

a

R

R i

i

a

a s

s

l

l N

N

n

n l

l

e

i

i a

a

d

n

I

I a

a

N

IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES.

p

i

s

s n

n

v

c

c p

p

G

p

p s

s

e

a

a l

l

e

e t

t

i

r

r C

C

a

t

r

c

e

h

h u

u

n

O

t

f

f e

e

c

o

u

u c

c

D

D s

s

t

r

l

l e

e

i

l

’

’ e

e

E

E o

o

y

y s

s

m

Note to Installer- Be sure to leave these instructions with the consumer.

.

n

.

n

S

S i

i

u

u n

n

s

u

s

A

A s

s

f

e

e t

t

N

N o

o

t

r

.

. u

u

r

b

D

D c

c

e

f

f u

u

O

O t

t

t i

i

p

t

o

R

u

OWNER- Keep these instructions for future reference.

r

n

n o

o

D

D r

r

s

s e

e

p

I

A

A e

e

w

w r

r

r e

e

r

N

r

N

N i

i

F

l

f

t

y

C

e

h

O

r

E

E g

g

t

R

e

h

h r

r

S

r

S

Note- This appliance must be properly grounded (if applicable).

n

n o

o

e

e Y

Y

.

. c

c

u

u O

O

e

c

c n

n

.

o

o U

U

d

n

R

e

s

d

u

u S

S

(

m

A

i

i f

f

f B

B

F

e

e a

a

r

E

r

e

p

.

f

T

p

p o

o

Y

l

r

i

i e

e

c

a

y

b

b o

o

i

l

n

u

e

e s

s

)

b

.

t

t r

r

e

e u

u

g

g c

c

i

n

n t

t

i

-

- o

o

R

c

n

n a

a

e

e s

s

r

a

a e

e

c

d

f

o

o u

u

t

t m

m

h

l

FOR YOUR SAFETY

ELECTRICAL REQUIREMENTS

FOR YOUR SAFETY

l

l y

y

e

e p

p

.

s

s I

I

l

l M

M

e

e t

t

P

e

O

l

l y

y

y R

R

a

a T

T

n

E

E A

A

d

L

i

n

N

E

E s

s

T

C

C t

t

-

- r

r

T

T u

u

S

R

c

a

Before you begin-Read these

I

t

v

C

C i

i

o

e

I

A

A n

n

Before you begin-Read these

M

t

L

L s

s

h

h P

P

e

R

R f

f

O

o

s

E

E R

R

e

e r

r

B

Q

Q T

T

l

instructions completely and

o

e

U

U A

A

f

f c

c

G

o

I

I N

N

instructions completely and

a

R

O

r

r l

l

T

e

E

E V

V

i

-

- n

n

M

M y

y

E

O

s

o

E

E R

R

i

i p

p

B

n

u

N

N N

N

carefully.

e

e S

S

s

b

T

T c

c

N

I

t

t E

E

N

r

e

S

t

carefully.

o

u

o

R

g

g G

G

t

c

r

r V

V

i

i e

e

’

n

t

t s

s

C

E

i

-

- t

t

o

R

O

o

u

c

c A

A

n

n a

a

s

e

e D

D

I

s

IMPORTANT- Save these

L

L n

n

r

r e

e

a

t

E

e

L

L s

s

c

.

h

d

d f

f

S

IMPORTANT- Save these

t

o

o e

e

u

u a

a

t

t m

m

s

h

h l

l

A

A l

l

l l

l

e

y

e

e e

e

N

p

p .

.

s

s r

r

i

I

l

l D

D

n

M

-

e

e s

s

B

instructions for local inspector’s use.

O

O O

O

t

e

e r

r

R

R u

u

W

s

D

c

u

u N

N

t

I

I i

i

A

r

r E

E

o

e

N

N R

R

n

t

t s

s

-

- o

o

IMPORTANT- OBSERVE ALL

f

K

w

w o

o

l

l e

e

e e

e

r

i

a

a t

t

e

e f

f

h

v

v u

u

p

e

e t

t

t t

t

u

h

h h

h

r

e

e e

e

N

c

s

GOVERNING CODES AND ORDIANCES.

r

o

e

e o

o

e

n

n t

t

f

i

i e

e

n

s

-

r

s

u

u e

e

T

t

m

m n

n

r

r h

h

u

c

c i

i

c

c p

p

s

e

Note to Installer- Be sure to leave

t

t r

r

.

i

a

a o

o

o p

p

n

n p

p

e

s

l

l r

r

i

i l

l

a

a y

y

n

n g

g

c

these instructions with the consumer.

B

r

e

e o

o

e

m

m u

u

f

f o

o

n

u

u r

r

d

s

e

t

d

y

b

b o

o

e

i

(

OWNER- Keep these instructions

n

O

O f

f

f o

o

o N

N

N o

o

o p

p

p r

r

r o

o

I

I i

i

i n

n

n I

I

I M

M

M G

G

O

O N

N

o

o t

t

t t

t

t h

h

e

s

s O W

W

N

N f o r

r

r f

f

u

t

t t

t

t e

e

-

T

T p

p

p e

e

r

l

y

n

s

s t

t

r

r u

u

c

c t

t

t i

i

i c

c

c a

a

r

r e

e

f

f u

u

u l

l

y

.

. I M

M

M P

P

O

R

R T

T

A

A i n s

s

s t

t

r

r u

u

c

c t

t

t i

i

o

n

n P

P

P O

O

R

T

T A

A

N

N V

V

V E

E

R

N

N I

I

N

G

G e

e

e t

t

o

o I

I

n

n s

s

t

a

l

l e

e

e i

i

i n

n

s

t

t r

r

r u

u

c

t

t E

E

E R

R

-

K

e

p

p u

u

u r

r

r e

e

r

e

e f

f

f e

e

r

e

e h

h

h i

i

i s

s

a

p

p p

p

l

i

a

a g

g

r

r o

o

u

u n

n

d

e

u

i

i f

f

f b

b

a

a p

p

e

e g

g

i

i n

n

-

- o

o

R

R n

n

for future reference.

e

e s

s

a

a c

c

d

d o

o

t

t m

m

p

l

l e

e

Note- This appliance must be

t

t e

e

l

y

a

N

properly grounded (if applicable).

T

-

- S

S

a

a v

v

e

t

t s

s

h

Before you begin-Read these

e

e f

f

o

s

e

e r

r

l

l o

o

o c

c

a

l

T

instructions completely and

i

-

- n

n

O

s

p

B

e

e S

S

c

c E

E

R

V

carefully.

C

E

E O

O

A

A D

D

L

L E

E

L

L S

S

A

IMPORTANT- Save these

l

l e

e

N

N r

r

D

-

- B

B

O

O e

e

R

s

s u

u

instructions for local inspector’s use.

i

r

r o

o

e

e n

n

t

t s

s

o

w

l

l e

e

e i

i

i t

t

h

IMPORTANT- OBSERVE ALL

t

t t

t

h

h h

h

e

e e

e

c

s

o

e

n

n i

i

i n

n

GOVERNING CODES AND ORDIANCES.

s

t

t n

n

r

u

u c

c

c e

e

t

t .

.

i

i o

o

o n

n

Note to Installer- Be sure to leave

n

n c

c

e

m

m u

u

these instructions with the consumer.

s

s t

t

t d

d

b

e

e (

(

i

i f

f

a

a p

p

OWNER- Keep these instructions

p

l

l i

i

c

c a

a

b

l

e

e )

)

) .

.

for future reference.

for future reference. Note- This appliance must be

Note- This appliance must be

Note- This appliance must be properly grounded (if applicable).

properly grounded (if applicable).

p

p l

l

l i

i

i c

c

a

a b

b

l

l e

e

e )

)

) .

.

. h

h

h e

e

e s

s

e

e n

n

n d

d

t

t o

o

o r

r

’

s

u

s

s e

e

.

D

D I

I

I A

A

N

C

E

E S

S

S a

a

.

. v

v

v e

e

e s

s

s u

u

u m

m

e

e r

r

.

. s

s

p

C

E

E S

S

.

e

e r

r

r .

.

N

N p

p

p B

B

B i

i

i n

n

n s

s

s c

c

a

r

r I

I

I M

M

P

O

O i

i

i n

n

n s

s

t

r

u

I

M

M P

P

O

R

G

O

O V

V

E

R

N

N o

o

t

t e

e

t

o

t

t h

h

h e

e

s

s e

e

i

n

O

W

N

N E

E

R

-

- f

f

f o

o

r

r f

f

f u

u

t

t u

u

r

r e

e

e N

N

N o

o

t

t e

e

-

- T

T

T h

h

i

i s

s

s r

r

r o

o

p

p e

e

r

r l

l

l y

y

g

r

o

P

P O

O

O i

i

n

n s

s

t

r

u

c

c I

I

I M

M

P

O

R

R G

G

G O

O

V

E

R

N

o

t

t e

e

e t

t

o

I

t

t h

h

e

e s

s

e

e i

i

n

s

O

t

W

N

E

E R

R

-

- f

f

K

K o

o

o r

r

f

f u

u

t

t u

u

u r

r

e

r

r o

o

e

e t

t

e

-

- T

T

h

h i

i

s

s r

r

a

a o

o

o p

p

e

e r

r

r l

l

y

y g

g

r

r e

e

o

o f

f

u

u o

o

r

r e

e

y

y o

o

u

b

b t

t

t r

r

r u

u

c

c t

t

t i

i

o

o n

n

s

s e

e

c

c f

f

f u

u

l

l l

l

l y

y

y .

.

. R

R

R T

T

A

N

N T

T

-

- S

S

S c

c

c t

t

t i

i

o

o n

n

s

s f

f

o

r

r T

T

T A

A

N

T

-

- O

O

O B

B

N

N I

I

N

N G

G

C

O

O D

D

I

I n

n

n s

s

t

t a

a

l

l l

l

l e

e

e r

r

-

s

B

t

t r

r

r u

u

c

c t

t

i

i o

o

o n

n

s

K

w

e

e p

p

t

t h

h

e

e s

s

r

e

e f

f

e

e r

r

r e

e

n

n c

c

e

e .

.

a

a p

p

p p

p

l

l i

i

i a

a

n

n c

c

e

e m

m

u

u n

n

d

d e

e

d

d (

(

i

i f

f

f a

a

instructions for local inspector’s use.

R

R T

T

A

A N

N

T

-

- S

S

IMPORTANT- OBSERVE ALL

a

a t

t

v

v i

i

i o

o

n

s

s f

f

o

o r

r

GOVERNING CODES AND ORDIANCES.

T

l

o

o A

A

c

N

N T

T

-

- O

O

Note to Installer- Be sure to leave

B

N

S

S I

I

E

E N

N

G

C

O

these instructions with the consumer.

D

D n

n

E

E s

s

S

S t

t

a

a l

l

l e

e

e r

r

-

OWNER- Keep these instructions

B

e

e r

r

r u

u

s

c

c t

t

t i

i

o

o n

n

for future reference.

s

s w

w

w e

e

i

i t

t

t e

e

p

t

t h

h

Note- This appliance must be

e

e s

s

s e

e

e f

f

i

i e

e

n

r

r e

e

n

n c

c

properly grounded (if applicable).

e

e .

.

. p

p

p p

p

l

l i

i

i a

a

n

Before you begin-Read these

c

e

m

m n

n

u

u d

d

e

d

instructions completely and

(

i

i f

f

f a

a

a e

e

p

p g

g

p

i

i n

n

-

- R

R

carefully.

e

a

a d

d

d o

o

t

t m

m

h

p

p l

l

IMPORTANT- Save these

e

e t

t

e

e l

l

l y

y

a

n

instructions for local inspector’s use.

a

a v

v

v e

e

IMPORTANT- OBSERVE ALL

t

t h

h

e

s

s e

e

e l

l

l o

o

o c

c

a

GOVERNING CODES AND ORDIANCES.

l

i

i n

n

s

p

e

e S

S

c

c E

E

t

R

Note to Installer- Be sure to leave

V

E

A

A L

L

L E

E

L

L S

S

these instructions with the consumer.

A

N

D

D O

O

O e

e

R

R s

s

OWNER- Keep these instructions

u

u r

r

e

t

t o

o

o l

l

e

e i

i

a

a t

t

for future reference.

h

t

h

h e

e

c

c o

o

n

n i

i

Note- This appliance must be

n

s

s t

t

r

r u

u

c

c t

t

t i

i

i o

o

n

properly grounded (if applicable).

s

s u

u

s

s t

t

b

b e

e

e p

p

p p

p

l

l i

i

i c

c

a

b

l

l e

e

e )

)

.

t

t e

e

l

l y

y

y a

a

n

n d

d

d e

e

e t

t

h

h e

e

e s

s

e

e a

a

a l

l

i

i n

n

n s

s

p

e

c

t

t o

o

R

r

r V

V

’

’ s

s

s E

E

u

A

s

s L

L

e

e L

L

.

. A

A

N

N D

D

O

O R

R

D

D u

u

I

A

A r

r

r e

e

N

N t

t

C

o

E

E l

l

l e

e

S

a

.

. h

h

v

v e

e

e t

t

h

h e

e

c

c o

o

o n

n

s

s s

s

u

u t

t

m

r

r u

u

e

e c

c

r

t

.

. i

i

i o

o

o n

n

s

s t

t

b

b e

e

e l

l

l i

i

i c

c

a

b

l

l e

e

e )

)

) .

.

. e

e

e s

s

e

e d

d

o

o r

r

’

s

u

s

s e

e

e .

.

D

D I

I

I A

A

N

C

E

E S

S

.

. v

v

v e

e

e u

u

u m

m

e

e r

r

.

4

Installation Instructions

SINGLE BUILT-IN OVEN CUTOUT OPTIONS

WALL MOUNT—SINGLE BUILT-IN OVEN OPTION

Cabinet Width 30” Recommended

Cutout Location from Floor 32 1/2”

Cutout Depth 23 1/2” Min. Cutout Width 28 1/2” Min.

28 5/8” Max.

Cutout Height 27 1/4” Min.

27 5/16” Max.

A

WALL MOUNT—SINGLE BUILT-IN OVEN OPTION (CONT.)

NOTE: If the cabinet does not have a front

frame and the sides are less than 3/4” thick, shim both sides equally to establish the cutout width.

If the cabinet does not have a solid bottom, two braces or runners must be installed level with the bottom of the cutout to support the weight of the oven. For single ovens, the runners and braces must support 225 lbs.

The solid bottom or runners must be level with the bottom of the cutout or the bottom trim may not install correctly and then interfere with the door opening.

NOTE: This oven is not approved for stackable or side by side installation.

A

7”

21”

Cutout Width

28 1/2” Min

28 5/8” Max.

All corners must be cut square

Allow 11/16” for overlap of oven over side edges of cutout

Cutout Height 27 1/4” Min. 27 5/16” Max.

Opening between inside walls must be at Least 28 1/2” Wide

Required Junction Box Area

Recommended cutout location from floor 32 1/2”

Allow 1” minimum for overlap of oven

to and 1 1/4”

overlap of oven

bottom of cutout

Allow a minimum of 21” for clearance to adjacent corners, drawers, walls, etc. when door is open

Cabinet

Width 30”

2” x 4” or equivalent runners level with bottom of cutout

Suitable Bracing to Support Runners

21 5/8”

Over Centerline

of Cabinet

3 1/2”

6”

12”

CUTOUT OPTIONS FOR SINGLE BUILT-IN OVENS

Skip to Step 3 for Double Built-In Oven models.

There are 4 installation options for single built-in ovens. Choose the appropriate one for your application:

WALL MOUNT—SINGLE BUILT-IN OVEN OPTION

WALL MOUNT—SINGLE BUILT-IN OVEN BELOW AN ADVANTIUM

™

OVEN OPTION

WALL MOUNT—SINGLE BUILT-IN OVEN ABOVE A WARMING DRAWER OPTION

UNDER COUNTER—SINGLE BUILT-IN OVEN OPTION

D

C

B

A

2

C

L

Installation Instructions

WALL MOUNT—SINGLE BUILT-IN OVEN BELOW AN ADVANTIUM OVEN OPTION

• When installed over a single wall oven, allow at least 2” between the two openings. This separation will provide clearance for bottom overlap of the Advantium oven and top overlap of the single wall oven.

• If you are replacing a GE/Monogram electric double oven with the combined installation of an Advantium and single wall oven, the middle rail separating the two openings may need to be larger than the 2” min. shown.

• Always maintain 36 3/4” min. distance from the floor to the Advantium oven cutout in any installation combination.

• When installed in combination with a GE/Monogram single wall oven, use separate electrical junction boxes.

• Refer to Advantium oven installation instructions for electrical requirements and installation details of that product.

• Advantium ovens are approved for installation above only certain specified wall oven models. See the label attached to the top of the oven for approved Advantium oven models.

B

WALL MOUNT—SINGLE BUILT-IN OVEN ABOVE A WARMING DRAWER OPTION

• A 2” min. clearance between oven and warming drawer cutouts is required.

• Additional clearance may be required if 2 x 4 blocks are used to support the solid floor of the oven above. Check to be sure that oven supports above the Warming Drawer location do not obstruct the required interior depth and height.

• Refer to warming drawer installation instructions for electrical requirements and installation details of that product.

• Warming drawers are approved for installation below only certain specified wall oven models. See the label attached to the top of the oven for approved warming drawer models.

C

24”

Min.

Construct solid bottom min. 3/8” plywood supported by 2 x 4 or 1 x 2 runners, all four sides

30”

2” Min.

Advantium

cutout

Oven

cutout

23 1/2” Min.

inside

Bottom of warming drawer must be 1” above toekick

2” Min.

Warming

drawer cutout

Oven

cutout

A

Construct solid bottom min. 3/8” plywood

NOTE: A single wall oven can be installed in combination with the Advantium oven above and a warming drawer below as long as the dimensions and information on this page are applied to the combination installation.

5