Gasmate BBQ HOT OZI II User Manual

Portable Camping BBQ HOT 0ZI

SERIES II

Model No. BQ2007

FEATURES

• Versatile and portable

• Large 40.5cm (16”) cooking plate

• 6 unique stabilising legs

• High pressure - no regulator required

• Ideal for camping, picnics or a

quick BBQ at home

• Propane only

• Suits any camping cylinder
between 2Kg and 4.5Kg

• AGA certified

02855 01/12

Gasmate® is a registered trademark of: Sitro Group Australia Pty Ltd www.sitro.com.au

Aber, Hamilton, N.Z www.gasmate.co.nz

Important: Retain these instructions for future use.

Camping cylinder not included

GENERAL INFORMATION

Gas Installation Codes

• Appliance must be used in accordance with the
installation requirements of your gas supply

authority, or the appropriate installation code

issued by Standards Australia AS 5601.

• Appliances for use with bottled gas are labelled
‘propane gas’.

Clearances

Minimum Clearances from combustible materials

must be: Wall - 500mm. Above - 500mm.

Tube Assembly Safety

The tube assembly supplied with the appliance is

suitable for propane gas, and a 3/8” LH camping

cylinder only.

The tube assembly supplied with the appliance must
be used. Replacement tube assemblies must be

those specied by the appliance manufacturer.

Only use the tube assembly supplied with this

appliance for direct connection to the camping cylinder.

“DO NOT USE ADAPTORS”.

When connecting the tube assembly to the gas
camping cylinder, take care to avoid unnecessary
twisting of the tube assembly. Twist the hand wheel
only (thread is left hand).

After the assembly has been secured, turn on the
gas and check for leaks by brushing a soap and
water solution overall connections.

DO NOT USE this appliance if it is leaking, damaged

or does not operate properly.

If you are unable to correct the leak by tightening
the connections, turn off the gas and contact the

supplier immediately.

Always ensure the appliance is kept away from
ammable materials and the gas camping cylinder is
clear of any heat source. When changing over from
an empty gas cylinder to a full one make sure this
procedure is carried out in a well ventilated location,

preferably outside, away from people and away from

any sources of ignition; such as naked ames, pilot
ames, electric heaters/equipment.

Specifications

Appliance specifications can be found on the data
swing tag attached to the appliance body.

Gas Cylinder Use & Safety

This is a high pressure appliance and must only

be used with the tube assembly supplied. This
appliance shall only be used with propane
gas cylinders certified to AS 2469. It may

be hazardous to attempt to fit other types of gas

containers.

The gas cylinder should be lled by a reputable gas
supplier and visually inspected and re-qualied at
each lling.

Always keep cylinder in an upright position.
Always close the cylinder valve when the appliance

is not in use.

Do not subject gas cylinder to excessive heat.

IMPORTANT

Read these instructions for use carefully.
Familiarise yourself with the appliance
before connecting it to its gas container.
Keep these instructions for future
reference.

• Only use in well ventilated areas.

• Outdoor use only.

• Failure to comply with these instructions could
result in a re or explosion which could cause

serious bodily injury, death or property

damage.
CAUTION: Accessible parts may be very hot.

Keep young children away.

• DO NOT modify this appliance.

• DO NOT move this appliance during use.

• Turn off the gas supply at the gas cylinder

after use.

• Parts sealed by the manufacturer or their
agent must not be manipulated by the user.

• This appliance is only to be used outdoors.

• Do not test for gas leaks with an open ame.

• If this information is not followed exactly a re
causing death or serious injury may occur.

• Do not store a spare gas cylinder under or

near this appliance. Never ll the cylinder

beyond 80% full. This appliance is only to be
used and stored outdoors.

• If there is a leak on your appliance (smell
of gas), immediately attempt to turn off the
cylinder valve. Remove the appliance to a
well ventilated location away from any ignition
source. Only check for leaks outdoors using

soapy water.

• DO NOT try to detect leaks using a ame.

• Do not use a 1.25Kg camping cylinder.

• To check that the gas cylinder is lled, when

shaken a sloshing sound will be heard.

2

Never Store your Gas Cylinder Indoors.

If you store your appliance indoors, ALWAYS
disconnect the gas cylinder rst and store the

cylinder safely outside. Cylinders must be stored

outdoors in a well ventilated area out of reach of
children, and must not be stored in a building,
garage or any other enclosed area.

Gas connection is 3/8” LH

Location of your Appliance

Outdoor use only

DO NOT use your appliance in garages, porches,
sheds, breezeways, or other enclosed areas. Your
appliance is to be used OUTDOORS ONLY. The

appliance is not intended to be installed in or on

recreational vehicles and/or boats and should not

be placed on any surface that will burn. Do not

obstruct the ow of combustion and ventilation air

around the appliance.

Protect Children

Keep children away from appliance during use and
until appliance has cooled after you have nished.

Do not allow children to operate appliance.

Always ensure that no sporting or physical activities
are carried out in close proximity to the appliance
during use and while still hot.

Tools You Will Need

None required.

Check Appliance for any Damage

Inspect appliance parts as you proceed. Contact
your supplier for assistance regarding replacement
of any damaged or missing parts. Do not assemble
or operate a appliance that appears damaged.
Appliance for use with gas cylinders are labelled
‘propane gas’. Check labelling at the gas connection

on your appliance.

Product details:

BQ2007 Hot Ozi BBQ

Gas Type Propane

Injector Size Ø0.25mm

Gas Consumption 16MJ/H or 320g/H

Gas Pressure Cylinder pressure

Overall size (mm) 420 x 550

Weight 4.0kg

Acceptable gas
cylinder sizes

Min; 2Kg to Max; 4.5Kg

(not including cylinder)

FOR YOUR SAFETY

• Do not store or use petrol or other ammable
liquids in the vicinity of this or any other

appliance.

• Gas cylinders should be stored outdoors in a

well ventilated area out of the reach of
children. Any indoor storage shall comply with
AS/NZS 1596.

• Do not store empty or full spare gas cylinders

under or near this or any other appliance.

• Never test for gas leaks with a lit match or
open ame.

• Never lean over cooking surface when lighting.

• This appliance must not be used indoors.

Outdoor use only.

• Only use in well ventilated areas.

• Carbon monoxide hazard - This appliance can

produce carbon monoxide which has no odour.
Using it in an enclosed space (for example:
caravan, tent, car, mobile home)

may cause death.

• This appliance shall only be used in an
above ground open-air situation with natural
ventilation, without stagnant areas, where gas
leakage and products of combustion are rapidly
dispersed by wind and natural convection.

• The openings at the base of the burner provide
air for combustion, they should never be
obstructed. If the ame becomes signicantly
orange check these openings for blockage.

• Ensure the appliance is set up on a level and

stable surface.

• Do not move the appliance while in use or

when hot.

• Use all 6 feet provided, these are fitted to

the base of the camping cylinder, equally

spaced apart.

3