How it Works
Galaxy
Loading...
177P65SG
User Manual
10 pgs533.44 Kb0

Galaxy 177P60S, 177P65SG, 177P68 User Manual

Download
User Manual
Panini Grills
Models: 177P60S, 177P65SG, 177P68
Please read and keep these instructions. Indoor use only.
1
04/2017
User Manual
WARNING: Any modifications or incorrect installation, unauthorized adjustments or maintenance by unauthorized per-
sonnel may result in property loss or injury. Please contact the supplier for any necessary adjustment or repair, which should only be done by trained professionals.
CAUTION: For your safety, do not place or store any flammable liquid or gas items near the sandwich grill.
WARNING: This equipment must be connected to a grounded power outlet for your safety.
2
User Manual
Notes
1. This product is intended for commercial use only.
2. Do not disassemble or modify the machine.
3. Lift the upper grill assembly smoothly; jerking it up may cause damage or injury.
4. Before cleaning, disconnect power and allow machine to cool.
5. Do not immerse in water or spray water onto the grills. Water may cause short circuit and injury or damage.
6. To avoid damage, do not jam materials onto the grill or place heavy objects there.
7. When the machine is in use, the body and grill plates are hot, and will cause burns if touched.
8. Do not use an ungrounded power supply cord.
Cautions
1. It is recommended that the machine be unplugged during thunderstorms to avoid potential damage from nearby lightning strikes.
2. Avoid damaging the controls or grill surfaces with sharp or heavy objects.
3. Turn off power after daily use.
4. Do not use the machine with a damaged power cord.
5. Any internal repair or maintenance should be performed by a factory authorized repair technician.
Important Features
1. External shell and grease collector tray are stainless steel.
2. The grills are designed to be easy to use and maintain.
3
User Manual
Specifications
Single Panini Grill
Model Number P60S, P65SG, P68
Voltage 120V, 60 Hz
Power 1.75 Kw
Temp. Controls 1
Temp. Range 120 F - 570 F
Upper Grill (overall) 8 1/2"x 8 1/2"
Lower Grill 8 1/2"x 8 1/2"
Overall Size 17"x 12"x 10"
Notes
1. This machine is intended for use at 120V 60 Hz only.
2. A suitable circuit protector (fuse, circuit breaker, etc. ) should be located near the machine.
3. Be certain cable is properly connected to voltage source.
4. Do not place any hard objects on the grill. Do not slam the grill closed.
5. Recommended temperature range for normal use is 392°-482° F.
6. The machine is intended for use where room temperature is below 113°F and humidity below 85%.
7. Do not use caustic or abrasive products for cleaning.
Operating Instructions
1. Be sure power cord is properly connected to a proper source (120V, 60 Hz)
2. Power indicator should indicate power available (light on).
3. Set to desired temperature (heating indicator will come on). Warm-up time is approximately 20 minutes. Heating indicator will cycle at set temperature.
4. When set temperature is reached, lift top grill, using black handle, and lightly grease grill plates with vegetable oil. Place food on grill and lightly press handle down. Excess oil will collect in the grease collection tray. Remove food when cooked. The heating elements will automatically cycle as needed.
5. Turn machine off when no longer needed and unplug from power source.
Instructions for First Time Use
In order to protect the plates of your new grill during transportation, a layer of food-safe oil was coated on the surface prior to shipment. This oil is harmless, but must be removed before you begin to use. To remove, preheat the grill until the oil liquefies. Next, carefully wipe away the melted oil with a clean, soft cloth. Once all of the oil is removed you can begin to use your grill
4
User Manual
Cleaning and Maintenance
1. Disconnect machine before cleaning and allow to cool.
2. Use only a damp towel with non-corrosive cleaner. Do not immerse or flush with water.
3. Wipe down outside surface to remove any soil.
4. Store in a dry clean area when not in use.
Attack tough grease, oil, and carbon with this ready to use decarbonizer and degreaser. Its unique formula is designed to clean ovens, grills, hoods and a wide variety of other surfaces.
Troubleshooting
Problem Possible Cause Action
Grill plates do not heat even though power indicators are lit.
Temperature can not be controlled. Defective controller Replace controller
Heating appears normal but power indicators are not lit.
No action when power is turned on. Defective fuse or open circuit
Do not use the machine if any of the above occur.
Any troubleshooting corrections should be performed by a qualified technician.
Defective controller Replace controller
Defective heater(s) Replace heater(s)
Defective indicator(s) Replace
Replace fuse or reset circuit
breaker
breaker
Daily Check
Before using the machine, visually inspect for any signs of damage or frayed power cord.
Be certain machine is on a level countertop.
After turning it on, check for anything unusual before you use it.
Inspect the machine every day before using.
If there is any question about operation, do not use.
5
User Manual
Parts Key Single Grill
Diagram # and Part Name Replacement Part Item #
1. Green "Power" Light 177PLIGHTGRN
2. Temperature Control Knob 177PKNOB (P60S, P65SG, P68, P78, P75SG, P70S)
3. Screw M4x6
4. Orange "Hot" Light 177PLIGHTORG
5. Lower Case
6. Internal Wrenching Screw M6x10
7. Flat Washer
8. Internal Wrenching Screw M5x25
9. Flat Spacer
10. Spring 177PSPRING
11. Rear Shaft
12. Shaft Retainer
13. Internal Wrenching Screw M6x40
14. Rear Upper Cover
6
(P60S, P65SG, P68, P78, P75SG, P70S)
(P60S, P65SG, P68, P78, P75SG, P70S)
(P60S, P65SG, P68, P78, P75SG, P70S)
User Manual
Diagram # and Part Name Replacement Part Item #
15. Slotted Screw M4x8
16. Spring Pin
17. Ground Screw M6x15
18. Power Cord 177FCORD
19. Bottom Plate 177P7BTMFLT (flat), 177P7BTMGRV (grooved), (P78, P75SG, P70S)
20. Upper Grill Cover
21. Slotted Screw M4x8
22. Top Cover
23. Slotted Screw M4x8
24. Upper Insulator
26. Top Grill Plate 177P7UPRFLT (flat), 177P7UPRGRV (grooved), (P78, P75SG, P70S)
27. Top Heating Element 177P7TOPELM
28. Wiring Guide Tube
29. Wiring Guide Tube Stop
30. Guide Tube Retainer
31. Retaining Ring
32. Upper Plate Shaft
33. Internal Wrenching Screw m6x8
34. Internal Wrenching Screw m6x8
35. Handle 177P7HANDLE
36. Grease Collector
37. Drip Tray 177P6RAY (P60S, P65SG, P68) 177PTRAY (P78, P75SG, P70S)
38. Thermostat 177PTHERM
40. Bottom Insulator
41. Bottom Pan
42. Slotted Screw M4x8
43. Barrier Strip Mounting Plate
44. Slotted Screw M4x8
45. Ceramic Termical Board
46. Hex Head Screw M6x20
47. Hex Nut M4
48. Rubber Foot
49. Rubber Heater Pressure Plate
50. Bottom Heating Element 177P7BTMELM (P78, P75SG, P70S)
51. Internal Wrenching Screw M6x8
52. Bottom Cover
53. Philips Head Screw M4x8
54. Hex Nut
(P60S, P65SG, P68, P78, P75SG, P70S)
(P60S, P65SG, P68, P78, P75SG, P70S)
(P60S, P65SG, P68, P78, P75SG, P70S)
(P60S, P65SG, P68, P78, P75SG, P70S)
7
User Manual
User Manual
8
User Manual
User Manual
9
User Manual
Limited Warranty
All equipment sold under the Galaxy trademark and used for commercial purpose is warranted against defects in materials and workmanship. The warranty runs for six months from the date of purchase and is for the benefit of the original purchaser only. All other warranties, Expressed or Implied, Statutory or otherwise, including Without Limitation and any implied warranty of Merchantability or Fitness for Purposes are excluded. The seller shall in no event be liable for direct, indirect, or consequential damages in connection with Galaxy commercial products.
This warranty is not effective if damage occurs due to accident, carelessness, improper installation, lack of proper set-up, supervision when required, or if the equipment is installed or operated in any manner contrary to the installation and operating instructions. Work performed by unauthorized personnel or unauthorized service agencies voids this warranty. This warranty does not apply to, and Galaxy is not responsible for, any warranty claims made on products sold or used outside of the United States. Residential use voids the warranty.
10
Loading...
Buy Points How it Works FAQ Contact Us Questions and Suggestions Privacy Policy Cookie Policy Terms of Use