DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.1 Decathlon Primary Components
22
24
31
15
21
32
30
16
10
5
26
1
9
8
20
17
7
2
3
12
36
6
25
11
4
35
Controllers, probes, and
related components are listed
in Optional Components and
Controllers, Section 2.3.
18
13
19
23
34
27
14
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
33
28
2-1
29
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
All items used only for either “D”, “SCFD”, “CFD”, or “FPD65” fryer models have been marked for clarity.
Unmarked items may be used on either model. If you have any questions, call the Frymaster and Dean 24-Hour Service
Hotline, 1-800-551-8633.
2.1.1 Decathlon D20 Primary Components
ITEM PART # COMPONENT
1 826-1875 Frypot - S/S
2 810-2167 Manifold, Gas
3 810-2050 Orifice, Natural Gas #44, 2.18 mm
* 810-2062 Orifice, Natural Gas #38, 2.58 mm
* 810-0710 Orifice, LP Gas #54, 1.40 mm
* 810-2060 Orifice, G20/G25 Gas #42, 2.40 mm (CE only)
* 810-2059 Orifice, G31 Gas #53, 1.51 mm (CE only)
4 810-2158 Pilot Burner, Natural/G20/25 Gas
* 810-2526 Pilot Burner, LP/G31 Gas
* 809-0766 Nut, Keps 10-32 SS Hex
* 809-0845 Screw, 10-32 x 3⁄8" Hex Slotted Head
* 810-0705 Tube, Pilot Gas Supply
* 810-0703 Tube,
5 200-1615 Manifold Support Bracket
6 210-5216 Diffuser Assembly
7
8 810-2151 Burner, Left Side
9 N/A Burner, Center
10 810-2150 Burner, Right Side
11 200-1331 Heat Shield
12 807-3552 Gas Valve, Natural Gas Electronic Ignition, 24 VAC
* 807-3628 Gas Valve, LP Gas Electronic Ignition, 24 VAC
* 810-2156 Gas Valve, Natural Gas, 120 VAC
* 810-2323 Gas Valve, LP Gas, 120 VAC
* 807-2091 Gas Valve, G20/G25 Gas, 24 VAC (CE only)
* 807-2127 Gas Valve, G31 Gas, 24 VAC (CE only)
* 807-3294 Gas Valve, Natural Gas Constant Pilot, 24 VAC
* 807-3295 Gas Valve, LP Gas Constant Pilot, 24 VAC
* 810-0691 Vent Tube
13 200-1148 Channel, Front and Rear
14 200-1675 Bracket, Lower Hinge
15 211-3261 Side Panel, Left
* 201-3268 Panel, Inner Left (multi-batteried units)
16 212-3261 Side Panel, Right
* 202-3268 Panel, Inner Right Side (multi-batteried units)
17 824-1025 Wireway, Control Panel
18 07-0132 Control Panel, Blank
* 07-0132-1 Control Panel, One Hole
* 07-0132-2 Control Panel, Two Holes
19
20 824-1125 Topcap (D50/D20)
* 210-3323 Topcap (D220)
21 106-1583SP Flue Assembly
* 200-1342 Shield, Flue Heat
* 200-1344 Front, Flue Box
* Not illustrated.
►►► See Drain Manifold Components, Section 2.5
►►► See Optional Components, Section 2.3
1
⁄4" x 20" Pilot Gas Supply
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-2
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.1.1 Decathlon 20 Primary Components (cont.)
ITEM PART # COMPONENT
* 200-1351 Rear, Flue Box
* 200-3647 Deflector, Flue
22 823-3368 Flue Cap
23 106-2121SP Door Assembly (D20)
* 210-3266 Panel, Door Outer
* 200-3267 Panel, Door Inner
* 810-0180 Handle, Door, Chrome
* 809-0918
Screw, 10-24 x
* 809-0191 Washer,
* 200-1301 Pin, Door, 20 ¼”
* 810-0066 Magnetic Catch, Door
24 823-0271 Basket, Twin
25 803-0327 Grid, Frypot, Screen-type
26 210-3368 Hanger, Basket, D20 Single System
* 210-3911 Hanger, Basket, D250/20 System
27 810-0356 Caster, Plate-mount 5-inch without Brake
* 810-2406 Caster, Single Stud-mount 5-inch without Brake
28 810-0357 Caster, Plate-mount 5-inch with Brake
* 810-2405 Caster, Single Stud-mount 5-inch with Brake
* 826-1389
Screw,
1
⁄
4
29 813-0669 Drain Nipple, Extended 1" Drain
30 106-0913SP Cordset, 10' Power
31 210-2804 Cover, Outlet Duct
32 200-3285 Panel, Structural Back (D20, in multi-batteried systems)
* 200-1674 Panel, Structural Back (D220)
33 810-2411 Leg, Single Bolt Mount (black)
* 806-3811 Leg Package, 4-bolt Mount (4 per set)
* 806-5043 Leg, Single
34 823-3636 Leg Support Assembly
35 823-3346 Bracket, Burner Mounting
36 823-3715 Hanger, Basket D20 Single (Chili’s units only)
* Not illustrated.
1
⁄
" Slotted Head (use with 810-2105)
1
⁄4" Spring-lock (use with 810-2105)
-20 x
2
3
⁄
" Hex Head (for plate-mount casters, qty: 10)
4
2.1.2 Decathlon D50 Primary Components
ITEM PART # COMPONENT
1 826-1871 Frypot - S/S (SCFD50, CFD50)
* 826-1873 Frypot - S/S (D50)
* 826-1869 Frypot - S/S, (DD50 Deep Depth, used in fryer batteries with D60)
* 826-2037 Frypot, Cracker Barrel (1.5” Drain)
2 810-2169 Manifold, Gas (D50)
* 810-2130 Manifold, Gas (SCFD50)
3 810-2048 Orifice, Natural Gas #39 2.53 mm (non-CE D50GHP, SCFD50G)
* 810-2062 Orifice, Natural Gas #38, 2.58 mm
* 810-2059 Orifice, LP/G31 Gas #53, 1.51 mm (CE, D50; non-CE, D50G(DD)HP & SCFD50G)
4 810-2032 Pilot Burner, Natural/G20/25 Gas
* 810-2155 Pilot Burner, LP/G31 Gas
* 106-1439 Pilot Burner, Natural Gas, with Thermocouple
* Not illustrated.
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-3
y
)
y
)
)
)
p
)
)
)
)
)
y
y
(
y)
)
y
(
)
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.1.2 Decathlon D50 Primary Components (cont.)
ITEM PART # COMPONENT
* 106-0692 Pilot Burner, Natural Gas, with Thermopile
* 809-0766 Nut, Keps 10-32 SS Hex
* 809-0845
* 810-0705
* 810-0703
Screw, 10-32 x
1
Tube,
Tube,
⁄
" x 20" Pilot Gas Supply (one-piece gasline)
4
1
⁄
" x 17
4
5 200-1314 Bracket, Manifold Support
* 200-1615 Bracket, Manifold Support (right or left)
6 210-5175 Diffuser Assembly
7
►►► See Drain Manifold Components, Section 2.5
8 810-2151 Burner, Left Side
9 810-2149 Burner, Center
10 810-2150 Burner, Right Side
11 200-1330 Heat Shield
* 200-1363 Lower Heat Shield
12 807-3552 Gas Valve, Natural Gas Electronic Ignition, 24 VAC
* 807-3628 Gas Valve, LP Gas Electronic Ignition, 24 VAC
* 810-2156 Gas Valve, Natural Gas, 120 VAC
* 810-2323 Gas Valve, LP Gas, 120 VAC
* 807-3294 Gas Valve, Natural Gas, Constant Pilot, 24 VAC
* 807-3295 Gas Valve, LP Gas, Constant Pilot, 24 VAC
* 807-2091 Gas Valve, G20/G25 Gas, 24 VAC (CE onl
* 807-2127 Gas Valve, G31 Gas, 24 VAC (CE onl
* 810-0691 Vent Tube
13 200-1148 Channel, Front and Rear
* 200-2783 Channel, Base
14 200-1675 Lower Hinge Bracket (previous production D50
* 823-5346 Hinge, Lower Left (current production D50, SCFD50)
* 823-5347 Hinge, Lower Right (current production D50, SCFD50)
* 823-5348 Hinge, Upper Left (current production D50, SCFD50)
* 823-5349 Hinge, Upper Right (current production D50, SCFD50)
15 211-2787 Side Panel, Left Side
16 212-2787SP Side Panel, Right Side
17 824-0961 Wireway, Control Panel
18 210-3716 Control Panel, Blank
* 210-2908 Control Panel, One Hole
* 210-2051 Control Panel, Two Holes
* 210-3747 Control Panel, Three Holes
* 210-3715 Control Panel, Three Holes (basket lift option
19
►►► See O
tional Components, Section 2.3
20 824-1103 Top Cap, Single System(D50, CFD50
* 824-0982 Top Cap, Double System(D50, SCFD50
* 824-0983 Top Cap, Triple System(D50, SCFD50
* 824-0984 Top Cap, Quad System(D50, SCFD50
* 824-1125 Top Cap (D50/D20
21 106-1742SP Flue Box Assembl
* 823-3634 Flue Cap Assembl
* 200-2872 Shield, Flue Heat
* 200-1343 Front, Flue Box
* 200-1350 Rear, Flue Box
* 200-3651 Deflector, Flue
22 823-3521 Flue Cap, D50/CFD & 15MC (Single
23 106-1754SP Door Assembl
* 210-2869 Panel, Outer Door
* Not illustrated.
3
⁄
" Hex Slotted Head
8
1
⁄
" Pilot Gas Supply (one-piece gasline)
2
2-batter
D50
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-4
)
)
,
⁄
,
⁄
)
g
(
)
(
)
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.1.2 Decathlon D50 Primary Components (cont.)
ITEM PART # COMPONENT
* 200-1379 Panel, Inner Door
* 106-4727 Door Assembly, Left(SCFD50
* 106-4728 Door Assembly, Right(SCFD50
* 210-8946 Panel, Outer Door
* 201-8945 Panel, Inner Door, Left
* 202-8945 Panel, Inner Door, Right
* 810-0180 Handle, Chrome, Door
* 809-0918
* 809-0191
Screw
Washer
10-24 x
* 200-1301 Pin, Door, Lon
* 210-9889 Pin, Door
* 810-0066 Magnetic Catch, Door (D50)
* 810-1105 Magnetic Catch, Door (SCFD50)
24 803-0271 Basket, Twin
* 803-0099 Basket, Full
25 803-0277 Grid Assembly, Fine Mesh
26 210-1595 Hanger, Basket, Single System, (attaches to flue)
* 210-3131 Hanger, Basket, Double System (attaches to flue)
27 810-0356 Caster, Plate-mount, 5-inch without Brake
* 810-2281 Caster, Plate-mount, 5-inch with Brake (“Tile Safe” Cracker Barrel)
* 810-2406 Caster, Single Stud-mount, 5-inch without Brake
28 810-0357 Caster, Plate-mount, 5-inch with Brake
* 810-2280 Caster, Adj. Swivel, 3-inch with Brake (“Tile Safe” Cracker Barrel)
* 810-2405 Caster, Single Stud-mount, 5-inch with Brake
* 826-1389
Screw,
1
⁄
4
29 812-1226SP Drain Nipple, Extended 1¼” " Drain
* 812-1717 Drain Nipple, Extended 1½” Drain
30 106-0913SP Cordset, 10' Power
31 210-2804 Cover, Outlet Duct
32 200-1674 Back Panel, Lower (D50/CFD50)
33 810-2411 Leg, Single Bolt Mount (black)
* 806-3811 Leg Package, 4 Bolt Mount (4 per set)
34 823-3248 Leg Support Assembly
35 200-1329 Burner Mounting Bracket
36 823-4075 Hanger, Basket, Single with 6” Splash Guard
* 823-3710 Hanger, Basket, Double System (UFF) With 6” Splash Guard
* Not illustrated.
1
1
" Slotted Head (use with 810-2105)
" Spring-lock (use with 810-2105
D50
SCFD50
3
-20 x
⁄
" Hex Head (for plate-mount casters, qty: 10)
4
2.1.3 Decathlon D60 Primary Components
ITEM PART # COMPONENT
1 826-2229 Frypot - S/S, ½” Drain (D60, CFD60, SCFD60)
* 826-1802
Frypot - S/S, 1
* 826-1826 Frypot - S/S, Cascade Filter
* 812-1666 Coupling, Thermostat Entry
* 813-0036 Collar, Thermostat
* 210-1650 Deflector, Oil Return
* 812-1501
Nipple, 1
2 810-2072 Gas Manifold (weld assembly)
3 810-2048 Orifice, Natural Gas #39 2.53 mm (non-CE)
* Not illustrated.
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
1
⁄
" Drain Non-Filtration
4
1
⁄
" NPT x 1 NPT
2
2-5
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.1.3 Decathlon D60 Primary Components (cont.)
ITEM PART # COMPONENT
* 810-2059 Orifice, LP Gas #53 1.51 mm (CE and non-CE)
* 810-2060 Orifice, Nat. Gas/G20/G25 (CE only)
4 810-2032 Pilot Burner, Natural/G20/25 Gas (primary and trailing, 120V)
* 810-2155 Pilot Burner, LP/G31 Gas (primary and trailing)
* 812-1674 Pilot Burner, Mod. Natural Gas (electronic ignition)
* 809-0766 Nut, Keps 10-32 SS Hex (primary and trailing)
* 809-0845
* 810-0705
* 810-0703
Screw, 10-32 x
Tube, Pilot Gas Supply,
Tube, Pilot Gas Supply,
* 810-2138 Valve, Trailing Pilot, Adjustable (trailing pilot only)
5 200-1314 Bracket, Manifold Support
* 200-1615 Bracket, Manifold Support (right or left)
6 210-8387 Diffuser Assembly
7
►►►
See Drain Manifold Components, Section 2.5
8 810-2151 Burner, Left Side
9 810-2149 Burner, Center
10 810-2150 Burner, Right Side
11 200-1324 Heat Shield, Lower (D60)
* 200-1363 Heat Shield, Lower (SCFD60)
* 824-0970 Heat Shield, Vessel (SCFD60)
* 812-0211 Insulation, Kaowool Blanket, .5” x 7.5” x 17.5”
* 824-0969 Support, Burner
12 807-3552 Gas Valve, Natural Gas, Electronic Ignition, 24 VAC (¾” in, ½” out)
* 807-3628 Gas Valve, LP Gas, Electronic Ignition, 24 VAC
* 807-3294 Gas Valve, Natural Gas, Constant Pilot, 24 VAC
* 807-3295 Gas Valve, LP Gas, Constant Pilot, 24 VAC
* 810-2156 Gas Valve, Natural Gas, 120 VAC
* 810-2323 Gas Valve, LP Gas, 120 VAC
* 807-2091 Gas Valve, G20/G25 Gas, 24 VAC (CE only)
* 807-2127 Gas Valve, G31 Gas, 24 VAC (CE only)
* 810-0691 Vent Tube
* 823-3347 Frame, Slide Base (SCFD60)
13 200-2493 Channel, Rear and Front (D60)
* 200-3219 Channel, Rear and Front (SCFD60)
* 200-1198 Channel, Base (Single)
* 200-1463 Channel, Base (Double)
* 200-1393 Channel, Lower Joiner (SCFD60)
14 200-1675 Lower Hinge Bracket (previous production D60)
* 823-5346 Hinge, Lower Left (current production D60, SCFD60)
* 823-5347 Hinge, Lower Right (current production D60, SCFD60)
* 823-5348 Hinge, Upper Left (current production D60, SCFD60)
* 823-5349 Hinge, Upper Right (current production D60, SCFD60)
15 211-2532 Side Panel, Left Side (unit exterior; D60)
16 212-2532 Side Panel, Right Side (unit exterior; D60)
* 211-4570 Side Panel, Left Side (unit exterior; SCFD60)
* 212-4570 Side Panel, Right Side (unit exterior; SCFD60)
* 201-4775 Side Panel, Left Side with Hole (unit interior)
* 202-4775 Side Panel, Right Side with Hole (unit interior)
* Not illustrated.
3
⁄
" Hex Slotted Head (primary and trailing)
8
1
⁄
" x 23" (one-piece gasline)
4
1
⁄
" x 17
4
1
⁄
" (one-piece gasline)
2
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-6
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.1.3 Decathlon D60 Primary Components (cont.)
ITEM PART # COMPONENT
* 201-1245 Panel, Inner Left (divider located over filter unit)
* 202-1245 Panel, Inner Right (divider located over filter unit)
17 824-0951 Wireway, Control Panel (D60)
* 824-1195 Wireway, Control Panel (SCFD60)
18
19
20 824-0987 Top Cap (Single)
* 824-0937 Top Cap (2-battery)
* 106-1258 Flue Assembly
* 809-0997
* 809-0169
* 809-0428
* 809-0417
21 106-0997 Flue Box Assembly
* 200-1339 Front, Flue Box
* 200-1773 Back, Flue Box
* 200-1325 Shield, Flue Box
* 809-0167
* 200-3649 Deflector, Flue
22 106-1703SP Flue Cap (Single)
* 823-3516 Flue Cap (2-battery)
23 106-2898SP Door Assembly, with Liner (D60)
* 200-1185 Panel, Door, Inner
* 210-1424 Panel, Door, Outer
* 106-4721 Door Assembly, Left (SCFD60)
* 200-4794 Panel, Door, Inner
* 211-8935 Panel, Door, Outer
* 106-4722 Door Assembly, Right (SCFD60)
* 200-4794 Panel, Door, Inner
* 212-8935 Panel, Door, Outer
* 810-0180 Handle, Door, Chrome
* 809-0918
* 809-0191
* 200-1301 Pin, Door (D60)
* 210-9889 Pin, Door (SCFD60)
* 810-0066 Magnetic Catch/Plate, Door (D60)
* 810-1105 Magnetic Catch/Plate, Door (SCFD60)
24 803-0304
25 803-0149 Grid Assembly, Mesh
* 810-2235 Grid Assembly, Rack
26 210-2737SP Basket Hanger, Single, no Splash Guard
* 823-3349 Basket Hanger, Double, Tall
* 823-4780 Basket Hanger, Chili’s Single System, 6” Splash Guard
* 823-4999 Basket Hanger, Chili’s Double System, 6” Splash Guard
27 810-0356 Caster, Plate-mount 5" without Brake
* 810-2406 Caster, Single Stud-mount 5" without Brake
28 810-0357 Caster, Plate-mount 5" with Brake
* 810-2405 Caster, Single Stud Mount 5" with Brake
* 826-1389
* Not illustrated.
►►► See Control Panel Options, Joiner Strips, and Accessories, Section 2.2
►►► See Optional Components, Section 2.3
1
⁄
Washer,
Screw, #12 x
Screw,
Nut, Flange
Screw, Sheet Metal 10 A x
Screw, 10-24 x
Washer,
Fry Basket, 6 x 8
Screw,
SAE “N” S/S
2
3
⁄
" Hex Washer Slotted Head
4
1
-20 x
⁄
” Hex Head
2
1
⁄
-20 Serrated
4
5
⁄
B
8
1
⁄
" Slotted Head (use with 810-2105)
2
" Spring-lock (use with 810-2105)
3
⁄
3
⁄
" Hex Head (for plate-mount casters, qty: 10)
4
" x 16
4
3
⁄
"
4
1
⁄
4
1
⁄
4
1
⁄
4
-20 x
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-7
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.1.3 Decathlon D60 Primary Components (cont.)
ITEM PART # COMPONENT
29 812-1226SP Drain Nipple, Extended, 1 ¼”
*
812-1717SP Drain Nipple, Extended, 1 ½”
30 106-0913SP Cordset, 10’ Power
31 210-2804 Cover, Outlet Duct
32 200-1327 Back Panel, Lower
* 200-1213 Back Panel, Upper
33 810-2411 Leg, Single Bolt Mount (black)
* 806-3811 Leg Package, 4 Bolt Mount (4 per set)
34 823-3248 Leg Support Assembly
35 200-2065 Bracket, Burner Mounting
* Not illustrated.
2.1.4 Decathlon FPD65 Primary Components
ITEM PART # COMPONENT
* 200-2308 Post, Door (SCFD60)
* 201-1182 Gusset, Side Panel Left (SCFD60)
* 202-1182 Gusset, Side Panel Right (SCFD60)
* 200-1611 Base (SCFD60)
* 210-2804 Duct, Door Access (SCFD60)
* 200-2713 Plate, Suction Manifold (SCFD60)
* 210-1180 Insert, Suction Manifold (SCFD60)
* 823-3948SP Frypot - S/S
* 812-1666 Coupling, Thermostat Entry
* 813-0036 Collar, Thermostat
* 210-1650 Deflector, Oil Return
* 812-1501
Nipple, 1
2 810-2072 Gas Manifold (weld assembly)
3 810-2048 Orifice, Natural Gas #39 2.53 mm (non-CE)
* 810-2059 Orifice, LP Gas #53 1.51 mm (CE and non-CE)
* 810-2497 Orifice, Butane Gas #55 1.32mm
* 810-0710 Orifice, LP Gas #54 1.4mm
* 810-2050 Orifice, Natural Gas #44 2.18mm
* 810-2060 Orifice, Natural/G20/G25 Gas #42 (CE only)
4 810-2032 Pilot Burner, Natural/G20/25 Gas (primary and trailing, 120V)
* 810-2155 Pilot Burner, LP/G31 Gas (primary and trailing)
* 812-1674 Pilot Burner, Mod. Natural Gas (electronic ignition)
* 809-0766 Nut, Keps 10-32 SS Hex (primary and trailing)
* 809-0845
* 810-0705
* 810-0703
Screw, 10-32 x
Tube, Pilot Gas Supply,
Tube, Pilot Gas Supply,
* 810-2138 Valve, Trailing Pilot, Adjustable (trailing pilot only)
5 200-1314 Bracket, Manifold Support
* 200-1615 Bracket, Manifold Support (right or left)
6 210-5177 Diffuser Assembly
7
►►►
See Drain Manifold Components, Section 2.5
8 810-2151 Burner, Left Side
* Not illustrated.
1
⁄
" NPT x 1 NPT
2
3
⁄
" Hex Slotted Head (primary and trailing)
8
1
⁄
" x 23" (one-piece gasline)
4
1
⁄
" x 17
4
1
⁄
" (one-piece gasline)
2
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-8
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.1.4 Decathlon FPD65 Primary Components (cont.)
ITEM PART # COMPONENT
9 810-2149 Burner, Center
10 810-2150 Burner, Right Side
11 200-1363 Heat Shield, Lower
* 824-0970 Heat Shield, Vessel
* 824-0969 Support, Burner
12 807-3552 Gas Valve, Natural Gas, Electronic Ignition, 24 VAC
* 807-3628 Gas Valve, LP Gas, Electronic Ignition, 24 VAC
* 807-3294 Gas Valve, Natural Gas, Constant Pilot, 24 VAC
* 807-3295 Gas Valve, LP Gas, Constant Pilot, 24 VAC
* 810-2156 Gas Valve, Natural Gas, 120 VAC
* 810-2323 Gas Valve, LP Gas, 120 VAC
* 807-2091 Gas Valve, G20/G25 Gas, 24 VAC (CE only)
* 807-2127 Gas Valve, G31 Gas, 24 VAC (CE only)
* 810-0691 Vent Tube
* 823-3347 Frame, Slide Base
13 200-3219 Channel, Rear and Front
* 200-1198 Channel, Base
* 200-1393 Channel, Lower Joiner
14 200-9886 Lower Hinge Bracket
* 823-5346 Hinge, Lower Left
* 823-5347 Hinge, Lower Right
* 823-5348 Hinge, Upper Left
* 823-5349 Hinge, Upper Right
15 211-4570 Side Panel, Left Side (unit exterior)
16 212-4570 Side Panel, Right Side (unit exterior)
* 201-4775 Side Panel, Left Side with Hole (unit interior)
* 202-4775 Side Panel, Right Side with Hole (unit interior)
* 201-4237 Panel, Inner Left (divider located over filter unit)
* 202-4237 Panel, Inner Right (divider located over filter unit)
17 824-1195 Wireway, Control Panel
18
19
20 824-0987 Top Cap
* 824-0937 Top Cap, Two-vat
* 106-2634SP Flue Assembly
* 809-0997
* 809-0169
* 809-0417
* 809-0428
21 Flue Box Assembly
* 200-1339 Front, Flue Box
* 200-1773 Back, Flue Box
* 200-1325 Shield, Flue Box
* 809-0167
* 200-3649 Deflector, Flue (use screws 809-0437)
* 210-6525 Deflector, Flue, Chili’s (use screws 809-0437)
22 106-1703SP Flue Cap, Single System
* 823-3516 Flue Cap, Double System
23 106-2898SP Door Assembly, with Liner
* Not illustrated.
►►► See Control Panel Options, Joiner Strips, and Accessories, Section 2.2
►►► See Optional Components, Section 2.3
1
⁄
Washer,
Screw, #12 x
Nut, Flange
Screw,
Screw, Sheet Metal 10 A x
SAE “N” S/S
2
3
⁄
4
1
⁄
-20 Serrated
4
1
⁄
-20 x
4
1
" Hex Washer Slotted Head
⁄
” Hex Head
2
5
⁄
B
8
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-9
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.1.4 Decathlon FPD65 Primary Components (cont.)
ITEM PART # COMPONENT
* 200-4794 Panel, Door, Inner
* 210-4792 Panel, Door, Outer
* 106-4721 Door Assembly, Left
* 200-4794 Panel, Door, Inner
* 211-8935 Panel, Door, Outer
* 106-4722 Door Assembly, Right
* 200-4794 Panel, Door, Inner
* 212-8935 Panel, Door, Outer
* 810-0180 Handle, Door, Chrome
* 809-0918
* 809-0191
Screw, 10-24 x
Washer,
* 200-1301 Pin, Door, 20” long
* 810-1105 Magnetic Catch/Plate, Door (offset)
24 803-0304
Fry Basket, 6 x 8
25 803-0149 Grid Assembly, Mesh
* 810-2235 Grid Assembly, Rack
26 210-2737SP Basket Hanger, Single System, no Splash Guard
* 823-4780 Basket Hanger, Chili’s Single System, 6” Splash Guard
* 823-4999 Basket Hanger, Chili’s Double System, 6” Splash Guard
* 823-4767 Splash Guard
27 810-0356 Caster, Plate-mount 5" without Brake
* 810-2406 Caster, Single Stud-mount 5" without Brake
28 810-0357 Caster, Plate-mount 5" with Brake
* 810-2405 Caster, Single Stud Mount 5" with Brake
* 826-1389
Screw,
1
⁄
4
29 812-1226SP Drain Nipple, Extended
30 106-0913SP Cordset, 10’ Power
31 210-2804 Cover, Outlet Duct
32 200-1213 Upper Structural Back
* 200-1327 Lower Structural Back
33 810-2411 Leg, Single Bolt Mount (black)
* 806-3811 Leg Package, 4 Bolt Mount (4 per set)
34 823-3248 Leg Support Assembly
35 200-2065 Bracket, Burner Mounting
* 200-2308 Post, Door
* 201-1182 Gusset, Side Panel Left
* 202-1182 Gusset, Side Panel Right
* 200-1611 Base
* 210-2804 Duct, Door Access
* 200-2713 Plate, Suction Manifold
* 210-1180 Insert, Suction Manifold
* Not illustrated.
1
⁄
" Slotted Head (use with 810-2105)
1
⁄
-20 x
2
" Spring-lock (use with 810-2105)
4
3
⁄
3
⁄
" Hex Head (for plate-mount casters, qty: 10)
4
" x 16
4
3
⁄
"
4
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-10
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.1.5 Decathlon D80 Primary Components
ITEM PART # COMPONENT
* 823-3494SP
* 826-1891
* 823-3396SP
Frypot - S/S 1
Frypot - S/S 1
Frypot - S/S 1
2 810-2072 Gas Manifold (welded assembly)
3 810-2049 Orifice, Natural Gas #43 2.26 mm (non-CE D80G)
* 810-0710 Orifice, LP Gas #54 1.40 mm (non-CE D80G)
* 810-2161 Orifice, Natural Gas #38 2.58 mm (non-CE D80GHP)
* 810-2063 Orifice, LP Gas #52 1.61 mm (SCFD80G)
* 810-2060 Orifice, G20/G25 Gas (CE only)
* 810-2059 Orifice, G31 (CE only)
4 810-2032 Pilot Burner, Natural/G20/25 Gas (primary and trailing)
* 810-2155 Pilot Burner, LP/G31 Gas (primary and trailing)
* 812-1674
* 809-0845
* 812-1674
* 810-0705
* 810-0703
Pilot Burner, Mod. Natural Gas (electronic ignition)
Screw, 10-32 x
Tube, Pilot Gas Supply,
Tube, Pilot Gas Supply,
Tube, Pilot Gas Supply,
* 810-2138 Valve, Trailing Pilot, Adjustable (trailing pilot only)
5 200-1314 Manifold Support Bracket
* 200-1615 Manifold Support Bracket (right or left)
6 210-5197 Diffuser Assembly
7
►►► See Drain Manifold Components, Section 2.5
8 810-2151 Burner, Left Side
9 810-2149 Burner, Center
10 810-2150 Burner, Right Side
11 200-2707 Heat Shield
* 200-1363 Lower Heat Shield
12 807-3552 Gas Valve, Natural Gas Electronic Ignition, 24 VAC
* 807-3628 Gas Valve, LP Gas Electronic Ignition, 24 VAC
* 810-2156 Gas Valve, Natural Gas, 120 VAC
* 810-2323 Gas Valve, LP Gas, 120 VAC
* 807-2091 Gas Valve, G20/25 Gas, 24 VAC (CE only)
* 807-2127 Gas Valve, G31 Gas, 24 VAC (CE only)
* 810-0691 Vent Tube
13 200-2686 Channel, Front and Rear
14 200-1675 Lower Hinge Bracket
*
*
*
*
823-5346 Hinge, Lower Left
823-5347 Hinge, Lower Right
823-5348 Hinge, Upper Left
823-5349 Hinge, Upper Right
15 211-2532 Side Panel, Left Side (D80)
16 212-2532 Side Panel, Right Side (D80)
* 201-4775 Side Panel, Left Side with hole (SCFD80)
* 202-4775 Side Panel, Right Side with hole (SCFD80)
* 211-4570 Side Panel, Left Side without hole (SCFD80)
* 212-4570 Side Panel, Right Side without hole (SCFD80)
17 824-0954 Wireway, Control Panel
18 210-2778 Control Panel, One Hole (D80)
* Not illustrated.
1
⁄
" Drain (D80, after 10/99)
4
1
⁄
" Drain (D80, before 10/99)
4
1
⁄
" Drain (D80, SCFD80)
2
3
⁄
" Hex Slotted Head (primary and trailing)
8
1
⁄
" x 23" (one-piece gasline)
4
1
⁄
" x 20" (one-piece gasline)
4
1
⁄
" x 17
4
3
⁄
" (one-piece gasline)
4
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-11
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.1.5 Decathlon D80 Primary Components (cont.)
ITEM PART # COMPONENT
* 210-2777 Control Panel, Two Holes (D80)
* 210-5061 Control Panel, One Hole (SCFD80)
* 210-5910 Control Panel, Two Holes (SCFD80)
19
20 824-0986 Top Cap (D80/CFD80)
* 824-1013 Top Cap, 2-battery (SCFD80)
* 824-1007 Top Cap, 3-battery (SCFD80)
* 824-1006 Top Cap, 4-battery (SCFD80)
21 823-3659 Flue Box Assembly (D280, SCFD280)
* 106-1442SP Flue Box Assembly (D380/480, CFD80, SCFD380/480)
* 200-1347 Front, Flue Box
* 200-1349 Back, Flue Box
* 200-1316 Shield, Flue Box
* 200-3645 Deflector, Flue
22 823-3512 Flue Cap (D80)
* 823-3659 Flue Cap (SCFD80)
23 106-1698SP Door Assembly
* 210-1151 Panel, Outer Door
* 200-2688 Panel, Inner Door
* 810-0180 Door Handle, Chrome
* 809-0918 Screw, 10-24 x 1⁄2" Slotted Head (use with 810-2105)
* 809-0191 Washer,
* 200-1301 Pin, Door, Long (D80)
* 210-9889 Pin, Door (SCFD80)
* 810-0066 Magnetic Catch, Door (D80)
* 810-1105 Magnetic Catch, Door (SCFD80)
24 803-0304 Fry Basket, 6 x 83⁄4" x 163⁄4"
25 810-2122 Grid Assembly (mesh-style)
* 803-0300 Grid Assembly (rack-style)
26 200-3120 Hanger, Basket, Single System, M/S (D80)
* 210-2887 Hanger, Basket, Single System, S/S, no splash guard (SCFD80)
* 200-3119 Hanger, Basket, Double System, M/S (D80)
* 210-3117 Hanger, Basket, Double System, S/S (SCFD80)
27 810-0356 Caster, Plate-mount, 5-inch without Brake
* 810-2406 Caster, Single Stud-mount, 5-inch without Brake
28 810-0357 Caster, Plate-mount, 5-inch with Brake
* 810-2405 Caster, Single Stud-mount, 5-inch with Brake
* 826-1389 Screw,
29 812-1226SP Drain Nipple, Extended, 1 ¼”
* 812-1717SP Drain Nipple, Extended, 1 ½”
30 106-0913SP Cordset, 10’ Power
31 210-2804 Cover, Outlet Duct
32 200-2683 Back, Upper Cabinet
* 200-2982 Back, Lower Cabinet
33 810-2411 Leg, Single Bolt Mount (black)
* 806-3811 Leg Package, 4 Bolt Mount (4 per set)
34 823-3248 Leg Support Assembly
35 200-2734 Burner Mounting Bracket
36 823-3649 Hanger, Basket with 6” Splash Guard
* Not illustrated.
►►► See Optional Components, Section 2.3
1
⁄4" Spring-lock (use with 810-2105)
1
⁄4-20 x 3⁄4" Hex Head (for plate-mount casters, qty: 10)
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-12
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.2 Control Panel Options, Joiner Strips, and Accessories
3
2
1
7
8
5
6
4
9
ITEM PART # COMPONENT
1 210-3562 Controller (D50)
2 210-3021 Solid, with Indicator Light (D60)
3 210-6405 Controller (D60, D65)
4 210-2051 McDonald’s™ (D50)
5 210-4672 Basket Lift, with Thermatron Controller (D60)
6 210-5061 Solid, with Indicator Light (D80)
7 210-5910 Solid, for Matching Cabinet (D80)
8 210-3910 Controller (15MC/50/20)
9 210-1256 Controller (SCFD60/150)
210-4847 D50/D50
211-4816 2424/D50
212-4816 D50/2424
210-3327 D20/D50
210-3017 DD50/D60/D80
210-1679 SM/D220
* 823-3938 Crumb Scoop, Split Pot
* 106-2631SP Sediment Tray
* 823-3947 Chicken Crisper, D60
* Not illustrated.
Control Panels
Joiner Strips
Accessories
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-13
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.3 Optional Components and Controllers
1
65432
8
11109
1512 13 14
191817
20
23
7
16
2422
25
21
26
ITEM PART # COMPONENT
1 826-2013 Thermostat, Sunne
2 810-2035 Knob, Thermostat
3 826-2117 Spark Module, Domestic and CE (Rajah Connector, 807-3484)
* 807-3484 Rajah Connector (for Blue/Gray Honeywell module, 807-4037, no longer avail.)
4 807-1311 Pilot Assembly, Natural Gas with Electronic Ignition
* 807-1553 Pilot Assembly, LP Gas with Electronic Ignition
* 807-1315 Ignition Cable (for computer operated fryers)
* 810-0705
* 807-1310 Flame Sensor
* Not illustrated.
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
Tube,
1
⁄
" x 20" One Piece Pilot Gas Supply
4
2-14
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.3 Optional Components and Controllers (cont.)
ITEM PART # COMPONENT
* 803-0278 Brush, L-shaped
* 803-0197 Fryer’s Friend
* 803-0293 Gloves
* 106-1839SP Pilot Assembly (w/computer and electronic ignition), Natural
* 106-1128 Pilot Assembly (w/computer and electronic ignition), LP
* 106-1235 Pilot Assembly (without computer), Natural
* KIT0092 Air Shutter Kit
5 210-3562 Control Panel, Computer (D50)
* 210-1256 Control Panel, Computer (D60)
* 823-1800 Control Panel, Computer (FPD65)
* 210-1520 Control Panel, Computer (D80)
6 106-6609 Computer, Compu-Fry III.5, Full-vat
* 806-8305 Computer, CM4-S
* 806-8308 Computer, CM4-S (FPD65)
* 806-5139 Computer, Remote
* 806-4807 Computer, Compu-Fry III.5, Dual-vat
* 806-4803 Cable Assembly, Compu-Fry to Interface Board
7 823-3433 Bezel Assembly, Control Panel
* 910-7283 Bezel Assembly, Control Panel (FPD65)
8 106-0802SP Face Plate/Potentiometer, 120 VAC Electronic Thermostat
* 820-0135 Face Plate, Electronic Thermostat
* 106-0801 Potentiometer, Electronic Thermostat (molex connector; with trim resistor)
* 106-5809 Potentiometer, Electronic Thermostat (molex connector; without trim resistor)
* 816-0534 Knob, Control, Electronic Thermostat
9 807-3485 Thermopile
* 807-1026 Sound Device
* 806-4803 Cable Assembly (Harness)
10 812-1284 Thermocouple (CE ONLY)
* 807-3550 Thermocouple
11 106-1768SP ECO Connector, Honeywell Valves Only (CE ONLY)
* 810-2398 ECO Connector, Robertshaw Valves Only (CE ONLY)
12 106-5419SP Probe Assembly, GO (D20, D50, D60, D80)
* 106-1976 Probe Assembly, Temperature, New Design, 4-pin (D60 & D80)
* 106-1424 Probe Assembly (RTD), Temperature (Dean computer)
* 106-1261SP Harness Assembly, GO Probe
* 810-2164 Spring, Space, Electronic Thermostat Probe
* 210-1386 Clamp, Electronic Thermostat Probe
13 210-6564 Bracket, Pilot Thermocouple
14 810-2401 Bracket, Thermopile
15 810-1001 Piezo Ignitor (trigger)
* 200-1868 Piezo Bracket
* 807-3540 Electrode, Piezo
16 807-3551 Transformer, Honeywell 120/24 VAC (threaded mounting/electronic ignition)
* 807-0855 Transformer, 120/12 VAC
* 807-0800 Transformer, 120/24 VAC
* 807-1999 Transformer, Dual CE (CE ONLY, 208-240/12-24V)
17 807-3560 High-limit Thermostat, Manual Reset 410° F (CE)
* 807-3680 High-limit Thermostat, Manual Reset 450° F (NON-CE, 1998-present)
* 807-3559 High-limit Thermostat, Manual Reset 435° F (pre-1998)
* Not illustrated.
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-15
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.3 Optional Components and Controllers (cont.)
ITEM PART # COMPONENT
* 810-2046 Spring, Spacer, High-limit Capillary Bulb
* 810-2047 Spring, Spacer, Thermostat Capillary Bulb
* 210-1433 Clamp, Thermostat/High-limit Capillary Bulb
18 807-1321 Fuse Holder, Buss
* 2747 Fuse Holder, Slot-head, Safety (CE ONLY)
* 807-3592 Fuse 2A Slow-blow (230V systems)
* 807-3750 Fuse 5A (120V systems)
19 106-6710 Interface Board, Dean Computer Only
20 807-0834 Relay, 12VDC 15A 1PDT (basket lift)
21 807-0833 Relay, 12VDC 5A 1PDT (latching)
* 807-4114 Relay, 24VAC Coil, Reset
22 807-3574 Switch, Power (green lens)
23 807-3580 Switch, Rocker, Manual Filter Power
24 807-3579 Switch, Six-terminal Boil-out
25 807-3576 Switch, Fryer Reset (momentary)
* 807-3578 Switch, 3-position, ON-OFF-ON
* 807-3582 Indicator Light, Green
* 807-3581 Indicator Light, Red
* 807-3611 Pump Relay
* 807-3578 Socket, Pump Relay
* 807-3575 Switch Insert, Blank
26 210-2786 Switch Guard (for Items 22-25, optional)
* Not illustrated.
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-16
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.4 Transformers & Component Boxes; Multi-batteried Decathlons
ITEM PART COMPONENT
1 823-3242 Control Box (D50/CFD50/SCFD50)
* 106-2691 Control Box (FPD65)
2 210-1364 Plate, Face (for Item 1)
* 210-2966 Plate, Face (for Item 1, FPD65)
3 200-1322 Bracket, Spark Module
4 200-1326 Cover, Spark Module (Fryers 3 & 4)
5 807-3551 Transformer
6 200-2307 Bracket, Spark Module Attachment (Fryers 1 & 2)
7 824-0961 Wireway, Control Panel (D50)
* 824-0951 Wireway, Control Panel (D60)
* 824-1195 Wireway, Control Panel (SCFD models)
* 824-1162 Wireway, Control Panel (D80)
8 826-2086 Thermatron Board, 115/230V
* 106-3729 Thermatron Board, 24V, Melt Cycle
* 826-2088 Kit, Thermatron, 24V
* 826-2031 Kit, Thermatron, 115/220V
9 200-3212 Housing, Electronic Thermostat, Two Cut-outs
10 210-3214 Face Plate, Electronic Thermostat, Power/Boil-out
* 807-3536 Potentiometer, Electronic Thermostat (spade terminals; with trim resistor)
* 106-0801 Potentiometer, Electronic Thermostat (molex connector; with trim resistor)
* 106-5809 Potentiometer, Electronic Thermostat (molex connector; without trim resistor)
* 816-0534 Knob, Electronic Thermostat Potentiometer
11 807-3680 High-limit Thermostat, Manual Reset 450° F (non-CE only)
* 807-3559 High-limit Thermostat, Manual Reset 435° F
* 807-3560 High-limit Thermostat, Manual Reset 410° F (CE only)
* 106-1131SP Harness, Spark Module
* 807-3592 Fuse, 2A, Slow Blow
* 807-3577 Circuit Breaker, 7 amp
* Not illustrated.
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-17
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
During the transition phase, some Decathlon series fryers were equipped with 3” round drain systems while others were
equipped with 1.5” round drain systems. Compare the fryer in question with the illustrations on pages 2-18 to 2-29 to
determine which system it uses.
2.5 Oil Drain Manifold Components
2.5.1 1.5” Oil Drain Manifold, Drain Flush, and Drain Valve Components
22
20
19
21
23
To Drain
Valve
18
10
9
7
17
16
15
12
11
14
13
To Drain
Valve
To Drain
Valve
6
5
1
4
8
32
24
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-18
25
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.5.1 1.5” Oil Drain Manifold, Drain Flush, and Drain Valve Components (cont.)
ITEM PART # COMPONENT
1 823-3221 Elbow with Bracket, Left
* 823-3222 Elbow with Bracket, Right
2 823-5167 Drain Pipe, Left Side
3 210-2311 Clamp, Center Drain Pipe
4 823-4931 Drain Pipe, Right Side
5 813-0749
6 200-5621 Drain Manifold Tube, 17”
* 200-1827 Drain Manifold Tube, 13”
7 813-0659
* 813-0391 Nipple, 1 ¼” x Close
* 813-0748 Tee, 1 ½” NPT x 1 ¼” NPT (with handle bracket)
8 809-0884
* 816-0544 O-ring, Slip-joint Nut
9 813-0686
10 810-1057
11 813-0051
12 813-0165
13 810-1668
* 810-1669
14 810-1069
* 806-6849 Tilt Switch, Drain Valve
15 106-1401 Bracket, Microswitch (optional on some units)
16 200-1617 Washer, Drain Valve (use without microswitch)
17 210-2029 Bracket, Microswitch Activator
18 210-4727 Handle (Actuator), Drain Valve, Round
* 823-3405 Handle (Actuator), Drain Valve, Flat
* 823-3440 Handle, Push/Pull Drain
* 809-0885
* 809-0843 Cotter Pin
* 816-0547 Cap, Red Vinyl for Handle
19 807-2104 Microswitch (optional on some units)
20 809-0842 Nut, Nylock #4-40 (microswitch to bracket)
21 816-0220 Insulation, Microswitch
22 200-1257 Retainer, Nut
23 810-2127
24 810-2052
* 810-1338 Drain Valve, 1" (D20 only)
* 200-2371 Handle, Valve Lever (for use with 810-1338 and 823-3440 only)
25 810-2126
* 810-1018
* 210-2342 Drain Extension, Left
* 210-2343 Drain Extension, Right
* Not illustrated.
1
Tee, 1
Pipe Cap, 1
Nut, Slip-joint 1
Bell Reducer, 1
Flex Line,
Coupling,
Elbow, Street
Adapter,
Adapter,
Flex Line,
⁄
" NPT With Handle Bracket
2
1
⁄
"
2
1
⁄
"
2
1
1
⁄
" x
⁄
" NPT
2
5
" x 13"
⁄
8
1
⁄
" NPT
2
5
" O.D. x
⁄
8
5
" O.D. x
⁄
8
5
" x 29
⁄
8
1
⁄
2
1
" x
⁄
" 90°
2
2
1
⁄
" Male (use with 810-1057 and 810-1069)
2
1
⁄
" Female (use with 810-1057 and 810-1069)
2
1
⁄
"
2
DRAIN VALVE COMPONENTS
Washer,
Drain Valve, 1
Drain Valve, 1
Drain Valve, 1
Drain Valve, 1
3
⁄
" x 1 x .083"
8
1
⁄
" Full Port (with washers & nut)
2
1
⁄
" (1" standard port)
4
1
⁄
", Full Port
4
1
⁄
", Left
4
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-19
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.5.2 3” Oil Drain Manifold, Drain Flush, and Drain Valve Components
19
17
15
18
13
22
14
23
20
Place Over
Stud
21
16
10
19
20
13
22
14
Place Over
Stud
21
To Drain
Valve
4
8
Stud located on
underside of tube
12
To Drain
Valve
11
To Drain
To Drain
3
6
Valve
1
Valve
2
5
7
9
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-20
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.5.2 3” Oil Drain Manifold, Drain Flush, and Drain Valve Components (cont.)
ITEM PART # COMPONENT
1 823-4712 Tube, 3" Oval Dump
2 823-4681 Tube, 3" Right Drain (8.06” long, closed end)
3 823-4682 Tube, 3" Center Drain (8” long, open ends)
4 823-4844 Tube, 3" Left Drain (12.44” long, closed end)
5 823-5188 Tube, 3" Right Filter (10.38” long, open ends)
6 200-6603 Tube, 3" Joiner (11.5" long)
7 200-9365 Tube, 3" Joiner (8.63" long)
8 809-0969 Clamp, T-bolt
9 816-0625 Boot/Sleeve
* 106-2568SP Wash Down Hose Assembly
* 106-1837 Quick Disconnect, Female
* 813-0699 Quick Disconnect, Male
* 810-1434 Hose Assembly
* 106-1454 Nozzle Assembly, Hose with Handle
* 106-1227 Heater Strip 120V, 25W, 36”
106-1726
10 810-1669
11 810-1668
12 810-1056
106-3976
106-3977
13 810-2783
14 823-4734 Handle, Drain Valve Rotating
15 807-2104 Microswitch, CE Micro-roller Lever
16 106-1401 Microswitch Bracket Assembly
17 200-4402 Guard, Drain Microswitch
18 816-0220 Insulation, RF Switch
19 816-0547 Cap, Red Vinyl for Handle
20 200-6116
21 200-1617 Washer, Drain Microswitch
22 200-1257 Retainer, Drain Valve
23 826-1366 Nut, 4-40 Keps Hex w/External Teeth (pkg. of 25)
* 816-0630 Cap, Vinyl (one per clamp, covers T-bolt threads)
* Not illustrated.
Flush Oil Drain Line
Adapter, Female
Adapter, Male
Flexline,
5
⁄
8
5
" O.D. x
⁄
8
5
" O.D. x
⁄
8
" O.D. x 52.5" Long
Drain Valve Assembly, 1
Drain Valve Assembly, 1
Drain Valve, 1
Strap, 1
1
" Full Port with O-ring
⁄
2
1
" (holds tube to valve via the stud)
⁄
2
1
" Long
⁄
2
1
" Long
⁄
2
1
" without Microswitch
⁄
2
1
" with Microswitch
⁄
2
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-21
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
During the transition phase, some Decathlon series fryers were equipped with 3” round drain systems while others were
equipped with 1.5” round drain systems. Compare the fryer in question with the illustrations on pages 2-18 to 2-29 to
determine which system it uses.
2.6 Oil Return Manifold Components
2.6.1 Oil Return Manifold Components; D & FPD65 Models
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-22
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.6.1 Oil Return Manifold Components; D & FPD65 Models (cont.)
ITEM PART # COMPONENT
1 813-0003
2 813-0022
3 813-0087
4 813-0156
5 813-0173
6 813-0247
7 813-0298
8 813-0345
9 813-0368
10 813-0646
11 813-0654
12 813-0672
13 813-0673
14 810-2125
* 200-1143 Retainer, Oil Return Valve Nut
* 809-0877 Nut, Oil Return Valve
15 813-0006
16 813-0625
17 813-0165
18 813-0634
19 813-0062
* Not illustrated
1
1
Tee,
Nipple,
Nipple,
1
Plug,
Union,
Nipple,
Nipple,
Elbow,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
⁄
" x
2
1
⁄
1
⁄
⁄
" NPT Hex Head BM
2
1
⁄
2
1
⁄
1
⁄
1
⁄
2
1
⁄
1
⁄
1
⁄
1
⁄
1
⁄
1
⁄
" x
2
" NPT x Close BM
2
" NPT x 1
2
" NPT BM
" NPT x 3
2
" NPT x 2" BM
2
" NPT 45° BM
" NPT x 16" BM
2
" NPT x 5" BM
2
" x 4" NPT BM
2
" x 8" NPT BM
2
1
" x 8
⁄
2
2
Oil Return Valve,
Bushing, Hex
Nipple,
Elbow, Street
Elbow,
Elbow,
1
⁄
3
⁄
1
⁄
1
⁄
2
" x Close NPT BM
8
1
⁄
2
3
" x
⁄
" NPT 90° BM
2
8
" NPT 90° BM
2
⁄
" NPT BM
2
1
⁄
" BM
2
1
⁄
" BM
2
" NPT BM
3
⁄
"
8
3
" x
⁄
" NPT BM
8
1
" x
⁄
" NPT 90° BM
2
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-23
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.6.2 Oil Return Manifold Components; SCFD, CFD, & FPD65 Models
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-24
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
⁄
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.6.2 Oil Return Manifold Components; SCFD, CFD, & FPD65 Models (cont.)
ITEM PART # COMPONENT
106-4100 Oil Return Assembly – Middle
106-4101 Oil Return Assembly – End
1 106-4006
* 106-3997 Valve Assembly (use with wand)
* 106-5516 Valve Assembly, 3-way Oil Return
* 106-5231 Valve Assembly, FPD
2 810-1668
3 810-2320
4 813-0003
5 813-0022
6 813-0096
7 813-0165
8 813-0173
9 813-0247
10 813-0362
11 813-0463
12 813-0661
13 813-0654
14 813-0597
* 810-2125
* 813-0006
* 813-0062
* 810-1067 Flexline, 8.5” Oil Return
* 810-1055 Flexline, 11.5” Oil Return
* 810-1400 Flexline, 21.00” Oil Return
* 810-1056 Flexline, 52.5” Oil Return
* 810-2320 Flexline, 9.00” Oil Return
* 813-0087
* 813-0460
* 813-0625
* 813-0672
* 813-0607
* 813-0099
* 813-0845
* 813-0646
* 813-0373
* 813-0298
* 813-0098
* 813-0742
* 813-0515
* 813-0265
* 813-0093
* 813-0281
* 813-0368
* 813-0644
* 813-0673
* 813-0698
* Not illustrated.
Valve Assembly,
Adapter, Male
Flexline,
1
Tee,
2
" x
Nipple,
Nipple,
Elbow, Street
Union,
1
Nipple,
Nipple,
1
Plug,
2
Nipple,
Nipple,
Nipple,
Ball Valve,
Bushing,
Elbow,
1
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
Nipple,
1
" Oil Return (see Page 2-21)
2
5
" OD x
5
1
2
1
2
2
1
2
1
2
8
" x 9.00" Long
8
1
1
" x
2
2
" x Close NPT BM
" x 6.00” NPT BM
1
" x
2
" NPT
" x 3.50" NPT BM
" NPT x 7.50" BM
1
"
2
" BM
1
" NPT 90° BM
2
" Counter Sink
1
" x 2.25" NPT BM
2
1
” x 4.00” NPT BM
2
1
“ x 11.50” NPT BM
2
3
" Drain
8
3
1
" to
" NPT BM Hex Reducing
2
" 90° BM
2
1
" x 1.50" NPT BM
2
1
" x 3.00" NPT BM
2
3
" NPT x CL Black CLS
8
1
" x 8.00" NPT BM
2
1
" x 23.5” NPT BM
2
1
" x 7.00" NPT BM
2
1
" x 29.75" NPT BM
2
1
" x 5.00" NPT BM
2
1
" x 11.00" NPT BM
2
1
" x 2.00" NPT BM
2
1
" x 6.50" NPT BM
2
1
" x 5.50" NPT BM
2
1
" x 12.00" NPT BM
2
1
" x 2.50" NPT BM
2
1
" x 4.00" NPT BM
2
1
" x 5.00" NPT BM
2
1
" x 16.00" NPT BM
2
3
" x 1.5" NPT BM
8
1
" x 8.5" NPT BM
2
1
" x 10.5" NPT BM
2
8
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-25
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
During the transition phase, some Decathlon series fryers were equipped with 3” round drain systems while others were
equipped with 1.5” round drain systems. Compare the fryer in question with the illustrations on pages 2-18 to 2-29 to
determine which system it uses.
2.7 Oil Return and Oil Flush Components
2.7.1 Oil Return and Oil Flush Components; D & FPD65 Models
Rear View
1
2
10
4
6
3
16
5
9
8
7
17
11
12
13
14
15
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-26
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.7.1 Oil Return and Oil Flush Components; D & FPD65 Models (cont.)
ITEM PART # COMPONENT
1
106-1824 Bracket, Oil Return Microswitch, Left
106-3595 Bracket, Oil Return Microswitch, Right
201-4455 Bracket, Oil Return Microswitch, Left (FPD)
202-4455 Bracket, Oil Return Microswitch, Right (FPD)
810-2144 Spacer, 4-40
807-2104 Microswitch, Oil Return
809-0846 Screw, 4-40 x 1" Slotted Head
809-0842 Nut, 4-40 Nylock
200-1341 Bracket, Microswitch Rod
809-0360 Screw, #8 x
826-1389 Screw,
809-0428 Screw,
809-0823 Nut,
809-0070 Nut,
2 810-0697 Disconnect, Male Suction Tube
* 826-1392 O-rings, for Male Disconnect (pack of 5)
3 813-0608 Coupling, Full,
4 823-3188 Suction Manifold Assembly
5 813-0062 Elbow, 90° BM
6 813-0515 Nipple,
7 813-0173 Union,
8 813-0251 Nipple,
9 813-0672 Nipple,
10
* 813-0022 Nipple,
* 813-0156 Plug,
* 813-0003 Tee,
11 809-0885 Washer,
* 809-0843 Cotter Pin, Plated
12 823-3344 Handle (Actuator), Oil Return Valve
13 823-3187 Handle, Oil Return Left Fryer (UFF System)
14 823-3198 Handle, Oil Return Right Fryer (UFF System, Fryer 3 & 4)
* 823-3481 Handle, Oil Flush Valve
* 816-0547 Cap, Drain Valve Handle, Red
15 816-0548 Cap, Oil Return Handle, Yellow
* 816-0549 Cap, Oil Flush Handle, Blue
16 810-2100 Motor, Pump 120-230V
17 810-2098 Pump, 8 GPM
* 810-2252 Pump, Chili’s, 5 GPM
* Not illustrated.
Microswitch Bracket Assembly, Oil Return
1
3
" x
" Aluminum
⁄
⁄
4
8
3
" Hex Washer Slotted Head
⁄
8
1
⁄
1
⁄
1
-20 Nylock
⁄
4
1
-20 Hex SS
⁄
4
1
” NPT x 12" BM
⁄
2
1
" NPT BM
⁄
2
1
” NPT x 4
⁄
2
1
” NPT x 8" BM
⁄
2
3
-20 x
4
-20 x ½” Hex Head
4
" Hex Head
⁄
4
1
" NPT BM
⁄
2
1
" BM
⁄
2
Oil Suction Start Fitting
1
" NPT x Close
⁄
2
1
" NPT Hex Head
⁄
2
1
" NPT BM
⁄
2
3
" x 1" x .083"
⁄
8
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-27
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.7.2 Oil Return and Oil Flush Components; SCFD, CFD, & FPD65 Models
7
3
2
15
14
13
16
6
8
1
17
9
12
5
11
4
18
19
10
20
21
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-28
22
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.7.2 Oil Return and Oil Flush Components; SCFD, CFD, & FPD65 Models (cont.)
ITEM PART # COMPONENT
106-4006
1 901-2772 Handle, RF Left
2 900-2935 Retainer, Nut
3 816-0220 Insulation, RF Switch
4 810-0278
5 826-1366 Nut, 4-40 Keps Hex w/External Teeth (pkg. of 25)
6 807-2103 Microswitch, Straight Lever (CE)
7 200-6806 Cover, Safety Switch
8 106-3962 Bracket Assembly, RF Switch
106-1225SP
9 813-0062 Elbow, 90° BM
10 813-0173
11 813-0654
12 813-0674
13 200-1230 Bracket, Front Male Manifold
106-0774SP
14 810-0697 Disconnect, Male Suction Tube
* 826-1392 O-rings, for Male Disconnect (pack of 5)
15 813-0608
16 823-3188 Suction Manifold
106-0858
17 813-0022
18 813-0463
19 813-0003
* 210-8790 Bracket, Oil Return/Flush Retainer
* 200-8929 Handle, Oil Return
* 200-9850 Handle, Oil Return (Application Series “DF” fryers)
* 816-0548 Cap, Oil Return Handle, Yellow
* 816-0637 Cap, Oil Return Handle, Blue
20 810-2100 Motor
21 810-2252 Pump, Chili’s, 5GPM
22 810-2098 Pump, 8GPM
* Not illustrated.
Microswitch Bracket Assembly, Oil Return
Ball Valve,
1
" Oil Return
⁄
2
Oil Suction Assembly
Union,
Nipple, TBE
Nipple, TBE
1
" NPT 150# BM
⁄
2
1
" NPT x 4" Black
⁄
2
1
" NPT x 7
⁄
2
1
" Black
⁄
4
Suction Manifold Assembly
Coupling,
Oil Suction Start Fitting
Nipple,
Plug,
Tee,
1
" NPT BM Full
⁄
2
1
" NPT x Close
⁄
2
1
" Counter Sink
⁄
2
1
" NPT BM
⁄
2
Pump and Motor
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-29
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.8 UFF Filtration Components
2.8.1 UFF Filtration Components; D50 Series Fryers
12
10
8
11
9
2
3
4
1
5
6
ITEM PART # COMPONENT
1 106-2115SP Filter Pan
2 809-0805 Screw, ¼-20 x ½"
3 809-0428 Screw, ¼-20 x ½" Steel
4 809-0820 Nut, Oval Locking, ¼-20
5 823-4794 Insert, Caster
6 810-2805 Caster, 2”
7 823-3574 Support Grid, Bottom Pan Screen
8 803-0289 Filter Paper, 22” x 34" (100 sheets per box)
9 823-3573 Hold-down Ring, Weighted
10 823-4320 Crumb Basket
11 106-0752SP Lid Assembly, Front
12 106-1755SP Lid Assembly, Rear
* 106-3230SP Lid Assembly, One Piece, Chili’s
* 106-2568SP Wand Assembly
* Not illustrated.
7
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-30
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.8.2 UFF Filtration Components; SCFD50 Series Fryers
2
4
3
5
8
6
7
ITEM PART # DESCRIPTION
1 106-5144SP Filter Pan
2 823-5639 Lid, Filter Pan
3 823-3573 Ring, Hold Down
4 823-5191 Crumb Basket
5 200-8003 Screen, Sana Grid
6 810-2805 Caster, 2”
7 809-0823 Nut, Nylock, ¼-20
8 813-0568 Pipe Plug, 1/8 NPT Socket-head
9 803-0170 Filter Paper, 16.5” x 25.75” (100 sheets per box)
* Not illustrated.
9
1
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-31
)
(
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.8.3 UFF Filtration Components; D60 and D80 Series Fryers
6
7
5
4
ITEM PART # COMPONENT
1 106-0749SP Filter Pan (UFF 60)
* 106-1584SP Filter Pan (UFF 80)
* 106-4521 Filter Pan (UFF 100)
2 823-3365 Support Grid, Bottom Pan Screen
3 803-0289 Filter Paper, 22 x 34" (100 sheets per box
* 803-0303 Filter Paper, 26 x 34" (100 sheets per box) (UFF 80)
4 823-3361 Hold-down Ring, Weighted (UFF 60)
* 823-3439 Hold-down Ring, Weighted (UFF 80)
5 823-4320 Crumb Basket (UFF 60)
* 823-3443 Crumb Basket (UFF 80)
6 106-0752SP Lid, Front (UFF 60)
* 106-1587SP Lid, Front (UFF 80)
7 106-0753SP Lid, Rear (UFF 60)
* 106-1588SP Lid, Rear (UFF 80)
8 809-0428 Screw, ¼-20 x ½" Steel
9 823-4794 Insert, Caster
10 809-0820 Nut, Oval Locking, ¼-20
11 809-0805 Screw, ¼-20 x ½"
12 210-2805 Caster, 2"
* Not illustrated.
3
1
2
10
9
11
8
12
UFF 60)
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-32
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.8.4 UFF Filtration Components; SCFD60 and FPD65 Series Fryers
2
3
4
5
ITEM PART # COMPONENT
1 106-1220SP Filter Pan (SCFD)
* 823-4109 Filter Pan (FPD)
2 106-4725SP Lid Assembly (SCFD)
* 106-6119SP Lid Assembly (FPD)
3 823-4320 Crumb Basket (SCFD)
* 823-3872 Crumb Basket (FPD)
4 823-3361 Hold Down Ring (SCFD)
* 810-2350 Filter Leaf (FPD)
5 200-5726 Screen, Bottom Filter (SCFD)
* 810-2582 Fitting, Filter Leaf (FPD)
6 810-2805 Caster, 2”
7 809-0070 Nut, ¼-20 Hex S/S
8 803-0289 Filter Paper, 22” x 34” (100 sheets; 803-0266, 25 sheets)
* Not illustrated.
8
1
6
7
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-33
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.8.5 UFF Filtration Components; SCFD80 Series Fryers
4
ITEM PART # COMPONENT
1 823-5406 Filter Pan
2 106-5321 Lid, Front (UFF 80)
3 106-5317 Lid, Rear (UFF 80)
4 823-5412 Crumb Basket
5 823-5409 Hold Down Ring
6 823-3365 Grid
7 810-2805 Caster, 2”
8 823-5407 Insert, Caster
9 809-0804 Nut, ¼-20 Cap (with Ext. Tooth)
10 809-0191 Washer, ¼“ Spring Lock
11 809-0428 Screw, ¼-20 x ½ Hex Head
12 813-0679 Plug, ⅛” S/S Square Head Pipe (Suction)
* 813-0704 Plug, ⅜” S/S Hex Head
13 803-0303 Filter Paper, 26” x 34” (100 sheets per box)
* Not illustrated.
13
3
5
6
2
1
12
9
7
8
10
11
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-34
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.9 SUFF Filtration Components
2.9.1 SUFF Filtration Components; D50 Series Fryers
7
6
3
8
ITEM PART # COMPONENT
1 823-3796 Filter Pan (SUFF 50)
* 813-0684 Plug, Hex Socket, 3/8" NPT
* 813-0679 Plug, 1/8" SS Square Head (Female Disconnect)
2 823-3790 Support Grid, Bottom Pan Screen
3 803-0317 Filter Paper, 8-1/4 x 25-3/4"
4 823-3795 Hold-down Ring, Weighted
5 823-3736 Crumb Basket
6 823-3797 Filter Pan Cover, Front
7 823-3798 Filter Pan Cover, Back
8 809-0428 Screw, ¼-20 x ½" Steel
9 823-4794 Insert, Caster
10 809-0820 Nut, Oval Locking, ¼-20
11 809-0805 Screw, ¼-20 x ½"
12 810-2805 Caster, 2"
* Not Illustrated.
2
10
11
4
5
1
9
12
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-35
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.9.2 SUFF Filtration Components; CFD50 Series Fryers
3
13
7
5
1
10
9
8
12
2
4
6
11
ITEM PART # COMPONENT
1 823-3796 Filter Pan
2 823-3798 Lid, Filter Pan, Rear
3 823-3797 Lid, Filter Pan, Front
4 823-3795 Hold-down Ring
5 823-5423 Crumb Basket (SUFF50/60/80)
6 823-3790 Grid, Bottom Filter
7 803-0317 Filter Paper, 8.25” x 25.75”
8 810-2805 Caster, 2”
9 823-5407 Insert, Caster
10 809-0804 Nut, ¼-20 Cap (with Ext. Tooth)
11 809-0428 Screw, ¼-20 x ½” Hex Head
12 809-0191 Washer, ¼” Spring Lock
13 813-0679 Plug, 1/8" SS Square Head
* Not Illustrated.
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-36
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.9.3 SUFF Filtration Components; D60 and D80 Series Fryers
7
6
4
3
2
10
8
11
ITEM PART # COMPONENT
1 823-3774 Filter Pan (SUFF 60)
* 823-3821 Filter Pan, (SUFF 80)
* 813-0684 Plug, Hex Socket, 3/8" NPT
* 813-0679 Plug, 1/8" SS Square Head (Female Disconnect)
2 823-3768 Support Grid, Bottom Pan Screen (SUFF 60/80)
3 803-0289 Filter Paper, 22” x 34" (SUFF 60/80)
4 823-3770 Hold-down Ring, Weighted (SUFF 60)
* 823-3849 Hold-down Ring, Weighted (SUFF 80)
5 823-3736 Crumb Basket (SUFF 60/80)
6 823-3766 Filter Pan Cover, Front (SUFF 60)
* 823-3739 Filter Pan Cover, Front (SUFF 80)
7 823-3767 Filter Pan Cover, Back (SUFF 60)
* 823-3741 Filter Pan Cover, Back (SUFF 80)
8 809-0428 Screw, ¼-20 x ½" Steel
9 823-4794 Insert, Caster
10 809-0820 Nut, Oval Locking, ¼-20
11 809-0805 Screw, ¼-20 x ½"
12 810-2805 Caster, 2"
* Not Illustrated
5
1
9
12
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-37
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.9.4 SUFF Filtration Components; CFD60 and CFD80 Series Fryers
ITEM PART # COMPONENT
1 823-5420 Filter Pan (SUFF 60)
* 823-3821 Filter Pan (SUFF 80)
* 106-1433 Filter Pan, Early Style, External Pickup (SUFF 80)
2 823-5424 Filter Pan Cover, Front (SUFF 60)
* 823-3739 Filter Pan Cover, Front (SUFF 80)
3 823-5425 Filter Pan Cover, Back (SUFF 60)
* 823-3741 Filter Pan Cover, Back (SUFF 80)
4 823-5422 Hold-down Ring, Weighted (SUFF 60)
* 823-3849 Hold-down Ring, Weighted (SUFF 80)
5 823-5423 Crumb Basket (SUFF 60/80)
6 823-5421 Support Grid, Bottom Pan Screen (SUFF 60/80)
7 809-0428 Screw, ¼-20 x ½" Steel
8 813-0679 Plug, 1/8" SS Square Head (Female Disconnect)
9 809-0804 Nut, ¼-20 Locking (with ext. tooth)
10 809-0191 Washer, ¼ Spring Lock
11 810-2805 Caster, 2"
12 823-5407 Insert, Caster
13 803-0289 Paper, Filter- 22 x 34" (SUFF 60/80)
* 813-0684 Plug, Hex Socket, 3/8" NPT
* Not Illustrated.
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-38
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.10 Basket Lift Components; D50, D60, and D80 Models
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-39
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.10 Basket Lift Components; D50, D60, and D80 Series Fryers (cont.)
ITEM PART # COMPONENT
106-1914 Basket Lift Assembly (D50)
106-1870 Basket Lift Assembly (D60)
106-1926 Basket Lift Assembly (D80)
1 200-1376 Bracket, Restraining
2 200-2069 Member, Lift Control Arm
Channel, Support Autolift
3 200-3094 Channel (D80)
* 200-2735 Channel (D60)
* 200-3072 Channel (D50)
4 809-0879 Receiver,
5 809-0907 Screw,
* 809-0863 Nut,
6 810-2140 Bushing (Bronze), Oiltite
7 813-0035 Bushing (Bronze), Oiltite .640 I.D.
Back, Basket Lift Motor
8 824-0996 Back (D80)
* 824-0958 Back (D60)
* 824-0990 Back (D50)
Cover, Basket Lift Motor
9 824-0997 Cover (D80)
* 824-0959 Cover (D60)
* 824-0991 Cover (D50)
10 200-1693 Plate, Motor Mounting
11 807-0107 Motor, Gear
12 823-3626 Switch, Limit Cam
13 807-2104 Microswitch
* 810-2144 Spacer
* 809-0846 Screw, 4-40 x 1"
* 809-0842 Nut, 4-40 Nylock
Motor Housing
14 200-3150 Housing, Front (D80)
* 200-2736 Housing, Front (D60)
* 200-3087 Housing, Front (D50)
15 200-3114 Housing, Bottom (D80)
* 200-2739 Housing, Bottom (D60)
* 200-3079 Housing, Bottom (D50)
16 200-3116 Housing, Back (D80)
* 200-2740 Housing, Back (D60)
* 200-3091 Housing, Back (D50)
17 807-0140 Connector,
* 807-3087 Basket Lift Timer, 120V, 60 Hz, 15 min.
* 810-1822 Timer Knob
* 810-1823 Timer Button
* 826-1552 Basket Lift Timer Kit
18 823-3505 Left Basket Lift Arm
19 823-3499 Right Basket Lift Arm
* Not illustrated.
3
⁄
8
5
-18 Hex
⁄
16
3
" Tinnerman Stud
⁄
4
1
" x
" Shoulder
⁄
4
3
"
⁄
8
3
1
" x
"
⁄
⁄
8
4
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
2-40
DECATHLON SERIES GAS FRYERS
CHAPTER 2: PARTS LIST
2.11 Trough, Holster, and Cover Components; D60, FPD65, & D80 Models
3
4
1
2
ITEM PART # COMPONENT
1 106-2668 Holster Assembly, Vat Cover
2 823-3384 Trough, Holster Assembly
3 106-1447 Cover, Full-vat
4 106-2585SP Cover, Split-vat
* 106-2897SP Cover, FPD
* 810-2030 Handle, Vat Cover (Full- and Split-)
* 809-0107 Screw, 8-32 x
* 823-4767 Splash Guard
* 803-0278 L-shaped Brush
* 803-0197 Fryer’s Friend
* 823-3938 Crumb Scoop
* Not illustrated.
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
3
" Round Slotted Head
⁄
8
2-41
Loading...